NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
109 reportsClear category filterMileage unknown · Apr 29, 2016
Electrical System
TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. THE CONTACT STATED THAT THERE WAS A PROGRESSING FAILURE IN WHICH THE VEHICLE WAS RANDOMLY STALLING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE BUT, AS THE FAILURE CONTINUED, IT TOOK LONGER THAN NORMAL TO GET THE VEHICLE TO RESTART. THE CONTACT WAS UNABLE TO DETERMINE WHEN THE VEHIC…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. THE CONTACT STATED THAT THERE WAS A PROGRESSING FAILURE IN WHICH THE VEHICLE WAS RANDOMLY STALLING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE BUT, AS THE FAILURE CONTINUED, IT TOOK LONGER THAN NORMAL TO GET THE VEHICLE TO RESTART. THE CONTACT WAS UNABLE TO DETERMINE WHEN THE VEHICLE WOULD START DUE TO THE FAILURE. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VIN WAS NOT INCLUDED IN A MANUFACTURER RECALL TO ADDRESS THE REPAIR. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #10862222
105,238 miles · Apr 26, 2016
Electrical System
DRIVING AFTER 45 MINUTES TO 1 HR STOP FOR SHORT BREAK (APPROXIMATELY 15 MINUTES). SHUT CAR OFF THEN UPON RETURNING TO CAR THE CAR WON'T START. TRIES TOO OR HESITATES. CALL TRIPLE AAA THEY HOOK IT UP TO COMPUTER CAN'T FIND ANYTHING WRONG. STARTER GOOD, ALTERNATOR GOOD, BATTERY GOOD. STILL WON'T START. HOOK TO JUMP PACK MIGHT STAR…
Read full complaint
DRIVING AFTER 45 MINUTES TO 1 HR STOP FOR SHORT BREAK (APPROXIMATELY 15 MINUTES). SHUT CAR OFF THEN UPON RETURNING TO CAR THE CAR WON'T START. TRIES TOO OR HESITATES. CALL TRIPLE AAA THEY HOOK IT UP TO COMPUTER CAN'T FIND ANYTHING WRONG. STARTER GOOD, ALTERNATOR GOOD, BATTERY GOOD. STILL WON'T START. HOOK TO JUMP PACK MIGHT START. THIS HAS HAPPENED 5 TIMES IN 2 WEEKS. GARAGE CAN'T FIND ANYTHING WRONG EITHER. ONCE STARTED FINISH DRIVING ANOTHER 1/2 HOUR SHUT VECHICLE OFF FOR EITHER 6 HOURS OR MORE; STARTS FINE AS LONG AS I DON'T STOP ANYWHERE. HELP
NHTSA ODI #10861535
224,000 miles · Apr 25, 2016
Electrical SystemEngineUnknown Or OtherFire
I WAS DRIVING AND MY CHILDREN SMELLED SMOKE. I PULLED OVER AND OPENED THE HOOD AND SAW A FIRE. A STRANGER STOPPED AND TRIED PUTTING IT OUT WITH A FIRE EXTINGUISHER BUT IT CAUGHT ON SO QUICKLY THAT THERE WAS NO CHANCE. I SUFFERED A COMPLETE LOSS SINCE THE ENTIRE CAR WAS ENGULFED IN FLAMES.
NHTSA ODI #10861252
247,000 miles · Sep 18, 2015
Electrical System
TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. THE CONTACT ATTEMPTED TO ILLUMINATE THE HEADLIGHTS, BUT THE HEADLIGHTS FAILED TO ILLUMINATE. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO A DEALER AND THE MECHANIC REPLACED THE TIPM MODULE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MI…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. THE CONTACT ATTEMPTED TO ILLUMINATE THE HEADLIGHTS, BUT THE HEADLIGHTS FAILED TO ILLUMINATE. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO A DEALER AND THE MECHANIC REPLACED THE TIPM MODULE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 247,000.
NHTSA ODI #10765168
128,000 miles · Jul 29, 2015
Electrical SystemFire
TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. WHILE DRIVING AT APPROXIMATELY 30 MPH, THERE WAS SMOKE EMITTING FROM THE DASHBOARD. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE CONTROL MODULE BOX WAS DESTROYED. IN ADDITION, THE WIRE HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTUR…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. WHILE DRIVING AT APPROXIMATELY 30 MPH, THERE WAS SMOKE EMITTING FROM THE DASHBOARD. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE CONTROL MODULE BOX WAS DESTROYED. IN ADDITION, THE WIRE HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 128,000.
NHTSA ODI #10744775
118,779 miles · May 18, 2015
Electrical SystemEngineSteering
TECHNICIAN FOUND PERFORATION ON THE FRONT SUBFRAME/CRADLE AREA ESTIMATED COST TO REPLACE $ 2,566.62.
NHTSA ODI #10717219
134,444 miles · May 5, 2015
Electrical SystemFire
I WAS GOING DOWN THE FREEWAY WHEN MY BATTERY LIGHT CAME ON OUT OF NOWHERE AND THEN A SMELL OF BURNT RUBBER STARTED COMING THROUGH THE CAR I PULLED OVER AND SHUT THE ENGINE OFF POPPED THE HOOD AND FOUND A FIRE ON MY ALTERNATOR . I WAS ABLE TO PUT THE FIRE OUT BUT MY CHILDREN WERE IN THE CAR I AM AFRAID TO DRIVE IT. *TR
NHTSA ODI #10714565
175,000 miles · Apr 4, 2015
Electrical System
I WAS DRIVING AT ABOUT 30 MPH WHEN THE CAR COMPLETELY SHUT DOWN. THE CAR WAS THEN JUMPED AND I TRIED TO DRIVE IT AROUND THE CORNER AND IT COMPLETELY SHUT DOWN AGAIN THIS TIME LOSING ALL CONTROL...NO BRAKES OR STEERING. I ALMOST CRASHED INTO THE CARS THAT WERE PARKED. THESE CARS ARE DEATH TRAPS AND NEED TO BE RECALLED! THE WHOLE …
Read full complaint
I WAS DRIVING AT ABOUT 30 MPH WHEN THE CAR COMPLETELY SHUT DOWN. THE CAR WAS THEN JUMPED AND I TRIED TO DRIVE IT AROUND THE CORNER AND IT COMPLETELY SHUT DOWN AGAIN THIS TIME LOSING ALL CONTROL...NO BRAKES OR STEERING. I ALMOST CRASHED INTO THE CARS THAT WERE PARKED. THESE CARS ARE DEATH TRAPS AND NEED TO BE RECALLED! THE WHOLE FRAME IS ALSO ROTTING OUT. IN A PERFECT WORLD I WOULD JUST RUN OUT AND BUY A NEW CAR BUT I AM A MOTHER OF 3 AND THAT'S JUST NOT ABLE TO HAPPEN RIGHT NOW. I'M NOT EVEN SURE IF THE CAR CAN BE REPAIRED. IT HAD TO BE TOWED TO 2 DIFFERENT MECHANICS AND I HAVEN'T HEARD BACK WHETHER OR NOT IT CAN BE FIXED! SOMEONE NEEDS TO STEP UP TO THE PLATE AND HOLD CHRYSLER ACCOUNTABLE! I'VE HAD NOTHING BUT PROBLEMS SINCE DAY ONE AND WHEN I PUT MY V.I.N # IN IT SAYS THERE ARE NO RECALLS ON MY CAR....THAT'S A JOKE! THIS CAR IS A LEMON! *TR
NHTSA ODI #10703716
97,000 miles · Mar 8, 2015
Electrical System
NOTHING BUT PROBLEMS HUGE ISSUE ELECTRICAL PROBLEMS, DASH WON'T TURN OFF SO I HAVE TO USE THE FOUR WAY BUTTON TO KICK THE DASH OFF SO IT DOESN'T RUN MY BATTERY DEAD,NAVIGATION SYSTEM STOPPED WORKING,HEATER/AC CONTROL PANEL STOPPED WORKING ALONG WITH RADIO AND DVD SYSTEM,SOMETIMES THE DOORS LOCK AND SOMETIMES THEY DON'T CAN'T USE…
Read full complaint
NOTHING BUT PROBLEMS HUGE ISSUE ELECTRICAL PROBLEMS, DASH WON'T TURN OFF SO I HAVE TO USE THE FOUR WAY BUTTON TO KICK THE DASH OFF SO IT DOESN'T RUN MY BATTERY DEAD,NAVIGATION SYSTEM STOPPED WORKING,HEATER/AC CONTROL PANEL STOPPED WORKING ALONG WITH RADIO AND DVD SYSTEM,SOMETIMES THE DOORS LOCK AND SOMETIMES THEY DON'T CAN'T USE BRAND NEW KEY FOR KEYLESS ENTRY,SHORT SOMEWHERE RUNNING THE BATTERY DEAD HAD ALTERNATOR CHECKED AND IT'S GOOD HAD THREE NEW BATTERIES ALSO THESE CARS ARE JUNK !! *TR
NHTSA ODI #10692837
156,000 miles · Jan 28, 2015
Electrical SystemExterior LightingService Brakes
ALL OF THE DASH LIGHTS, ABS, BRAKE, INTERIOR LIGHTS, HEADLIGHTS HAVE BEEN FLICKERING FOR A SOLID 3 DAYS. I WAS DRIVING AT NIGHT ON A NON-LIT STRETCH OF ROAD WHEN ALL MY LIGHTS WENT OUT, INSIDE AND OUT WITH A CAR APPROACHING FROM THE OTHER DIRECTION. I TRIED TO USE MY HIGH BEAMS AND THEY WERE OUT TOO. I HAD MY CHILDREN AND HAD T…
Read full complaint
ALL OF THE DASH LIGHTS, ABS, BRAKE, INTERIOR LIGHTS, HEADLIGHTS HAVE BEEN FLICKERING FOR A SOLID 3 DAYS. I WAS DRIVING AT NIGHT ON A NON-LIT STRETCH OF ROAD WHEN ALL MY LIGHTS WENT OUT, INSIDE AND OUT WITH A CAR APPROACHING FROM THE OTHER DIRECTION. I TRIED TO USE MY HIGH BEAMS AND THEY WERE OUT TOO. I HAD MY CHILDREN AND HAD TO PULL OVER. I HAVE READ REVIEWS AND THIS SEEMS TO BE A HUGE PROBLEM WITH THESE CARS YET NO RECALL? WHY? THIS IS SO DANGEROUS! THIS IS MY MAIN VEHICLE I DRIVE FOR WORK AND WITH MY FAMILY. I KNOW AM SCARED TO DRIVE IT AND WHAT PEOPLE HAVE STATED ITS HARD AND EXPENSIVE TO FIX! *TR
NHTSA ODI #10679417
NHTSA investigations
3EA06010 · Fuel Tank Punctures
Opened Jun 15, 2006 · Closed Oct 11, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage; Fuel System, Other:storage:tank Assembly
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (4)
Fuel System, Gasoline:storage
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Other:storage
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Other:storage:tank Assembly
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JANUARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
RQ06002 · Engine Stalling
Opened Feb 27, 2006 · Closed Jun 22, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Fuel System, Gasoline; Vehicle Speed Control
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
Additional source detail variants (3)
Engine And Engine Cooling
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
Fuel System, Gasoline
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
Vehicle Speed Control
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PACIFICA VEHICLES TO CORRECT A CONDITION THAT COULD RESULT IN ENGINE STALL WHILE MAKING A LEFT-HAND TURN AFTER A COLD-START.DURING RQ06-002 IT WAS DETERMINED THAT RECALL 04V-113 DID CORRECT THE SPECIFIC CAUSE OF THE ENGINE STALLING CONDITION FOR THAT SPECIFIC POPULATION.HOWEVER, TWO OTHER CONDITIONS WERE IDENTIFIED THAT COULD ALSO CAUSE ENGINE STALLING DURING TURNING MANEUVERS:(1) AN ISSUE WITH MISBUILT FUEL PUMPS THAT PRIMARILY AFFECTED ABOUT 17,000 MY 2005 PACIFICA VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004; AND (2) A SOFTWARE CONDITION AFFECTING VAPOR PURGE IN ABOUT 131,000 MY 2005-06 PACIFICA VEHICLES BUILT FROM JULY 2004 THROUGH NOVEMBER 2005. AN ENGINEERING ANALYSIS, EA06-013, HAS BEEN OPENED TO FURTHER EXAMINE THE SCOPE, FREQUENCY AND SAFETY CONSEQUENCES ASSOCIATED WITH EACH OF THESE CONDITIONS IN THE SUBJECT VEHICLES.
PE06009 · Fuel Tank Punctures
Opened Feb 22, 2006 · Closed Jun 15, 2006
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
ON FEBRUARY 22, 2006, ODI OPENED PE06-009 TO INVESTIGATE REPORTS THAT THE FUEL TANKS ON MODEL YEAR (MY) 2004 TO 2005 CHRYSLER PACIFICA VEHICLES MAY BE PUNCTURED BY CONTACT WITH ROAD DEBRIS.THE NUMBER OF REPORTS SUBMITTED BY CHRYSLER WAS SIGNIFICANTLY HIGHER THAN THOSE SUBMITTED BY OTHER MANUFACTURERS WHO WERE REQUESTED TO SUBMIT DATA AS PART OF INVESTIGATION PE05-050 INTO MY 2003 TO 2006 NISSAN MURANO VEHICLES THAT MAY HAVE HAD INSUFFICIENT SHIELDING OF THE FUEL TANK TO PREVENT PUNCTURES AFTER CONTACT WITH ROAD DEBRIS.NISSAN ISSUED RECALL 06V-003 INVOLVING INCREASING THE SHIELDING OF THE FUEL TANKS TO REDUCE THE LIKELIHOOD OF TANK PUNCTURES. CHRYSLER HAS NOTED THAT THEY HAD IN PLACE FROM JANUARY 2003 TO JUNE 2005 A PARTS RESTRICTION PROGRAM ON PACIFICA FUEL TANK REPLACEMENTS WHICH MAY HAVE MADE THE NUMBER OF REPORTS ARTIFICIALLY HIGH IN COMPARISON TO MANUFACTURERS WHICH DID NOT HAVE A SIMILAR PROGRAM IN EFFECT.CHRYSLER ALSO QUESTIONED WHETHER MANY OF THE FIELD REPORTS OF FUEL TANKS REPLACED DUE TO DAMAGE FROM UNKNOWN CAUSE WERE ACTUALLY PUNCTURED. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-010) TO GATHER ADDITIONAL INFORMATION CONCERNING THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Illustration