2019 Chrysler Pacifica PLUG-IN Hybrid

The contact owns a 2019 Chrysler Pacifica Plug-In Hybrid. The contact stated while driving 75 MPH down a winding mountain road, the message “Pull Over Immediately - Vehicle will Shut down Soon” was displayed. The contact pulled over and was able to restart the vehicle. The contact stated that the message was displayed three times. The vehicle was driven to the local dealer, where it was diagnosed that a software update and transmission rebuild were needed. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was approximately 70,200.

Van engine failed during driving. This is a known issue by Chrysler and they will not repair the underlying problem - this is related to a prior recall. Instead, it only suggested replacing the battery which is a temporary fix. Separately, this van has a pending recall due to a fire risk. Unable to use the plug-in hybrid function of the van nor park it in a garage due to the recall issue. It has been almost four months since the recall notice without any news of when Chrysler will fix this problem. I requested a buy back due to the inherent risk of severe injury from simply being inside this van but was denied.

On [XXX] around 12:00 PM, while traveling northbound in the HOV lane at 70 MPH on [XXX] near [XXX] , with two small children in the passenger row and two adults in the front, the following error suddenly appeared on the dashboard: "Stop Safely -- Vehicle Will Shut Off Soon." Power to the engine stopped as a result and the car coasted. A "red turtle" warning and a "Check Engine" error also displayed. No other errors, unfamiliar sounds, or mechanical noises preceded these errors, nor had there been any other recent problems with the car. We pulled over to the shoulder immediately and turned the car off for approximately 5 minutes to see whether the errors would persist. With the "Stop Safely" error no longer on the dashboard, we turned the car on again and drove it to the dealership. On that drive, the previous errors appeared a second time. The dealership, Carl Burger Dodge Chrysler Jeep RAM World (La Mesa CA), has confirmed that the transmission needs to be replaced and that it is unsafe to drive the vehicle until the transmission is replaced. On August 30, 2024, the dealership said that they are waiting for Stellantis to release the transmission and "that won't happen any time soon." As of today, September 2, 2024, Carl Burger has failed to provide a timeline for the replacement and have informed us that we must deal with Stellantis in order to get the case escalated and the car repaired. They have also refused to offer us a replacement/loaner vehicle while ours is in the shop. Mileage: 51,000 Stellantis Case Number [XXX] Dealership: https://www.carlburger.com/ INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving a message appeared on the dash "SERVICE CHARGING SYSTEM" and vehicle doesn't even accelerate(we stay in Des Moines and visited my cousin in Dallas,TX, this is where this issue happened). Luckily I was on local road I was able to pull off, what would be the situation if it happens on interstate with such high speed travelling vehicles behind me. I was driving with my 2 kids and wife and I feel it's more dangerous to take a trip with this vehicle. Please try to find a solution or issue an recall and doesn't want this situation to happen to anybody.

Loss of Motive Power reoccurrences (2 incidents) AFTER 1803A182 Safety Recall 03A correction was performed, 9 May 2023, by reprogramming Hybrid Control Processor/Aux Hybrid Control Processor on 2019 Chrysler Pacifica Plug-In Hybrid (mileage: 35,180) Experienced a sudden loss of power twice; 16 and 17 September 2023. - 16 SEPTEMBER: Having just merged into one lane from two and speeding up hill (from approx. 20 mph) to merge onto highway, a sudden loss of power occurred without an adequate shoulder to pull off, resulting in time critical crash avoidance maneuvers by all vehicles behind us. No known crashes occurred within our viewing range. ADDITIONAL DETAILS: Unable to shut down vehicle for 2-3 minutes Check Engine Light illuminated Dash Diagnostic screen: “Service Charging System” error Electric Power available: 56% Fuel: 3/8th) - 17 SEPTEMBER: After running a preliminary diagnostic test with my personal OBD tester, I noticed that the Check Engine Light turned off after the connection activated. I did NOT clear any codes. After printing the list of faults generated from the evening prior, I chose to take it for a short test drive. While waiting at a stop light within a mile from my house, the same issue occurred again, “Service Charging System” error followed by two additional alternating notification on the dash, “Service Shifter” error and “Service Shifter Stop Safely Shut Off Vehicle to Engage Park,” with the transmission indicator selector knob lost illumination and became non-responsive. (as seen in attached pictures from previous incidents) Luckily, everyone was stopped this time. Within 20-30 seconds, the entire vehicle, including dashboard went completely dead then blipped back on as if nothing had happened, allowing me to make it home safely.

While driving down the road at approximately 45 mph, the car suddenly shut down with no power. The display said there was a charging error and to put the vehicle in park. I parked the vehicle on the shoulder, turned it off, and restarted. The engine started and I drove off, but 5 minutes later it suddenly shut off once again. I repeated this process 2 times until the final time, the vehicle would not restart, and we were stranded on the shoulder of a busy road in icy conditions. A mechanic ran a diagnostic on the vehicle and there are no error codes, but it will not start and says there is a charging error, even though it is not plugged in. The sudden stops are very dangerous, especially in snowy/icy conditions. We are 600 miles away from home and do not feel safe operating this vehicle on a long road trip on busy highways.

Very LOUD metallic clanking noise while driving 40-50 mph coming from front left wheel. When I inspected it, I saw that the front left wheel bearing hub mounting bolt had backed out of the hub and steering knuckle and onto the CV shaft end, which is what caused the clanking. I have photos of this damage. Vehicle is 3 years old and has 46,000 miles on it. I believe it should be obvious why wheel bearing hub mounting bolts backing out on their own is quite dangerous. This problem has not been confirmed by my local dealer. The manufacturer has not been made aware of this problem. There was no warning sign that this would occur. It happened spontaneously while driving this morning.

While driving 70MPH on the freeway the power to the engine failed. The dash showed a power error, telling me to plug the vehicle in. After coasting to the shoulder, the power to the car would not turn off, nor would the engine turn back on. I sat on the shoulder of the I-15 Freeway in Rancho Bernardo, CA for 45 minutes until a tow truck could come and tow the car to the dealership where it was purchased, Bob Baker Chrysler in Carlsbad, CA. The service technician, Juan Gonzalez, kept the car for about a week trying to replicate the problem, detect the issue, or learn anything about it. He could not determine the cause or the solution. However the car would start again and appeared to drive normally again. After 7 days the car was returned to me with out any repairs or any explanations or any assurance that this would not happen again. My family was placed in serious danger by being forced to sit in the car on the small shoulder a major interstate freeway without any power to the engine.