The drivers side front seatbelt pretensioner assembly contains a braided steel cable. The cable, through normal use, has become damaged to the point that individual wires have broken free from the crimped connector. The damaged wires of the cable have penetrated through the plastic sheath covering the cable causing a needle sha…
Read full complaint
The drivers side front seatbelt pretensioner assembly contains a braided steel cable. The cable, through normal use, has become damaged to the point that individual wires have broken free from the crimped connector. The damaged wires of the cable have penetrated through the plastic sheath covering the cable causing a needle sharp poking hazard when reaching one’s hand toward the seat back adjustment lever. My wife had a minor laceration to her finger and I was also poked when trying to identify the cause. Upon further inspection I found that approximately 80 percent of the diameter of the pretensioner cable had broken free from the crimped connector. In the event of a collision, the cable would likely break free from the seatbelt, possibly causing serious injury to the driver. I tried to obtain a replacement part through the GM dealer parts network, but the part is listed as discontinued and unavailable. This leaves the vehicle unsafe in the event of an accident. The damaged components are available for inspection. The vehicle has not been inspected by anyone but myself. There were no warning lamps or symptoms of the problem prior the the injury. I am the original owner of the vehicle and it has never been involved in a collision. The vehicle has been properly maintained and is used only for personal transportation.
NHTSA ODI #11690373
Mileage unknown · Apr 20, 2023
Air BagsSeat BeltsCrashInjury
Passenger Airbags failed to engage when occupied during accident, drivers side activated. Results in injured passenger
NHTSA ODI #11517990
Mileage unknown · Nov 26, 2022
Seat Belts
There are two issues with the seat belt on the driver’s seat. 1) The buckle (female portion, the part with the button) is stuck and won’t release the tongue (male portion) without intervention with a screwdriver. 2) The plastic portion of the tongue (male portion) of the seatbelt caught on my clothes and snapped, and the whole t…
Read full complaint
There are two issues with the seat belt on the driver’s seat. 1) The buckle (female portion, the part with the button) is stuck and won’t release the tongue (male portion) without intervention with a screwdriver. 2) The plastic portion of the tongue (male portion) of the seatbelt caught on my clothes and snapped, and the whole tongue assembly fell off the webbing. Definitely a safety concern if there’s no longer a way to buckle the seat belt because the male end fell off.
NHTSA ODI #11494959
7,500 miles · Apr 15, 2014
Air BagsSeat Belts
WHEN A CELL PHONE IS PLACED ON THE CENTER OF THE PASSENGER SEAT, THE PASSENGER SEAT BELT WARNING LIGHT ILLUMINATES AND ARMS THE PASSENGER AIR BAG. NO WEIGHT REQUIRED. *TT
General Motors, LLC (GM) is recalling certain 2013 Buick Verano, Chevrolet Camero, Sonic, and Volt vehicles. The driver-side air bag inflator may explode during deployment due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver-side air bag module, free of charge. On some 2013 Volt vehicles, the steering wheel will be replaced as well, free of charge. Owner notification letters were mailed October 23, 2023. Owners may contact Buick customer service at 1-800-521-7300 and Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N232413120.
General Motors LLC (GM) is recalling certain 2013 Chevrolet Volt vehicles. An update to the Hybrid Powertrain Control Module 2 (HPCM2) may have disabled the cell balancing function causing a low-voltage condition.
Consequence & remedy
Consequence: If the voltage drops, the vehicle may lose propulsion, increasing the risk of crash.
Remedy: GM will notify owners, and dealers will reprogram the HPCM2, free of charge. The recall began July 24, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18215.
General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Consequence & remedy
Consequence: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Consequence: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
Engine And Engine Cooling:engine:gasoline
General Motors LLC (GM) is recalling certain model year 2011-2013 Volt vehicles manufactured August 25, 2010, to June 26, 2013. If the driver exits the vehicle without turning off the electrical system, the battery may drain low enough that the gasoline engine will automatically start itself to recharge the electric battery.
Consequence: If the engine runs for an extended period of time in an enclosed space, there may be a build up of carbon monoxide, increasing the risk of personal injury.
Remedy: GM will notify owners, and dealers will update the engine management software to limit the time that the stationary vehicle can be left in the ON position, free of charge. The recall began April 15, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14617.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
PE19013 · Passenger Sensing System
Opened Sep 17, 2019 · Closed Jul 2, 2021
Status: closed (inferred from source dates) · Air Bags:sensor:occupant Classification:front Passenger
In September 2019, the Office of Defects Investigation (ODI) opened PE19-013 to assess the potential safety related effects of a malfunction of the Passenger Sensing System (PSS) in 2012-2013 Model Year (MY) Chevrolet Volt vehicles. Consumers reported that due to a malfunction of the PSS, the air bag system malfunction indicator light (MIL) was activated. Many of the complaints noted the malfunction occurred after the warranty period expired and mentioned high repair costs as a major deterrent to the repair of the vehicle.The PSS sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the frontal passenger air bag. The PSS may develop a malfunction due to bunching of the sensor mat in the seat trench. The bunching of the sensor mat could cause the mat to repeatedly fold in the same location. Over time, the repeated folding can cause an increased resistance in the sensor mat. An increased resistance in the PSS sensor mat is detected as a fault in the air bag system diagnostic. If this fault is detected, a diagnostic trouble code will be stored in the air bag control unit and the air bag MIL will illuminate.Further, if the fault is detected, the passenger frontal and knee air bags will be suppressed in a crash of sufficient severity to warrant a commanded deployment regardless of the nature of size of the occupant of the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the PSS sensor mat. Reports alleging only that the air bag light is on with no cause stated, or where a different cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than a PSS malfunction.The subject vehicles have been in service for approximately ten (10) years. An analysis of General Motors (GM) warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar occupant detection system failure investigations, indicates the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.GM has instituted a cost reduction program for the repair/replacement of the PSS in the subject vehicles. Based on this cost reduction program as well as:1) a comparatively low warranty rate; 2) no reported injuries, deaths or asymmetric deployments; and 3) the age of the vehicles; ODI is closing this Preliminary Evaluation. The closing of this investigation does not constitute a finding by NHTSA that a safety related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
2013 Chevrolet Volt Problems, Complaints & Recalls | Skip That Year
Illustration