2021 Chrysler Pacifica

I had purchased the vehicle three days beforehand. It was a lemon law buyback car. I had driven around 120 miles or so that day. The high that day was at least 90 degrees or so. It was past the halfway mark of driving that day, when I tested the Level 2 EVSE I had bought. It didn't work because the plug wasn't energized, but I did notice that the time to charge was reading 3 hours instead of the expected 2 hours. Once I got back to town, I plugged in to a Chargepoint charger, which was only charging at a Level 1 rate. I contacted the dealer to report the problem, and then went to my storage locker. On the way, the AC stopped working. When I tried to leave, the vehicle would not start. Suspecting an overheating problem, I left the hood open for a half hour or so, and after that, the vehicle started up. On my way home, the vehicle suffered a complete loss of motive power, displaying a message saying "Stop Safely Vehicle Will Shut Off Soon", leaving me stranded in a parking lot. This was followed by a message saying "Service Charging System". After another hour or so of sitting with the hood up, the vehicle worked again. This has happened multiple times since then. I have traced the problem to the battery pack reaching a temperature of 55 C, at which point the vehicle invariably shuts down. One time it did this, I was on stuck on the side of a road with no shoulder, after dark. The dealers I have taken it to could not reproduce the problem, as it takes hours of driving to trigger, and they are not willing to drive it enough to reproduce the problem. A case was raised with the manufacturer, but their protocols were insufficient to reproduce the problem. I have recently learned that the problem is apparently the same problem that the original owner had, and that the vehicle was bought back for originally. I have collected extensive CSV logs documenting the defect. The vehicle is obviously still unfixed, as they will not fix it until they duplicate the problem.

I was traveling at highway speed. The hybrid was utilizing mostly the battery. I needed to accelerate to the speed of those around me. The van switched from just battery to utilizing battery and gas power. About a minute after it switched, the engine completely shut off. A warning flashed up on the dash display to “Stop safely Vehicle will shut off soon”. The engine shut off. I could no longer use the gas, the only thing I could do was coast to a stop. This was very terrifying because I was traveling at such a high speed on the interstate. I immediately put on my hazards and coasted to a stop. This was harmful to others on the interstate because they had to slow down behind me or get around me. Eventually when I was slow enough, I managed to coast onto the shoulder and come to a complete stop. I was able to reproduce the problem upon restarting the vehicle. I have taken the van to a dealership but they have not been able to look into it yet. The engine light is now on in the vehicle. This happens consistently at high speeds

While driving early in morning on local highway (70mph speed limit), car flashed "Service Charging System" shut off the engine and power to the vehicle including acceleration, and check engline light illuminated. Thankfully early hours made it possible to drift to side of road to put car in park. Engine light illuminated dash and dash flashed "shift to P to start." Car would not shut off after pressing the start button nor depressing the break either (hazards were engaged at this point). Hazards had to be shut off in order to completely shut off the vehicle to restart it. Dangerous on major highway with no lights or hazards on side of road. 25 degrees outside. This is the Second time this has occurred to this vehicle. The last time occurred on 1/20/2023 the exact same way shutting off power and engine of the car on the same local highway with similar cold temperature (always issues with this car in the cold, hybrid battery system fails in cold below 40 or temperatures higher than 90). Last time a grounding issue was found in the transmission and was replaced. I will be contacting the dealership for repair today will update if it is still grounding issues or something new causing same problem. As i made in my last nhtsa report in january on this vehicle, the fact this car shuts down while in motion and you have no control over the car is dangerous and can cost people their lives. As a hybrid system, the van should automatically switch to gas only and bypass the hybrid charging system to continue functioning as any car would. By shutting down the engine and everything you are jeopardizing the lives of everyone on the roads. Both incidents of mine occurred on a highway at high speeds. I am just thankful I was not on a bridge at the time it failed as it would have caused an accident. I heard nothing about or from my last nhtsa report. Please for the safety of everyone look into these hybrids. Look into this car history and you'll see the constant repairs it has had.

Was driving at 72-74mph on Dallas North Tollway on Oct 6th. Vehicle is a Chrysler Pacifica Hybrid 2021 model - Limited Plug in Hybrid trim. Battery charge was 2% (less than 1 mile range) Fuel was 95% showing 395 miles of range left After the battery depletes, the vehicle is supposed to switch over into ICE mode (Gas engine kicks on) Car was running only on Electric power and when the battery hit 0%, the car stalled on the highway and showed multiple warning lights Service Hybrid Electric System Charge system not available EBD2 Engine Malfuction Transmission Temperature Automatic Transmission Fluid overheating Check Engine light Car still had power (power steering and brakes working) but lost all propulsion suddenly Luckily i was able to safely pull over on the shoulder Turned car off and on and still had same warning lights and car's engine would not start Finally waited 15 minutes, disconnected battery (12v) and tried it and now engine started Came home and charged battery to 100% (showed 32 miles of range) but now car will never run on Electric motors - Only via Gas engine This is a serious safety issue - I had the same exact problem on my 2018 Pacifica Plugin Hybrid which was diagnosed as a HCM (Hybrid Control Module) issue. It was the subject of a recall. This is the 2021 model with less than 25,000 miles and its still a major safety concern. Chrysler should immediately address the problem and issue a safety recall Car is currently at Frisco Chrysler Dodge Jeep Ram for the last 7 days waiting to be diagnosed

The charging system is shutting down my vehicle while driving in high speed heavy traffic. I was traveling with my grandchildren and my dog and my vehicle stopped in 90+ degree weather in the middle of no where. Once it ran again I got it to a charging station so I could continue my travels. The check engine light went away and we were traveling home when the charging system shut us down again doing 65 mph on the interstate about 30 miles from any town with no cell service. My vehicle had to be towed from the 30 miles to the closest town and then towed again from the closest town to the closest Chrysler dealership. They can't even get to my vehicle for over 3 weeks and I am out thousands of dollars in rental car fees. I even took my car to the Chrysler dealer before my trip because the check engine light came on and they ran a diagnostics that said my front camera wasn't working. No a single thing about the problems I was about to encounter for about the 5th time!! This happened last year also and I was without a working vehicle for almost 2 1/2 months. This has been an ongoing problem that started about 5 months after I purchased my vehicle. I don't feel safe on the roads because the vehicle just STOPS!! This a such a lemon of a car and the Chrysler dealer knew about these problems before they sold me my vehicle.

While driving above referenced vehicle, I was driving southbound on Hwy 515 when i noticed a vehicle driving northbound began to lose control, so i slowed down and then began to watch the vehicle cross the median and headed straight for me. I pushed the pedal to the floor to accelerate to get out of his way but the vehicle did not respond, i pushed the pedal again on several occasions and the vehicle just bucked and did not accelerate. Unfortunately the vehicle hit me right in the door at a high rate of speed. Unbeknownst to me this vehicle had been in the shop on several occasions for this exact problem: This can all be verified due to the fact i had a Chrysler service manager on the phone as this horrific experience unfolded

Between March 1, 2023 and April 6, 2023, the engine experienced unexpected shutdown on 4 different days. On April 7, 2023, a dealer in Madison, WI serviced the car under recall notice 03A. On April 17, 2023, the car's dash presented a warning message "Stop Safely: Vehicle will shut off soon." On all occasions I have waited 30 seconds and restarted the car successfully. This behavior of the car is unacceptable. It is likely that I will be driving in a situation where it will not be safe to shut down the car, come to a stop, and restart it while driving in traffic.

Chrysler issued a safety notice to me last week via mail, which informed me that my vehicle may stop at any time without warning. This is a serious safety and accessibility issue for me, as this is my family's sole vehicle. There is no ETA for when or if a repair will be available. I have ceased using the vehicle on any highway and keep speeds under 40 mph for safety reasons, but am incredibly scared to do so and have gotten no support from Chrysler. The dealership offered no assistance. The recall hotline informed me verbatim that "there is no plan nor expected plan to provide a loaner, rental, or other compensation to those affected by this recall" on a call on 3.10.23. Chrysler's corporate call center informed me of the same thing but informed me I could submit any costs for transportation or a rental vehicle and they would "consider" reimbursement. I am currently paying on a vehicle that is not safe to use. Chrysler is offering me no remedies at all.