IllustrationTL* THE CONTACT OWNS A 2006 CHRYSLER PACIFICA. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE, THE INDEPENDENT MECHANIC DISCOVERED THAT THE ENTIRE SUBFRAME WAS CORRODED AND RUSTED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT SAFE TO OPERATE. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 76,000.
2006 Chrysler Pacifica
Owner reports · Recalls · Investigations
More warning signs than most Pacifica years
Owner complaints for the 2006 Chrysler Pacifica are substantially higher than the model-year median of 189.
About this comparison →How this year compares
Owner complaints by model year
Compare all Pacifica years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
480–25K
6925–50K
10350–75K
12275–100K
195100–150K
79150K+
616 reports with mileage · 110 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 198 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 146 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports7 fire reports16 injury reports
What owners actually said
726 reportsMY SUB-FRAME IS RUSTING OUT ON MY CAR. I SEE THAT THERE IS A CLASS ACTION LAWSUIT REGARDING THIS HAZARDOUS CONDITION. BY DOING RESEARCH, I UNDERSTAND THAT THE ENGINE CRADLE CAN FALL OUT. I HAVE A 2006 CHRYSLER PACIFICA TOURING.
A FEW WEEKS BEFORE THIS HAPPENED, I NOTICED MY REAR TIRE LEANING OUTWARD. TOOK IT TOO THE SHOP A FEW TIMES WONDERING WHAT WAS THE CAUSE. IT WAS DETERMINED FROM A DEALERSHIP IT WAS THE STRUTS. I WAS TOLD THE PACIFICA WAS KNOWN FOR IT. SO I HAD THE STRUTS REPLACED. IT HELPED BUT THE TIRE WAS STILL LEANING, IT WASN'T PERFECT LIKE T…
Read full complaint
A FEW WEEKS BEFORE THIS HAPPENED, I NOTICED MY REAR TIRE LEANING OUTWARD. TOOK IT TOO THE SHOP A FEW TIMES WONDERING WHAT WAS THE CAUSE. IT WAS DETERMINED FROM A DEALERSHIP IT WAS THE STRUTS. I WAS TOLD THE PACIFICA WAS KNOWN FOR IT. SO I HAD THE STRUTS REPLACED. IT HELPED BUT THE TIRE WAS STILL LEANING, IT WASN'T PERFECT LIKE THE REST. I WAS TOLD THAT THERE WAS NO OTHER REASON BECAUSE EVERYTHING LOOKED GOOD UNDERNEATH AND SUSPENSION. I LOOKED SEVERAL TIMES, MYSELF. NOT SEEING ANY MAJOR RUST OR ANYTHING UNSAFE. THEN DRIVING ON THE FREEWAY 150 MILE'S FROM HOME, AT 70 MPH, A HARD BANG AND THE REAR END LIFTED UP AND DROPPED DOWN. CAR UNCONTROLLABLE. FINALLY ABLE TO STOP AND REALIZE THE SUBFRAME DROPPED RIGHT OUT OF THE CAR LEAVING MY REAR DIFFERENTIAL ON THE GROUND. IT HAD RUSTED FROM THE TOP OF THE SUBFRAME DOWN. LOOKED ON LINE AND SEEN IT WAS HAPPENING TO OTHER PEOPLE. CALLED CHRYSLER WAS TOLD MY PROBLEM. HENCE MY FIRST AMERICAN MADE CAR AND MY LAST. POS!!!
TL* THE CONTACT OWNS A 2006 CHRYSLER PACIFICA. THE CONTACT STATED THAT THE ENGINE CRADLE PREMATURELY RUSTED TO THE POINT THAT IT WAS CORRODED AND MAY FRACTURE. THE VEHICLE WAS TAKEN TO A MECHANIC, WHO INSPECTED AND DIAGNOSED THAT THE ENGINE CRADLE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMA…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHRYSLER PACIFICA. THE CONTACT STATED THAT THE ENGINE CRADLE PREMATURELY RUSTED TO THE POINT THAT IT WAS CORRODED AND MAY FRACTURE. THE VEHICLE WAS TAKEN TO A MECHANIC, WHO INSPECTED AND DIAGNOSED THAT THE ENGINE CRADLE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 163,000.
WHEN TAKING MY 2006 CHRYSLER PACIFICA TO BE SERVICED FOR BROKEN MOTOR MOUNT. MY VEHICLE WAS BROUGHT IN THE SHOP, NOT EVEN 30 MINUTES PASSED AND I WAS CONTACTED IMMEDIATELY BY THE MECHANIC, THAT IN THE PROCESS OF REPLACING MY MOTOR MOUNT HE NOTICED THAT MY CRADLE WAS ROTTED OUT AND VERY UNSAFE TO DRIVE BECAUSE THIS WAS A VERY IMP…
Read full complaint
WHEN TAKING MY 2006 CHRYSLER PACIFICA TO BE SERVICED FOR BROKEN MOTOR MOUNT. MY VEHICLE WAS BROUGHT IN THE SHOP, NOT EVEN 30 MINUTES PASSED AND I WAS CONTACTED IMMEDIATELY BY THE MECHANIC, THAT IN THE PROCESS OF REPLACING MY MOTOR MOUNT HE NOTICED THAT MY CRADLE WAS ROTTED OUT AND VERY UNSAFE TO DRIVE BECAUSE THIS WAS A VERY IMPORTANT COMPONENT ON MY VEHICLE, (STEERING, ENGINE, TRANSMISSION AND ECT.) ARE BEING HELD UP BY THE CRADLE, AND THE MECHANIC STATED THAT THE ENGINE CAN FALL OUT AT ANYTIME! I AM IN FEAR FOR MY FAMILY AND I, TO KNOW THAT WE TRAVEL AT HIGH SPEEDS ON THE FREE WAY. WE LIVE IN A CITY WHERE THERE ARE MANY POT HOLES AND CRATERS IN THE STREETS WE DRIVE ON, AND TO KNOW THAT WE CAN BE IN DANGER IS INSANE. HE QUOTED ME AROUND $3,000 TO REPAIR AND I CANNOT AFFORD TO COVER THIS ISSUE. THERE HAS TO BE SOMETHING DONE BY THE CHRYSLER CORP. HOPEFULLY THIS SPEAKS FOR MANY OWNERS OF THIS SAME VEHICLE.
TL* THE CONTACT OWNS A 2006 CHRYSLER PACIFICA. WHILE THE VEHICLE WAS AT AN INDEPENDENT MECHANIC FOR A ROUTINE OIL CHECK, THE TECHNICIAN NOTICED THAT THE FRONT END FRAME THAT HELD THE ENGINE WAS CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WA…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHRYSLER PACIFICA. WHILE THE VEHICLE WAS AT AN INDEPENDENT MECHANIC FOR A ROUTINE OIL CHECK, THE TECHNICIAN NOTICED THAT THE FRONT END FRAME THAT HELD THE ENGINE WAS CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 102,000. THE VIN WAS NOT AVAILABLE.
I TOOK THE CAR IN FOR AN OIL CHANGE AND WAS TOLD THE SUBFRAME WAS CORRODED. I WAS TOLD TO TAKE IT TO A DEAL TO HAVE IT INSPECTED. THE DEALER VERIFIED THAT THE SUBFRAME WAS RUSTED AND UNSAFE TO DRIVE. I CHECKED FOR RECALLS AND THERE WEREN'T ANY FOR 2006. THERE WERE RECALLS FOR 2004 AND 2005 WITH THE SAME PROBLEM STATING THAT T…
Read full complaint
I TOOK THE CAR IN FOR AN OIL CHANGE AND WAS TOLD THE SUBFRAME WAS CORRODED. I WAS TOLD TO TAKE IT TO A DEAL TO HAVE IT INSPECTED. THE DEALER VERIFIED THAT THE SUBFRAME WAS RUSTED AND UNSAFE TO DRIVE. I CHECKED FOR RECALLS AND THERE WEREN'T ANY FOR 2006. THERE WERE RECALLS FOR 2004 AND 2005 WITH THE SAME PROBLEM STATING THAT THE SUBFRAME WAS NOT PROPERLY COATED WHICH RESULTED IN THE RUST. THEY STATED THERE WAS A HIGHER INCIDENCE OF RUST IN SALT BELT STATES WHICH APPLIES TO THIS VEHICLE. THERE IS ALSO A CLASS ACTION SUIT FOR VEHICLES FROM 2004-2008. WHEN I CONTACTED CHRYSLER CUSTOMER SERVICE, THEY INFORMED ME THAT THERE WAS NO RECALL FROM 2006 AND THERE WAS NOTHING THEY COULD DO TO HELP. THEY FELT AS THOUGH THE PROBLEM HAD BEEN CORRECTED. I DISAGREE SINCE THE SAME PROBLEM OCCURRED A YEAR LATER. I FEEL AS THOUGH CHRYSLER IS RESPONSIBLE AND SHOULD CORRECT THIS PROBLEM.
MY REGULAR AUTOMOBILE SERVICE COMPANY RECENTLY COMPLETED A REPAIR AND REPLACEMENT OF THE FRONT BRAKE COMPONENTS ON MY 2006 CHRYSLER PACIFICA. UPON ROUTINE INSPECTION OF THE VEHICLE'S UNDERCARRIAGE, THEY IDENTIFIED SEVERE CORROSION OF THE "ENGINE CRADLE". THEY ADVISED THAT ENGINE CRADLE WAS IN VERY POOR CONDITION AND THAT FAILU…
Read full complaint
MY REGULAR AUTOMOBILE SERVICE COMPANY RECENTLY COMPLETED A REPAIR AND REPLACEMENT OF THE FRONT BRAKE COMPONENTS ON MY 2006 CHRYSLER PACIFICA. UPON ROUTINE INSPECTION OF THE VEHICLE'S UNDERCARRIAGE, THEY IDENTIFIED SEVERE CORROSION OF THE "ENGINE CRADLE". THEY ADVISED THAT ENGINE CRADLE WAS IN VERY POOR CONDITION AND THAT FAILURE WAS LIKELY IN THE NEAR FUTURE CAUSING THE ENGINE TO DROP OUT OF THE VEHICLE. I IMMEDIATELY CONTACTED THE CHRYSLER/DODGE DEALERSHIP WHERE I PURCHASED THE CAR. THEY TOLD ME THAT THEY WERE AWARE OF A PROBLEM WITH THE ENGINE CRADLES IN THAT MODEL YEAR PACIFICA, BUT THAT THERE CURRENTLY WAS NO RECALL TO CORRECT THE PROBLEM. I WAS QUOTED $3,000.00 TO REPLACE THE ENGINE CRADLE, WHICH I CAN NOT AFFORD. MY COMPLAINT IS THAT IF THIS IS A SAFETY ISSUE, WHY IS THERE NO RECALL OR ANY OTHER APPARENT EFFORT TO CORRECT THE PROBLEM? THE VEHICLE IS IN OTHERWISE GOOD SHAPE AND RUNS WELL, BUT I AM AFRAID OF DRIVING IT, CONCERNED THAT MY FAMILY OR I COULD BE SERIOUSLY INJURED. CAN YOU ASSIST ME?
WAS PULLING OUT TO CROSS A STREET AND CAR CUT OFF. I WAS CROSSING TRAFFIC AND STOPPED TO ONCOMING TRAFFIC. THE INCIDENT TOOK PLACE TWICE. ONLY THE 2ND TIME DID I ALMOST GET HIT BY ANOTHER VEHICLE. CURRENTLY CAR IS AT A CHRYSLER DEALER. THE PROBLEM IS I COULD HAVE BEEN HIT BY ONCOMING TRAFFIC.
TL* THE CONTACT OWNS A 2006 CHRYSLER PACIFICA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR ROUTINE MAINTENANCE, THE MECHANIC AT THE DEALER STATED THAT THERE WAS SEVERE RUST ON THE ENTIRE SUB FRAME OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHRYSLER PACIFICA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR ROUTINE MAINTENANCE, THE MECHANIC AT THE DEALER STATED THAT THERE WAS SEVERE RUST ON THE ENTIRE SUB FRAME OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 105,000. UPDATED 09/18/15*LJ *CN
Official recalls
106V432000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Nov 9, 2006
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE AND THE POWER TRAIN CONTROL MODULE (PCM) SOFTWARE MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN OPERATING CONDITIONS.
Consequence & remedy
Consequence: THIS COULD CAUSE A CRASH TO OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPROGRAM THE POWER TRAIN CONTROL MODULE. THE FUEL PUMP MODULE WILL ALSO BE REPLACED ON VEHICLES BUILT FROM AUGUST 1, 2004 THROUGH SEPTEMBER 30, 2004. THE RECALL BEGAN ON NOVEMBER 21, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA06013 · Engine Stalling
Opened Jun 22, 2006 · Closed Nov 29, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Power Train; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Vehicle Speed Control
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Additional source detail variants (7)
Engine And Engine Cooling
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Fuel System, Gasoline
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Fuel System, Gasoline:delivery
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Fuel System, Gasoline:delivery:fuel Pump
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Power Train
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Vehicle Speed Control
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
EA06010 · Fuel Tank Punctures
Opened Jun 15, 2006 · Closed Oct 11, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage; Fuel System, Other:storage:tank Assembly
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (4)
Fuel System, Gasoline:storage
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Other:storage
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Other:storage:tank Assembly
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
RQ06002 · Engine Stalling
Opened Feb 27, 2006 · Closed Jun 22, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Fuel System, Gasoline; Vehicle Speed Control
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
Additional source detail variants (3)
Engine And Engine Cooling
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
Fuel System, Gasoline
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
Vehicle Speed Control
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.