TL* - THE CONTACT CALLED REGARDING THE 2005 CHEVROLET UPLANDER. THE CONTACT STATED THAT THE POWER SLIDING DOOR OPENED AND CLOSED UNEXPECTEDLY. THE CONTACT TOOK THE VEHICLE IN TO THE DEALER FIVE TIMES. THE DEALE ADVISED THE CONTACT THAT EITHER THEY COULD NOT DUPLICATE THE FAILURE OR THAT THEY HAD REPAIRED IT. ON ONE OCCA…
Read full complaint
TL* - THE CONTACT CALLED REGARDING THE 2005 CHEVROLET UPLANDER. THE CONTACT STATED THAT THE POWER SLIDING DOOR OPENED AND CLOSED UNEXPECTEDLY. THE CONTACT TOOK THE VEHICLE IN TO THE DEALER FIVE TIMES. THE DEALE ADVISED THE CONTACT THAT EITHER THEY COULD NOT DUPLICATE THE FAILURE OR THAT THEY HAD REPAIRED IT. ON ONE OCCASION, THE DEALER REINSTALLED A LOOSE LOCK ROD. ON ANOTHER OCCASION, THE DEALER REPROGRAMMED THE SLIDING DOOR MODULE. THE FAILURE MILEAGE WAS 24,000. WHEN THE DOOR MALFUNCTIONED THE WARNING INDICATOR WAS A BELL ALERTING HER THE DOOR OPENED, THERE WERE NO OTHER WARNING INDICATORS. THE FRONT TWO TIRES WERE REPLACED AT 14,000 MILES DUE TO EXCESSIVE WEAR. THE BACK TWO TIRES WERE REPLACED AT 24,000 DUE TO EXCESSIVE WEAR. THE CONTACT STATED AT 37,000 MILES, THE VEHICLE NEEDED FOUR NEW TIRES DUE TO WEAR. THE DEALER SAID THE CAUSE WAS DUE TO THE TIRES NOT HAVING BEEN ALIGNED WHEN THE TIRES WERE REPLACED. THE CONTACT STATED THAT THE BRAKES HAVE HAD TO BE RESURFACED TWICE. SHE HEARD A KNOCKING NOISE IN THE FRONT END OF THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO DEALER FOUR TIMES. THE DEALER REPLACED TWO STEERING GEARS IN THE STEERING COLUMN. THE DEALER REPLACED STRUTS AND THE STABILIZER BAR, HOWEVER THE KNOCKING NOISE CONTINUED. THE CONTACT HAD THE REPAIR. INVOICES. THE CURRENT MILEAGE WAS 37000.*AK
NHTSA ODI #10184034
26,000 miles · Nov 28, 2006
Electrical SystemExterior LightingSuspension
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THE FRONT SUSPENSION PULLED TO THE LEFT AND RIGHT SIDE WITHOUT WARNING. THE VEHICLE'S FRONT SUSPENSION WAS INSPECTED BY THE DEALER WHO DETERMINED A FRONT ALIGNMENT WAS NEEDED. AFTERWARDS, THE PROBLEM PERSISTED, AND THE VEHICLE WAS RETURNED TO THE DEALER, WHO DETERMINED ALL …
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THE FRONT SUSPENSION PULLED TO THE LEFT AND RIGHT SIDE WITHOUT WARNING. THE VEHICLE'S FRONT SUSPENSION WAS INSPECTED BY THE DEALER WHO DETERMINED A FRONT ALIGNMENT WAS NEEDED. AFTERWARDS, THE PROBLEM PERSISTED, AND THE VEHICLE WAS RETURNED TO THE DEALER, WHO DETERMINED ALL FOUR TIRES WERE WORN AND NEEDED TO BE REPLACED. THE TIRES WERE CONTINENTAL P225/60R17. ADDITIONALLY, THE DASH INSTRUMENT CLUSTER PANEL LIGHTS AND HEADLIGHTS FLICKERED ON AND OFF WHILE THE VEHICLE WAS AT AN IDLE. THE VEHICLE WAS INSPECTED BY THE DEALER, WHO DETERMINED THE SENSOR FOR THE EXTERIOR LIGHTS NEEDED TO BE REPLACED. AFTER REPLACEMENT OF THE TIRES AND LIGHTING SENSORS, THE PROBLEMS PERSISTED. THE MANUFACTURER WAS ALERTED.
NHTSA ODI #10174574
11,000 miles · Jan 6, 2006
Engine And Engine CoolingSuspension
DT*: THE CONTACTED STATED THE VEHICLE MAKES NOISE AND VIBRATES EXCESSIVELY WHEN PRESSING THE ACCELERATOR PEDAL OR TURNING THE STEERING WHEEL TO THE LEFT AND RIGHT. VEHICLE SPEED DOES NOT AFFECT THE SOUND OR VIBRATION. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER SEVERAL TIMES FOR INSPECTION. THE LOCAL DEALER NEVER DIAGNOSED THE PRO…
Read full complaint
DT*: THE CONTACTED STATED THE VEHICLE MAKES NOISE AND VIBRATES EXCESSIVELY WHEN PRESSING THE ACCELERATOR PEDAL OR TURNING THE STEERING WHEEL TO THE LEFT AND RIGHT. VEHICLE SPEED DOES NOT AFFECT THE SOUND OR VIBRATION. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER SEVERAL TIMES FOR INSPECTION. THE LOCAL DEALER NEVER DIAGNOSED THE PROBLEM. SO THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION. THE MECHANIC FOUND THE FOLLOWING PROBLEMS WITH THE VEHICLE AND NOTED THEM ON A SERVICE INVOICE "RUB MARKS ON THE LEFT DRIVE AXLE, THE REAR MOTOR MOUNT IS NOT HOLDING THE ENGINE SOLID AND THE ENGINE IS MOVING EXCESSIVELY ON THE CRADLE." THE INDEPENDENT MECHANIC SUSPECTS THE CASTER OR CAMBER MAY BE OUT CAUSING OUTER TIRE WEAR ON BOTH THE PASSENGER AND DRIVER SIDE TIRES. THE INDEPENDENT REPAIR SHOP ONLY INSPECTED THE VEHICLE AND THEY NEVER MADE ANY REPAIRS, AS THE VEHICLE WAS UNDER WARRANTY. THE VEHICLE WAS RETURNED TO THE SERVICE DEALER WHO NEVER DIAGNOSED A SPECIFIC PROBLEM. HOWEVER, THE DEALER REPLACED THE TIRES, STRUTS, HUBS AND SOME UNDERCARRIAGE PARTS. THE CONTACT FINALLY RECEIVED A CALL FROM THE MANUFACTURER OFFERING TO PROVIDE THE CONTACT WITH A REPLACEMENT VEHICLE. THE MANUFACTURER DETERMINED THE VEHICLE COULD NOT BE REPAIRED BECAUSE OF DAMAGE TO THE UNDER CARRIAGE, HOWEVER THE MANUFACTURER NEVER SPECIFIED HOW THEY CAME TO THIS CONCLUSION.*AK
THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.
Consequence & remedy
Consequence: A SQUEAKING OR CLUNKING NOISE MAY DEVELOP. THE TRAILING ARM BUSHINGS MAY PREMATURELY WEAR AND THE TRAILING ARM MAY FRACTURE OR SEPARATE, ALLOWING THE REAR AXLE TO BECOME PARTIALLY SEPARATED FROM THE CHASSIS INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.
Consequence & remedy
Consequence: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.
ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.
Consequence & remedy
Consequence: IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
PE05063 · Electrical Harness Damage
Opened Nov 29, 2005 · Closed Mar 6, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2005 Chevrolet Uplander Problems, Complaints & Recalls | Skip That Year
Illustration