NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
117 reportsClear category filter187,000 miles · Oct 7, 2024
Engine
The contact owns a 2014 Chevrolet Traverse. The contact stated while driving 45-60 MPH, the traction control and engine warning lights illuminated. The vehicle lost motive power and stalled. After several minutes, the vehicle restarted. The vehicle was taken to the local dealer, where it was diagnosed and determined that the num…
Read full complaint
The contact owns a 2014 Chevrolet Traverse. The contact stated while driving 45-60 MPH, the traction control and engine warning lights illuminated. The vehicle lost motive power and stalled. After several minutes, the vehicle restarted. The vehicle was taken to the local dealer, where it was diagnosed and determined that the number two fuel injector was stuck open. The vehicle was repaired, but the failure recurred. The vehicle failed to start. The manufacturer was contacted, who opened a case and referred the contact to the NHTSA Hotline. The failure mileage was approximately 187,000.
NHTSA ODI #11618501
Mileage unknown · Apr 15, 2024
Electrical SystemEngineVehicle Speed Control
While driving, check engine light went on, stabilitrack and traction control went off (information from Driver Information Center) and power was reduced. This occurred several times a week and vehicle slowed down dramatically and had to be driven slowly from the roadway. This was a dangerous situation. After safely stopping, I w…
Read full complaint
While driving, check engine light went on, stabilitrack and traction control went off (information from Driver Information Center) and power was reduced. This occurred several times a week and vehicle slowed down dramatically and had to be driven slowly from the roadway. This was a dangerous situation. After safely stopping, I was able to resume travel after turning off engine and restarting, although check engine light would remain on for several on/off cycles. Engine stored code P1682. This has also happened while at a stop and when the accelerator was pressed, the vehicle would stall (sometimes in middle of intersection).
NHTSA ODI #11583018
Mileage unknown · Apr 9, 2024
Engine
misfires on 3 cylinders bank 2, timing chain stretched, camshaft actuator not locking into position inspected by dealer and independent service center check engine light came on, codes P0300 and P05CD problems accelerating past 35 mph
NHTSA ODI #11582002
Mileage unknown · Jan 9, 2024
Engine
- Engine locked up and does not turn at all - Engine failed while our son was driving on the hwy to school and the car stalled. He was not able to turn the steering wheel and the gas peddle would not work. Luckily he knew to get off the road right away. - Gustmans Chevrolet in Kaukauna, WI confirmed this problem. After doing res…
Read full complaint
- Engine locked up and does not turn at all - Engine failed while our son was driving on the hwy to school and the car stalled. He was not able to turn the steering wheel and the gas peddle would not work. Luckily he knew to get off the road right away. - Gustmans Chevrolet in Kaukauna, WI confirmed this problem. After doing research and talking with the dealership. They said they are finding this is a common issue in the 2012-2014 Chevy Traverse, Buick Enclaves, and Acadias. - Just the dealership as of now - The check engine light went on and then went off the day before. No other message in the vehicle popped up. - The sad part is most of these vehicles are still in good shape and well taken care of. To be told we can only get $500 for this vehicle is just wrong. These vehicle engines should last longer than 9-10 years, Especially when we have done all the other maintenance on our vehicle.
NHTSA ODI #11564384
Mileage unknown · Nov 21, 2023
Engine
Vapor Canister Purge Valve - GM (12690512) failed on my car.
NHTSA ODI #11556317
111,081 miles · Oct 17, 2023
Electrical SystemEngine
2014 Chevy Traverse - stalls while driving very abruptly. Reduce engine power and service stablitrak comes on. Then traction control warning lights flash. Very very dangerous. Happen while driving car begins to shake violently and recently stalled in middle of busy intersection. No way this should not be recalled it's definitel…
Read full complaint
2014 Chevy Traverse - stalls while driving very abruptly. Reduce engine power and service stablitrak comes on. Then traction control warning lights flash. Very very dangerous. Happen while driving car begins to shake violently and recently stalled in middle of busy intersection. No way this should not be recalled it's definitely a known issue. Unable to restart the vehicle. The vehicle was towed to an independent mechanic however, the mechanic was unable to provide a cause for the failure. Towed to Chevy Dealership in Lancaster NY - Basil quoted $4k+ for repair to engine control relay and timing chain. If there is recall on this we will keep and get fixed if not will need to pass and look at other vehicles. Everything starts to go after warranty dates are up or after you hit a certain mileage. We have always purchased GM vehicles my father is GM retiree. Please help.
NHTSA ODI #11550420
87,000 miles · Sep 21, 2023
Electrical SystemEngine
The contact owns a 2014 Chevrolet Traverse. The contact stated that while driving at 75 MPH, The contact smelled fumes and the vehicle had turned off independently. When the vehicle turned off the steering became firm. The traction and service engine warning light was illuminated. The vehicle was towed back home. The vehicle had…
Read full complaint
The contact owns a 2014 Chevrolet Traverse. The contact stated that while driving at 75 MPH, The contact smelled fumes and the vehicle had turned off independently. When the vehicle turned off the steering became firm. The traction and service engine warning light was illuminated. The vehicle was towed back home. The vehicle had been diagnosed by an independent mechanic. The contact was informed that the failure was a faulty front and back valve, relay switch throttle and ignition switch. The vehicle had been repaired. The manufacturer was made aware of the failure and told the contact to make a complaint. The failure mileage was approximately 87,000.
NHTSA ODI #11545848
139,470 miles · Sep 5, 2023
Engine
[XXX] I WAS GOING DOWN THE INTERSTATE AND THE STABILITRAK, TRACTION CONTROL, CHECK ENGINE LIGHTS ALL CAME ON. ENGINE REDUCED POWER LIGHT CAME ON I LOST ALL POWER OF THE VEHICLE, I WAS IN HEAVY TRAFFIC AND FORCED OFF OF THE ROAD BECAUSE MY ENGINE DIED. I WENT FROM DOING 70 MPH DOWN TO 10 MPH AND CAME VERY CLOSE TO GETTING REAR E…
Read full complaint
[XXX] I WAS GOING DOWN THE INTERSTATE AND THE STABILITRAK, TRACTION CONTROL, CHECK ENGINE LIGHTS ALL CAME ON. ENGINE REDUCED POWER LIGHT CAME ON I LOST ALL POWER OF THE VEHICLE, I WAS IN HEAVY TRAFFIC AND FORCED OFF OF THE ROAD BECAUSE MY ENGINE DIED. I WENT FROM DOING 70 MPH DOWN TO 10 MPH AND CAME VERY CLOSE TO GETTING REAR ENDED. This would have caused a chain reaction rear end crash with multiple vehicles. WHEN I GOT TO THE SHOULDER OF THE ROAD I WASN'T ABLE TO GET MY VEHICLE STARTED. I waited about 10 minutes tried it again. It turned over with yellow engine light remaining on. THIS HAS HAPPENED ON MULTIPLE OCCASIONS. 1 HAVE SEEN WHERE THIS IS A PROBLEM IN THIS YEAR MODEL OF THIS VEHICLE AND WONDERING WHY IT HASN'T BEEN RECALLED YET BY THE MANUFACTURER BEFORE SOMEONE LOSES THERE LIFE. This is my only vehicle and I feel that it is unsafe to drive. I have a one year old granddaughter and her safety is at risk. Please help fix this problem as we need a car to drive. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11542807
Mileage unknown · May 15, 2023
EnginePower TrainVehicle Speed Control
Automobile suddenly starts trembling while reducing velocity on its own and turn on trac off light, check engine light is on.
NHTSA ODI #11522178
Mileage unknown · Aug 21, 2022
Electrical SystemEngine
While driving, check engine light went on, stabilitrack and traction control went off (information from Driver Information Center) and power was reduced. This occurred several times over a period of two to three weeks and vehicle slowed down dramatically and had to be driven slowly from the roadway. This was a dangerous situatio…
Read full complaint
While driving, check engine light went on, stabilitrack and traction control went off (information from Driver Information Center) and power was reduced. This occurred several times over a period of two to three weeks and vehicle slowed down dramatically and had to be driven slowly from the roadway. This was a dangerous situation and luckily it never happened at highway speeds in one of the left lanes of traffic. After safely stopping, I was able to resume travel after turning off engine and restarting, although check engine light would remain on for several on/off cycles. Engine stored code P1682. Brought to dealer service and they repaired per TSB #19-NA-276 related to issues in fuse box. Repair was $406.48. This is a known issue with manufacturer. Also, many owners have mentioned this safety issue on Internet forums and YouTube videos.
NHTSA ODI #11480456
Official recalls
7May 10, 2023
General Motors, LLC (GM) is recalling certain 2014-2017 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. GM began mailing final owner letters February 23, 2024 and will continue mailing through December 2025. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N232404980.
Oct 7, 2021
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Air Bags:frontal
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Oct 1, 2014
General Motors LLC (GM) is recalling certain model year 2013-2014 Cadillac CTS, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL, and 2014 Buick Enclave, Chevrolet Express, Impala, Silverado HD, Traverse, GMC Acadia, Savana, and Sierra HD vehicles. In the affected vehicles, the chassis electronic module may be internally contaminated, resulting in an electrical short.
Consequence & remedy
Consequence: If the module experiences an electrical short, the vehicle could stall, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the chassis electronic module, free of charge. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-006 (Cadillac), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GMs number for this recall is 14515.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Apr 30, 2014
General Motors LLC (GM) is recalling certain model year 2014 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles manufactured March 26, 2013, through August 15, 2013. In the affected vehicles, the engine control module (ECM) software may cause the fuel gauge to read inaccurately.
Consequence & remedy
Consequence: An inaccurate fuel gauge may result in the vehicle unexpectedly running out of fuel and stalling, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the ECM to correct the fuel gauge reading, free of charge. The recall began on June 27, 2014. Owners may contact General Motors at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM's number for this recall is 14007.
Additional source detail variants (3)
Electrical System:software
General Motors LLC (GM) is recalling certain model year 2014 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles manufactured March 26, 2013, through August 15, 2013. In the affected vehicles, the engine control module (ECM) software may cause the fuel gauge to read inaccurately.
Consequence: An inaccurate fuel gauge may result in the vehicle unexpectedly running out of fuel and stalling, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the ECM to correct the fuel gauge reading, free of charge. The recall began on June 27, 2014. Owners may contact General Motors at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM's number for this recall is 14007.
Electrical System: Instrument Cluster/panel
General Motors LLC (GM) is recalling certain model year 2014 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles manufactured March 26, 2013, through August 15, 2013. In the affected vehicles, the engine control module (ECM) software may cause the fuel gauge to read inaccurately.
Consequence: An inaccurate fuel gauge may result in the vehicle unexpectedly running out of fuel and stalling, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the ECM to correct the fuel gauge reading, free of charge. The recall began on June 27, 2014. Owners may contact General Motors at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM's number for this recall is 14007.
Fuel System, Gasoline
General Motors LLC (GM) is recalling certain model year 2014 Buick Enclave, Chevrolet Traverse, and GMC Acadia vehicles manufactured March 26, 2013, through August 15, 2013. In the affected vehicles, the engine control module (ECM) software may cause the fuel gauge to read inaccurately.
Consequence: An inaccurate fuel gauge may result in the vehicle unexpectedly running out of fuel and stalling, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the ECM to correct the fuel gauge reading, free of charge. The recall began on June 27, 2014. Owners may contact General Motors at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM's number for this recall is 14007.
Feb 21, 2014
General Motors LLC (GM) is recalling certain model year 2014 Buick Regal, LaCrosse, Verano, and Enclave, and Chevrolet Impala, Malibu, Cruze, and Traverse, and GMC Acadia vehicles equipped with automatic transmissions. In the affected vehicles, the transmission shift cable adjuster may disengage from the transmission shift lever. As such, these vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect." They also fail to conform to FMVSS number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If a vehicle's shift cable disengages from the transmission shift lever, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the driver may be able to shift the lever to the "PARK" position, but the vehicle transmission may not be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: General Motors will notify owners, and dealers will inspect and replace any affected transmission shift cable adjusters, free of charge. The recall began on April 10, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Buick owners at 1-800-521-7300, and GMC owners at 1-800-462-8782. General Motors' number associated with this recall is 14048.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration