2024 Chevrolet Trax

The contact's father owns a 2024 Chevrolet Trax. The contact stated that while driving at an undisclosed speed and making a left, she observed a noise emanating from under the vehicle that sounded like loose gravel, and she observed smoke outside of the "turn off ignition" message displayed. The contact stated that she observed white/grey smoke coming through the vents in the cabin of the vehicle. The vehicle was turned off, and when the contact exited the vehicle, she observed fire under the engine compartment, and the fire spread rapidly. The fire department distinguished the fire. The police reported the incident, but there was no report taken. The vehicle was towed to an independent mechanic, where it was deemed inoperable. The manufacturer was notified of the failure. The failure was 7,696.

The engine failed at approximately 44,000 miles. The vehicle uses a wet timing belt engine design, where the timing belt runs inside the engine oil. The engine suddenly stopped working and now requires a full engine replacement. This failure happened much earlier than expected for a modern vehicle and could be a safety risk if the engine fails while driving.

For the past 3 to 6 months I've been hearing a gear backlash sound while using the adaptive cruise control when it would slow down for a car in front of the vehicle then when it would start to speed up. Brought the vehicle to the dealership on October 20th, 2025. They said that the sound is normal and there's a service bulletin that says its normal in other Chevy models. Then on November 28th, 2025 I was driving home, turn right at a light, and started to accelerate. Then I heard the same backlash noise as before then the check engine light came on with the oil light. I pulled over immediately and turned off the engine just to see all the oil spilling out of the engine compartment onto the ground and white smoke. Got it towed to the dealership and they told me that "the engine had multiple components fail inside it and that I need a new engine assembly." Currently the engine is still in the vehicle awaiting a new engine assembly what is currently on backorder with no expected arrival time.

Serra Chevy has my trax. A mechanic checked it it is blown engine. No time frame for an engine. I believe a fail msg flashed after engine failed all systems stopped i pulled to side of road oil pouring out from under my vehical. I was driving on expressway (approx 70 mi per hour) approx 1 1/2 hour drive to dinner theater 120 miles away. I was 5 mins away from destination. I paid 120.00 plus ins covered miles towed. No fires just whitish grey smoke from engine...I was shocked my new car was failing.

While accelerating from a tertiary road (45mph) to a highway (60mph), the engine suddenly produced a loud rhythmic clacking sound that increased in frequency based on rpms. No warnings or check engine light was activated. No increase in temp or change to oil pressure was noted. The vehicle was driven approximately 6 miles with no change in the sound. Vehicle was parked and sat for 2 hours. Vehicle was restarted. Sound continued. Vehicle was driven for approximately .3 miles when a warning came across the dash and an alarm sounded. It indicated no oil and to immediately halt driving. Continued for an additional .3 miles to a safe pull off point and parked the car. The oil level was checked and the dipstick measurement indicated a full oil reservoir. The following day the vehicle was towed to IG Burton Chevrolet in Lewes DE. Due to scheduling the vehicle was not diagnosed for 1 week. Initially the diagnosis was a faulty oil pump. Upon further exploration metal components were found within the oil pump that fell into it from the engine. The service department determined that a full engine replacement was required and would covered under warranty.

Made first report after car was at shop over 60 days case# 1168 5928 NHSA Motor and Screen Made report to GM Customer service 1-800-222-1020 case # 78472987 On 10-3-2025 Received 2024 Chevy Trax back from Ozark Chevrolet on about 9-21-2025 from motor being replaced on 9-22-25 check engine light came on took to dealership they said it was a quart low on transmission oil from them replacing motor The next evening check engine light came back on car started ticking at 45 mph and reduced power notification came on pulled over checked for leaks was none proceeded another mile and car quit running called Ozark Chevrolet they said have it towed to them on 10-6-2025 Ozark Chevrolet called said it blowed another motor the same way the 1st motor blowed they said it would take 7-10 days for motor to be in Motor #1 blowed at 19,200 miles.. Motor #2 blowed with less than 200 miles on it

WE HAVE NOTICED THAT THE CHECK ENGINE DOES NOT ILLUMINATE WHEN STARTING OR EVEN WITH ACTIVE CODES IN VEHICLE HAVE BROUGHT THIS TO THE DEALERS ATTENTION SEVERAL TIME TO NOT BE ACKNOWLEGDED THE REAR BRAKES LOCK UP WHEN YOU TOUCH THE BRAKE PEDAL HAVE BROUGHT THIS UP SEVERAL TIME TO NOT BE ADDRESSED THE VEHICLE WHEN DRIVING AT SPEEDS GREATER THAT 55 MPH THE VEHICLE GOES SIDEWAYS AND SCARES YOU HAVE BROUGHT UP SEVERAL TIMES TO NOT BE ADDRESSED THE FORWARD COLLISION DOES NOT WORK THE VEHICLE HAS ACTIVE CODES AND THE CHECK ENGINE SHOULD ILLUMINATE AND WHEN TAKE IN FOR SERVICE WE ASK WHY AND ARE JUST IGNORED ALL THESE PROBLEMS STARTED 2 DAYS AFTER BUYING THE VEHICLE IN SEPTEMBER OF 2023. iN ADDITION TO THE TRANSMISSION LEAKING, WAS TOLD HOWEVER THAT IT IS NOT A BIG ENOUGH ISSUE TO BE COVERED UNDER WARRENTY. THESE HAVE ALL BEEN ADDRESSED WITH DEALERSHIP AS WELL AS MANUFACTURER, AND AS OF TODAY 09/20/2025 THESE ISSUES HAVE NOT BEEN RESOLVED

The contact owns a 2024 Chevrolet Trax. The contact stated that upon parking the vehicle on a downward angle, there was an abnormal popping sound coming from the engine. There was no warning light illuminated. In addition, the contact stated that the infotainment screen intermittently went blank while driving at various speeds. The contact stated that on one occasion, while driving 50 MPH and entering a highway, there was a banging sound coming from the vehicle, with white smoke coming from the engine. There was no warning light illuminated. Due to the failure, the contact immediately pulled over and had the vehicle towed to an independent mechanic. The manufacturer was notified of the failure, and the vehicle was towed to a dealer. While at the dealer, the vehicle was diagnosed with engine failure. The contact was then informed that the engine was on backorder, and the vehicle remained with the dealer. The vehicle was not repaired. The failure mileage was approximately 19,000.

Purchased the 2024 Trax in April 2024 and immediately received a critical engine and transmission notification the same day we took delivery. Returned the vehicle to the dealership and was told it was an faulty oil sensor issue, which they took care of. The car now has ~9,500 miles and the engine failed yesterday. While accelerating on the freeway, we heard a loud pop, saw smoke coming from the engine and tail pipe, the engine light and oil light came on, and a message on the dashboard said to turn off the engine immediately. The engine seized and began leaking all of the oil/fluid out onto the pavement. We had to pull onto the left shoulder of the freeway because the engine seized, which is extremely dangerous (the tow truck driver was nearly hit trying to load the vehicle onto the flatbed tow truck). The Trax had just been serviced at a local dealership for scheduled maintenance (oil and filter change, tire rotation and 27-point vehicle Inspection) on Friday, August 8th. The car was towed back to the same dealership, at which time we were informed that a rod was loose inside the engine and created a hole, which caused the engine to run on 2 cylinders and fail. The dealer claims the damage is unrelated to the recent oil change and confirmed that they did NOT inspect the engine during the scheduled maintenance appointment. We pay for OnStar and receive monthly vehicle health reports. Besides the critical engine and transmission notice we received when we first picked up the vehicle and a recall notice - which we had resolved - there have been no other messages or symptoms before yesterday's engine failure. The vehicle is still at the dealership and we are waiting to hear how this situation will be resolved.