NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
9 reportsClear category filterMileage unknown · Jul 25, 2017
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT SMELLED COOLANT. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO SHOTTENKIRK CHEVROLET (LOCATED AT 755 HICKMAN RD, WAUKEE, IA 50263) WHERE IT WAS DIAGNOSED THAT THE WATER PUMP NEEDED TO BE REPLACED. THE VEHICLE …
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT SMELLED COOLANT. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO SHOTTENKIRK CHEVROLET (LOCATED AT 755 HICKMAN RD, WAUKEE, IA 50263) WHERE IT WAS DIAGNOSED THAT THE WATER PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #11010586
Mileage unknown · May 6, 2015
Air BagsEngine And Engine CoolingSeat Belts
LETTER FROM CONGRESSMAN GOSAR ON BEHALF OF CONSTITUENT RE 2011 CHEVY TRAVERSE MULTIPLE RECALLS (ATTN: STEPHEN BRIGGS). *SMD THE CONSUMER STATED HER VEHICLE HAD THREE MAJOR SAFETY RECALLS REGARDING THE AIR BAGS, SEAT BELTS AND WATER PUMP. RECENTLY, WHILE DRIVING THE STABILTRAK SERVICE TRACTION CONTROL LIGHT ILLUMINATED, FOLLOW…
Read full complaint
LETTER FROM CONGRESSMAN GOSAR ON BEHALF OF CONSTITUENT RE 2011 CHEVY TRAVERSE MULTIPLE RECALLS (ATTN: STEPHEN BRIGGS). *SMD THE CONSUMER STATED HER VEHICLE HAD THREE MAJOR SAFETY RECALLS REGARDING THE AIR BAGS, SEAT BELTS AND WATER PUMP. RECENTLY, WHILE DRIVING THE STABILTRAK SERVICE TRACTION CONTROL LIGHT ILLUMINATED, FOLLOWED BY THE ENGINE POWERING DOWN AND THE ENGINE LIGHT ILLUMINATED, AT WHICH POINT THE VEHICLE DECELERATED FROM 65 MPH TO LESS THAN 5 MPH. *JB
NHTSA ODI #10714847
43,000 miles · Feb 23, 2014
Engine And Engine CoolingTraction Control System
WHILE TRAVELING ON THE HIGHWAY HEADING TO THE AIRPORT, WE WERE GOING APPROXIMATELY 60MPH.THE ENGINE LIGHT CAME ON AND TRUCK BEGAN TO POWER DOWN. THE TRACTION CONTROL/STABILI TRACK LIGHT ALSO CAME ON AND WE WERE LOSING SPEED AND COULD NOT ACCELERATE. WITH OTHER VEHICLES AROUND US WERE GOING 60MPH OR MORE WE HAD TO TRY AND GET OFF…
Read full complaint
WHILE TRAVELING ON THE HIGHWAY HEADING TO THE AIRPORT, WE WERE GOING APPROXIMATELY 60MPH.THE ENGINE LIGHT CAME ON AND TRUCK BEGAN TO POWER DOWN. THE TRACTION CONTROL/STABILI TRACK LIGHT ALSO CAME ON AND WE WERE LOSING SPEED AND COULD NOT ACCELERATE. WITH OTHER VEHICLES AROUND US WERE GOING 60MPH OR MORE WE HAD TO TRY AND GET OFF HIGHWAY TO SIDE OF ROAD BEFORE OUR TRUCK LOST POWER ALL TOGETHER. WE THEN SHUT OFF THE TRUCK LET IT SIT FOR FEW MINUTES AND THEN TURNED TRUCK BACK ON. WE WERE THEN ABLE TO PULL BACK ON TO HIGHWAY AT FULL SPEED. IT HAPPENED A TWO MORE TIMES BEFORE WE WERE ABLE TO REACH OUR DESTINATION. THREE DAYS LATER WE WERE BACK IN OUR TRUCK LEAVING THE AIRPORT HEADING HOME AND WITHIN 5 MINUTES OF BEING ON THE ROAD OUR TRUCK BEGAN TO POWER DOWN AGAIN, CHECK ENGINE LIGHT CAME ON AND STABILI TRACK LIGHT ALSO CAME ON. WE HAD TO AGAIN PULL OVER BUT THIS TIME AT LEAST 5 TIMES BEFORE WE WERE ABLE TO MAKE IT HOME. IT WAS A VERY DANGEROUS AND SCARY ORDEAL. WE CONTACTED ATLANTIC CHEVY ABOUT THE PROBLEM AND WE BROUGHT TRUCK IN A WEEK LATER DUE TO THE FACT THAT THEY SAID THEY DID NOT HAVE A LOANER VEHICLE AVAILABLE FOR US. WE WERE TOLD THAT IT WAS THE THROTTLE BODY AND WE WERE NOT COVERED SINCE WE WERE PAST OUR 3YR/36,000 MILES WARRANTY. AFTER MUCH RESEARCH, WE HAVE FOUND THAT WE ARE ONE OF MANY OTHER GM CUSTOMERS WHO HAVE HAD THE SAME SITUATION WITH THEIR VEHICLE POWERING DOWN IN THE MIDDLE OF DRIVING. THIS IS NOT JUST A RANDOM PROBLEM WITH OUR VEHICLE BUT APPEARS TO BE A DEFECTIVE PROBLEM WITH THE PART. CUSTOMERS ARE BEING EXPECTED TO PAY FOR THIS TO BE FIXED WHEN IN FACT IT SHOULD BE A RECALL ON THE PART OR IT SHOULD BE COVERED UNDER THE FEDERAL EMISSIONS WARRANTY. I HOPE BY US FILING THIS COMPLAINT THAT IT WILL BE LOOKED INTO FURTHER AND THAT IT WILL BE HANDLED IN THE WAY THAT SATISFIES ALL GENERAL MOTOR CUSTOMERS WHO HAVE HAD TO DEAL WITH THIS PROBLEM. THANK YOU. *TR
NHTSA ODI #10565509
38,000 miles · May 10, 2013
Electronic Stability Control (esc)Engine And Engine CoolingFuel System, Gasoline
WAS AT TARGET ONE EVENING AND NOTICED A SWEET UNUSUAL SMELL COMING FROM THE TRAVERSE. I TOOK A LOOK UNDERNEATH THE CAR AND NOTICED PINK SUBSTANCE DRIPPING FROM THE ENGINE. UPON LEAVING TARGET I NOTICED THAT THE ARM ON THE TEMPERATURE GAUGE WAS HIGHER THAN NORMAL. I DROVE 40MPH FOR A MILE AND THE GAUGE SHOT UP TO THE TOP. I WAS 2…
Read full complaint
WAS AT TARGET ONE EVENING AND NOTICED A SWEET UNUSUAL SMELL COMING FROM THE TRAVERSE. I TOOK A LOOK UNDERNEATH THE CAR AND NOTICED PINK SUBSTANCE DRIPPING FROM THE ENGINE. UPON LEAVING TARGET I NOTICED THAT THE ARM ON THE TEMPERATURE GAUGE WAS HIGHER THAN NORMAL. I DROVE 40MPH FOR A MILE AND THE GAUGE SHOT UP TO THE TOP. I WAS 25 MINUTES FROM HOME. I HAD TO STOP 6 TIMES TO LET THE ENGINE COOL DOWN IN ORDER TO MAKE IT HOME AND I HAD ALL FOUR OF MY KIDS IN THE CAR WITH ME AS WELL. IT TOTALLY FREAKED THEM OUT. I HAD TO RENT A CAR FOR THE WEEKEND AS I NEEDED TRANSPORTATION TO GET AROUND. I HAD A COMPANY THAT WILL COME TO YOUR HOME TO FIX YOUR CAR. FOUND OUT IT WAS MY FUEL PUMP. AFTER 4 HOURS OF LABOR AND $400.00 LATER IT WAS FIXED. FOUR MONTHS LATER, TODAY MAY 10, 2013 AS I'M DRIVING HOME FROM WORK, THE CAR BEGINS TO BEEP AND THE TRACTION CONTROL LIGHT AND ABS LIGHT COMES ON AND SERVICE STABILITRAK SYSTEM AND TRACTION CONTROL OFF DISPLAYS IN THE DISPLAY WINDOW. IT SEEMED AS IF IT WAS HARD TO ACCELERATE AS WELL. THIS IS THE 2ND THING THAT IS PROBABLY GOING TO BE FAIRLY EXPENSIVE TO FIX THAT HAS HAPPENED TO THIS CAR. IT IS THE WEEKEND AND NOW HAVE TO TRY AND FIND A PLACE TO TAKE MY CAR AND HAVE IT SERVICED. SEEING NOW THAT THERE HAVE BEEN SEVERAL COMPLAINTS WITH THIS SPECIFIC COMPONENT ON THE CAR, CHEVROLET NEEDS TO RECALL THIS CAR AND FIX THIS. THIS IS VERY DANGEROUS AND COULD CAUSE AN ACCIDENT. I THINK IT'S RIDICULOUS TO HAVE TO CONTINUE TO PAY FOR THINGS THAT CONTINUE TO BREAK DOWN ON THIS VEHICLE. I AM A SINGLE PARENT AND CANNOT CONTINUE TO FINANCIALLY BE ABLE TO DO THIS. *TR
NHTSA ODI #10511435
11,000 miles · Apr 19, 2012
Electrical SystemEngine And Engine Cooling
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED DIFFICULTY STARTING. THE CONTACT ALSO STATED THAT THE VEHICLE LOST POWER AND STALLED INTERMITTENTLY. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE. THE DEALER PERFORMED A…
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED DIFFICULTY STARTING. THE CONTACT ALSO STATED THAT THE VEHICLE LOST POWER AND STALLED INTERMITTENTLY. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE. THE DEALER PERFORMED A DIAGNOSTIC TEST THAT WAS UNABLE TO LOCATE A FAILURE CODE. THE VEHICLE WAS THEN TEST DRIVEN AND THE FAILURE WAS DUPLICATED. THE DEALER REPLACED THE GROUND WIRES AND THE COMPUTER MODULE, BUT THE FAILURE WAS NOT CORRECTED. THE VEHICLE WAS NOT REPAIRED. THE VIN INFORMATION WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 11,000 AND THE CURRENT MILEAGE WAS 16,000. .,.UPDATED 05/15/12 * BF THE CONSUMER STATED GM WAS TAKING THE NECESSARY STEPS TO REPLACE HIS VEHICLE. UPDATED 05/21/12
NHTSA ODI #10455738
15,000 miles · Jan 23, 2012
Engine And Engine Cooling
THE HEATING AND COOLING LINES GOING TO THE REAR HEATING AND COOLING OF VEHICLE ARE IN DIRECT LINE OF ANYTHING KICKED UP FROM THE FROM RIGHT WHEEL. SHOULD THESE LINES BE CRUSHED OR BROKEN OPEN, A COMPLETE COOLANT LOSS WILL OCCUR. THESE COOLANT SHOULD BE SHIELDED FROM ROAD DEBRIS. *TR
NHTSA ODI #10444850
2,000 miles · Dec 6, 2011
Engine And Engine CoolingPower Train
THE VEHICLE ALWAYS ROLL BACKS WHEN YOU ARE STOPPED ON A SLOPE. THIS HAPPENS TO ME AT ALL TIMES WHEN I AM PICKING UP KIDS FROM SCHOOL AND HAVE A STOP SIGN AT A SLOPE. THE SLOPE IS NOT VERY STEEP AND OTHER CAR I HAVE DOES NOT HAVE THIS PROBLEM. JUST BIZZARE THAT YOU REALLY HAVE TO ACCELERATE YOUR WAY OUT, EVEN THEN THE CAR ROLLS B…
Read full complaint
THE VEHICLE ALWAYS ROLL BACKS WHEN YOU ARE STOPPED ON A SLOPE. THIS HAPPENS TO ME AT ALL TIMES WHEN I AM PICKING UP KIDS FROM SCHOOL AND HAVE A STOP SIGN AT A SLOPE. THE SLOPE IS NOT VERY STEEP AND OTHER CAR I HAVE DOES NOT HAVE THIS PROBLEM. JUST BIZZARE THAT YOU REALLY HAVE TO ACCELERATE YOUR WAY OUT, EVEN THEN THE CAR ROLLS BACK....ALMOST HIT ANOTHER VEHICLE BEHIND ME. *TR
NHTSA ODI #10438737
11,000 miles · Dec 6, 2011
Engine And Engine Cooling
CALL VIBRATES AND SUDDENLY CAME TO A HALT. WAS ABLE TO MOVE THE CAR TO SHOULDER. PRIOR TO THIS I NOTICED THE CAR WAS SHOWING ME A RPM INDICATOR ON 2 AND 3 EVEN WHEN IN PARKED CONDITION, SCARY. MANAGED TO GET THE CAR TO DEALERSHIP. DEALERSHIP ADVISED THAT CYLINDER ARE MISFIRING, ABOUT 3 TO 4 OF THEM. SURPRISED THAT THIS CAN HAPP…
Read full complaint
CALL VIBRATES AND SUDDENLY CAME TO A HALT. WAS ABLE TO MOVE THE CAR TO SHOULDER. PRIOR TO THIS I NOTICED THE CAR WAS SHOWING ME A RPM INDICATOR ON 2 AND 3 EVEN WHEN IN PARKED CONDITION, SCARY. MANAGED TO GET THE CAR TO DEALERSHIP. DEALERSHIP ADVISED THAT CYLINDER ARE MISFIRING, ABOUT 3 TO 4 OF THEM. SURPRISED THAT THIS CAN HAPPEN IN LESS THAN 9 MONTHS OF BUYING THE CAR... *TR
NHTSA ODI #10438735
11,000 miles · Dec 6, 2011
Engine And Engine Cooling
CAR SHAKES AND VIBRATES WHEN STOPPED AT STOP SIGNS AND LIGHTS. CAR SUDDENLY CAME TO A COMPLETELY HALT. WAS ABLE TO GET HELP AND MOVE IT TO SHOULDER. WAS ABLE TO START THE CAR LATER IN THE DAY AND DRIVE TO THE DEALER. DEALER MENTIONED THAT 4 CYLINDERS ARE MISFIRING. SURPRISED THAT A CAR ONLY 9 MONTHS OLD AND WITH 11K MILES WOULD …
Read full complaint
CAR SHAKES AND VIBRATES WHEN STOPPED AT STOP SIGNS AND LIGHTS. CAR SUDDENLY CAME TO A COMPLETELY HALT. WAS ABLE TO GET HELP AND MOVE IT TO SHOULDER. WAS ABLE TO START THE CAR LATER IN THE DAY AND DRIVE TO THE DEALER. DEALER MENTIONED THAT 4 CYLINDERS ARE MISFIRING. SURPRISED THAT A CAR ONLY 9 MONTHS OLD AND WITH 11K MILES WOULD DO THAT. *TR
NHTSA ODI #10438707
Official recalls
5Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Apr 9, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET TRAVERSE, BUICK ENCLAVE, AND GMC ACADIA VEHICLES CURRENTLY REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING AND THE DISTRICT OF COLUMBIA. SNOW OR ICE BUILDUP ON THE WINDSHIELD OR ON THE WIPER MAY RESTRICT THE MOVEMENT OF THE WIPER ARM, CAUSING THE WIPER ARM TO LOOSEN AND CAUSE THE WIPER TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS OCCURS, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL TIGHTEN THE WIPER ARM NUTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 20, 2012.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration