IllustrationTHE REAR VIEW MIRROR THAT CONTAINS A BACKUP CAMERA LOOKS VERY CLOUDY/FOGGY AND IS VISIBLE HARD TO USE. ALSO THE SECOND ROW SEATS (DRIVER AND PASSENGER) SEAT BELTS ARE NO LONGER BUCKLING PROPERLY. MY 11 YEAR OLD SEATS BACK THERE AND EVERYTIME WE HIT A BUMP THE SEATBELT POPS OUT OF ITS BUCKLE.
2011 Chevrolet Traverse
Owner reports · Recalls · Investigations
More warning signs than most Traverse years
Owner complaints for the 2011 Chevrolet Traverse are substantially higher than the model-year median of 302.
About this comparison →How this year compares
Owner complaints by model year
Compare all Traverse years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
650–25K
7125–50K
13250–75K
9675–100K
116100–150K
17150K+
497 reports with mileage · 111 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 204 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 165 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electronic Stability Control (esc). Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports4 fire reports15 injury reports
Seat Belts complaints
21 reportsLETTER FROM CONGRESSMAN GOSAR ON BEHALF OF CONSTITUENT RE 2011 CHEVY TRAVERSE MULTIPLE RECALLS (ATTN: STEPHEN BRIGGS). *SMD THE CONSUMER STATED HER VEHICLE HAD THREE MAJOR SAFETY RECALLS REGARDING THE AIR BAGS, SEAT BELTS AND WATER PUMP. RECENTLY, WHILE DRIVING THE STABILTRAK SERVICE TRACTION CONTROL LIGHT ILLUMINATED, FOLLOW…
Read full complaint
LETTER FROM CONGRESSMAN GOSAR ON BEHALF OF CONSTITUENT RE 2011 CHEVY TRAVERSE MULTIPLE RECALLS (ATTN: STEPHEN BRIGGS). *SMD THE CONSUMER STATED HER VEHICLE HAD THREE MAJOR SAFETY RECALLS REGARDING THE AIR BAGS, SEAT BELTS AND WATER PUMP. RECENTLY, WHILE DRIVING THE STABILTRAK SERVICE TRACTION CONTROL LIGHT ILLUMINATED, FOLLOWED BY THE ENGINE POWERING DOWN AND THE ENGINE LIGHT ILLUMINATED, AT WHICH POINT THE VEHICLE DECELERATED FROM 65 MPH TO LESS THAN 5 MPH. *JB
ON AUGUST 6, 2014 WE HAD OUR VEHICLE SERVICED BY THE DEALER DUE TO AN AIRBAG RECALL AND AT THE TIME THE VEHICLE HAD 38,000 MILES. SHORTLY THERE AFTER WE NOTICED A GRINDING NOISE WHEN WE MADE A RIGHT HAND TURN. AT FIRST IT HAPPENED INTERMITTENTLY BUT EVENTUALLY IT BECAME NOTICEABLE AT LOW RATES OF SPEED (5 - 10 MPH). TODAY WE T…
Read full complaint
ON AUGUST 6, 2014 WE HAD OUR VEHICLE SERVICED BY THE DEALER DUE TO AN AIRBAG RECALL AND AT THE TIME THE VEHICLE HAD 38,000 MILES. SHORTLY THERE AFTER WE NOTICED A GRINDING NOISE WHEN WE MADE A RIGHT HAND TURN. AT FIRST IT HAPPENED INTERMITTENTLY BUT EVENTUALLY IT BECAME NOTICEABLE AT LOW RATES OF SPEED (5 - 10 MPH). TODAY WE TOOK THE VEHICLE TO THE DEALERSHIP FOR THE THIRD RECALL THIS BEING THE POWER STEERING PUMP. WE WERE INFORMED THAT THIS WAS COVERED BY GM BUT WE ALSO HAD A LEAK IN OUR RACK AND PINION AND IT WOULD COST $1200 TO REPAIR. WE INTEND TO FIGHT THIS SINCE IT APPEARS IT MAY BE LINKED TO THE STEERING RECALL. WE ALSO HAVE NOTICED THAT THE DRIVER SIDE SEAT BELT HAS CUT A GROOVE INTO THE PLASTIC SEATBELT COVER NEAR THE SHOULDER HARNESS. WE WERE TOLD THAT THIS WAS NOT RELATED TO THE EARLIER SEAT BELT RECALL WHICH HAD BEEN SERVICED. THIS COULD EFFECT THE INTEGRITY OF THE SEAT BELT SYSTEM IF THE BELT GETS SNAGGED BY THE PLASTIC GROOVE WHICH HAS APPEARED. THIS SHOULD NOT HAPPEN WITH A CAR THAT IS LESS THAN 3 YEARS OLD. *TR
THIS IS REGARDING THE HANDLING OF THE SAFETY RECALLS THAT CHEVY HAS ISSUED. WE WERE ADVISED TO BRING OUR VEHICLE IN FOR NO CHARGE REPLACEMENT ON PARTS. AFTER BRINGING THE SUV IN AND WAITING OVER AN HOUR I WAS ADVISED THE PARTS HAD TO BE ORDERED AND WOULD RECEIVE A CALL AS SOON AS THEY WERE IN. 5 WEEKS LATER, STILL NO CALL. I C…
Read full complaint
THIS IS REGARDING THE HANDLING OF THE SAFETY RECALLS THAT CHEVY HAS ISSUED. WE WERE ADVISED TO BRING OUR VEHICLE IN FOR NO CHARGE REPLACEMENT ON PARTS. AFTER BRINGING THE SUV IN AND WAITING OVER AN HOUR I WAS ADVISED THE PARTS HAD TO BE ORDERED AND WOULD RECEIVE A CALL AS SOON AS THEY WERE IN. 5 WEEKS LATER, STILL NO CALL. I CALLED AND WAS ADVISED THE PARTS WERE IN. THERE WAS NO EXPLANATION AS TO WHY WE DIDN'T RECEIVE A CALL AS SOON AS THE PARTS WERE IN, AS THIS IS A SAFETY ISSUE AND WE HAVE A 1 YEAR OLD WHO RIDES IN THIS VEHICLE. BROUGHT THE SUV IN TO BE REPAIRED, WAS ADVISED 3 HOURS. AFTER 9HOURS WITH NO CALL, WE CALLED. WE WERE TOLD THAT THE PARTS THAT CAME IN WERE DEFECTIVE AND THEY NEEDED TO ORDER NEW PARTS. IT SHOULD BE KNOWN AND INVESTIGATED AS TO WHAT SERVICE CHEVY IS DOING ON RECALLS THAT ARE A SAFETY ISSUE, THE NEW PARTS ARE DEFECTIVE ALSO! I CALLED CHEVY AND FILED A COMPLAINT REGARDING THIS DEALERSHIP AND SERVICE. *TR
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. THE CONTACT STATED THAT THE DRIVER SIDE FLEXIBLE STEEL CABLE FRACTURED. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V266000 (SEAT BELTS). THE CONTACT STATED THAT THE PART NEEDED TO REMEDY THE RECALL WAS UNAVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE I…
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. THE CONTACT STATED THAT THE DRIVER SIDE FLEXIBLE STEEL CABLE FRACTURED. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V266000 (SEAT BELTS). THE CONTACT STATED THAT THE PART NEEDED TO REMEDY THE RECALL WAS UNAVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS UNKNOWN.
MIDDLE SEATBELT ON THE SECOND ROW LOCKED WITH MY GRANDCHILD IN IT. WAS UNABLE TO GET HER CAR SEAT OUT. FINALLY GOT IT LOSE AND WAS TOLD BY THE DEALER IT WOULD COST ALMOST 350.00 TO FIX THIS. THIS HAS BEE LIKE THIS FOR OVER A YEAR. *TR
I TOOK MY VEHICLE IN FOR THE SEAT BELT RECALL. THE RECALL WAS PERFORMED, LEAVING QUESTIONS. HOW DOES REMOVING THE SLEEVE ON THE SEAT BELT AND REPLACING IT WITH SHRINK WRAP PLASTIC MAKE THIS SAFER? THERE IS NOW NOTHING TO PREVENT THE SEAT BELT CABLE FROM RUBBING ON THE SIDES OF THE NOW HOLE WHERE THE SLEEVE WAS. NOT TO MENTION TH…
Read full complaint
I TOOK MY VEHICLE IN FOR THE SEAT BELT RECALL. THE RECALL WAS PERFORMED, LEAVING QUESTIONS. HOW DOES REMOVING THE SLEEVE ON THE SEAT BELT AND REPLACING IT WITH SHRINK WRAP PLASTIC MAKE THIS SAFER? THERE IS NOW NOTHING TO PREVENT THE SEAT BELT CABLE FROM RUBBING ON THE SIDES OF THE NOW HOLE WHERE THE SLEEVE WAS. NOT TO MENTION THIS LEAVES THIS AREA LOOKING TERRIBLE AND UNFINISHED. *TR
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. THE CONTACT STATED WHILE WAITING AT A TRAFFIC LIGHT, A VEHICLE CRASHED INTO THE REAR END AND PUSHED THE VEHICLE INTO AN INTERSECTION. THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELT FAILED TO RESTRAIN HER. THE CONTACT SUSTAINED INJURIES TO THE CHEST, KNEE AND A FRACTURED HAND. THE …
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. THE CONTACT STATED WHILE WAITING AT A TRAFFIC LIGHT, A VEHICLE CRASHED INTO THE REAR END AND PUSHED THE VEHICLE INTO AN INTERSECTION. THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELT FAILED TO RESTRAIN HER. THE CONTACT SUSTAINED INJURIES TO THE CHEST, KNEE AND A FRACTURED HAND. THE POLICE REPORT WAS FILED. THE CONTACT ALSO STATED THAT THE AIR BAG LIGHT ILLUMINATED THREE TIMES PRIOR TO THE FAILURE HOWEVER, THE DEALER WAS NOT ABLE TO DUPLICATE THE FAILURE AND AS A TEMPORARY REMEDY RESET THE LIGHT. THE CONTACT ALSO LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER 14V118000 (AIR BAG). THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE WAS 45,000.
IN OUR 8 PASSENGER TRAVERSE WE HAVE FREQUENT TROUBLE WITH THE MIDDLE ROW, MIDDLE SEAT BELT LOCKING UP WHEN IT IS NOT USED. THE PROBLEM OCCURS WHEN SOMEONE GOES TO BUCKLE THEIR BELT IN THIS SEAT - IT WILL NOT DISENGAGE AND WE HAVE TO MANIPULATE THE SEAT OR THE AREA AROUND THE WHERE THE SEAT BELT RETRACTS INTO THE SEAT TO GET IT …
Read full complaint
IN OUR 8 PASSENGER TRAVERSE WE HAVE FREQUENT TROUBLE WITH THE MIDDLE ROW, MIDDLE SEAT BELT LOCKING UP WHEN IT IS NOT USED. THE PROBLEM OCCURS WHEN SOMEONE GOES TO BUCKLE THEIR BELT IN THIS SEAT - IT WILL NOT DISENGAGE AND WE HAVE TO MANIPULATE THE SEAT OR THE AREA AROUND THE WHERE THE SEAT BELT RETRACTS INTO THE SEAT TO GET IT TO DISENGAGE. SOMETIMES IT BECOMES SO DIFFICULT OR TIME CONSUMING WE HAVE TO MOVE THAT PERSON TO THE 3RD ROW SEATING IN THE FAR BACK. IT IS ONLY THIS SEAT BELT THAT DOES THIS AND AFTER CONDUCTING AN INTERNET SEARCH, WE ARE NOT THE ONLY CONSUMERS HAVING THIS ISSUE. THIS IS AN INCONVENIENCE AT THIS POINT BUT AM CONCERNED IT IS A SAFETY ISSUE - IF THE SEAT BELT BEHAVES THIS WAY, HOW DO I KNOW IT WILL WORK PROPERLY IN AN ACCIDENT? WHEN WE BROUGHT OUR CAR TO THE DEALER TO LOOK AT THIS ISSUE THEY TOLD US THEY COULD REPLACE THE SEAT BELT. MY CONCERN IS THIS SEEMS LIKE A DESIGN FLAW AND IF THEY REPLACE THE SEAT BELT WITH THE SAME OEM PART, WHAT PREVENTS THE ISSUE FROM RECURRING? *TR
I GOT INTO MY CAR ONE DAY. I PULLED THE SEATBELT TO BUCKLE IT AND THE PIECE THAT HOOKS NEXT TO THE SEAT AND DOOR WAS BROKEN OFF. I TOOK IT INTO SUNDANCE AND THE MECHANIC TOLD ME ITD BE $250 TO FIX IT BUT HE'S NEVER SEEN ANYTHING LIKE THAT IN 40 YEARS AND THERES NO WAY WE COULDVE BROKEN IT. I STILL HAVENT HAD MONEY TO FIX IT AND …
Read full complaint
I GOT INTO MY CAR ONE DAY. I PULLED THE SEATBELT TO BUCKLE IT AND THE PIECE THAT HOOKS NEXT TO THE SEAT AND DOOR WAS BROKEN OFF. I TOOK IT INTO SUNDANCE AND THE MECHANIC TOLD ME ITD BE $250 TO FIX IT BUT HE'S NEVER SEEN ANYTHING LIKE THAT IN 40 YEARS AND THERES NO WAY WE COULDVE BROKEN IT. I STILL HAVENT HAD MONEY TO FIX IT AND ITS NOT COVERED UNDER WARRANTY FOR SOME REASON. *JS
Official recalls
521V246000 · Air Bags:critical Fasteners
Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
15V415000 · Structure:body:hatchback/liftgate
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
14V266000 · Seat Belts
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
14V118000 · Air Bags:side/window
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
12V151000 · Visibility:windshield Wiper/washer:linkages
Apr 9, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET TRAVERSE, BUICK ENCLAVE, AND GMC ACADIA VEHICLES CURRENTLY REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING AND THE DISTRICT OF COLUMBIA. SNOW OR ICE BUILDUP ON THE WINDSHIELD OR ON THE WIPER MAY RESTRICT THE MOVEMENT OF THE WIPER ARM, CAUSING THE WIPER ARM TO LOOSEN AND CAUSE THE WIPER TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS OCCURS, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL TIGHTEN THE WIPER ARM NUTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 20, 2012.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648