NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
222 reportsMileage unknown · May 1, 2026
Fuel/propulsion SystemPower TrainVehicle Speed Control
I was driving my 2018 Chevy Volt at about 30 mph on EV mode. The battery was at 50%, the car was performing normally. Then the battery jumped to 100%, the check engine light came on, and the vehicle lost power. I was in rush hour traffic and unable to get the vehicle to go faster than 5-10 mph. I switched to "normal" mod…
Read full complaint
I was driving my 2018 Chevy Volt at about 30 mph on EV mode. The battery was at 50%, the car was performing normally. Then the battery jumped to 100%, the check engine light came on, and the vehicle lost power. I was in rush hour traffic and unable to get the vehicle to go faster than 5-10 mph. I switched to "normal" mode to engage the gasoline engine, hoping this would help but it did not. The gas engine RPM fluctuated wildly and did not restore the ability to accelerate the vehicle. I was still unable to go faster than 5-10 mph. I was a few blocks from home and managed to get home safely. The engine code was P1E00. I put the vehicle on the charger and it seemed fine the next day. This exact situation I ran into - reduced engine power - is addressed in Special Coverage N232432680, which includes this vehicles VIN. I took the car to the GM dealer today and they are telling me that the car is fine, they can find no problems. I mentioned that this issue is covered under Special Coverage N232432680, and was told that unless they can reproduce the issue in the shop, that they cannot apply Special Coverage N232432680.
NHTSA ODI #11735155
Mileage unknown · Apr 29, 2026
Electrical SystemPower Train
The vehicle (2018 Chevrolet Volt) is experiencing an intermittent failure of the Battery Energy Control Module (BECM). Diagnostic trouble code P1E5B was stored in the system. This is a well-documented defect in this vehicle population that frequently results in a sudden, unexpected loss of propulsion power while driving ("Propul…
Read full complaint
The vehicle (2018 Chevrolet Volt) is experiencing an intermittent failure of the Battery Energy Control Module (BECM). Diagnostic trouble code P1E5B was stored in the system. This is a well-documented defect in this vehicle population that frequently results in a sudden, unexpected loss of propulsion power while driving ("Propulsion Power Reduced" mode), posing a significant safety risk in high-speed traffic. Although a Chevrolet dealership confirmed the presence of the stored fault code, they refused to perform the repair under the extended warranty (Special Coverage N23243268) because the Check Engine Light was not actively illuminated at the exact time of inspection. The manufacturer requires the vehicle to be operated until the fault recurs, exposing the driver and others to the danger of stalling on highways or at busy intersections. The failed component remains in the vehicle and is available for inspection.
NHTSA ODI #11734473
Mileage unknown · Apr 3, 2026
Unknown Or Other
Dealer non-Compliance with Recall N192273600 I am reporting Anderson Chevrolet for failure to identify and perform a mandatory federal emission recall while the vehicle was in their possession for service. Because the dealer neglected their statutory duty to perform the free recall repair, I was forced to spend $584.83 at indepe…
Read full complaint
Dealer non-Compliance with Recall N192273600 I am reporting Anderson Chevrolet for failure to identify and perform a mandatory federal emission recall while the vehicle was in their possession for service. Because the dealer neglected their statutory duty to perform the free recall repair, I was forced to spend $584.83 at independent shops to diagnose and fix a defect that is a direct mechanical match to the recall repair. General Motors has denied reimbursement, claiming the independent shops repair is ineligible, despite the fact that the dealer’s original negligence created the need for the independent repair. I did call the General Motors Customer Relations department, was told by Breanna a case would be opened and followed up by Angel. No case number given. Angel called the next day and informed me the reimbursement was denied because services were rendered by an independent shop.
NHTSA ODI #11729081
Mileage unknown · Mar 23, 2026
Fuel/propulsion System
The vehicle losses power on high speed, check engine comes on, low propulsion massage displays. Vehicle does not charge. Issues similar to the investigation DCS6812.
NHTSA ODI #11726565
Mileage unknown · Feb 8, 2026
EngineFuel/propulsion SystemUnknown Or Other
It was the XXX recall for the DTC P0442/check engine light code. The dealership said that the recall had been satisfied in 6/2020 by putting a buffer in to separate the 2 lines but not replacing the part. Now the exact same code DTC P0442/check engine light in the exact spot that occurred for the original recall. The dealership …
Read full complaint
It was the XXX recall for the DTC P0442/check engine light code. The dealership said that the recall had been satisfied in 6/2020 by putting a buffer in to separate the 2 lines but not replacing the part. Now the exact same code DTC P0442/check engine light in the exact spot that occurred for the original recall. The dealership originally quoted $5,093, then after me complaining that it is the same recalled problem they dropped the cots to $2384. I believe that is an agreement that the manufacturer should cover this. Of course I will have to pay to get my car but I would like the manufacturer to reimburse me for it seeing it was a manufacturer default. I spoke to the manufacturer they flat out refused to cover it. I obviously disagree. Would like you to pressure them to change their decision. Thank you, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11716611
Mileage unknown · Dec 22, 2025
Power Train
My 2018 Chevrolet Volt frequently fails to recognize when the vehicle is shifted into Park. The dashboard displays “Shift to Park” even though the gear selector is already in Park. When this occurs, the vehicle will not power off, requiring multiple attempts to move the shifter before shutdown is possible. This creates a safety…
Read full complaint
My 2018 Chevrolet Volt frequently fails to recognize when the vehicle is shifted into Park. The dashboard displays “Shift to Park” even though the gear selector is already in Park. When this occurs, the vehicle will not power off, requiring multiple attempts to move the shifter before shutdown is possible. This creates a safety risk because the vehicle may be left powered on unintentionally and may not properly secure itself in Park. In one occasion, the vehicle moved backwards even when shifter was in Park, which created a collision risk. This is a known defect affecting many GM vehicles, including the Chevrolet Volt, and has been widely reported by owners. I am concerned about unintended vehicle movement, battery drain, and driver safety.
NHTSA ODI #11706600
111,000 miles · Dec 17, 2025
Electrical SystemEngineTires
The contact owns a 2018 Chevrolet Volt. The contact stated that the battery module became inoperable. While attempting to start the vehicle, the message "Engine Unavailable - Service Soon” was displayed. The contact was unable to use the vehicle. The contact stated that the TPMS warning light was illuminated. The contact associa…
Read full complaint
The contact owns a 2018 Chevrolet Volt. The contact stated that the battery module became inoperable. While attempting to start the vehicle, the message "Engine Unavailable - Service Soon” was displayed. The contact was unable to use the vehicle. The contact stated that the TPMS warning light was illuminated. The contact associated the failure with Technical Service Bulletin: 18-NA-261. The contact called the local dealer and was referred to the manufacturer for assistance. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that the VIN was not under recall. The failure mileage was approximately 111,000.
NHTSA ODI #11705567
Mileage unknown · Dec 9, 2025
Electrical SystemFuel/propulsion SystemPower Train
On June 27, 2025, while driving, the vehicle displayed a "Propulsion Power Reduced" warning message and a Check Engine Light illuminated. I immediately experienced a loss of power. I brought the vehicle to an authorized Chevrolet dealer the same day. On July 1, 2025, the dealer diagnosed the failure as a faulty Battery Energy C…
Read full complaint
On June 27, 2025, while driving, the vehicle displayed a "Propulsion Power Reduced" warning message and a Check Engine Light illuminated. I immediately experienced a loss of power. I brought the vehicle to an authorized Chevrolet dealer the same day. On July 1, 2025, the dealer diagnosed the failure as a faulty Battery Energy Control Module (BECM) and high-voltage system fault (Code P1E00), requiring a full replacement of the high-voltage battery pack (Part #24296900). The manufacturer (GM) was contacted, and the replacement battery was ordered on July 2, 2025. As of December 2025, the vehicle remains in dealer possession (over 5 months) with no repair completed. The manufacturer has stated the part is on indefinite backorder with no ETA. The failure of this component renders the vehicle inoperable and presents a safety risk due to sudden loss of propulsion power while in motion. The manufacturer has confirmed the failure but is unable to provide a remedy within a reasonable timeframe.
NHTSA ODI #11704006
129,000 miles · Dec 2, 2025
Electrical System
The contact owns a 2018 Chevrolet Volt. The contact stated that while attempting to start the vehicle, the engine failed to turn over as intended. Additionally, the vehicle would not charge when connected to a charger. The check engine warning light illuminated. The vehicle was taken to a local dealer, where the BECM was reset. …
Read full complaint
The contact owns a 2018 Chevrolet Volt. The contact stated that while attempting to start the vehicle, the engine failed to turn over as intended. Additionally, the vehicle would not charge when connected to a charger. The check engine warning light illuminated. The vehicle was taken to a local dealer, where the BECM was reset. The vehicle was repaired; however, the check engine warning light remained illuminated. In addition, the contact stated that the message "Reduced Power" was displayed on the instrument panel. The vehicle was taken back to the same local dealer where it was diagnosed, and determined that the BECM needed to be replaced. The vehicle was not repaired due to the cost. The contact related the failure to an unknown Chevrolet recall; however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 129,000.
NHTSA ODI #11702424
Mileage unknown · Nov 14, 2025
Electrical SystemFuel/propulsion System
Why in operation the car goes into Shift to Park and Also getting a Propulsion Power Reduce
NHTSA ODI #11699315
Official recalls
2Sep 26, 2018
General Motors LLC (GM) is recalling certain 2018-2019 Cadillac CT6, Escalade ESV, Chevrolet Suburban, Volt, and GMC Yukon XL vehicles. Certain second-row or third-row rear seatbelts retractor assemblies may not automatically lock when the seatbelt is fully pulled out of the retractor, possibly preventing a child seat from being properly secured. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: If the child seat is not properly secured in the event of a crash, it can increase the risk of injury.
Remedy: GM will notify owners, and dealers will inspect the rear seatbelt retractors and replace them if necessary, free of charge. The recall began November 7, 2018. Owners may contact Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 18315.
Aug 30, 2018
General Motors LLC (GM) is recalling certain 2018-2019 Chevrolet Equinox, Impala, Cruze, Volt and Bolt EV vehicles, GMC Terrain vehicles, Buick Lacrosse and Regal vehicles, Cadillac XTS and XTS Professional vehicles and 2018 Chevrolet Malibu vehicles. The rear brake caliper pistons may have an insufficient coating causing gas pockets to form, potentially reducing rear brake performance.
Consequence & remedy
Consequence: A reduction of braking performance can increase the risk of a crash.
Remedy: GM will notify owners, and dealers will bleed the vehicle's brake system, free of charge. The recall began October 11, 2018. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18279.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Illustration