IllustrationPASSENGER SIDE HEADLAMP BULB HOLDER LOOSENED AND FELL TO REST ON HEADLIGHT HOUSING MELTING THE PLASTIC AND STARTED A FIRE,MELTED WIRING HARNESS COMPLETE HEADLIGHT ASSEMBLY AND HEADLIGHT MOUNTING ASSEMBLY, FIRE WAS PUT OUT RIGHT AWAY COULD HAVE BURN THE WHOLE CAR FLAMES WHERE SHOOTING OUT OF ENGINE COMPARTMENT. *TR
2005 Chevrolet Uplander
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Chevrolet Uplander do not stand out strongly from the model-year median of 119.
About this comparison →How this year compares
Owner complaints by model year
Compare all Uplander years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
670–25K
2225–50K
2950–75K
1475–100K
17100–150K
11150K+
160 reports with mileage · 36 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Latches/locks/linkages. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports1 fire reports16 injury reports
Electrical System complaints
57 reportsTHIS 2005 CHEVY UPLANDER HAS HAD ELECTRICAL PROBLEMS SINCE I TOOK IT OFF THE SHOWROOM FLOOR, FROM ALL LIGHTS FLASHING INTERIOR DASH AND EXTERIOR AS WELL. FUEL SYSTEM LIGHTS AS WELL AS JUST ABOUT EVERY OTHER FAILURE WARNINGS INSIDE THIS VEHICLE, TO NO FUEL JUST AFTER FILL UP, TO SERVICE ABS SYSTEM AND DOOR OPENS ON AND OFF SINCE …
Read full complaint
THIS 2005 CHEVY UPLANDER HAS HAD ELECTRICAL PROBLEMS SINCE I TOOK IT OFF THE SHOWROOM FLOOR, FROM ALL LIGHTS FLASHING INTERIOR DASH AND EXTERIOR AS WELL. FUEL SYSTEM LIGHTS AS WELL AS JUST ABOUT EVERY OTHER FAILURE WARNINGS INSIDE THIS VEHICLE, TO NO FUEL JUST AFTER FILL UP, TO SERVICE ABS SYSTEM AND DOOR OPENS ON AND OFF SINCE I OWNED IT, EVERY TIME I BROUGHT IT IN FOR SERVICE THEY TOLD ME THAT IT NEEDS TO BE HAPPENING AT THAT TIME OTHERWISE THEY CANT FIX IT!! JUST NOW AFTER SEEING ALL THE COMPLAINTS ABOUT THIS POOR MADE PIECE OF S..IT. I HAD TO HAVE MY HEAD EXAMINED TO BUY THIS CAR OFF THE LEASE I HAD. AS THE ONLY OWNER OF THE CAR I KNOW ITS NOT MY LACK OF MAINTENANCE CAUSE THE PROBLEMS, ITS THE MULTI BILLION DOLLAR GM SHOULD BE HELD ACCOUNTABLE FOR THIS. SOMEONE PLEASE HELP US WITH THIS ISSUE, AND BAIL US OUT JUST LIKE GM HAS BEEN, WERE JUST AVERAGE PEOPLE TRYING TO GET BY. *TR
THE PASSENGER SIDE POWER SLIDING DOOR DOES NOT CLOSE PROPERLY AND OPENS ON ITS OWN INTERMITTENTLY. ALSO, ONCE THE DOOR IS CLOSED THE "OPEN DOOR CHIME" DOES NOT STOP. THE CHIME CONTINUES TO GO OFF WHILE DRIVING, PARKED AND WHEN THE CAR IS TURNED OFF WITH THE KEY OUT OF THE IGNITION. THIS IS OBVIOUSLY A SAFETY ISSUE. I TRIED CONTA…
Read full complaint
THE PASSENGER SIDE POWER SLIDING DOOR DOES NOT CLOSE PROPERLY AND OPENS ON ITS OWN INTERMITTENTLY. ALSO, ONCE THE DOOR IS CLOSED THE "OPEN DOOR CHIME" DOES NOT STOP. THE CHIME CONTINUES TO GO OFF WHILE DRIVING, PARKED AND WHEN THE CAR IS TURNED OFF WITH THE KEY OUT OF THE IGNITION. THIS IS OBVIOUSLY A SAFETY ISSUE. I TRIED CONTACTING THE DEALERSHIP WHERE THE VEHICLE WAS PURCHASED AND EXPLAINED TO THEM THE SAFETY HAZARD DEFECT BUT WAS TOLD THAT THEY WILL NOT FIX THE PROBLEM UNLESS I PAID FOR IT. AFTER DOING FURTHER RESEARCH, I HAVE FOUND THAT THIS IS A VERY COMMON PROBLEM FOR ALL GM MINI VANS ESPECIALLY THE UPLANDER MINI VANS, WITH POWER SLIDING DOORS. HOWEVER, SINCE THERE HASN'T BEEN AN OFFICIAL SAFETY RECALL, DEALERSHIPS WILL NOT FIX THE PROBLEM WITHOUT PAYMENT. AGAIN THIS IS A SAFETY PROBLEM AND A RECALL SHOULD BE ISSUED. *TT
PURCHASED 2005 CHEVY UPLANDER APRIL 2010. NOT EVEN A MONTH OR LESS HAVING IT HAD TO REPLACE VOLTAGE REGULATOR/ALTERNATOR/RADIO/STARTER. THE LIGHTS WOULD DIM, FLICKER, WOULDN'T START. NOW ONE YEAR LATER THE SAME PROBLEM AS RETURN AND THIS TIME IT CUT OFF GOING DOWN THE ROAD. IT WONT START SOMETIMES AND THE VOLTAGE READER GOES U…
Read full complaint
PURCHASED 2005 CHEVY UPLANDER APRIL 2010. NOT EVEN A MONTH OR LESS HAVING IT HAD TO REPLACE VOLTAGE REGULATOR/ALTERNATOR/RADIO/STARTER. THE LIGHTS WOULD DIM, FLICKER, WOULDN'T START. NOW ONE YEAR LATER THE SAME PROBLEM AS RETURN AND THIS TIME IT CUT OFF GOING DOWN THE ROAD. IT WONT START SOMETIMES AND THE VOLTAGE READER GOES UP AND DOWN. IT IS THE SAME PROBLEM OCCURRING. THIS IS VERY UNSAFE TO BE DOING THIS AND YOU SHOULD HAVE NOT TO REPLACE THE SAME PARTS EVERY YEAR! *TR
WE HAVE HAD 3 CHEVY UPLANDER VANS RECENTLY AND THE POWER DOORS LIKE TO COME OPEN ON THEIR OWN WHEN YOU ARE DRIVING AT VARIOUS SPEEDS. THIS IS VERY DANGEROUS IF YOU HAVE CHILDREN. THE DOOR CHIME ALSO KEEPS DINGING AND MAKING NOISE EVEN WHEN THE DOOR IS CLOSED. *TR
BOUGHT MINI-VAN NEW IN 2005 HAS ONLY 24000 MILES ON IT. IT HAS BEEN BACK TO 2 DIFFERENT DEALERS 22 TIMES,FOR ELECTRICAL ISSUES. THE POWER SLIDING DOOR'S OPEN UP THEMSELVES SOMETIMES WHILE YOUR ARE DRIVING SOMETIMES WHILE IT IS PARKED.(DOOR'S ARE LOCKED STILL DOES IT.)HAVE HAD 5 DVD PLAYER'S REPLACED ,REAR WIPER MOTOR REPLACED,2 …
Read full complaint
BOUGHT MINI-VAN NEW IN 2005 HAS ONLY 24000 MILES ON IT. IT HAS BEEN BACK TO 2 DIFFERENT DEALERS 22 TIMES,FOR ELECTRICAL ISSUES. THE POWER SLIDING DOOR'S OPEN UP THEMSELVES SOMETIMES WHILE YOUR ARE DRIVING SOMETIMES WHILE IT IS PARKED.(DOOR'S ARE LOCKED STILL DOES IT.)HAVE HAD 5 DVD PLAYER'S REPLACED ,REAR WIPER MOTOR REPLACED,2 RADIOS,HEATED SEAT COIL, FRONT END PARTS REPLACED TWICE WITHIN 2000 MILES NEW TIRES AT 11,000 MILES (ALL 4 ) FUEL SYSTEMPARTS REPLACED, REAR AXLE SERVICED TWICE WITHIN 1,000 MILES,POWER SYSTEM REPAIRED 3 TIMES,BRAKES ROTORS RESURFACED 2 TIMES AFTER ONLY10,000 MILES,HEADLIGHT NOT WORKING PROPERLY (HAVE COMPLAINED ABOUT THAT 3 TIMES HAVE NOT FOUND PROBLEM,STILL DOES IT),ENGINE HARMONIC BALANCER BOLT LOOSE RETIGHTEN, PLUS MUCH MORE .THAT IS THE SHORT LIST.HAVE MADE CLAIM WITH BETTER BUSINESS BUREAU WOULD NOT DO ANYTHING.HAVE FILED CLAIMS WITH GENERAL MOTOR'S TALKED WITH 4 UPPER MANAGEMENT PERSONAL THEY HAVE DECIDED THE ONLY THING THEY WHAT TO DO IS OFFER US A $1000 TOWARD A NEW GENERAL MOTOR'S CAR.THE PROBLEM WITH THAT IS I DO NOT WHAT TO BUT ANOTHER G.M. CAR OR TRUCK BECAUSE OF THE WAY THEY HAVE HANDLED US WITH THIS ONE. EVERY 3 MONTH'S NOW THE SERVICE A.B.S LIGHT COMES ON AND THEN THE ALL-WHEEL DRIVE IS DISABLED. THE VAN IS NOW OUT OF WARRANTY AND WE ARE STUCK WITH THIS PIECE OF JUNK HAVING TO GET FIXED EVERY 3 MONTH'S. PLEASE HELP US COME TO SOME KIND OF SOLUTION,HAVE CHECKED ON-LINE AND FOUND A LOT OF UPLANDER OWNER'S HAVING THE SAME PROBLEM'S RELATED TO ELECTRICAL ISSUES SO IT'S NOT JUST THIS ONE. THANK YOU.*TR
LIGHTS ON MY UPLANDER GO OUT WHILE DRIVING AT NIGHT. WHEN I BOUGHT IT IN 2005 IT HAPPENED MAYBE EVERY 2 MONTHS. NOW IT IS TWICE A WEEK. I CAN'T DRIVE SAFELY AT NIGHT. OTHER TIMES THEY FLICKER AND GROW VERY DIM. *TR
NOISE FRONT END WHILE DRIVING REPAIR 3 TIMES SAME PROBLEMS TODAY. THERE IS A VIBRATION WHEN SLOWING DOWN TODAY SAME PROBLEMS.NEVER REPAIR.NOISE FRONT END WHEN TAKING OFF CAN FEEL AND HEAR A CLUNK. CLANGING SOUND WHEN SHIFTING INTO DRIVE OR REVERSE.STARTER STICKING REPROGRAMMING SAME PROBLEM. STEERING SHAFT IS A PROBLEM CHANGE …
Read full complaint
NOISE FRONT END WHILE DRIVING REPAIR 3 TIMES SAME PROBLEMS TODAY. THERE IS A VIBRATION WHEN SLOWING DOWN TODAY SAME PROBLEMS.NEVER REPAIR.NOISE FRONT END WHEN TAKING OFF CAN FEEL AND HEAR A CLUNK. CLANGING SOUND WHEN SHIFTING INTO DRIVE OR REVERSE.STARTER STICKING REPROGRAMMING SAME PROBLEM. STEERING SHAFT IS A PROBLEM CHANGE 3 TIMES SAME PROBLEMS.(REPAIR THE PARTS ON DID YOU CHANGE IT COMPLETELY ? ).NEVER RECALL FAILURE. TODAY SAME PROBLEMS POOR SERVICE ONLY PROMISE. *TR
THE LIGHTS (INTERIOR AND EXTERIOR) WILL FLICKER IN MY 2005 CHEVROLET UPLANDER. IT HAS BECOME AN UNSAFE SITUATION AS ONCOMING TRAFFIC THINK THAT I AM FLASHING MY HIGHBEAMS AT THEM. I HAVE NOT REPLACED THE VOLTAGE REGULATOR YET, BUT I AM SURE THIS IS THE PROBLEM. GM SHOULD ISSUE A RECALL FOR THIS ITEM. MY CAR IS PAST THE WARRA…
Read full complaint
THE LIGHTS (INTERIOR AND EXTERIOR) WILL FLICKER IN MY 2005 CHEVROLET UPLANDER. IT HAS BECOME AN UNSAFE SITUATION AS ONCOMING TRAFFIC THINK THAT I AM FLASHING MY HIGHBEAMS AT THEM. I HAVE NOT REPLACED THE VOLTAGE REGULATOR YET, BUT I AM SURE THIS IS THE PROBLEM. GM SHOULD ISSUE A RECALL FOR THIS ITEM. MY CAR IS PAST THE WARRANTY PERIOD (60000 MILES), AND GM WILL ONLY REPAIR IF I PAY FULL PRICE AND LABOR FOR THIS SAFETY ITEM. *TR
THE AUTOMATIC DOORS ON OUR 2005 CHEVY UPLANDER OPEN BY THEMSELVES, THE ALARMS GO OFF SAYING THEY ARE NOT SHUT, AND IF THE DRIVER'S SIDE REAR DOOR IS OPENED, IT TAKES ABOUT A HALF HOUR TO GET IT TO SHUT AGAIN. *TR
Official recalls
310V110000 · Suspension:rear
Mar 19, 2010
THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.
Consequence & remedy
Consequence: A SQUEAKING OR CLUNKING NOISE MAY DEVELOP. THE TRAILING ARM BUSHINGS MAY PREMATURELY WEAR AND THE TRAILING ARM MAY FRACTURE OR SEPARATE, ALLOWING THE REAR AXLE TO BECOME PARTIALLY SEPARATED FROM THE CHASSIS INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.
05V287000 · Parking Brake
Jun 20, 2005
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.
Consequence & remedy
Consequence: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.
05V061000 · Seats:mid/rear Assembly
Feb 18, 2005
ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.
Consequence & remedy
Consequence: IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
PE05063 · Electrical Harness Damage
Opened Nov 29, 2005 · Closed Mar 6, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.