IllustrationThe vehicle has a failure of the BECM and the EGR valve and cooler. Both parts are unavailable. I've been without my car for over a month. The service center cannot tell me when parts will be available.
2018 Chevrolet Volt
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2018 Chevrolet Volt do not stand out strongly from the model-year median of 169.
About this comparison →How this year compares
Owner complaints by model year
Compare all Volt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 50 of 222 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports0 fire reports1 injury reports
Power Train complaints
84 reportsThe car lost propulsion while driving on the interstate, luckily the car was able to make it the shoulder. The check engine light was not on prior to this and it was taken to the dealership where it diagnosed as a faulty battery energy control module (BECM). The part is awaiting replacement, but no spare parts are currently av…
Read full complaint
The car lost propulsion while driving on the interstate, luckily the car was able to make it the shoulder. The check engine light was not on prior to this and it was taken to the dealership where it diagnosed as a faulty battery energy control module (BECM). The part is awaiting replacement, but no spare parts are currently available.
When the vehicle is placed in park and I attempt to turn it off, the dash will indicate the vehicle is not in park and subsequently, the vehicle cannot be turned off. Sometimes, if you wiggle the shifter or move it through all the settings (RNDL) and back to park, it will resolve the issue. Sometimes, it can take a few minutes t…
Read full complaint
When the vehicle is placed in park and I attempt to turn it off, the dash will indicate the vehicle is not in park and subsequently, the vehicle cannot be turned off. Sometimes, if you wiggle the shifter or move it through all the settings (RNDL) and back to park, it will resolve the issue. Sometimes, it can take a few minutes to resolve the issue. It's getting worse. If you can't shut off car someone can steal it, you also can't lock doors.
The contact owns a 2018 Chevrolet Volt. The contact stated that after coming to a complete stop and shifting into park(P), the message "Shift to Park" was displayed. The contact stated that the transmission shifted to park(P) after several attempts to park the vehicle. The contact then turned off the vehicle. The local dealer a…
Read full complaint
The contact owns a 2018 Chevrolet Volt. The contact stated that after coming to a complete stop and shifting into park(P), the message "Shift to Park" was displayed. The contact stated that the transmission shifted to park(P) after several attempts to park the vehicle. The contact then turned off the vehicle. The local dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The failure mileage was 25,000.
While driving my 2018 chevy volt I received a reduced propulsion error. I pulled over to assess and turn off the car and turn it back on only to find when I turned it back on I received an enginer failure error and the car would not drive forward or reverse. I had to have it towed to a Chevy dealership for evaluation. I unders…
Read full complaint
While driving my 2018 chevy volt I received a reduced propulsion error. I pulled over to assess and turn off the car and turn it back on only to find when I turned it back on I received an enginer failure error and the car would not drive forward or reverse. I had to have it towed to a Chevy dealership for evaluation. I understand from research and talking to service experts this is a common failure among the 2017 and 2018 Chevy volt and it is abhorrent that Chevy has not issued a recall on a common failure that compromises the safety of the driver and other drivers around them.
Car doesn't shift into gear, just goes into neutral. Car says 'shift into park' and won't turn off when in park and the power button is pushed.
On Nov 21, 2022, after approximately of 10 minutes (5 miles of driving), while attempting to accelerate from a stop, the vehicle lost the ability to accelerate. The vehicle was in full EV mode in the middle of a busy intersection. The vehicle had a full charge (50+ EV range remaining or 100% total EV remaining). The driver attem…
Read full complaint
On Nov 21, 2022, after approximately of 10 minutes (5 miles of driving), while attempting to accelerate from a stop, the vehicle lost the ability to accelerate. The vehicle was in full EV mode in the middle of a busy intersection. The vehicle had a full charge (50+ EV range remaining or 100% total EV remaining). The driver attempted to press down more on the accelerator to no avail. After approximately 5-10 seconds, in the busy intersection, without the ability to make the vehicle accelerate, the driver noticed the vehicle jerk (which occurred 2-3 times) at which point the ICE turned on and provided power to the vehicle, allowing the driver to drive out of the intersection. After several minutes of driving, the driver noticed "Reduced propulsion warning" was noticed/illuminated in addition to "Check Engine Light". After this point, the driver noted that the propulsion felt approximately 20% of "normal propulsion". The driver was also concerned about the ability to drive up very small hills due to reduction of propulsion/power. Upon arrival at the destination (2-3 miles from incident), the vehicle was safely parked, the vehicle's codes were checked with an OBD2 code reader and 19 codes were noted. Given the manifestation and safety issue of the vehicle, the vehicle was towed to Quality Chevrolet in Escondido where it remains as of 1/10/23. The codes collected on 11/21/22 include the following: 1. P0A46, 2. P0AC4, 3. P1E00, 4. P1B0B, 5. P1B43, 6. P1E1E, 7. P0AC4, 8. P1E00, 9. P0A46, 10. P1AF0, 11. P1AF2, 12. P1B0B, 13. P1B43, 14. P1E1E, 15. P1E22, 16. P0A46, 17. P1B0B, 18. P1B43, 19. P1E1E. Per the OBD2 code reader, the primary code was P0A46 (Drive Motor 2 Position Sensor Performance). As of 1/9/23, the dealer has indicated that the primary problem is with the entire Transmission assembly which requires replacement. The replacement assembly is not in stock, is back-ordered and there is no ETA to receive the transmission assembly. The vehicle has 32243 miles on it.
Reduc d propulsion power warning while driving in EV mode. ICE started and was able to make it 1/2 mile home. Failure diagnosed to a faulty BECM. Has been at the dealer for 1 month today with no word on when the part or repair will be done.
The gear shifter for the Chevy Volt has an issue where it does not register in Park. I need to contantlty move through the gears to have it be in park.
I put it in park, and try to turn off the car, but it says "Shift to Park", and won't let me turn off the car.
Official recalls
218V673000 · Seat Belts:rear/other
Sep 26, 2018
General Motors LLC (GM) is recalling certain 2018-2019 Cadillac CT6, Escalade ESV, Chevrolet Suburban, Volt, and GMC Yukon XL vehicles. Certain second-row or third-row rear seatbelts retractor assemblies may not automatically lock when the seatbelt is fully pulled out of the retractor, possibly preventing a child seat from being properly secured. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: If the child seat is not properly secured in the event of a crash, it can increase the risk of injury.
Remedy: GM will notify owners, and dealers will inspect the rear seatbelt retractors and replace them if necessary, free of charge. The recall began November 7, 2018. Owners may contact Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 18315.
18V576000 · Service Brakes, Hydraulic:foundation Components:disc:caliper
Aug 30, 2018
General Motors LLC (GM) is recalling certain 2018-2019 Chevrolet Equinox, Impala, Cruze, Volt and Bolt EV vehicles, GMC Terrain vehicles, Buick Lacrosse and Regal vehicles, Cadillac XTS and XTS Professional vehicles and 2018 Chevrolet Malibu vehicles. The rear brake caliper pistons may have an insufficient coating causing gas pockets to form, potentially reducing rear brake performance.
Consequence & remedy
Consequence: A reduction of braking performance can increase the risk of a crash.
Remedy: GM will notify owners, and dealers will bleed the vehicle's brake system, free of charge. The recall began October 11, 2018. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18279.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.