NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
148 reports145,000 miles · Mar 25, 2005
Power TrainInjury
WHILE THE CONSUMER WAS STANDING BY THE VEHICLE IT SUDDENLY BEGAN TO ROLL FORWARD. CONSUMER RAN BEHIND THE VEHICLE, GRABBED THE DOOR AND WAS DRAGGED A FEW FEET, INJURING HIS KNEES, BEFORE HE WAS ABLE TO OPEN THE DOOR AND SLAM THE GEAR INTO PARK. CONSUMER TOOK THE VEHICLE TO THE DEALER, WHERE HE WAS TOLD HE HAD STRIPPED A GEAR. H…
Read full complaint
WHILE THE CONSUMER WAS STANDING BY THE VEHICLE IT SUDDENLY BEGAN TO ROLL FORWARD. CONSUMER RAN BEHIND THE VEHICLE, GRABBED THE DOOR AND WAS DRAGGED A FEW FEET, INJURING HIS KNEES, BEFORE HE WAS ABLE TO OPEN THE DOOR AND SLAM THE GEAR INTO PARK. CONSUMER TOOK THE VEHICLE TO THE DEALER, WHERE HE WAS TOLD HE HAD STRIPPED A GEAR. HOWEVER, THERE WAS A RECALL FOR THE SHIFT INTERLOCK. CONSUMER FELT THAT SINCE THE RECALL CAUSED HIM TO STRIP THE GEAR WHEN THE VEHICLE ROLLED, SHOULD BE PART OF THE REPAIR MADE TO THE VEHICLE, ALONG WITH THE SHIFT INTERLOCK NHTSA RECALL 04V021000.*AK
NHTSA ODI #10115830
105,000 miles · Feb 16, 2005
Exterior Lighting
A YELLOW SUBSTANCE ACCUMULATED INSIDE THE HEADLIGHTS LENS. THIS WOULD DISTRACT THE DRIVER'S VIEW WHEN DRIVING DURING NIGHT HOURS. *JB MANUFACTURER WAS NOTIFIED. *TT
NHTSA ODI #10108721
Mileage unknown · Oct 6, 2004
Power Train
CONSUMER HAD TO PUT 2 TRANSMISSIONS INTO VEHICLE. THIS ONE THAT IS IN THE VEHICLE NOW IS DEFECTIVE. CONSUMER PUT KEY INTO THE IGNITION, AND SOMETIMES THE VEHICLE WILL JERK.ALSO, WHILE DRIVING SOME TIMES VEHICLE WILL NOT CHANGE GEARS. CONSUMER FELT THAT THERE SHOULD BE A RECALL ON THE TRANSMISSION. *AK
NHTSA ODI #10095285
Mileage unknown · Jul 27, 2004
Visibility
POWER SUN ROOF FLEW OUT OF THE TOP OF THE CAR. THE FRAM AND BASIC CAB;E STRUCTURE REMAINED BUT THE GLASS BLEW OUT. REPLACEMENT COST IS ESTIMATED AT $800 PLUS LABOR. THIS SEEMS VERY HIGH TO ME. IT COULD HAVE CAUSED AN ACCIDENT IF SOMEONE HAD BEEN TRAVELING BEHIND US.*AK
NHTSA ODI #10082785
101,000 miles · May 19, 2004
Engine And Engine CoolingFuel System, GasolinePower Train
THIS VEHICLE WAS PURCHASED USED. 2 WEEKS AFTER PURCHASE THE REAR BRAKE BADS FAILED CAUSING THEM TO GRIND ON THE ROTORS. BRAKES AND ROTORS WERE REPLACED. DRIVERS SIDE SEAT SUPPORT IS BROKEN. POWER STEERING PUMP HAS A LEAK. TRANSMISSION CLUTCHES BURNED OUT REQUIRING REPLACEMENT. WATER PUMP FAILED ALONG WITH FAILING TIMING BELT & T…
Read full complaint
THIS VEHICLE WAS PURCHASED USED. 2 WEEKS AFTER PURCHASE THE REAR BRAKE BADS FAILED CAUSING THEM TO GRIND ON THE ROTORS. BRAKES AND ROTORS WERE REPLACED. DRIVERS SIDE SEAT SUPPORT IS BROKEN. POWER STEERING PUMP HAS A LEAK. TRANSMISSION CLUTCHES BURNED OUT REQUIRING REPLACEMENT. WATER PUMP FAILED ALONG WITH FAILING TIMING BELT & TIMING BELT TENSIONER CAUSING NEEDED REPLACEMENT. ENGINE HAS SEVERAL OIL LEAKS. RACK & PINION SYSTEM IS SHIFTING, CAUSING A THUMPING SOUND AND VEHICLE SHIFTING WHILE CORNERING AT TIMES. SELT BELT ON DRIVERS SIDE DOESN'T RETRACT PROPERLY. BRAKES PERFORM POORLY, REQUIRING EXCESSIVE PEDAL TO STOP VEHICLE. FUEL RAIL IS LEAKING FUEL, AWAITING MECHANIC DETERMINATION IF IT'S COVERED UNDER THE RECALL. *AK
NHTSA ODI #10072869
86,000 miles · Apr 29, 2004
Seats
THE DRIVER'S SIDE SEAT STUCK WHILE ADJUSTING IT BACKWARDS OR FORWARDS. THE DEALER EXAMINED THE VEHICLE AND DETERMINED THAT THE SEAT RAIL BRACKET WAS DEFECTIVE. *AK IN ORDER TO GET THE SEAT TO MOVE UNLESS IT WAS RUN BACK AND FORTH A FEW TIMES IT WOULD FINALLY LURCH TO THE SIDE THEN FORWARD. THIS WOULD DISTRACT THE DRIVER. …
Read full complaint
THE DRIVER'S SIDE SEAT STUCK WHILE ADJUSTING IT BACKWARDS OR FORWARDS. THE DEALER EXAMINED THE VEHICLE AND DETERMINED THAT THE SEAT RAIL BRACKET WAS DEFECTIVE. *AK IN ORDER TO GET THE SEAT TO MOVE UNLESS IT WAS RUN BACK AND FORTH A FEW TIMES IT WOULD FINALLY LURCH TO THE SIDE THEN FORWARD. THIS WOULD DISTRACT THE DRIVER. *SC *JB
NHTSA ODI #10064645
Mileage unknown · Apr 20, 2004
Structure
THE ENGINE CRADLE HAD RUSTED AND BROKEN IN TWO. *PH *NM
NHTSA ODI #10071558
96,000 miles · Jan 15, 2004
Engine And Engine Cooling
MY HUSBAND AND I PURCHASED A 1995 CHRYSLER LHS BACK IN THE WINTER OF 2000. WHEN WARMER WEATHER HIT WE TURNED ON OUR AIR CONDITIONER AND THE CAR BEGAN TO SCREAM, WE TOOK IT BACK AND SUPPOSEDLY THEY FIXED IT, IT HAPPENED AGAIN AND WE TOOK IT BACK TO THE PLACE WE BOUGHT IT FROM AGAIN SAME THING FOR A THIRD TIME AND BECAUSE WE DIDN'…
Read full complaint
MY HUSBAND AND I PURCHASED A 1995 CHRYSLER LHS BACK IN THE WINTER OF 2000. WHEN WARMER WEATHER HIT WE TURNED ON OUR AIR CONDITIONER AND THE CAR BEGAN TO SCREAM, WE TOOK IT BACK AND SUPPOSEDLY THEY FIXED IT, IT HAPPENED AGAIN AND WE TOOK IT BACK TO THE PLACE WE BOUGHT IT FROM AGAIN SAME THING FOR A THIRD TIME AND BECAUSE WE DIDN'T HAVE THE MONEY FOR AN EXTENDED WARRANTY THEY INFORMED US THEY THERE WAS REALLY NOTHING THEY COULD DO FOR US BUT INSTALL A USED CONDENSER UNIT EACH TIME. WELL IT WORKED FOR A LITTLE WHILE AND THEN IT QUIT AGAIN. MY HUSBAND WENT AND BOUGHT THE PARTS WE NEEDED AND FIXED IT HIMSELF. IT WORKED FINE FOR A FEW MONTHS AND NOW SAME THING, NO AIR CONDITIONER. JUST RECENTLY WE BEGAN HAVING A PROBLEM WITH THE CAR STALLING WHILE DRIVING. MY HUSBAND REPLACED THE CRANKSHAFT POSITION SENSOR, IT WORKED FINE FOR A DAY AND WHILE DRIVING WITH MY 18 MONTH OLD SON IN 90 DEGREE WEATHER IT STALLED ABOUT 25 TIMES DURING OUR RIDE HOME. I HAD TO PULL OVER, SHUT THE CAR OFF WAIT 5 MINS AND THEN TRY AGAIN. I HELD UP TRAFFIC 3 TIMES BECAUSE THERE WAS NOT A SHOULDER TO PULL OVER ON. I HATE THIS CAR. NOW THERE ARE SO MANY THINGS THAT COULD BE THE PROBLEM, AS FOR PUTTING IT ON A DIAGNOSTICS MACHINE, WE DID THAT AND BECAUSE THE CAR NEEDS TO BE DRIVEN TO STALL, NO CODES WILL COME UP, OUT ANOTHER $125. THIS CAR IS NOTHING BUT A MONEY PIT. AS FOR THE RECALLS, WELL THIS SCARES ME AS I COULD NOT POSSIBLE FIND OUT THE TRUTH IF THE RECALL REPAIRS WERE EVER MADE. THE FIRE HAZARD IS ENOUGH NOT TO WANT TO DRIVE THE CAR. THE RECALL I FOUND DEALS WITH THE FUEL INJECTION DELIVERY SYSTEM, SYSTEM CAN LEAK FUEL FROM SOME OF THE SEALING O-RINGS OR FROM HAIR LINE CRACKS IN THE THERMOSET FUEL INJECTION RAIL. DEALERS WILL REPLACE THE FUEL RAIL O RINGS AND REINFORCE THE OUTLET (PASSENGER) SIDE FUEL RAIL. VEHICLES SHOWING FUEL LEAKAGE ON THE OUTLET RAIL MUST HAVE THE OUTLET RAIL REPLACED WHICH INCLUDES CHANGING THE UPPER AND LOWER INJECTOR O-RINGS
NHTSA ODI #10070443
Mileage unknown · Dec 10, 2003
Steering
LOST OF STEERING AND BRAKES DUE TO CRACKING AND FAILURE OF SUBFRAME.*MR THE CONSUMER TOOK THE VEHICLE TO THE SERVICE DEALER FOR REPAIRS IT COST APPROXIMATELY $1040.00. THE CONSUMER THEN FOUND OUT THERE WAS A RECALL FOR THE CONTROL ARMS. THE CONSUMER CONTACTED THE DEALER TO RECEIVE REIMBURSEMENT FOR REPAIRS HE HAD TO PAY, THE C…
Read full complaint
LOST OF STEERING AND BRAKES DUE TO CRACKING AND FAILURE OF SUBFRAME.*MR THE CONSUMER TOOK THE VEHICLE TO THE SERVICE DEALER FOR REPAIRS IT COST APPROXIMATELY $1040.00. THE CONSUMER THEN FOUND OUT THERE WAS A RECALL FOR THE CONTROL ARMS. THE CONSUMER CONTACTED THE DEALER TO RECEIVE REIMBURSEMENT FOR REPAIRS HE HAD TO PAY, THE CONSUMERS CLAIM WAS DENIED AND HE WAS TOLD THAT THE WARRANTY HAD EXPIRED. *CB (RECALL #99V215000) *JB
NHTSA ODI #10051726
79,000 miles · Jul 18, 2003
Seats
WHILE DRIVING, THE DRIVER'S SEAT COLLAPSED WITHOUT WARNING. THE DEALER WAS NOTIFIED. *NLM. THE BOLTS ON THE DRIVERS SEAT BROKE IN PIECES. *TS *JB
NHTSA ODI #10015904
NHTSA investigations
8DP04007 · Fuel Rail, Brake Fluid, Chassis
Opened Oct 13, 2004 · Closed Oct 27, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail; Service Brakes, Hydraulic:fluid; Structure:frame And Members
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
Additional source detail variants (3)
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
Service Brakes, Hydraulic:fluid
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
Structure:frame And Members
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
EA99031 · Steering System Rack And Pinion
Opened Oct 29, 1999 · Closed Sep 13, 2001
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE99044 · Steering System Rack And Pinion
Opened Jun 28, 1999 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Steering
SINCE OPENING THE PRELIMINARY EVALUATION (PE), ODI HAS RECEIVED 6 ADDITIONAL COMPLAINTS.DURING THE PE IT WAS DETERMINED MULTIPLE FAILURE MODES ARE INVOLVED IN THIS MATTER.THE WARRANTY CLAIM RATE IS HIGH FOR A STEERING SYSTEM CONCERN.THE ISSUES REPORTED INVOLVE PREMATURE WEAR OUT AT THE RACK AND PINION INTERFACE WITH THE INNER TIE ROD END(S), BINDING AND STICKING OF THE STEERING GEAR, CRACKED OR BROKEN TIE ROD ENDS, SHEARED RACK AND PINION ASSEMBLY BOLTS, AND WEAR OUT OF THE RACK AND PINION MOUNT BUSHINGS.MANY OF THE COMPLAINANTS MENTION STEERING WONDER AND LOOSE STEERING.THREE OF THE MOST RECENT COMPLAINTS ALLEGE A COMPLETE LOSS OF STEERING DUE TO SHEARED BOLTS.ODI IS UPGRADING THIS PE IN ORDER TO PERFORM A THOROUGH TECHNICAL ANALYSIS OF THE VARIOUS SYSTEM FAILURE ALLEGATIONS AND TO QUANTIFY THE EFFECT THAT THESE FAILURES HAVE ON VEHICLE CONTROL.
RQ98018 · Fuel Injection Delivery System Fuel Leak
Opened Oct 7, 1998 · Closed Jul 8, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System
No summary supplied.
EA98007 · Fuel Injector Assembly Leakage
Opened Mar 10, 1998 · Closed Feb 1, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:fuel Injection System; Fuel System, Gasoline:fuel Injection System:fuel Rail
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
Fuel System, Gasoline:fuel Injection System
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
Fuel System, Gasoline:fuel Injection System:fuel Rail
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
EA95028 · Underhood Fuel Leaks
Opened Sep 22, 1995 · Closed Feb 24, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WAARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSSING REPORT IS INCLUDED IN THE PUBLIC FILE.
Illustration