NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
608 reports74,875 miles · Nov 3, 2016
Electrical SystemEngine
TAKATA RECALL I HAVE A 2011 CHEVY TRAVERSE LTZ WITH JUST UNDER 75K MILES. I HAD THE THROTTLE BODY REPLACED IN OCTOBER 2014 BEFORE THERE WAS A RECALL. TODAY, I GOT OUT OF CLASS, PICKED UP MY CHILDREN FROM SCHOOL AND WENT TO THE GROCERY STORE. THIS IS A 2 MILE TRIP ROUND-TRIP. I WAS DRIVING PAST THE KIDS SCHOOL STRAIGHT AHEAD ON …
Read full complaint
TAKATA RECALL I HAVE A 2011 CHEVY TRAVERSE LTZ WITH JUST UNDER 75K MILES. I HAD THE THROTTLE BODY REPLACED IN OCTOBER 2014 BEFORE THERE WAS A RECALL. TODAY, I GOT OUT OF CLASS, PICKED UP MY CHILDREN FROM SCHOOL AND WENT TO THE GROCERY STORE. THIS IS A 2 MILE TRIP ROUND-TRIP. I WAS DRIVING PAST THE KIDS SCHOOL STRAIGHT AHEAD ON CITY STREETS DOING ABOUT 15 MPH, JUST A FEW BLOCKS FROM OUR HOUSE, THE WARNING LIGHTS BEGAN TO BEEP AND THE DIC HAD SEVERAL MESSAGES. "ENGINE HOT A/C OFF" "ENGINE POWER IS REDUCED" AND "ENGINE OVERHEATED IDLE ENGINE". IT BECAME VERY DIFFICULT TO HANDLE THE TRUCK. THE HIGH IN CHICAGO TODAY WAS 60 DEGREES AND I ONLY MADE THE ONE TRIP MENTIONED ABOVE. I PLAN ON TAKING IT TO THE DEALER TOMORROW BUT I WANT TO KNOW IF THIS IS A PROBLEM PEOPLE ARE HAVING. *TR
NHTSA ODI #10924133
74,000 miles · Nov 1, 2016
Electronic Stability Control (esc)Vehicle Speed Control
2011 CHEVY TRAVERSE. SPORADICALLY DECELERATES WHILE DRIVING, FLASHES TRACTION CONTROL OFF AND SERVICE STABILTRAK, CHECK ENGINE LIGHT. PULL OVER AND LET IT "REST" FOR 15 MINUTES, IT WILL RESUME DRIVING. HAVE ALREADY HAD THIS ISSUE "REPAIRED" FROM CHEVY STORE10 MONTHS AGO. MOSTLY OCCURS WHILE IN MOTION, ONCE WHILE DRIVING 70MPH ON…
Read full complaint
2011 CHEVY TRAVERSE. SPORADICALLY DECELERATES WHILE DRIVING, FLASHES TRACTION CONTROL OFF AND SERVICE STABILTRAK, CHECK ENGINE LIGHT. PULL OVER AND LET IT "REST" FOR 15 MINUTES, IT WILL RESUME DRIVING. HAVE ALREADY HAD THIS ISSUE "REPAIRED" FROM CHEVY STORE10 MONTHS AGO. MOSTLY OCCURS WHILE IN MOTION, ONCE WHILE DRIVING 70MPH ON HWY DECELERATED TO 35 MPH AND ALMOST CAUSED ACCIDENT. NOW DEALERSHIP IS SUGGESTING I MAKE ANOTHER EXPENSIVE FIX, WHICH MAY OR MAY NOT FIX THE ISSUE. THIS CAR IS A LEMON!!!! TODAY WE ARE BLOCKING TRAFFIC IN A PARKING DECK BECAUSE IT HAS DECIDED TO HAPPEN AGAIN, NO DRIVE, BUT REVERSE WORKS FINE. *TR
NHTSA ODI #10920524
52,000 miles · Oct 24, 2016
Electronic Stability Control (esc)
WHILE DRIVING AT AROUND 40MPH, SERVICE STABILITRAK/ SERVICE TRACTION CONTROL WARNINGS CAME ON. WHILE MAKING A TURN, THE ENGINE CUT OUT AND I WAS JUST ABLE TO PULL OFF TO THE SIDE OF THE ROAD. THIS PROBLEM OCCURRED AFTER 4 FUEL INJECTORS WERE CLOGGED REQUIRING NEW INJECTORS, NEW OXYGEN SENSORS AND DAMAGE TO ALL THREE CATALYTIC C…
Read full complaint
WHILE DRIVING AT AROUND 40MPH, SERVICE STABILITRAK/ SERVICE TRACTION CONTROL WARNINGS CAME ON. WHILE MAKING A TURN, THE ENGINE CUT OUT AND I WAS JUST ABLE TO PULL OFF TO THE SIDE OF THE ROAD. THIS PROBLEM OCCURRED AFTER 4 FUEL INJECTORS WERE CLOGGED REQUIRING NEW INJECTORS, NEW OXYGEN SENSORS AND DAMAGE TO ALL THREE CATALYTIC CONVERTERS. AIR BAG WARNINGS COME ON INTERMITTENTLY, AS DO THE TIRE SENSOR WARNINGS. I'M NOW FINDING OUT THAT THESE STABILITRAK ISSUES HAVE BEEN ONGOING FOR YEARS WITH VARIOUS CHEVY AWD MODELS, WHILE GM DOES NOTHING ABOUT IT. *TR
NHTSA ODI #10918537
60,000 miles · Oct 24, 2016
Structure
FRONT DOOR HINGE ROLLER IS SIEZED, BOTH RIGHT AND LEFT SIDES RESULTING IN DIFFICULTY OPENING AND CLOSING DOOR, EXTREME METAL ON METAL CLUNKING SOUND
NHTSA ODI #10918428
114,000 miles · Oct 20, 2016
Structure
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. WHEN OPENING THE LIFTGATE, THE POWER LIFTGATE GAS STRUTS SUDDENLY FAILED AND CAUSED THE LIFTGATE TO DROP SUDDENLY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED AS PART OF NHTSA CAMPAIGN NUMBER: 15V415000 (STRUCTURE). THE MANUFACT…
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. WHEN OPENING THE LIFTGATE, THE POWER LIFTGATE GAS STRUTS SUDDENLY FAILED AND CAUSED THE LIFTGATE TO DROP SUDDENLY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED AS PART OF NHTSA CAMPAIGN NUMBER: 15V415000 (STRUCTURE). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000.
NHTSA ODI #10917659
94,000 miles · Oct 20, 2016
Power Train
EVEN ON THE SLIGHTEST OF INCLINES, AFTER STOPPING WHILE IN DRIVE, THE VEHICLE ROLLS BACKWARD. A FEW TIMES IT ALMOST ROLLED BACKWARD INTO THE CAR BEHIND ME. IT'S AN ACCIDENT WAITING TO HAPPEN. OTHER TRAVERSE OWNERS HAVE TOLD ME THE SAME THING HAPPENS IN THEIRS.
NHTSA ODI #10917614
63,500 miles · Oct 17, 2016
Air BagsCrashInjury
TL* THE CONTACT OWNED A 2011 CHEVROLET TRAVERSE. WHILE DRIVING 65 MPH ON THE HIGHWAY, THE DRIVER FELL ASLEEP, VEERED OFF THE ROAD, AND CRASHED INTO A TREE. THE SIDE AIR BAGS DEPLOYED, BUT THE DRIVER'S SIDE AND FRONT PASSENGER SIDE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE DRIVER AND FRONT PASSENGER SUSTAINED WHIP…
Read full complaint
TL* THE CONTACT OWNED A 2011 CHEVROLET TRAVERSE. WHILE DRIVING 65 MPH ON THE HIGHWAY, THE DRIVER FELL ASLEEP, VEERED OFF THE ROAD, AND CRASHED INTO A TREE. THE SIDE AIR BAGS DEPLOYED, BUT THE DRIVER'S SIDE AND FRONT PASSENGER SIDE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE DRIVER AND FRONT PASSENGER SUSTAINED WHIPLASH. TWO CHILD PASSENGERS EXPERIENCED WHIPLASH, BRUISES, AND CUTS. ANOTHER CHILD PASSENGER WAS SHAKEN UP AND EXPERIENCED LOW BLOOD PRESSURE. ANOTHER ADULT PASSENGER SUSTAINED A FRACTURED BACK AND EXTENSIVE MEDICAL TREATMENT. THE VEHICLE WAS DESTROYED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V118000 (AIR BAGS). THE FAILURE MILEAGE WAS NOT AVAILABLE. ...UPDATED 12/14/16 *BF
NHTSA ODI #10916454
57,000 miles · Oct 11, 2016
Vehicle Speed Control
I ACCELERATED FROM ONRAMP TO HIGHWAY. I RELEASED PEDAL BUT ENGINE REVS RAPIDLY INCREASED AND VEHICLE SURGED FORWARD TOWARD VEHICLE IN FRONT OF ME. BRAKES DID NOT STOP MY VEHICLE . I DOWN SHIFTED TO LOW GEAR PULLED ONTO SHOULDER TO AVOID COLLISION. I APPLIED BRAKES AGAIN .I SLOWED AND SHIFTED TO NEUTRAL AND PARK . REVS RETURNED …
Read full complaint
I ACCELERATED FROM ONRAMP TO HIGHWAY. I RELEASED PEDAL BUT ENGINE REVS RAPIDLY INCREASED AND VEHICLE SURGED FORWARD TOWARD VEHICLE IN FRONT OF ME. BRAKES DID NOT STOP MY VEHICLE . I DOWN SHIFTED TO LOW GEAR PULLED ONTO SHOULDER TO AVOID COLLISION. I APPLIED BRAKES AGAIN .I SLOWED AND SHIFTED TO NEUTRAL AND PARK . REVS RETURNED TO NORMAL AND I SHUT OFF ENGINE. VEHICLE TOWED TO DEALER.
NHTSA ODI #10915299
108,000 miles · Sep 30, 2016
EnginePower Train
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. WHILE DRIVING VARIOUS SPEEDS, "ENGINE POWER LOW" ILLUMINATED ON THE INSTRUMENT PANEL AND THE VEHICLE STALLED. THE FAILURE OCCURRED ON TWO OCCASIONS AND WAS INTERMITTENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIMING LINK ON THE INSIDE OF TH…
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. WHILE DRIVING VARIOUS SPEEDS, "ENGINE POWER LOW" ILLUMINATED ON THE INSTRUMENT PANEL AND THE VEHICLE STALLED. THE FAILURE OCCURRED ON TWO OCCASIONS AND WAS INTERMITTENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIMING LINK ON THE INSIDE OF THE MOTOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 108,000. THE VIN WAS NOT AVAILABLE. ..UPDATED 10/26/16 *BF *TR
NHTSA ODI #10910729
Mileage unknown · Sep 26, 2016
Fuel/propulsion System
ON MY 2011 CHEVY TRAVERSE ON THE FUEL GAUGE ONCE THE FUEL LEVEL REACHES A HALF TANK IT SUDDENLY DROPS TO EMPTY. IT IS HARD TO READ THE FUEL LEVEL AFTER THAT BECAUSE HONESTLY WHO HAS TIME TO SIT AND CALCULATE MILAGE USED EVERYDAY (I KNOW I DON'T) I HAVE READ ON OTHER FORUMS THAT THIS WAS HAPPENING ON OTHER YEARS OF TRAVERSES AND …
Read full complaint
ON MY 2011 CHEVY TRAVERSE ON THE FUEL GAUGE ONCE THE FUEL LEVEL REACHES A HALF TANK IT SUDDENLY DROPS TO EMPTY. IT IS HARD TO READ THE FUEL LEVEL AFTER THAT BECAUSE HONESTLY WHO HAS TIME TO SIT AND CALCULATE MILAGE USED EVERYDAY (I KNOW I DON'T) I HAVE READ ON OTHER FORUMS THAT THIS WAS HAPPENING ON OTHER YEARS OF TRAVERSES AND WAS TOLD TO REPORT IT. EVEN IF THE CAR SITS FOR AWHILE IT WON'T READ THE CORRECT FUEL LEVEL THAT IS UNTIL FUEL HAS BEEN ADDED TO ABOVE THE HALF TANK MARK.
NHTSA ODI #10909724
Official recalls
5Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Apr 9, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET TRAVERSE, BUICK ENCLAVE, AND GMC ACADIA VEHICLES CURRENTLY REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING AND THE DISTRICT OF COLUMBIA. SNOW OR ICE BUILDUP ON THE WINDSHIELD OR ON THE WIPER MAY RESTRICT THE MOVEMENT OF THE WIPER ARM, CAUSING THE WIPER ARM TO LOOSEN AND CAUSE THE WIPER TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS OCCURS, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL TIGHTEN THE WIPER ARM NUTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 20, 2012.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration