NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
57 reportsClear category filter341,000 miles · Nov 17, 2018
Electrical System
DRIVING THE VEHICLE ALONG THE INTERSTATE AT 65 MPH AT NIGHT, THE IGNITION SWITCH RUN POSITION ROTATED TO OFF AND THE ENGINE AND ALL HEADLIGHTS, DASH, ETC, SHUTDOWN ALONG WITH THE POWER STEERING AND POWER BRAKES. THE INCIDENT HAS JUST STARTED HAPPENING AND 340,000 MILES ON IT. ONLY WAY TO GET ROLLING IS TO PUT THE AUTO TRANS LEV…
Read full complaint
DRIVING THE VEHICLE ALONG THE INTERSTATE AT 65 MPH AT NIGHT, THE IGNITION SWITCH RUN POSITION ROTATED TO OFF AND THE ENGINE AND ALL HEADLIGHTS, DASH, ETC, SHUTDOWN ALONG WITH THE POWER STEERING AND POWER BRAKES. THE INCIDENT HAS JUST STARTED HAPPENING AND 340,000 MILES ON IT. ONLY WAY TO GET ROLLING IS TO PUT THE AUTO TRANS LEVER TO NEUTRAL AND TWIST THE IGNITION KEY TO CRANK POSITION AND LET KEY SETTLE TO RUN POSITION. THE IGNITION SWITCH ITSELF HAS A SPRING DETENT AND IT SETS IN A POCKET AT RUN. SO THIS SWITCH HAS A SPRING THAT OVER TIME WEAKENS AND ALLOWS THE WHOLE KEY CYLINDER ANS SWITCH TO DROP OUT OF RUN AND SHUT OFF THE ELECTRICAL. SOLUTION WAS TO PUT IN A NEW SWITCH OR JUST USE A SINGLE KEY INSTEAD OF A FULL SET OF KEYS HANGING FROM THE KEY SLOT.. THE FULL REPLACEMENT OF THE SWITCH RUNS 350$, PRTS AND LABOR.
NHTSA ODI #11152217
180,000 miles · Jan 3, 2018
Electrical System
MY ELECTRICAL WILL GO OUT AS I AM DRIVING. THE CAR HAS STOPPED COMPLETELY AND THE ELECTRICAL AS I WAS DRIVING. MY CAR WILL TURN ON AND THEN OFF, AND I HAVE TO DO IT ABOUT 5 TIMES BEFORE I CAN EVEN GET IT TO STAY ON AND DRIVE. SOMETIMES THE ELECTRICAL WILL STOP AFTER THAT BUT I CAN STILL DRIVE. THIS IS NOT SAFE. IT HAS BEEN …
Read full complaint
MY ELECTRICAL WILL GO OUT AS I AM DRIVING. THE CAR HAS STOPPED COMPLETELY AND THE ELECTRICAL AS I WAS DRIVING. MY CAR WILL TURN ON AND THEN OFF, AND I HAVE TO DO IT ABOUT 5 TIMES BEFORE I CAN EVEN GET IT TO STAY ON AND DRIVE. SOMETIMES THE ELECTRICAL WILL STOP AFTER THAT BUT I CAN STILL DRIVE. THIS IS NOT SAFE. IT HAS BEEN GOING ON FOR SOME TIME.
NHTSA ODI #11058184
183,000 miles · Sep 9, 2017
Electrical System
THE IGNITION SLIPS INTO THE OFF MODE WHILE VEHICLE IS RUNNING, THUS DISABLING EVERYTHING, INCLUDING POWER STEERING AND BRAKES. I HAVE HAD IT HAPPEN WHILE MOVING OUT OF PARKING SPOTS ON A PUBLIC STREET, AND MANY TIMES AFTER START UP WHEN I'M NOT MOVING. I HAVE QUIT DRIVING IT UNTIL I CAN GET IT REPAIRED DUE TO SAFETY CONCERN.
NHTSA ODI #11022430
167,000 miles · Apr 23, 2017
Electrical SystemSeatsInjury
MY DAUGHTER WAS DRIVING MY CAR WITH THE HEATED SEATS ON. SHE FELT IT GET EXTREMELY HOT. SHE TURNED OFF SEAT WARMERS. WHEN SHE GOT OUT OF CAR, THE SEAT HAD MELT/BURN MARKS AND HER LEGGINGS AND SKIN HAD BURN/RED MARKS. I HAD A MECHANIC LOOK INTO THIS AND HE SAID DO NOT USE SEAT WARMERS-IT WILL CAUSE A FIRE. NEW SEAT IS AT LEAST $5…
Read full complaint
MY DAUGHTER WAS DRIVING MY CAR WITH THE HEATED SEATS ON. SHE FELT IT GET EXTREMELY HOT. SHE TURNED OFF SEAT WARMERS. WHEN SHE GOT OUT OF CAR, THE SEAT HAD MELT/BURN MARKS AND HER LEGGINGS AND SKIN HAD BURN/RED MARKS. I HAD A MECHANIC LOOK INTO THIS AND HE SAID DO NOT USE SEAT WARMERS-IT WILL CAUSE A FIRE. NEW SEAT IS AT LEAST $500 WITHOUT LABOR. MAKES ME QUESTION ENTIRE ELECTRICAL SYSTEM. IN ADDITION, YOU HAVE CONNECTED SO MANY THINGS TOGETHER, THAT REPLACING ONE THING MEANS REPLACING A WHOLE CONSOLE. I AM A TRUE CHEVY PERSON- USED TO OWN? BE ASSOCIATED WITH A CHEVY BERETTA, 1964 CORVAIR, CITATION, MALIBU... LOOKING TO BUY AGAIN, BUT THIS BURNING WAS SCARY!
NHTSA ODI #10980035
181,000 miles · Oct 4, 2016
Electrical SystemSteering
TL* THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. WHILE DRIVING APPROXIMATELY 25 MPH, THE POWER STEERING FAILED AND THE RADIO BECAME INOPERABLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 181,000.
NHTSA ODI #10913720
150,000 miles · Aug 17, 2016
Electrical SystemUnknown Or Other
WHILE DRIVING DOWN THE INTERSTATE MY UPLANDER SHUTS OFF FOR NO REASON OR WARNING. NO CHECK ENGINE LIGHTS COME ON. I HAD ONSTAR RUN A TEST AND NOTHING IS FOUND.
NHTSA ODI #10896596
83,000 miles · Sep 17, 2015
Electrical SystemEngineUnknown Or Other
SEVERAL TIMES SINCE PURCHASING MY 2005 CHEVY UPLANDER, THE IGNITION HAS JUST SHUT OFF. NORMALLY THIS WAS WHEN IDOLING SO I WASN'T TOO SURE. HOWEVER, IT JUST TURNED OFF WHEN I WAS DRIVING 65 MPH ON A MAJOR EXPRESSWAY IN CHICAGO. THIS COULD HAVE BEEN CATASTROPHIC. THIS IGNITION SWITCH IS THE SAME ONE THAT IS CURRENTLY IN THE …
Read full complaint
SEVERAL TIMES SINCE PURCHASING MY 2005 CHEVY UPLANDER, THE IGNITION HAS JUST SHUT OFF. NORMALLY THIS WAS WHEN IDOLING SO I WASN'T TOO SURE. HOWEVER, IT JUST TURNED OFF WHEN I WAS DRIVING 65 MPH ON A MAJOR EXPRESSWAY IN CHICAGO. THIS COULD HAVE BEEN CATASTROPHIC. THIS IGNITION SWITCH IS THE SAME ONE THAT IS CURRENTLY IN THE GM RECALL, YET IT HAS NOT BEEN RECALLED YET. PLEASE RECALL ALL VEHICLES WITH THIS IGNITION SWITCH AS MOST VEHICLES HAVE ALREADY BEEN RECALLED. WHY WAIT ON THE RECALL UNTIL MORE PEOPLE ARE IN ACCIDENTS AND POSSIBLY DIE? IT ISN'T WORTH THE RISK.
NHTSA ODI #10764963
104,430 miles · Feb 10, 2015
Electrical SystemPower Train
WHILE MY WIFE WAS DRIVING TO WORK, AND WITHOUT ANY SORT OF ISSUE TO PROVOKE IT, THE IGNITION CAME OUT OF THE RUN OR ON POSITION, CAUSING THE VEHICLE TO ABRUPTLY SHUT OFF. I DID SOME RESEARCH AND FOUND THAT THIS WAS THE SAME IGNITION AS ALL THE OTHER VEHICLES THAT HAVE BEEN RECALLED, YET THIS ONE WAS NOT ON THE LIST. LUCKILY SHE …
Read full complaint
WHILE MY WIFE WAS DRIVING TO WORK, AND WITHOUT ANY SORT OF ISSUE TO PROVOKE IT, THE IGNITION CAME OUT OF THE RUN OR ON POSITION, CAUSING THE VEHICLE TO ABRUPTLY SHUT OFF. I DID SOME RESEARCH AND FOUND THAT THIS WAS THE SAME IGNITION AS ALL THE OTHER VEHICLES THAT HAVE BEEN RECALLED, YET THIS ONE WAS NOT ON THE LIST. LUCKILY SHE HAD HER WITS ABOUT HER AND PULLED INTO THE CENTER TURN LANE. BUT THE ISSUE PERSISTED, GENERALLY ONLY WHEN TRYING TO START THE VEHICLE OR WHEN SHIFTING THE VEHICLE INTO DIFFERENT GEARS (PARK, REVERSE, DRIVE, ETC.). IT COST ME $312 TO FIX THIS ISSUE BETWEEN PARTS AND LABOR *TR
NHTSA ODI #10682552
119,000 miles · Sep 16, 2014
Electrical SystemEngine
TL* THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART AFTER MULTIPLE ATTEMPTS. ON ANOTHER OCCASION, THE ENTIRE ELECTRICAL COMPONENTS FAILED. IN ADDITION, THE BRAKE AND THE CHECK ENGINE WARNING LIGHT ILLUM…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET UPLANDER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART AFTER MULTIPLE ATTEMPTS. ON ANOTHER OCCASION, THE ENTIRE ELECTRICAL COMPONENTS FAILED. IN ADDITION, THE BRAKE AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT ALSO STATED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE VEHICLE AND HESITATED TO ACCELERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. ADDITIONALLY, THERE WAS AN ELECTRICAL SHORTAGE FOR THE INTERIOR LIGHTING, AND HEAD GASKET NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 119,000.
NHTSA ODI #10633553
45,000 miles · Jun 17, 2014
Electrical SystemStructure
THE SLIDING DOOR ON REAR PASSENGER SIDE OF VAN WOULD NOT CLOSE WITHOUT THE 'OPEN DOOR BELL' BEEPING CONSTANTLY (EVEN AFTER CLOSED). SOMETIMES AFTER RE-CLOSING, IT WOULD STOP BUT THIS EVENTUALLY BECAME A CONSTANT HAPPENING. WE LIVE IN PA. AND WERE IN FL. WHEN THIS FIRST HAPPENED, SO WE TOOK IT TO A DEALER TO HAVE IT FIXED. AP…
Read full complaint
THE SLIDING DOOR ON REAR PASSENGER SIDE OF VAN WOULD NOT CLOSE WITHOUT THE 'OPEN DOOR BELL' BEEPING CONSTANTLY (EVEN AFTER CLOSED). SOMETIMES AFTER RE-CLOSING, IT WOULD STOP BUT THIS EVENTUALLY BECAME A CONSTANT HAPPENING. WE LIVE IN PA. AND WERE IN FL. WHEN THIS FIRST HAPPENED, SO WE TOOK IT TO A DEALER TO HAVE IT FIXED. APPROX. A YEAR LATER, THE SAME THING HAPPENED. AGAIN, AFTER OPENING AND CLOSING THE DOOR A NUMBER OF TIMES THE BEEPING WOULD SOMETIMES STOP, BUT WHEN WE NEEDED TO USE THE DOOR, IT WOULD REPEAT. WE TOOK IT TO THE DEALER THE SECOND TIME TO HAVE IT REPAIRED. NOW, WE ARE EXPERIENCING THE SAME THING AGAIN AND THE BEEPING WILL NOT STOP! THIS IS WAY TOO EXPENSIVE FOR US TO HANDLE. WE ARE SENIORS AND CANNOT AFFORD TO PAY FOR THIS KIND OF DEFECT. PLEASE HELP US! *TR
NHTSA ODI #10598804
NHTSA investigations
3EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
PE05063 · Electrical Harness Damage
Opened Nov 29, 2005 · Closed Mar 6, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration