Engine. Review the 373 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 287 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 174 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

27 crash reports14 fire reports14 injury reports

Power Train complaints

155 reports

Clear category filter

2,500 miles · Jul 18, 2019

Power Train

Read full complaint

WHEN DRIVING FORWARD SPEED AROUND 10-20 MILES AN HOUR OR 1500 -1750 RPM, THE TRANSMISSION WILL SHIFT EXTREMELY HARD (IT FEELS LIKE SOMEONE IS HITTING THE CAR FROM BEHIND-IT IS A VIOLENT SHIFT). I HAVE TAKEN THIS VEHICLE IN SEVERAL TIMES SINCE PURCHASING NEW IN FEBRUARY 2018. THEIS OCCURS TWO TO THREE TIMES A DAY OR EVEN MORE DURING THE WEEK. I HAVE EXPERIENCED THIS ISSUE PULLING FORWARD FROM MY DRIVE WAY TO GETTING ON THE HIGHWAY AND ACCELERATING. I HAVE TAKEN IT TO THE DEALERSHIP AND THEY HAVE DONE FLASH RESETS SEVERAL TIMES WITH NO SUCCESS. I THINK HAVING A BRANDNEW VEHICLE DOING THIS IS UNACCEPTABLE AND VERY DANGEROUS WITH THE VIOLENT SHIFTING. I WAS TOLD THE NEW 9 SPEED TRANSMISSIONS ALL ARE HAVING THIS TYPE OF ISSUE.

NHTSA ODI #11233248

Mileage unknown · Jul 10, 2019

Power Train

Read full complaint

TL* THE CONTACT OWNS A 2018 CHRYSLER PACIFICA. WHILE DRIVING 15 MPH, THE VEHICLE JERKED BACK AND FORTH WITHOUT WARNING. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AUTONATION CHRYSLER DODGE JEEP RAM PEMBROKE PINES (954-446-8775, LOCATED AT 13601 PINES BOULEVARD, PEMBROKE PINES, FL 33027), BUT THE FAILURE COULD NOT BE DUPLICATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER. THE DEALER COULD NOT DUPLICATE THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ODI #11230693

9,000 miles · May 26, 2019

Power Train

Read full complaint

SEPT 2018 AT APPROXIMATELY 9000 MILES: COMPLETE LOSS OF POWER WHILE DRIVING. ALL SYSTEMS RELAYED ERROR MESSAGES SUCH AS "POWER STEERING NOT AVAILABLE." LOST POWER STEERING AND POWER BRAKES. CAR COULD NOT BE PUT IN NEUTRAL OR PARK OR RESTARTED. THE VEHICLE WAS TOWED TO THE SHOP WHERE THEY REPLACED THE TRANSMISSION. IN DECEMBER THE CAR BEGAN HAVING ISSUES WITH THE AUTO START/STOP CAUSING THE CAR TO LOSE POWER WHILE STOPPED AT A LIGHT. IT WAS WORKED ON 3 TIMES FOR THIS OVER THE NEXT SEVERAL MONTHS, TO DATE THERE HAVE NOT BEEN ANY ISSUE OF THIS REOCCURRING. IN MAY 2019 AT 18000 MILES IT WAS RETURNED TO THE SHOP FOR A WHINING SOUND IN THE TRANSMISSION AND THEY REPLACED THE TRANSMISSION AGAIN.

NHTSA ODI #11210087

15,000 miles · May 21, 2019

Power Train

TAKARA RECALL. WHILE TAKING OFF FROM A STOP MY TRANSMISSION SHIFTS INTO A GEAR VERY HARD. IT MAKES A LOAD BANG AND YOU CAN FEEL IT. IT FEELS LIKE YOU GOT HIT. IT SEEMS TO BE GETTING WORSE.

NHTSA ODI #11209079

9,605 miles · May 21, 2019

Power TrainSuspension

Read full complaint

TL* THE CONTACT OWNS A 2018 CHRYSLER PACIFICA. WHILE DRIVING 25 MPH, THE CONTACT HEARD A LOUD ABNORMAL NOISE. THE CONTACT WAS ABLE TO PARK THE VEHICLE ON THE SIDE OF THE ROAD. WHILE SHE WAS EXITING THE VEHICLE, THE CONTACT NOTICED THAT THE FRONT DRIVER'S SIDE WHEEL WAS TURNED COMPLETELY TO THE LEFT. THE VEHICLE WAS TOWED TO ORCHARD CHRYSLER DODGE JEEP RAM (LOCATED AT 64600 VAN DYKE, WASHINGTON, MI 48095, (586) 430-5086) WHERE IT WAS DIAGNOSED THAT THE TIE ROD AND AXLES NEEDED TO BE REPLACED. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED PER AN UNKNOWN RECALL. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 9,605. *BF CONSUMER STATED AFTER THE ACCIDENT, THERE WAS A RECALL ON THE RIGHT SIDE TIE ROD. CONSUMER WANTS TO KNOW IF THE LEFT SIDE IS DEFECTIVE.*JB

NHTSA ODI #11209013

24,500 miles · Mar 8, 2019

EnginePower Train

Read full complaint

VEHICLE WAS BRIEFLY STOPPED IN TRAFFIC AT A LIGHT WITH ELECTRONIC START-STOP ENGAGED. WHEN FOOT WAS REMOVED FROM THE BRAKE, THE ENGINE STARTED BACK UP MOMENTARILY THEN SPUTTERED TO A STOP. THE ENGINE START/STOP BUTTON AND SHIFT KNOB WERE UNRESPONSIVE (COULD NOT SHIFT GEARS). NEUTRAL OVERRIDE CORD WAS PULLED, BUT INEFFECTIVE BECAUSE ELECTRONIC PARKING BRAKE STILL SEEMED TO BE ENGAGED. THE VEHICLE COULD NOT BE MOVED OUT OF TRAFFIC INTO A SAFE LOCATION AND HAD TO BE TOWED TO DEALERSHIP. HEATING AND POWER WINDOWS TURNED OFF AS WELL, AND POSSIBLY THE HAZARD LIGHTS WERE INEFFECTIVE (UNSURE BECAUSE IT WAS UNSAFE TO LEAVE THE VEHICLE AND CHECK).

NHTSA ODI #11185066

5,800 miles · Mar 7, 2019

Electrical SystemPower Train

VEHICLE CAME TO A STOP AND THEN SHUTDOWN SUDDENLY. VEHICLE WOULD NOT RESPOND TO INPUT AND CREATED A POTENTIALLY DANGEROUS SITUATION AND WE WERE STOPPED IN A DIVIDED MEDIAN WITHOUT POWER. DISPLAY SAYS "FCC SERVICE REQUIRED" AND THEN PROCEEDS TO SAY START/STOP REQUIRED AND CAUSED THE ENGINE TO DIE. REQUIRED PUTTING THE VEHICLE IN …

Read full complaint

NHTSA ODI #11184845

8,000 miles · Mar 5, 2019

Electrical SystemEnginePower Train

VEHICLE RANDOMLY LOSES POWER DRIVING DOWN THE ROAD. TRANSMISSION JERKS AND SOMETIMES SHIFTS TO PARK WHILE MOVING.

NHTSA ODI #11184261

5,500 miles · Feb 25, 2019

Fuel/propulsion SystemPower Train

Read full complaint

THE VEHICLE DURING OPERATION SUDDENLY DECELERATED AND WOULD NOT MOVE ON TWO OCCASIONS. THE FIRST OCCASION HAPPENED LESS THAN 1000 MILES ON THE OD. THE VEHICLE WAS TRAVELING AT 30MPH ON A CITY STREET WHEN IT LOST POWER TO THE WHEELS AND HAD TO PULL OFF THE ROAD. THE ENGINE WAS STILL RUNNING BUT THE VEHICLE WOULD NOT DRIVE. HAD TO TURN IT OFF AND ON AGAIN FOR IT TO OPERATE. THE SECOND OCCASION AT 5500 MILES IT JUST STOPPED AFTER PULLING OUT FROM A STOP SIGN IN THE MIDDLE OF AN INTERSECTION. THE TRACTION CONTROL LIGHT WENT ON BRIEFLY AS IT WAS STOPPING. AGAIN THE ENGINE WAS ON BUT IT WOULD NOT MOVE. HAD TO RESTART THE VEHICLE FOR IT TO OPERATE.

NHTSA ODI #11182239

4,260 miles · Feb 11, 2019

EnginePower Train

Read full complaint

ENGINE TURNED OFF/STALLED WITHOUT WARNING WHILE IN DRIVE GOING ABOUT 35 MPH ON A HIGHWAY EXIT RAMP. CHIMES STARTED BONGING AND 'D' ON DASHBOARD STARTED BLINKING. I WAS ABLE TO BRAKE TO A STOP. MSG APPEARED TO PUT CAR IN PARK TO RESTART. CAR RESTARTED IMMEDIATELY. THIS PROBLEM SOUNDS SIMILAR TO 2018 RECALL U87 FOR ENGINE STALLING, BUT MY VIN IS NOT COVERED IN RECALL. ALSO, NOTE THE 2017 RECALL U01 FOR ENGINE STALLING. SOME CONSUMERS NOTED IN THEIR COMPLAINTS THAT THE "FIX" DID NOT WORK. THIS IS VERY TROUBLING!! OBVIOUSLY TWO CONSECUTIVE YEAR RECALLS FOR ENGINE STALLING DOES NOT INSPIRE CONFIDENCE THAT THE PROBLEM HAS BEEN ADEQUATELY ADDRESSED. I DO NOT FEEL SAFE IN THIS CAR. SEE CURRENT REPORTED COMPLAINTS (FOR SAME PROBLEM) ONLINE: HTTP://WWW.ARFC.ORG/COMPLAINTS/2018/CHRYSLER/PACIFICA/ENGINE/PROBLEM.ASPX HTTP://WWW.CARPROBLEMZOO.COM/CHRYSLER/PACIFICA/2018/ENGINE-SHUT-OFF-WITHOUT-WARNING-PROBLEMS.PHP....*BF.. *TR

NHTSA ODI #11176151

Official recalls

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

23V010000 · Electrical System:wiring:connectors/plugs/receptacles; Hybrid Propulsion System: Inverter

Jan 17, 2023

Chrysler (FCA US, LLC) is recalling certain 2017-2023 Pacifica Plug-In Hybrid Electric vehicles (PHEVs). An internal transmission wiring connector may short circuit, resulting in an unexpected engine shutdown.

Consequence & remedy

Consequence: An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will update the Power Inverter Module (PIM) software and, if necessary, update the instrument panel cluster (IPC) and the electronic control module (ECM) software, free of charge. FCA US will notify dealers and begin notifying owners on or about: 03/21/2023 for 2021 model year vehicles, 05/02/2023 for 2019-2020 model year vehicles, and 06/15/2023 for 2017-2018 model year vehicles. FCA began notifying owners on February 23, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 03A.

Additional source detail variants (2)

Electrical System:wiring:connectors/plugs/receptacles

Consequence: An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will update the Power Inverter Module (PIM) software and, if necessary, update the instrument panel cluster (IPC) and the electronic control module (ECM) software, free of charge. FCA US will notify dealers and begin notifying owners on or about: 03/21/2023 for 2021 model year vehicles, 05/02/2023 for 2019-2020 model year vehicles, and 06/15/2023 for 2017-2018 model year vehicles. FCA began notifying owners on February 23, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 03A.

Hybrid Propulsion System: Inverter

Consequence: An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash.

19V886000 · Back Over Prevention: Sensing System: Camera; Equipment:electrical:radio/tape Deck/cd Etc.

Dec 12, 2019

Chrysler (FCA US LLC) is recalling certain 2018-2019 Pacifica vehicles equipped with an 8.4 inch radio display, 360 degree surround view camera system, and seat back video screens. A software error can cause the rearview camera image to remain displayed on the radio after the vehicle has been shifted out of reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."

Consequence & remedy

Consequence: The lingering rearview image can distract the driver, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will update the radio software, free of charge. The recall began January 9, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VE2.

Additional source detail variants (2)

Back Over Prevention: Sensing System: Camera

Consequence: The lingering rearview image can distract the driver, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will update the radio software, free of charge. The recall began January 9, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is VE2.

Equipment:electrical:radio/tape Deck/cd Etc.

Consequence: The lingering rearview image can distract the driver, increasing the risk of a crash.

19V348000 · Electrical SYSTEM:12V/24V/48V Battery

May 9, 2019

Chrysler (FCA US LLC) is recalling certain 2017-2019 Pacifica vehicles equipped with engine stop/start systems. A loose battery ground connection may result in an intermittent loss of power steering assist and/or a stall.

Consequence & remedy

Consequence: A loss of power steering assist or a stall can increase the risk of crash.

Remedy: Chrysler will notify owners, and dealers will inspect the battery ground surfaces, clean the contact surfaces as needed, and properly reassemble the ground connection, free of charge. The recall began May 24, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. FCA US' number for this recall is V53.

19V143000 · Suspension:front:control Arm:lower Arm

Feb 28, 2019

Chrysler (FCA US LLC) is recalling certain 2018 Chrysler Pacifica and Pacifica hybrid vehicles. The right front lower control arm may separate from the steering knuckle.

Consequence & remedy

Consequence: A control arm separation could increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the right front knuckle and lower control arm for damage, replacing the components as necessary. The right front lower control arm knuckle pinch bolt will be replaced with a larger-diameter pinch bolt. These repairs will be performed free of charge. The recall began April 26, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V15.

18V524000 · Electrical System:wiring:front Underhood

Aug 9, 2018

Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.

Consequence & remedy

Consequence: A vehicle stall can increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.

18V492000 · Power Train:automatic Transmission

Jul 26, 2018

Chrysler (FCA US LLC) is recalling certain 2019 Jeep Cherokee vehicles and 2018 Chrysler Pacifica non-hybrid vehicles. A component in the transmission may not have been welded properly, possibly causing the transmission to not transmit engine power to the wheels.

Consequence & remedy

Consequence: If the transmission weld fails, the vehicle will stop moving, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the transmission, free of charge. The recall is expected to begin September 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U85.

18V493000 · Power Train:axle Assembly:axle Shaft

Jul 26, 2018

Chrysler (FCA US LLC) is recalling certain 2018 Chrysler Pacifica vehicles. The front axle halfshafts may have been incorrectly assembled, preventing the shaft from being properly secured to the constant-velocity (CV) joint.

Consequence & remedy

Consequence: If the axle shaft disengages from the CV joint, the vehicle will have a loss of drive or allow the vehicle to move while in the "Park" position. Either condition may increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the left or right halfshaft assembly, free of charge. The recall began September 18, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U80.

18V395000 · Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module; EQUIPMENT:ELECTRICAL:ANTI-THEFT Devices

Jun 14, 2018

Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica vehicles. The Manual Park Release (MPR) plug may be removed without a tool. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."

Consequence & remedy

Consequence: If the MPR is engaged unintentionally, the vehicle could roll away striking and injuring a bystander or cause a crash.

Remedy: Chrysler will notify owners, and dealers will replace the MPR plug, free of charge. The recall began July 9, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U50.

Additional source detail variants (2)

EQUIPMENT:ELECTRICAL:ANTI-THEFT Devices

Consequence: If the MPR is engaged unintentionally, the vehicle could roll away striking and injuring a bystander or cause a crash.

Remedy: Chrysler will notify owners, and dealers will replace the MPR plug, free of charge. The recall began July 9, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U50.

Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module

Consequence: If the MPR is engaged unintentionally, the vehicle could roll away striking and injuring a bystander or cause a crash.

18V332000 · Electrical System:software; Electrical System:wiring; Vehicle Speed Control:cruise Control

May 17, 2018

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence & remedy

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Additional source detail variants (3)

Electrical System:software

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Vehicle Speed Control:cruise Control

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Electrical System:wiring

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

17V824000 · Equipment

Dec 21, 2017

Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence & remedy

Consequence: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.

Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.

17V542000 · Seat Belts:rear/other

Aug 31, 2017

Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica vehicles equipped with the 8-passenger seating option. In certain passenger seating and vehicle situations, the second-row center seating position seat belt buckle could cause the left outboard seat belt to become unlatched.

Consequence & remedy

Consequence: Inadvertent unlatching of the left outboard seat belt can increase the risk of injury in the event of a crash.

Remedy: Chrysler will notify owners, and dealers will install a shorter second-row seat belt buckle, free of charge. The recall began October 26, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T54.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE25009 · Intermittent Loss Of Electric Power Steering

Opened Sep 5, 2025 · No close date supplied

Status: open (inferred from source dates) · Steering:electric Power Assist System

The Office of Defects Investigation (ODI) is opening this Preliminary Evaluation to assess the scope, frequency, and potential safety consequences of alleged defects related to the electric power steering (EPS) system in model year (MY) 2017–2018 Chrysler Pacifica vehicles. ODI has received 94 Vehicle Owner Questionnaires (VOQs) reporting a condition in which the steering system exhibits a sticking sensation during gradual turns, particularly when the steering wheel is positioned near the 11 o'clock or 1 o'clock position. Complainants allege that during these events, increased steering effort is required to return the wheel to center. In many cases, this is followed by a sudden reactivation of EPS assistance, which may result in an oversteer condition. This behavior could increase the risk of a crash, especially at higher speeds. ODI has identified multiple VOQs describing similar symptoms. This investigation will assess the frequency, root cause, and potential safety-related consequences of the alleged EPS malfunction. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

RQ24004 · Loss Of Motive Power Due To An Internal Wiring Connector Short.

Opened Feb 27, 2024 · No close date supplied

Status: open (inferred from source dates) · Electrical System:wiring

On July 22, 2022, the Office of Defects Investigation (ODI) opened investigation PE22-008 regarding complaints alleging a loss of motive power condition potentially due to a transmission malfunction in Model Years 2019-2021 Chrysler Pacifica Plug-In Hybrid Electric Vehicles (PHEV). On January 17, 2023, Fiat Chrysler Automobiles (FCA) issued safety recall (NHTSA Recall 23V-010) involving 2017-2023 Model Years (MY) Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016, through January 9, 2023. The recall states that the loss of motive power condition in these vehicles is caused by an internal transmission wiring connector that may short circuit, resulting in an unexpected engine shutdown. An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash. In discussions with FCA on Recall 23V-010, ODI confirmed the recall was related to investigation PE22-008. The remedy for 23V-010 is to update the Power Inverter module (PIM) and/or Instrument Panel Cluster (IPC) software to provide drivers a message stating “Stop Safely - Vehicle Will Shut Off Soon” followed by a chime and MIL, PRNDL blinking (on cluster and shifter knob), low SOC (State of Charge) warning and reduced power mode. The recall remedy does not replace the defective hardware that was described in Recall 23V-010, and the wiring connector short still exists on these vehicles. To date, ODI has received 132 reports for the population of vehicles subject to recall 23V-010. These reports allege a loss of motive power condition that reduces the vehicles speed, followed by dashboard warning lamps displaying messages associated with recall 23V-010. The presence of these warning lamps and messages indicates the vehicle likely had the recall remedy applied. Follow up discussions with FCA confirm their remedy does not prevent a loss of motive power, but instead limits torque to the engine and after an unspecified number of miles or period of time, the engine will shut down. When this occurs, FCA relies on the owner to transport the vehicle to a dealership after they experience a loss of motive power condition, at which time the defective hardware is replaced. Furthermore, the dashboard messages introduced in the recall remedy may cause the driver to pull over in an unsafe location. Pulling over in an unsafe location may expose the occupants to undue harm. The Office of Defects Investigation is opening this Recall Query (RQ) to assess the adequacy, frequency, and safety consequence of the remedy for recall 23V-010. To review the ODI reports cited in the opening resume ODI report identification number document, go to NHTSA.gov.

RQ24001 · Ignition-off High Voltage Battery Fire (remedy Effectiveness Of Recall 22V-077)

Opened Jan 16, 2024 · No close date supplied

Status: open (inferred from source dates) · Electrical System:propulsion System:traction Battery

On February 11, 2022, Fiat Chrysler Automobiles (FCA) issued a safety recall (NHTSA Recall 22V-077) on all 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016 through August 7, 2018. The recall addresses ignition “OFF’ fires that originate at the high voltage (HV) battery pack assembly. An ignition ‘OFF’ vehicle fire can result in an increased risk of occupant injury, injury to persons outside the vehicle, and property damage, with little to no warning. At the time of the recall filing the root cause of the vehicle fires was unknown and under investigation by FCA and suppliers. A software remedy designed to improve thermal event detectability by monitoring battery diagnostics is currently being installed on subject vehicles as an interim remedy. As of November 23, 2023, the root cause of the battery failure is unknown. From December 2022 through December 2023, NHTSA has received four consumer complaints (VOQs) alleging vehicle thermal events involving recalled 2017 and 2018 Chrysler Pacifica PHEVs. Additional information collected from complainants confirmed a thermal event originating near or at the HV battery pack after the Recall 22V077 remedy had been applied to the vehicle. Follow up meetings with FCA and suppliers in November and December 2023 to discuss the ongoing root cause investigation and post-recall remedy incidents indicated a recent increase in HV battery thermal events. Furthermore, a review of NHTSA complaint data indicated the post-recall HV battery thermal event complaint rate now exceeds pre-recall levels. The Office of Defects Investigation (ODI) is opening this Recall Query (RQ) to review the effectiveness of the original recall remedy, understand the root cause of the battery fires, investigate additional reports of Pacifica PHEV HV battery fires, and to increase monitoring of the manufacturer root cause investigation. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

PE22008 · Transmission Fault Leading To Loss Of Motive Power

Opened Jul 22, 2022 · Closed Mar 27, 2024

Status: closed (inferred from source dates) · Power Train

On July 22, 2022, the Office of Defects Investigation (ODI) opened PE22008 to investigate allegation of loss of motive power, potentially due to transmission malfunction, in certain Chrysler Pacifica vehicles. In a January 17, 2023 letter to NHTSA, Fiat Chrysler Automobiles (FCA) submitted recall notice 23V-010 involving a transmission motor wiring defect in 67,118 model year (MY) 2017-2023 Chrysler Pacifica plug-in hybrid electric vehicles (PHEVs) manufactured from August 12, 2016 through January 9, 2023. FCA determined that an internal transmission connector short could result in an unexpected engine shutdown under certain conditions. Follow up correspondence with FCA confirmed this defect results in an electric motor position trouble code that was the basis for opening PE22008, therefore NHTSA is closing this investigation. The 23V-010 recall remedy is a software update to address the hardware failure associated with PE22008. When a hardware failure is detected, the vehicle limits motive power while instructing the driver to pull over to a safe location. NHTSA is concerned that drivers will pull over to an unsafe location when the warning message associated with the recall remedy displays on the dashboard. Due to the nature of the recall remedy and related reports, NHTSA has opened Recall Query RQ24004 to assess the recall remedy. The reports and failure report summary values included with this closing action are related to allegations of Recall 23V-010 remedy inadequacy. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.