ABOUT 2 YEARS AGO, MY CAR BEGAN STUTTERING AND STALLING OUT WITH NO WARNING. THE OIL LIGHT REPEATED FLASHES ON, THE CHECK ENGINE LIGHT FLASHES AND THEN STAYS ON, AND THE CAR WONT START OR JUST CUTS OFF. THE TRANSMISSION SPEED SENSOR WAS REPLACED. THE TRANSMISSION WAS REPLACED. THE OIL WAS CHANGED. THIS PAST 3 MONTHS ALONE, …
Read full complaint
ABOUT 2 YEARS AGO, MY CAR BEGAN STUTTERING AND STALLING OUT WITH NO WARNING. THE OIL LIGHT REPEATED FLASHES ON, THE CHECK ENGINE LIGHT FLASHES AND THEN STAYS ON, AND THE CAR WONT START OR JUST CUTS OFF. THE TRANSMISSION SPEED SENSOR WAS REPLACED. THE TRANSMISSION WAS REPLACED. THE OIL WAS CHANGED. THIS PAST 3 MONTHS ALONE, IT HAS BEEN AT THE SERVICE DEPARTMENT 6 TIMES FOR THIS SAME PROBLEM. I AM NOW BEING TOLD THAT I NEED A TUNE-UP, WHICH WILL COST $700, THEN THE EGR NEEDS REPLACED, AND A FEW OTHER THINGS. HOWEVER, WHEN THE MECHANIC HAD IT LAST WEEK, HE COULD NOT FIND ANYTHING WRONG WITH IT. I HAVE FOUND OUT THAT THE CIRRUS VEHICLES HAVE THIS SAME PROBLEMS THAT I AM HAVING. I WAS ON MY WAY TO THE MALL VIA THE PARKWAY WHEN THE CAR STALLED OUT. LUCKILY TRAFFIC WAS SLOW BECAUSE IF I WAS ON THE PARKWAY AND IT STALLED OUT, MY SISTER AND I COULD HAVE GOTTEN KILLED. THERE IS NO PREDETERMINED TIME WHEN THESE PROBLEMS OCCURRED. THE CAR ONLY HAS 89500 MILES ON IT. I HAVE ALL OF MY ORIGINAL REPAIR PAPERS. PROPER MAINTENANCE HAS ALWAYS BEEN DONE ON MY CAR. WHEN IT WORKS, IT IS GREAT. UNFORTUNATELY, I JUST NEVER KNOW WHEN IT IS GOING TO NOT START. *TR
NHTSA ODI #10259302
104,900 miles · Aug 11, 2008
Power Train
I CURRENTLY OWN A 1999 CHRYSLER CIRRUS V6. AUTO IS EQUIPPED WITH A 41TE AUTOMATIC TRANSMISSION WITH 104,000 MILES ON IT. ACCORDING TO AL WEB SITES I HAVE COME TO FIND THAT THE 41TE AUTOMATIC TRANSMISSION HAS PROVEN TO BE AN UNRELIABLE UNIT RESULTING IN PREMATURE FAILURE AND BEARING FAILURE. CHRYSLER HAS REFUSED TO ACKNOWLEDGE…
Read full complaint
I CURRENTLY OWN A 1999 CHRYSLER CIRRUS V6. AUTO IS EQUIPPED WITH A 41TE AUTOMATIC TRANSMISSION WITH 104,000 MILES ON IT. ACCORDING TO AL WEB SITES I HAVE COME TO FIND THAT THE 41TE AUTOMATIC TRANSMISSION HAS PROVEN TO BE AN UNRELIABLE UNIT RESULTING IN PREMATURE FAILURE AND BEARING FAILURE. CHRYSLER HAS REFUSED TO ACKNOWLEDGE THE DEFECT. AS OF THIS WRITING THE PINION BEARINGS HAVE FAILED IN MY VEHICLE AND CHRYSLER HAS REFUSED TO REPAIR AS THIS IS AN ONGOING PROBLEM WITH THIS TRANSMISSION FOR WHICH THE MANUFACTURER DENIES AN RESPONSIBILITY. THERE ARE THOUSANDS OF PEOPLE LIKE ME OUT THERE WITH NO RECOURSE. ESTIMATED REPAIR COST $2,000.00. 1999 CHRYSLER CIRRUS V6 ANY ASSISTANCE YOU CAN PROVIDE WOULD BE GREATLY APPRECIATED AS THERE ARE MANY OTHER PEOPLE LIKE ME OUT THERE. *TR
NHTSA ODI #10237702
119,000 miles · Jan 24, 2005
Power Train
WHILE DRIVING ANY SPEED, THE TRANSMISSION WOULD CAUSE THE VEHICLE TO JERK FORWARD. THE DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. THE CAUSE WAS NOT DETERMINED. PLEASE PROVIDE MORE INFORMATION.
NHTSA ODI #10108695
Mileage unknown · Nov 1, 2004
Power Train
NHTSA RECALL 04V021000 ON THE FLOOR SHIFT IGNITION PARK INTERLOCK. AFTER HAVING A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER INSTALLED, THE CHECK ENGINE LIGHT APPEARED ON THE DASHBOARD. CONSUMER WAS ALSO HAVING PROBLEM SHIFTING GEARS. THE VEHICLE WAS TAKEN BACK TO THE DEALER FOR INSPECTION. THE MECHANIC COU…
Read full complaint
NHTSA RECALL 04V021000 ON THE FLOOR SHIFT IGNITION PARK INTERLOCK. AFTER HAVING A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER INSTALLED, THE CHECK ENGINE LIGHT APPEARED ON THE DASHBOARD. CONSUMER WAS ALSO HAVING PROBLEM SHIFTING GEARS. THE VEHICLE WAS TAKEN BACK TO THE DEALER FOR INSPECTION. THE MECHANIC COULD NOT DUPLICATE THE PROBLEM PLEASE PROVIDE FURTHER DETAILS. *JB
NHTSA ODI #10099178
34,000 miles · Dec 10, 2003
Power Train
THE CONSUMER WAS ABLE REMOVE THE KEY FROM THE IGNITION SWITCH WHILE THE VEHICLE WAS NOT IN PARK. THE CAUSE HAD NOT BEEN DETERMINED. THE DEALERSHIP HAVE BEEN NOTIFIED BUT THE PROBLEM HAD NOT BEEN RESOLVED. *PH *SCC *JB
NHTSA ODI #10047823
45,030 miles · Oct 1, 2003
Power Train
THE TRANSMISSION SHUT DOWN WITHOUT WARNING. THERE WAS NO MOVEMENT AT ALL. THE VEHICLE HAD TO BE TOWED. DEALERSHIP WAS AWARE OF THE PROBLEM. PLEASE SUBMIT ADDITIONAL INFORMATION CONCERNING THIS PROBLEM. *AK *JB
NHTSA ODI #10037661
69,000 miles · Dec 30, 2002
Power TrainStructureTires
I WAS DRIVING TO WORK ON HIGHWAY 302 WHEN SUDDENLY THE SPEEDOMETER NEEDLE MOVED TO ZERO, THE CHECK ENGINE LIGHT CAME ON, THEN THE TRANSMISSION SHIFTED TO FIRST GEAR LOCKING THE WHEELS ALMOST CAUSING A WRECK, ALL OF THIS HAPPENED WITHIN TWO TO THREE SECONDS NOT MUCH TIME TO SLOW DOWN. DODGE/CHRYSLER WOULDN'T COVER THE COST SINCE…
Read full complaint
I WAS DRIVING TO WORK ON HIGHWAY 302 WHEN SUDDENLY THE SPEEDOMETER NEEDLE MOVED TO ZERO, THE CHECK ENGINE LIGHT CAME ON, THEN THE TRANSMISSION SHIFTED TO FIRST GEAR LOCKING THE WHEELS ALMOST CAUSING A WRECK, ALL OF THIS HAPPENED WITHIN TWO TO THREE SECONDS NOT MUCH TIME TO SLOW DOWN. DODGE/CHRYSLER WOULDN'T COVER THE COST SINCE I BOUGHT A PROGRAM CAR AS IS NO WARRANTY, BUT BEFORE I PURCHASED IT, THEY DID A BUMPER TO BUMPER CHECK AND STATED EVERYTHING CHECKED OUT, THE VERY NEXT DAY AFTER I PURCHASED THE CAR, THE REAR POWER WINDOWS FAILED, A YEAR LATER I HAD A FLAT AND THE COMPACT SPARE THEY PUT IN THE TRUNK WHEN I BOUGHT THE CAR DIDN'T MATCH THE BOLT PATTERN, ON 12/26/02 THE PIN IN THE DIFFERENTIAL OF THE TRANSAXLE CAME LOOSE AND DESTROYED THE TRANSMISSION AND WILL COST $2,600.00 TO REPLACE. CHRYSLER SURELY OUT DID THEMSELVES WITH THIS LEMON AND LUCKILY FOR ME I AVOIDED TWO MAJOR ACCIDENTS, AND 15 TRANSMISSION SHOPS STATED THIS IS THE MOST COMMON PROBLEM WITH THIS MAKE. I CAN'T BELIEVE YOU HAVE NOT MADE CHRYSLER RECALL THE DEFECTIVE SPEED SENSOR AND DEFECTIVE TRANSMISSION WHICH CAN CAUSE A DEVASTATING WRECK WITHOUT WARNING. SCC ****DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS****770796
NHTSA ODI #10006663
78,600 miles · Dec 30, 2002
Power Train
I CONTACTED FIFTEEN TRANSMISSION SERVICE STATIONS INCLUDING COLEMAN TAYLOR THEY STATED THIS IS THE MOST COMMON PROBLEM OF TRANSMISSION FAILURE ON THAT MODEL OF CAR. PREVIOUSLY ON THE FIRST SCREEN I TRIED TO ENTER THE 17 DIGIT VIN, IT WOULDN'T ACCEPT THE NO. # IS [XXX] THE 9 AND 16 DIGIT COULD EITHER BE A O OR 0. *JB ****DIM…
Read full complaint
I CONTACTED FIFTEEN TRANSMISSION SERVICE STATIONS INCLUDING COLEMAN TAYLOR THEY STATED THIS IS THE MOST COMMON PROBLEM OF TRANSMISSION FAILURE ON THAT MODEL OF CAR. PREVIOUSLY ON THE FIRST SCREEN I TRIED TO ENTER THE 17 DIGIT VIN, IT WOULDN'T ACCEPT THE NO. # IS [XXX] THE 9 AND 16 DIGIT COULD EITHER BE A O OR 0. *JB ****DIMSII IVOQ POSTED AFTER 12/12/ CUT-OVER TO ARTEMIS****770795 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10006631
Mileage unknown · Sep 18, 2002
Power Train
TRANSMISSION SLIPS GEARS, AND IT IS MAKING A VERY LOUD SOUND. CONSUMER HAD VEHICLE CHECKED, AND WAS TOLD THAT TRANSMISSION WAS SUPPOSE TO BE MAKING THAT KIND OF NOISE. BUT CONSUMER CAN BE RIDING ALONG AND CAN HEAR A LOUD SOUND. HE KNOWS THAT IS NOT SUPPOSE TO HAPPEN.*AK
NHTSA ODI #8019011
Mileage unknown · Feb 15, 2002
Power Train
GEAR SHIFT MOVES WITHOUT DEPRESSING THE BRAKE. *AK
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4 LITER ENGINES, THE HIGH PRESSURE POWER STEERING HOSE MAY PREMATURELY HEAT AGE AND DEVELOP A LEAK.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL REPLACE THE HIGH PRESSURE POWER STEERING HOSE FREE OF CHARGE. THE THE RECALL BEGAN ON APRIL 10, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE RIGHT REAR BRAKE TUBE CAN CONTACT THE EXHAUST SYSTEM CLAMP AND WEAR A HOLE IN IT.
Consequence & remedy
Consequence: DAIMLERCHRYSLER RECALL NO. 843. IF THIS HAPPENS, THE TUBE COULD LEAK, REDUCING THE EFFECTIVENESS OF ONE-HALF OF THE DIAGONALLY SPLIT BRAKING SYSTEM, AND RESULTING IN LONGER STOPPING DISTANCES.
Remedy: DEALERS WILL INSPECT THE BRAKE TUBES FOR VISIBLE EVIDENCE OF CONTACT WITH THE EXHAUST SYSTEM CLAMP. IF THE TUBE SHOWS EVIDENCE OF CONTACT, IT WILL BE REPLACED. IF NO EVIDENCE OF CONTACT EXISTS, THE TUBE WILL BE FASTENED WITH A CLIP.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA05019 · Power Steering Fluid Fires
Opened Nov 7, 2005 · Closed Jan 12, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Steering:hydraulic Power Assist:hose, Piping, And Connections
ODI HAS RECEIVED 29 REPORTS OF ENGINE COMPARTMENT FIRES THAT APPEAR TO BE RELATED TO POWER STEERING HOSE LEAKAGE IN MODEL YEAR (MY) 1999 AND 2000 CHRYSLER CIRRUS, DODGE STRATUS AND PLYMOUTH BREEZE VEHICLES (JA-CARS) EQUIPPED WITH 2.4L ENGINES.THESE REPORTS INDICATE THAT THE FIRE RESULTED FROM A POWER STEERING HOSE LEAK OR THAT IT OCCURRED AFTER AN EXTENDED DRIVE AND SHORTLY AFTER BEING PARKED - CONDITIONS CONSISTENT WITH IGNITION OF POWER STEERING FLUID ON A HOT ENGINE OR EXHAUST SURFACE DURING THE VEHICLE HOT SOAK PERIOD. ON JANUARY 6, 2006, DAIMLERCHRYSLER CORPORATION (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 1999 AND 2000 JA-CARS BUILT FROM JULY 1, 1998 TO JULY 31, 2000 AND EQUIPPED WITH 2.4L ENGINES (RECALL 06V-001).THE NOTIFICATION STATED THAT ?THE HIGH PRESSURE POWER STEERING HOSE MAY PREMATURELY HEAT, AGE AND DEVELOP A LEAK. POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN AN UNDER HOOD FIRE.DCC INDICATED THAT IT WAS AWARE OF 94 COMPLAINTS AND FIELD REPORTS THAT MAY BE RELATED TO THIS CONDITION WHEN IT MADE THE DEFECT DETERMINATION.TO REMEDY THE DEFECT CONDITION, DCC WILL REPLACE THE HIGH PRESSURE POWER STEERING HOSE ON THE AFFECTED VEHICLES WITH A NEW PART MADE FROM A HOSE MATERIAL WITH INCREASED HEAT RESISTANCE CAPABILITY. CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (2)
Engine And Engine Cooling
ODI HAS RECEIVED 29 REPORTS OF ENGINE COMPARTMENT FIRES THAT APPEAR TO BE RELATED TO POWER STEERING HOSE LEAKAGE IN MODEL YEAR (MY) 1999 AND 2000 CHRYSLER CIRRUS, DODGE STRATUS AND PLYMOUTH BREEZE VEHICLES (JA-CARS) EQUIPPED WITH 2.4L ENGINES.THESE REPORTS INDICATE THAT THE FIRE RESULTED FROM A POWER STEERING HOSE LEAK OR THAT IT OCCURRED AFTER AN EXTENDED DRIVE AND SHORTLY AFTER BEING PARKED - CONDITIONS CONSISTENT WITH IGNITION OF POWER STEERING FLUID ON A HOT ENGINE OR EXHAUST SURFACE DURING THE VEHICLE HOT SOAK PERIOD. ON JANUARY 6, 2006, DAIMLERCHRYSLER CORPORATION (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 1999 AND 2000 JA-CARS BUILT FROM JULY 1, 1998 TO JULY 31, 2000 AND EQUIPPED WITH 2.4L ENGINES (RECALL 06V-001).THE NOTIFICATION STATED THAT ?THE HIGH PRESSURE POWER STEERING HOSE MAY PREMATURELY HEAT, AGE AND DEVELOP A LEAK. POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN AN UNDER HOOD FIRE.DCC INDICATED THAT IT WAS AWARE OF 94 COMPLAINTS AND FIELD REPORTS THAT MAY BE RELATED TO THIS CONDITION WHEN IT MADE THE DEFECT DETERMINATION.TO REMEDY THE DEFECT CONDITION, DCC WILL REPLACE THE HIGH PRESSURE POWER STEERING HOSE ON THE AFFECTED VEHICLES WITH A NEW PART MADE FROM A HOSE MATERIAL WITH INCREASED HEAT RESISTANCE CAPABILITY. CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Steering:hydraulic Power Assist:hose, Piping, And Connections
ODI HAS RECEIVED 29 REPORTS OF ENGINE COMPARTMENT FIRES THAT APPEAR TO BE RELATED TO POWER STEERING HOSE LEAKAGE IN MODEL YEAR (MY) 1999 AND 2000 CHRYSLER CIRRUS, DODGE STRATUS AND PLYMOUTH BREEZE VEHICLES (JA-CARS) EQUIPPED WITH 2.4L ENGINES.THESE REPORTS INDICATE THAT THE FIRE RESULTED FROM A POWER STEERING HOSE LEAK OR THAT IT OCCURRED AFTER AN EXTENDED DRIVE AND SHORTLY AFTER BEING PARKED - CONDITIONS CONSISTENT WITH IGNITION OF POWER STEERING FLUID ON A HOT ENGINE OR EXHAUST SURFACE DURING THE VEHICLE HOT SOAK PERIOD. ON JANUARY 6, 2006, DAIMLERCHRYSLER CORPORATION (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 1999 AND 2000 JA-CARS BUILT FROM JULY 1, 1998 TO JULY 31, 2000 AND EQUIPPED WITH 2.4L ENGINES (RECALL 06V-001).THE NOTIFICATION STATED THAT ?THE HIGH PRESSURE POWER STEERING HOSE MAY PREMATURELY HEAT, AGE AND DEVELOP A LEAK. POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN AN UNDER HOOD FIRE.DCC INDICATED THAT IT WAS AWARE OF 94 COMPLAINTS AND FIELD REPORTS THAT MAY BE RELATED TO THIS CONDITION WHEN IT MADE THE DEFECT DETERMINATION.TO REMEDY THE DEFECT CONDITION, DCC WILL REPLACE THE HIGH PRESSURE POWER STEERING HOSE ON THE AFFECTED VEHICLES WITH A NEW PART MADE FROM A HOSE MATERIAL WITH INCREASED HEAT RESISTANCE CAPABILITY. CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
PE05036 · Engine Compartment Fires
Opened Jun 29, 2005 · Closed Nov 7, 2005
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline
ON JUNE 29, 2005, ODI OPENED PRELIMINARY EVALUATION PE05-036 TO INVESTIGATE COMPLAINTS OF ENGINE COMPARTMENT FIRES IN MODEL YEAR (MY) 1999-2000 CHRYSLER CIRRUS, DODGE STRATUS AND PLYMOUTH BREEZE PASSENGER CARS (JA CARS). THE JA CARS WERE INTRODUCED IN MY 1995 AND ENDED WITH MY 2000.THEY WERE PRODUCED WITH 2.0L, 2.4L AND 2.5L ENGINES.THE INCIDENT DATA IN THE FAILURE REPORT SUMMARY OF THIS RESUME ARE FOR SUBJECT VEHICLE ENGINE COMPARTMENT FIRES FOR ALL CAUSES. ACCORDING TO DAIMLERCHRYSLER, EVIDENCE COLLECTED FROM FIELD INSPECTIONS OF FIRE INCIDENT VEHICLES INDICATE THAT FLUID LEAKAGE FROM THE HIGH PRESSURE POWER STEERING HOSE IS THE MOST LIKELY CAUSE OF THE FIRES IN THE SUBJECT VEHICLES.THE SUBJECT HIGH PRESSURE POWER STEERING HOSE IS USED IN JA CARS WITH BOTH THE 2.4L AND 2.0L ENGINES IN MY 1995 THROUGH 2000.THE FIRE INCIDENT RATE IN THE MY 1999 THROUGH 2000 JA VEHICLES WITH 2.4L ENGINES IS SIGNIFICANTLY HIGHER THAN IN THE PRIOR MODEL YEAR VEHICLES USING THAT ENGINE AND IN ANY OF THE VEHICLES WITH THE 2.0L OR 2.5L ENGINES.DAIMLERCHRYSLER IS CONTINUING ITS INVESTIGATION OF THE ISSUE AND HAS PROVIDED PERIODIC UPDATES TO ODI. AN ENGINEERING ANALYSIS (EA05-019) HAS BEEN OPENED TO FURTHER ASSESS THE SCOPE AND FREQUENCY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
RQ03005 · Auto Trans IGNITION-PARK Interlock
Opened Apr 8, 2003 · Closed Jul 16, 2003
Status: closed (inferred from source dates) · Power Train:automatic Transmission:lever And Linkage:floor Shift
THREE OF THE MANFACTURER COMPLAINTS AND TWO OF THE MANUFACTURER CRASHES REPORTED ABOVE WERE DUPLICATES OF ODI REPORTS.THE MAJORITY OF CRASHES OCCURRED AFTER OPERATORS PARKED THE VEHICLE WITHOUT ENGAGING PARK GEAR POSITION; A NON-FUNCTIONAL IGNITION-PARK INTERLOCK SYSTEM SUBSEQUENTLY FAILED TO PREVENT KEY REMOVAL BEFORE THE OPERATORS EXITED THE VEHICLE.MOST OF THE CRASHES WERE MINOR AND INVOLVED MINOR PROPERTY DAMAGE.FOUR OF THE INJURY INCIDENTS OCCURRED WHEN UNATTENDED CHILDREN MOVED THE GEARSHIFT FROM THE PARK POSITION CAUSING THE VEHICLE TO ROLL AWAY, ONE INJURY OCCURRED WHEN THE OPERATOR WAS STRUCK BY A ROLL-AWAY VEHICLE AFTER PARKING AND EXITING.ALL INJURIES WERE RELATIVELY MINOR.A SIGNIFICANT NUMBER OF INTERLOCK SYSTEM FAILURES APPEAR TO BE RELATED TO DISENGAGEMENT OF THE INTERLOCK PIN THAT RIDES IN THE INTERLOCK LEVER SLOT WITHIN THE SHIFT MECHANISM.AN ENGINEERING ANALYSIS WILL BE OPENED TO FURTHER STUDY INTERLOCK SYSTEM FAILURES.
1999 Chrysler Cirrus Problems, Complaints & Recalls | Skip That Year
Illustration