Illustration2004 CHRYSLER PACIFICA. IN THE PAST 3 MONTHS WE HAVE REPLACED THE MOTOR MOUNTS AND THE ANTILOCK BRAKING SYSTEM MODULE. WE NOW HAVE A THROWN ROD IN THE MOTOR OR A MAJOR CYLINDER PROBLEM. THE VEHICLE ONLY HAS 80,000 MILES ON IT AND WE MAINTAIN IT REGULARLY. ARE THERE ANY OTHER PROBLEMS THAT ARE COMMON FOR THIS VEHICLE? *TR
2004 Chrysler Pacifica
Owner reports · Recalls · Investigations
More warning signs than most Pacifica years
Owner complaints for the 2004 Chrysler Pacifica are substantially higher than the model-year median of 189.
About this comparison →How this year compares
Owner complaints by model year
Compare all Pacifica years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
820–25K
7025–50K
9750–75K
14175–100K
257100–150K
104150K+
751 reports with mileage · 145 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 323 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 141 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 125 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
32 crash reports30 fire reports17 injury reports
Service Brakes, Hydraulic complaints
10 reports2004 CHRYSLER PACIFICA HAS A PROBLEM WITH THE MOTOR MOUNTS. CONSUMER STATES THE MOUNTS HAVE BEEN ON BACK ORDER SINCE DEC. 2008. *NJ THE CONSUMER STATED A NOISE WAS HEARD WHEN GONG OVER BUMPS IN THE ROAD. THE ANTI-LOCK WHEEL SENSOR WAS BAD, THE TIRE LIGHT ILLUMINATED, THE LOWER CONTROL ARMS AND FRONT SWAY BAR WERE REPLACED. T…
Read full complaint
2004 CHRYSLER PACIFICA HAS A PROBLEM WITH THE MOTOR MOUNTS. CONSUMER STATES THE MOUNTS HAVE BEEN ON BACK ORDER SINCE DEC. 2008. *NJ THE CONSUMER STATED A NOISE WAS HEARD WHEN GONG OVER BUMPS IN THE ROAD. THE ANTI-LOCK WHEEL SENSOR WAS BAD, THE TIRE LIGHT ILLUMINATED, THE LOWER CONTROL ARMS AND FRONT SWAY BAR WERE REPLACED. THE MOTOR MOUNTS WERE LEAKING OIL. THE INSTRUMENT CLUSTER WAS NOT WORKING AND THE EGR VALVE WAS REPLACED. *JB
THE FRONT ROTORS ON MY 2004 CHRUSLER PACIFICA ARE IN NEED OF "TURNING" AGAIN FOR THE SECOND TIME. THE FRONT ROTORS WERE FIRST TURNED BY CHRYSLER IN JANUARY 2006 AT ROUGHLY 40000 MILES, BUT NEED TURNING AGAIN NOW AT NEAR 50000 MILES. THIS, TO ME, IS INDICATIVE OF A WEAKNESS IN THE DESIGN OF THE BRAKE SYSTEM. *AK
WHEN DRIVING AT HIGHWAY SPEEDS OR SLOWER, WHEN SLOWING DOWN CAR WOULD SHAKE BAD,TOOK TO DEALER, SAID BAD TIRES. REPLACED TIRES KEEP DOING IT, BACK TO DEALER 3 WEEKS LATER LEFT TIRE ROD WAS BAD. DEALER REPLACED BRAKES, ROTORS AT 25,000 MILES, WE NOW HAVE 53,000 WHEN ROD GOES OUT. HELP ALSO TRANSMISSION PROBLEMS RESULTING IN LOOSE…
Read full complaint
WHEN DRIVING AT HIGHWAY SPEEDS OR SLOWER, WHEN SLOWING DOWN CAR WOULD SHAKE BAD,TOOK TO DEALER, SAID BAD TIRES. REPLACED TIRES KEEP DOING IT, BACK TO DEALER 3 WEEKS LATER LEFT TIRE ROD WAS BAD. DEALER REPLACED BRAKES, ROTORS AT 25,000 MILES, WE NOW HAVE 53,000 WHEN ROD GOES OUT. HELP ALSO TRANSMISSION PROBLEMS RESULTING IN LOOSE BOLTS IN FRONT AXLES LOUD CLUNK BACK AGAIN. *JB
2004 CHRYSLER PACIFICA - AT 31185 MILES THE VEHICLE HAD A CRACKED ROTOR. THE REAR PASSENGER SIDE ROTOR IS CLOSE TO DISINTEGRATING, THOUGH THE VEHICLE WAS MAINTAINED PER FACTORY SCHEDULE EVERY 3000 MILES AT A 5 STAR CHRYSLER DEALERSHIP. THIS COULD HAVE EASILY RESULTED IN A TOTAL BRAKE FAILURE, RISKING THE LIFE OF MY FAMILY. CHRYS…
Read full complaint
2004 CHRYSLER PACIFICA - AT 31185 MILES THE VEHICLE HAD A CRACKED ROTOR. THE REAR PASSENGER SIDE ROTOR IS CLOSE TO DISINTEGRATING, THOUGH THE VEHICLE WAS MAINTAINED PER FACTORY SCHEDULE EVERY 3000 MILES AT A 5 STAR CHRYSLER DEALERSHIP. THIS COULD HAVE EASILY RESULTED IN A TOTAL BRAKE FAILURE, RISKING THE LIFE OF MY FAMILY. CHRYSLER DOES NOT PROVIDE ANY GOODWILL COVERAGE FOR WHAT IS CLEARLY A SUPPLIER ISSUE. THE ROTOR IS CRACKED IN SEVERAL AREAS BUT IT IS FAR FROM BEING WORN. *JB
DT*: THE CONTACT STATED HAVING PROBLEMS WITH THE BRAKES. WHILE DRIVING 15 MPH THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALERSHIP WHO REPLACED THE FRONT BRAKES. THE BRAKE SENSORS DID NOT WORK PROPERLY WHEN THE INCIDENT OCCURRED. UPDATED 9/11/2006 - THE CALIPER BOLTS (SELF LOCKING) FELL OUT. THE DEALERSHIP INDICAT…
Read full complaint
DT*: THE CONTACT STATED HAVING PROBLEMS WITH THE BRAKES. WHILE DRIVING 15 MPH THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALERSHIP WHO REPLACED THE FRONT BRAKES. THE BRAKE SENSORS DID NOT WORK PROPERLY WHEN THE INCIDENT OCCURRED. UPDATED 9/11/2006 - THE CALIPER BOLTS (SELF LOCKING) FELL OUT. THE DEALERSHIP INDICATED THAT THIS SHOULD NEVER HAPPEN. *NM
BRAKES GRINDING AND SLIGHT VIBRATION, AS IF THE DISKS ARE WARPED. THE CAR HAS 21,000 MILES AND THE FRONT DISKS AND PADS WERE REPLACED SHORTLY AFTER I GOT THE CAR. MY MECHANIC SAID THE PADS ARE GOOD, BUT THE DISKS ARE DEFECTIVE; METAL PEELING OFF AND 40% WEAR ON THEM. CHRYSLER SAYS THIS IS NORMAL WEAR AND TEAR. *JB
I HAVE A 2004 CHRYSLER PACIFICA AWD, CURRENTLY HAS 50,000 MILES. WE HAVE HAD PROBLEMS SINCE WE DROVE IT OFF THE LOT. TIME AFTER TIME WE WERE TOLD THERE WERE NO CODES SIGNIFYING ANY PROBLEMS, AND THEY COULD NEVER DUPLICATE THE NOISES WE WERE EXPERIENCING. CLIMATE CONTROL SCREEN WENT OUT, THIS WAS REPLACED. MESSAGE DISPLAY WEN…
Read full complaint
I HAVE A 2004 CHRYSLER PACIFICA AWD, CURRENTLY HAS 50,000 MILES. WE HAVE HAD PROBLEMS SINCE WE DROVE IT OFF THE LOT. TIME AFTER TIME WE WERE TOLD THERE WERE NO CODES SIGNIFYING ANY PROBLEMS, AND THEY COULD NEVER DUPLICATE THE NOISES WE WERE EXPERIENCING. CLIMATE CONTROL SCREEN WENT OUT, THIS WAS REPLACED. MESSAGE DISPLAY WENT OUT, UNABLE TO SEE SAFETY WARNINGS, COMPASS, MENU DISPLAY STALLING WHEN TURNING AT SLOW SPEEDS POPPING AND CLUNKING NOISES WHEN TURNING SLOWLY LOAD CLANGING NOISE WHEN SHIFTING FROM PARK TO REVERSE, SOUNDS LIKE WE RAN OVER A LARGE METAL OBJECT. LEAKS ON DRIVER SIDE WHEN RAINING WARPED ROTORS AT 35,000 MILES FUEL GAUGE NEEDLE WILL PLUNGE FROM F TO E WHEN THERE IS A LEAST HALF TANK OF GAS. I HAVE TAKEN THE CAR IN ON NUMEROUS OCCASIONS, THEY CAN NEVER DUPLICATE THE PROBLEM NOISES TO DIAGNOSE OR FIX. *NM
BRAKES ON CHRYSLER ARE DEFECTIVE. THIS IS KNOWN BY CHRYSLER AT THEY WARRANT THE CAR FOR 36K BUTTHE BRAKES (ROTORS, PADS, LININGS AND DRUMS) ARE ONLY COVERED FOR 12K. IT IS OBVCIOUS CHRYSLER KNOWS THEY ARE NO GOOD THUS THE SHORT WARRANTY. IF THERE WERE ANY GOOD THEY SHOULD LAST FOR 50K OR MORE. VEHICLE ONLY HAS 26K.
DT: I WAS DRIVING ON FREEWAY AND SLOWED FOR OTHER TRAFFIC WHEN BRAKE PRESSURE APPLIED AND IT THEN BEGAN SHAKING AND STOPPED. UPON STOPPING IT REVVED THEN GEARED DOWN. TOOK TO DEALER, AND THEY MADE SOME ADJUSTMENTS TO THE TRANSMISSION, BUT SAID NOTHING WAS WRONG. THIS HAPPENED AGAIN. RETURNED TO DEALER, WHO THOUGHT THIS WAS…
Read full complaint
DT: I WAS DRIVING ON FREEWAY AND SLOWED FOR OTHER TRAFFIC WHEN BRAKE PRESSURE APPLIED AND IT THEN BEGAN SHAKING AND STOPPED. UPON STOPPING IT REVVED THEN GEARED DOWN. TOOK TO DEALER, AND THEY MADE SOME ADJUSTMENTS TO THE TRANSMISSION, BUT SAID NOTHING WAS WRONG. THIS HAPPENED AGAIN. RETURNED TO DEALER, WHO THOUGHT THIS WAS A COMPUTER PROBLEM, WHEN TRIED TO REPAIR IT THEY FRIED THE COMPUTER SYSTEM IN CAR. THE CAR STILL HAS THIS PROBLEM. CONTACT FEELS THIS CAR IS NOT DRIVABLE DUE TO THIS SITUATION. ALSO, HAS A CLANKING SOUND. HAS TO BEEN TO DEALER FOR THIS, AND SAID IT WAS BRAKES, AND ADJUSTED THOSE BRAKES. YET THIS CAR STILL HAS PROBLEMS. *AK
Official recalls
204V113000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Mar 4, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A NGC-1 POWERTRAIN CONTROL MODULE, THE SOFTWARE PROTOCOLE USED TO TEST THE VEHICLE EXHAUST GAS RECIRCULATION (EGR) SYSTEM MAY LEAD TO ENGINE STALLING UNDER CERTAIN OPERATING CONDITIONS.
Consequence & remedy
Consequence: THIS COULD CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPROGRAM THE POWERTRAIN CONTROL MODULE SOFTWARE. OWNER NOTIFICATION BEGAN ON MARCH 15, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V471000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Nov 10, 2003
ON CERTAIN SPORT UTILITY VEHICLES, THE CHASSIS FUEL SUPPLY TUBE MAY HAVE BEEN INCORRECTLY MANUFACTURED.
Consequence & remedy
Consequence: UNDER CERTAIN ENGINE AND VEHICLE DYNAMIC CONDITIONS, THE FUEL LINE MAY SEPARATE, RESULTING IN A FUEL LEAK AND AN INCREASED RISK OF A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A SECONDARY RETENTION CLIP TO THE FUEL LINE QUICK CONNECT. OWNER NOTIFICATION BEGAN ON DECEMBER 15, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA06010 · Fuel Tank Punctures
Opened Jun 15, 2006 · Closed Oct 11, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage; Fuel System, Other:storage:tank Assembly
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (4)
Fuel System, Gasoline:storage
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Other:storage
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Other:storage:tank Assembly
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
RQ06002 · Engine Stalling
Opened Feb 27, 2006 · Closed Jun 22, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Fuel System, Gasoline; Vehicle Speed Control
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
Additional source detail variants (3)
Engine And Engine Cooling
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
Fuel System, Gasoline
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
Vehicle Speed Control
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
PE06009 · Fuel Tank Punctures
Opened Feb 22, 2006 · Closed Jun 15, 2006
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
ON FEBRUARY 22, 2006, ODI OPENED PE06-009 TO INVESTIGATE REPORTS THAT THE FUEL TANKS ON MODEL YEAR (MY) 2004 TO 2005 CHRYSLER PACIFICA VEHICLES MAY BE PUNCTURED BY CONTACT WITH ROAD DEBRIS.THE NUMBER OF REPORTS SUBMITTED BY CHRYSLER WAS SIGNIFICANTLY HIGHER THAN THOSE SUBMITTED BY OTHER MANUFACTURERS WHO WERE REQUESTED TO SUBMIT DATA AS PART OF INVESTIGATION PE05-050 INTO MY 2003 TO 2006 NISSAN MURANO VEHICLES THAT MAY HAVE HAD INSUFFICIENT SHIELDING OF THE FUEL TANK TO PREVENT PUNCTURES AFTER CONTACT WITH ROAD DEBRIS.NISSAN ISSUED RECALL 06V-003 INVOLVING INCREASING THE SHIELDING OF THE FUEL TANKS TO REDUCE THE LIKELIHOOD OF TANK PUNCTURES. CHRYSLER HAS NOTED THAT THEY HAD IN PLACE FROM JANUARY 2003 TO JUNE 2005 A PARTS RESTRICTION PROGRAM ON PACIFICA FUEL TANK REPLACEMENTS WHICH MAY HAVE MADE THE NUMBER OF REPORTS ARTIFICIALLY HIGH IN COMPARISON TO MANUFACTURERS WHICH DID NOT HAVE A SIMILAR PROGRAM IN EFFECT.CHRYSLER ALSO QUESTIONED WHETHER MANY OF THE FIELD REPORTS OF FUEL TANKS REPLACED DUE TO DAMAGE FROM UNKNOWN CAUSE WERE ACTUALLY PUNCTURED. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-010) TO GATHER ADDITIONAL INFORMATION CONCERNING THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.