IllustrationMY SERVICE AIRBAGS FRONT DRIVER WIRE HARNESS AND CONNECTOR NO RADIO NO BLUE TOOTH
2011 Chevrolet Traverse
Owner reports · Recalls · Investigations
More warning signs than most Traverse years
Owner complaints for the 2011 Chevrolet Traverse are substantially higher than the model-year median of 302.
About this comparison →How this year compares
Owner complaints by model year
Compare all Traverse years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
650–25K
7125–50K
13250–75K
9675–100K
116100–150K
17150K+
497 reports with mileage · 111 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 204 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 165 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electronic Stability Control (esc). Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports4 fire reports15 injury reports
Electrical System complaints
67 reportsDRIVING AT HIGHWAY SPEED OF 75 MPH, THE MOTOR SIEZED WITHOUT ANY WARNING. THE MOTOR LOCKED AND THE TECHNICIAN SAID THE ENGINE NEEDS TO BE REPLACED. HE COMMENTED SOMETHING WRONG WITH THE ENGINEERING OF THE ENGINE SPECIFIC TO OIL. HE IS CONCERN THAT CHANGING THE ENGINE MAY RESULT IN THE SAME SITUATION GIVEN THE MOTOR'S DESIGN.
SITTING IN THE PARKING LOT WAITING FOR MY DAUGHTER TO GET OUT OF SCHOOL ALL OF A SUDDEN IT SMELLS HOT THEN START TO DRIVE OFF AND TRACTION CONTROL LIGHTS AND ABS GO WILD THEN I PULL OVER TURN OFF THE ENGINE OPEN THE HOOD AND THERE'S SMOKE LETTING IT COOL THE KEY WON'T REVERSE OUT OF THE IGNITION AND THERE'S NO POWER AT ALL
TAKATA RECALL, I WAS DRIVING MY CAR DOWN AN INTERSTATE AND THE COOLANT HAD LEAKED OUT AND OVERHEATED MY CAR I HAVE DONE HAD EACH HOSE AND HOUSING AND THE THERMOSTAT AND THE RESERVOIR TAKE REPLACED IN IT ABOUT 2 MONTHS AGO. IT'S IS NOW DOING THE SAME THING AGAIN IT STARTED AGAIN WHILE I WAS ON A HIGHWAY.
LESS THEN A YEAR AGO THE BATTERY GAUGE STARTED DIPPING BELOW 14V TO 12V PERIODICALLY WHILE DRIVING. WHEN GETTING OFF THE HIGHWAY ONE DAY(BATTER GAGUE DID NOT DIP) AND COMING TO A LIGHT ON A 2 LANE SMALLER MAJOR ROAD THE LIGHTS ALL CAME ON CHECK ENGINE, STABILITRAK, BATTERY, ETC AND THE CAR SHUT DOWN. FORTUNATELY, MY HUSBAND WAS…
Read full complaint
LESS THEN A YEAR AGO THE BATTERY GAUGE STARTED DIPPING BELOW 14V TO 12V PERIODICALLY WHILE DRIVING. WHEN GETTING OFF THE HIGHWAY ONE DAY(BATTER GAGUE DID NOT DIP) AND COMING TO A LIGHT ON A 2 LANE SMALLER MAJOR ROAD THE LIGHTS ALL CAME ON CHECK ENGINE, STABILITRAK, BATTERY, ETC AND THE CAR SHUT DOWN. FORTUNATELY, MY HUSBAND WAS ABLE TO CRUISE THROUGH THE LIGHT AND SOMEHOW EVERYONE WAS OUT OF HIS WAY SO HE COULD COME TO A STOP O THE SIDE OF A ROAD THAT THE SPEED LIMIT IS 50 ON. THE WINDOWS WERE OPEN COULDN'T DO ANYTHING. TOW CAME OUT AND HIS JUMPERS WERE ZAPPED. TRIED AGAIN AND WAS ABLE TO GET INTO N SO COULD BE FLAT-BEDDED TO THE MECHANIC. THE ALTERNATOR WAS FRIED, AND FRIED BATTERY AND MESSED UP AC. REPLACED ALT AND BATTERY AND OTHER PARTS THAT WERE FRIED. LESS THAN 6 MONTHS LATER BATTERY STARTED DIPPING REALLY LOW AND SO WE HAD THE CAR CHECKED SEVERAL TIMES AND NOTHING SEEMED WRONG. NOW WE'RE 10 MONTHS IN AND HAD TO REPLACE ALT. AGAIN AND WITHIN A WEEK (TODAY) BATTERY STARTED DIPPING TO 12V AGAIN. THIS IS WHILE DRIVING AND HAPPENS ABOUT 20 MINUTES OR SO INTO DRIVE. I DRIVE ON MAJOR HIGHWAYS AND HAVE MY CHILDREN IN THE CAR THE MAJORITY OF THE TIME. THIS IS DANGEROUS AND SEEMS TO BE A RECURRENT PROBLEM ON TONS OF THESE CARS. IF THE CAR DIES AGAIN, THANKFULLY THE STARS ALIGNED AND MY HUSBAND WAS ABLE TO AT LEAST PULL TO THE SIDE OF THE ROAD, WE MAY NOT BE SO LUCKY. OF COURSE, THE CAR IS OUT OF WARRANTY NOW TOO SO HOW IS IT THAT ALL THESE PEOPLE, INCLUDING US, WILL BE ASKED TO SHELL OUT TONS OF MONEY TO FIX A COMMON ISSUE THAT NEEDS TO BE TAKEN CARE OF SO PEOPLE DON'T DIE! THIS IS NOT SIMPLY A MAINTENANCE ISSUE.
THE VEHICLES CONTROL PANEL DISPLAYS MULTIPLE ERRORS SUCH AS ENGINE POWER IS REDUCED, PARK ASSIST OFF, TRACTION CONTROL OFF, BRAKE (IN RED), ABS AND ALL THE GAGES GO UP AND DOWN, AUTOMATIC LOCKS-LOCK AND UNLOCK ALL WHILE DRIVING ON CITY STREET AND HIGHWAYS. ATTEMPTING TO PULL THE CAR OVER, THE TRANSMISSION WONT GO INTO PARK. MULT…
Read full complaint
THE VEHICLES CONTROL PANEL DISPLAYS MULTIPLE ERRORS SUCH AS ENGINE POWER IS REDUCED, PARK ASSIST OFF, TRACTION CONTROL OFF, BRAKE (IN RED), ABS AND ALL THE GAGES GO UP AND DOWN, AUTOMATIC LOCKS-LOCK AND UNLOCK ALL WHILE DRIVING ON CITY STREET AND HIGHWAYS. ATTEMPTING TO PULL THE CAR OVER, THE TRANSMISSION WONT GO INTO PARK. MULTIPLE TIMES IT WON'T START AND SOMETIMES THE VEHICLE FAILS TO GAIN SPEED WHILE DRIVING.
THE AIR CONDITIONER STILL FAULTY. REPLACED HOSES AND FREON. THE STRUTS STILL LEAKING FLUID AROUND TIRE AREA SINCE PURCHASED. I SEE MANY COMPLAINTS ONLINE AT DIFFERENT FORUMS ABOUT THIS. MY ENGINE LIGHT COMES ON INTERMITTENTLY ANF WHEN I HAVE IT TESTED IT JUST SAYS O2 SENSORS. THE LIGHT WILL STAY ON FOR 1-2 DAYS AND THEN GO OUT A…
Read full complaint
THE AIR CONDITIONER STILL FAULTY. REPLACED HOSES AND FREON. THE STRUTS STILL LEAKING FLUID AROUND TIRE AREA SINCE PURCHASED. I SEE MANY COMPLAINTS ONLINE AT DIFFERENT FORUMS ABOUT THIS. MY ENGINE LIGHT COMES ON INTERMITTENTLY ANF WHEN I HAVE IT TESTED IT JUST SAYS O2 SENSORS. THE LIGHT WILL STAY ON FOR 1-2 DAYS AND THEN GO OUT AND REMAIN OFF FOR SEVERAL MONTHS AT A TIME. EVERYTHING IN THE CAR IS PLASTIC AND KEEPS POPPING OFF. I HAVE REPLACED SO MANY DOOR AND SEAT PIECES THAT THIS IS CRAZY EVEN DOWN TO REPLACING MOTOR MOUNTS. I LOVE CHEVROLET BUT THIS BY FAR HAS BEEN MY MOST AGGRAVATING AND COSTLY PURCHASE.... I USED TO GO TO MY LOCAL CHEVY DEALER FOR SERVICE BUT I NOTICED WHEN I LOG IN TO MY CHEVY/GM PROFILE THEY DON'T LOAD ANYTHING INNTHE SYSTEM FOR CHEVY TO SEE YOU ARE REALLY MAINTAINING YOUR CAR. THESE DEALERS ARE RIPPING PEOPLE OFF.
2ND OWNER. AT 91K MILES WHOLE ELECTRICAL SYSTEM BLEW OUT. COST $600 TO FIX. AT $111K MILES ENGINE LIGHT CAME ON. WENT TO DEALERSHIP AND TIMING CHAIN NEEDED TO BE REPLACED. PARKED THE VEHICLE AS DEALERSHIP SAID IT KEEPS HAPPENING FOR 2011 TRAVERSE AND THEY ARE WAITING FOR RECALL. 6 MONTHS LATER DECIDED TO TAKE CAR BACK TO DEALERS…
Read full complaint
2ND OWNER. AT 91K MILES WHOLE ELECTRICAL SYSTEM BLEW OUT. COST $600 TO FIX. AT $111K MILES ENGINE LIGHT CAME ON. WENT TO DEALERSHIP AND TIMING CHAIN NEEDED TO BE REPLACED. PARKED THE VEHICLE AS DEALERSHIP SAID IT KEEPS HAPPENING FOR 2011 TRAVERSE AND THEY ARE WAITING FOR RECALL. 6 MONTHS LATER DECIDED TO TAKE CAR BACK TO DEALERSHIP TO GET FIXED QUOTED $3800. ON WAY TO DEALERSHIP (20 MINUTES AWAY) GOING 40 MILES AN HOUR CAR STARTED MAKING MACHINE GUNS NOISES AND SLOWING DOWN. PULLED INTO A NEIGHBORHOOD AND PARKED CAR. CALLED A TOW COMPANY AND HAD THEM TOW IT BACK TO THE HOUSE. LUCKILY, OUR NEIGHBOR WORKS AT A MECHANIC SHOP AND CAME OVER. HE TURNED THE CAR ON AND IT SHUT RIGHT OFF. AFTER HIS EXAMINATION HE SAID MY ENGINE HAD SEIZED AND WOULD NEED TO REPLACE IT. ALREADY HAVING TO RESET THE ELECTRICAL SYSTEM NOW I NEED TO REPLACE A TIMING CHAIN AND REPLACE AN ENGINE?? SEEMS AFTER READING ALL OF THE COMPLAINTS THE 2011 TRAVERSE HAS MAJOR ISSUES AND THIS NEEDS TO BE ADDRESSED!
I HAD TO REPLACE AN ENGINE AT 30K MILES DUE TO 'METAL IN OIL". NEVER ONCE MISSED AN OIL CHANGE AND NO WARNING OF ANY ISSUE UNTIL CAR DIED IN THE MIDDLE OF A BUSY ROAD WHILE TRYING TO TURN RIGHT ONTO SIDE STREET.. AFTER REPLACING ENGINE HAD TO GET NEW WHEEL SENORS AS THEY WENT BAD 2 WEEKS LATER. ONE AND A HALF YEARS LATER HERE WE…
Read full complaint
I HAD TO REPLACE AN ENGINE AT 30K MILES DUE TO 'METAL IN OIL". NEVER ONCE MISSED AN OIL CHANGE AND NO WARNING OF ANY ISSUE UNTIL CAR DIED IN THE MIDDLE OF A BUSY ROAD WHILE TRYING TO TURN RIGHT ONTO SIDE STREET.. AFTER REPLACING ENGINE HAD TO GET NEW WHEEL SENORS AS THEY WENT BAD 2 WEEKS LATER. ONE AND A HALF YEARS LATER HERE WE ARE DASH FLASHING SAYING 'SERVICE STABILITRACK, SERVICE TRACTION CONTROL, ENGIRE POWER REDUCES". CHECK ENGINE LIGHT ALSO ON. MECHANIC SAYS I WILL NEED A NEW ACCELORATOR PEDAL ALONG WITH THROTTLE BODY. THE CAR ITSELF AT THIS POINT IS UNDER 50K MILES. ALSO PASSENGER SIDE WINDOW DOES NOT GO UP OR DOWN WITH DRIVE SIDE DOOR LEVERS.
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. WHILE DRIVING, THE VEHICLE LOST POWER AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE SAFELY TO HIS RESIDENCE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUF…
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET TRAVERSE. WHILE DRIVING, THE VEHICLE LOST POWER AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE SAFELY TO HIS RESIDENCE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT PROVIDE ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 82,000.
Official recalls
521V246000 · Air Bags:critical Fasteners
Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
15V415000 · Structure:body:hatchback/liftgate
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
14V266000 · Seat Belts
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
14V118000 · Air Bags:side/window
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
12V151000 · Visibility:windshield Wiper/washer:linkages
Apr 9, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET TRAVERSE, BUICK ENCLAVE, AND GMC ACADIA VEHICLES CURRENTLY REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING AND THE DISTRICT OF COLUMBIA. SNOW OR ICE BUILDUP ON THE WINDSHIELD OR ON THE WIPER MAY RESTRICT THE MOVEMENT OF THE WIPER ARM, CAUSING THE WIPER ARM TO LOOSEN AND CAUSE THE WIPER TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS OCCURS, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL TIGHTEN THE WIPER ARM NUTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 20, 2012.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648