Engine And Engine CoolingFuel System, GasolineService Brakes, Hydraulic
1ST THE CHECK ENGINE LIGHT KEEPS COMING ON AND WHEN PUT ON DIAGNOSTIC CODE CAME BACK PO463. THE VAN WOULDN'T PASS EMISSIONS AND WHEN YOU FILL UP WITH GAS IT WOULD SAY IT WAS EMPTY. THERE'S A LOUD POPPING NOISE SOUNDS LIKE AT AXLE. IT DOES THIS AFTER YOU STOP AT RED LIGHTS. I WAS TOLD THIS HAD TO DO WITH AXLE AND COULD BRAKE AND …
Read full complaint
1ST THE CHECK ENGINE LIGHT KEEPS COMING ON AND WHEN PUT ON DIAGNOSTIC CODE CAME BACK PO463. THE VAN WOULDN'T PASS EMISSIONS AND WHEN YOU FILL UP WITH GAS IT WOULD SAY IT WAS EMPTY. THERE'S A LOUD POPPING NOISE SOUNDS LIKE AT AXLE. IT DOES THIS AFTER YOU STOP AT RED LIGHTS. I WAS TOLD THIS HAD TO DO WITH AXLE AND COULD BRAKE AND CAUSE FATAL ACCIDENT, THE ABS LIGHT KEEPS COMING ON AND THE BRAKING SYSTEM SCARED ME TO DEATH. THE DOORS CONSTANTLY CHIME OR DING AND THE DOORS WILL OPEN GOING DOWN THE ROAD. I WAS SO UPSET BECAUSE I HAVE TO TRANSPORT MY ELDERLY AUNT AND TWO CHILDREN AND BEFORE I WAS ABOUT TO PAY TO HAVE ALL THIS FIXED I DECIDED TO CHECK OUT RECALL. I AM SO SHOCKED THAT YOU CAN LOOK THIS UP ONLINE AND THEY ARE 1000 DOCUMENTED COMPLAINTS ON ALL THE SAME PROBLEMS BUT YET NO RECALLS. IS IT GOING TO TAKE PEOPLE GETTING KILLED TO DO THIS. I AM PRAYING FOR SOMETHING LESS TRAGIC AND TRYING TO SAVE THESE PRECIOUS LIVES. THERE IS RESEARCH AND LAWSUITS THAT THE CHEVROLET UPLANDERS HAVE A LOT OF THESE PROBLEMS FROM 2005 TO 2008 ESPECIALLY WITH THE DOORS AND LIKE ME EVERYONE GETS ANNOYED AND UNPLUGS THEM AND HAVE TO USE THEM MANUALLY BUT WHY SHOULD WE WHEN ARE STILL PAYING FOR AUTOMATIC DOORS. THIS VAN IS TRULY UNSAFE AND A LEMON. I PRAY TO GOD EVERYDAY TO KEEP ME SAFE WHILE DRIVING AND HAVE TOLD MY HUSBAND IF I DIE WHILE DRIVING THIS VEHICLE HE SHOULD SUE!!! UPDATED 01/17/12 *BF THE CONSUMER STATED GM CALLED AND ASKED HER TO BRING THE VAN IN FOR A DIAGNOSTIC TEST. THEY STATED SHE WOULD HAVE TO PAY FOR THE TEST. THE FUEL SENSOR WAS REPLACED IN 2006. HOWEVER, THE CONSUMER STATED IT HAD TO BE REPLACED AGAIN. THEY ALSO ALIGNED THE DOORS IN 2008 WHICH WAS PROOF OF AN ONGOING PROBLEM. UPDATED 01/18/12 *TR
NHTSA ODI #10443302
40,000 miles · Dec 13, 2011
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
REAR PASSENGER SLIDING DOOR OPENS WHILE DRIVING. MOTOR DIES. MOTOR REPLACED. REAR PASSENGER SLIDING DOOR OPENS WHILE DRIVING. MOTOR DIES. MOTOR REPLACED. REAR PASSENGER SLIDING DOOR OPENS WHILE DRIVING. MOTOR DIES. MOTOR REPLACED. CAR WON'T TURNOVER TO START CAR WITHOUT HOLDING DOWN THE GAS PEDAL. HAD PARTS REPLACE…
Read full complaint
REAR PASSENGER SLIDING DOOR OPENS WHILE DRIVING. MOTOR DIES. MOTOR REPLACED. REAR PASSENGER SLIDING DOOR OPENS WHILE DRIVING. MOTOR DIES. MOTOR REPLACED. REAR PASSENGER SLIDING DOOR OPENS WHILE DRIVING. MOTOR DIES. MOTOR REPLACED. CAR WON'T TURNOVER TO START CAR WITHOUT HOLDING DOWN THE GAS PEDAL. HAD PARTS REPLACED. CAR WON'T TURNOVER TO START CAR WITHOUT HOLDING DOWN THE GAS PEDAL. HAD PARTS REPLACED. CAR WON'T TURNOVER TO START CAR WITHOUT HOLDING DOWN THE GAS PEDAL. HAD PARTS REPLACED. *TR
NHTSA ODI #10439757
Mileage unknown · Sep 12, 2006
Engine And Engine Cooling
MUFFLER WAS MAKING A LOUD NOISE WHEN ACCELERATOR IS DEPRESSED BRISKLY. FIRST MUFFLER WAS REPLACED, SECOND MUFFLER MAKES THE SAME LOUD NOISE WHEN ENGINE IS HOT AND ACCELERATOR IS DEPRESSED BRISKLY AS WELL. WAS TOLD THIS MAY BE A NORMAL CHARACTERISTIC OF THE VEHICLE. *NM
NHTSA ODI #10167954
Mileage unknown · Apr 30, 2006
Engine And Engine Cooling
I PURCHASED A BRAND NEW CHEVROLET UPLANDER 2006 85 MILES ON FEB 20, 2006. ON FEB 21, 2006, AS I TURNED ON THE ENGINE A MESSAGE STATED "LOW OIL PRESSURE, SERVICE ENGINE SOON". I BROUGHT IT TO THE DEALER THEY TOLD ME THE FORGOT TO RESET OIL LIGHT AFTER DEAL PREP. I WEEK AFTER SAME MESSAGE. ON APRIL 17, 2006 , MY VAN WAS IN …
Read full complaint
I PURCHASED A BRAND NEW CHEVROLET UPLANDER 2006 85 MILES ON FEB 20, 2006. ON FEB 21, 2006, AS I TURNED ON THE ENGINE A MESSAGE STATED "LOW OIL PRESSURE, SERVICE ENGINE SOON". I BROUGHT IT TO THE DEALER THEY TOLD ME THE FORGOT TO RESET OIL LIGHT AFTER DEAL PREP. I WEEK AFTER SAME MESSAGE. ON APRIL 17, 2006 , MY VAN WAS IN THE SHOP FOR FOUR DAYS. THE CHANGED OIL PUMP. THE SAME DAY WHILE DRIVING HOME THE SAME MESSAGE CAME ON AGAIN. I TOOK THE VAN IN AGAIN . I AM WAITING FOR DEALER TO CONTACT ME. *NM
THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.
Consequence & remedy
Consequence: A SQUEAKING OR CLUNKING NOISE MAY DEVELOP. THE TRAILING ARM BUSHINGS MAY PREMATURELY WEAR AND THE TRAILING ARM MAY FRACTURE OR SEPARATE, ALLOWING THE REAR AXLE TO BECOME PARTIALLY SEPARATED FROM THE CHASSIS INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.
CERTAIN CARGO VANS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARDS NO. 110, "TIRE SELECTION AND RIMS" AND NO. 120. "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THESE CARGO VANS WERE SHIPPED WITHOUT A TIRE AND LOADING INFORMATION LABELS BECAUSE THEY WERE INCORRECTLY DESIGNATED AS INCOMPLETE VEHICLES.
Consequence & remedy
Consequence: WITHOUT THE PROPER LABELS, OWNERS MAY BE UNAWARE OF THE CORRECT TIRE SIZE AND MAY OVERLOAD THESE VEHICLES.
Remedy: OWNERS WILL BE PROVIDED WITH NEW TIRE AND LOADING INFORMATION LABELS AND CERTIFICATION LABELS. AT THE CUSTOMER'S OPTION, A DEALER CAN PERFORM THE INSTALLATION FOR THEM. THE RECALL BEGAN ON MARCH 15, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
Consequence & remedy
Consequence: A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
2006 Chevrolet Uplander Problems, Complaints & Recalls | Skip That Year
Illustration