2018 Chevrolet Traverse

Special coverage programs for the 2018 Chevy Traverse front exhaust pipe mounting bracket failure. GM has focused on coverage specifically on 2019-2021 models, but 2018 models are affected as well. I'm being forced to pay for a new exhaust when 2018 models should have been included for the Specific special coverage (e.g., N212356540, N222385510) exists for 2019–2021 vehicles, offering repairs (sometimes for 15 years or 150,000 miles) when the front mounting bracket breaks.

My engine light came on, so I took it the mechanic. According to the reading it says it was my purge valve, they replaced. After driving 30 miles it came back on. I took it back and they thought it was a defected part so they replaced it again. After 30 miles, it came back on. The mechanic searched online and showed me this issue was for 2019 for a recall. I contacted GM to see if there is a recall for 2018. They said no. At this time the engine lights stays on, but it gives a evap engine light. I can't pass smog due to the issue. The gas tank does not have a cap, it's open. This is how it was when I purchased the vehicle.

The exhaust system on my 2018 Chevrolet Traverse has failed due to cracking in the exhaust pipe and/or muffler assembly. This appears to be consistent with known issues in similar model years where exhaust pipe brackets separate and cause cracks or holes in the exhaust system. The failure has resulted in excessive exhaust noise and potential exhaust leakage. The dealership has confirmed the issue and recommended repairs costing several thousand dollars but stated my VIN is not included in the existing recall or special coverage. Yes, the vehicle and failed components are available for inspection upon request. The failure of the exhaust system creates a risk of exhaust gases, including carbon monoxide, entering the passenger cabin, which poses a serious health hazard. Additionally, a compromised exhaust system can affect vehicle performance and emissions, and in some cases may increase the risk of fire if hot exhaust gases escape in unintended areas. This issue is especially concerning because it has been identified in other model years of the same vehicle, yet my vehicle is not currently covered, despite experiencing the same failure. This creates an ongoing safety concern for myself, my passengers, and others on the road. The problem been reproduced and confirmed by a certified Chevy dealer.

The vehicle has a design flaw which causes a bracket which connects the 2 pipes which connect to the catalytic converter to fail. Once the bracket has failed, the rear catalytic converter is allowed to vibrate more than designed, adding extra stress to the catalytic converter. Over time, this additional stress causes the catalytic converter to fail, releasing harmful gases directly from the engine exhaust manifold with carbon monoxide and other harmful gases into the air and into the passenger compartment of the vehicle. This is a know issue that GM has recalled on the 2019 (recall N212356540) and 2021 (recall N222385510) model year Traverse. Other years may have also been recalled that I am not aware of. For some reason, GM has neglected to take ownership of this issue on the 2018 Traverse which shares the same design as both the 2019 and 2021 model years. I have gone to the dealership and contact Chevrolet's customer service multiple times and they refuse to reimburse me for the cost of the necessary repairs. I have already purchased the broken and necessary, ancillary components and repaired the vehicle myself because I did not want to pay the dealership over $2000 in labor which they quoted me.

This vehicle's canister purge valve solenoid has failed multiple times since we purchased it used in 2021. We've taken it to multiple Chevrolet dealerships for repair and the issue has not been fixed. The issue is once the part fails, the vehicle is unable to be filled with fuel completely or it sputters when trying to start and the engine turns off or it stalls right after placing into drive. This causes a safety concern. There are multiple articles all over the internet and social media about the purge valve solenoid specifically in 2018 Traverses with no recalls. This is disappointing!

So since 8/02/23 when the vehicle had 54,000 miles it began to give electrical problems. I bought the car 01/16/23 it had only 26,000 miles. The service battery charging system light and battery saver mode went on and also the reduced steering light which began to shut the car down I immediately pulled over. Took it to gm dealer they tested battery was dead then charged it checked alternator it failed so they replaced alternator. 7 days later 8/10/23 the car is still running rough idle. Had savi code p0496 evap flow during non purge replaced purge solenoid. The car still the engine slightly was not 100 percent fixed I told them every time it wasn't good. 02/12/24 I took back to dealer engine running rough and every time I put gas it was hesitant the transmission I am assuming check engine light was on code p0496 the gm dealer diagnosised and replaced canister purge solenoid.so 2/28/24 battery saver mode light came on andservice battery charging vehicle stalled out checked alternator failed replaced alternator. 6/25/24 took to another gm dealer and the diagnosised it check engine light was on and told them my car wasn't starting well after I filled my gas and rough engine. Told me to come back 7/03/24 to do evap canister check engine light was on they found evap leak from from evap canister charged me 508 dollars. So I took vehicle from dealer towards hone filled up gas car would not start problem was not fixed called dealer immediately manager said get here before they close I did and manager left but on service guy got the master mechanic to look at it he said it's purge valve the next day they were closed due to 4th of July so was told to take back on 7/5/24 to replace purge solenoid. The gas issue was fixed but now the transmission is worse when I accelerate it stutters bad I been telling both dealers was told they can't look at vehicle unless check engine light was on so 3 faulty purge valves 2 alternators replaced and car stutters worse shift to park light.