IllustrationPARTS BEEN ACTING UP ON ME. BEEN HAVING NUMEROUS PROBLEMS WITH HYDRAULIC HOSE ON STEERING, WINDOWS/LOCKS ELECTRICAL AND BEEN CONSTANTLY REPLACING WHEELS AND HUB BEARINGS.
2006 Chevrolet Trailblazer
Owner reports · Recalls · Investigations
More warning signs than most Trailblazer years
Owner complaints for the 2006 Chevrolet Trailblazer are substantially higher than the model-year median of 87.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Trailblazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
420–25K
20625–50K
27150–75K
19175–100K
166100–150K
53150K+
929 reports with mileage · 179 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 437 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 251 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 112 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
29 crash reports59 fire reports23 injury reports
Electronic Stability Control (esc) complaints
23 reportsSTABILITRAK LIGHT COMES ON INTERMITTENTLY FOR NO APPARENT REASON. HAVE HAD BRAKE FLUID, BRAKE PADS, ROTORS, SENSORS AND TIRES REPLACED. TRACTION CONTROL AND ABS CHECKED; ALL IS GOOD. NO CEL CODE RELATING TO THIS ISSUE. TRACTION CONTROL OFF BUTTON DOESN?T WORK ONCE LIGHT APPEARS. THERE IS NO DIFFERENCE IN DRIVING WHEN LIGHT IS ON…
Read full complaint
STABILITRAK LIGHT COMES ON INTERMITTENTLY FOR NO APPARENT REASON. HAVE HAD BRAKE FLUID, BRAKE PADS, ROTORS, SENSORS AND TIRES REPLACED. TRACTION CONTROL AND ABS CHECKED; ALL IS GOOD. NO CEL CODE RELATING TO THIS ISSUE. TRACTION CONTROL OFF BUTTON DOESN?T WORK ONCE LIGHT APPEARS. THERE IS NO DIFFERENCE IN DRIVING WHEN LIGHT IS ON. STILL HAVEN?T FIGURED OUT WHAT CAUSES IT. BATTERY, POWER CORDS, AND ALTERNATOR HAVE BOTH HAD TO BE REPLACED DO TO ISSUES WITH THE VOLTAGE OUTPUTS. NOW TO REPLACE FUSE BOX AND ECM DUE TO MORE VOLTAGE OUTPUT ISSUES. CEL HAS HAD NO INDICATIONS OF AN ECM, FUSE BOX, ALTERNATOR, OR BATTERY PROBLEM UNTIL THEY WERE BEYOND REPAIR (THIS ALSO HAPPENED WITH OTHER TRANSFER CASE LEAK, LOSS OF REVERSE GEAR, AND FRONT DIFFERENTIAL LEAK) . CEL COMES AND GOES BY ITSELF AT ANYTIME WITH NO DIFFERENCE IN DRIVABILITY OR CONDITIONS. EACH TIME IT REAPPEARED IT?S THROWN DIFFERENT SENSORS AND/OR CIRCUITS FAILING OR HIGH/LOW VOLTAGES INCLUDING O2, MAF, TPS, EVAP SYSTEM, WHEEL SPEED, FUEL PRESSURE, OIL PRESSURE, STEERING WHEEL, GAS AND BRAKE PEDAL POSITION, AIR BAG IMPACT, JUST TO NAME A FEW. MY CAR HAS RECENTLY STARTED GOING INTO LIMP MODE AT RANDOM DUE TO THIS ELECTRICAL ISSUE. ONLY REMEDY FOR THIS PROBLEM IS DISCONNECTING THE WIRING HARNESS AND ALLOWING THE FUSE BOX AND ECM TO COOL DOWN. AND FINALLY, MY OIL FILLER TUBE SEAL BROKE AND OIL WAS SPITTING OUT INTO ENGINE BAY. COINCIDENTALLY, MY PCV VALVE TUBE HAD ALSO BROKEN, AND THE TUBE WAS HANGING LOOSE RIGHT IN FRONT OF THE OIL FILLER TUBE. AS A RESULT, PCV TUBING SUCKED UP A LARGE AMOUNT OF OIL INTO THE AIR INTAKE; WITH NO CHECK ENGINE LIGHT ILLUMINATION INDICATING ANY PROBLEMS DURING THE TIME OF FAILURE. MY AIR INTAKE SYSTEM IS NEARLY RUINED (NOT TO MENTION THE $$$ I SHELLED OUT IN OIL) AND THE WEAR DOWN ON PARTS HAS BEEN DETRIMENTAL TO THE LIFE OF THE ENGINE. THIS CAR IS NOTHING BUT A CASH COW FOR GM. *TR
I GO IN MY CAR AND START IT, AND ITS FINE GOING DOWN THE ROAD, BUT ONCE I CUT THE CAR OFF WHILE I RUN INTO THE STORE, AND I COME BACK OUT, START THE CAR, AND START GOING DOWN THE ROAD, THE TRACTION CONTROL LIGHT COMES ON, AND "SERVICESTABILITYTRAK" COMES ACROSS THE LITTLE SCREEN, AND WON'T CUT OFF AT ALL UNTIL I TURN THE CAR BAC…
Read full complaint
I GO IN MY CAR AND START IT, AND ITS FINE GOING DOWN THE ROAD, BUT ONCE I CUT THE CAR OFF WHILE I RUN INTO THE STORE, AND I COME BACK OUT, START THE CAR, AND START GOING DOWN THE ROAD, THE TRACTION CONTROL LIGHT COMES ON, AND "SERVICESTABILITYTRAK" COMES ACROSS THE LITTLE SCREEN, AND WON'T CUT OFF AT ALL UNTIL I TURN THE CAR BACK OFF.
WHETHER THE CAR IS TURNED ON, OR OFF WITH OR WITHOUT KEY IN THE IGNITION, IT HAS A SMALL SPEAKER OR TWEETER THAT STEADILY STAYS MAKING A FAINT BUZZ. THE CENTER CONSOLE IS VERY LOOSE, AND IF YOU PRESS OR KNOCK UP AGAINST THE RIGHT SIDE OR THE BACK SIDE, IT BECOMES LOUDER AND/OR QUIETER. THEN WHILE IN AUTO (2WD-4WD^OR4WDL) AND DRI…
Read full complaint
WHETHER THE CAR IS TURNED ON, OR OFF WITH OR WITHOUT KEY IN THE IGNITION, IT HAS A SMALL SPEAKER OR TWEETER THAT STEADILY STAYS MAKING A FAINT BUZZ. THE CENTER CONSOLE IS VERY LOOSE, AND IF YOU PRESS OR KNOCK UP AGAINST THE RIGHT SIDE OR THE BACK SIDE, IT BECOMES LOUDER AND/OR QUIETER. THEN WHILE IN AUTO (2WD-4WD^OR4WDL) AND DRIVING, THE TRANSMISSIONS FEELS TO NOT SWITCH GEER AT THE RIGHT TIME, OR FROM DRIVE TO REVERSE AND BACK TO DRIVE IT JOLTS FORWARD OR BACK REALLY HARD.
STABILITY LIGHT COMES ON AND OFF AND ALSO FUEL LEVEL SENSOR LIGHT CONSTANLY UP AND DOWN WITH THE LEVEL OF FUEL CAUSING SERVICE ENGINE LIGHT TO COME ON
I HAVE A 2006 CHEVY TRAILBLAZER WITH ONLY A LITTLE OVER 80,000 MILES ON IT. I HAVE BEEN HAVING ISSUES WITH THE STABILITRAK SYSTEM. I WILL GET READ OUTS ABOUT THE STABILITRAK NEEDS TO BE SERVICED OR THE STABILITRAK HAS KICKED IN WHEN IT HASN'T. THE STABILITRAK WILL TRY TO IN GAUGE FOR NO APPARENT REASON WHEN APPLING THE BRAKES. …
Read full complaint
I HAVE A 2006 CHEVY TRAILBLAZER WITH ONLY A LITTLE OVER 80,000 MILES ON IT. I HAVE BEEN HAVING ISSUES WITH THE STABILITRAK SYSTEM. I WILL GET READ OUTS ABOUT THE STABILITRAK NEEDS TO BE SERVICED OR THE STABILITRAK HAS KICKED IN WHEN IT HASN'T. THE STABILITRAK WILL TRY TO IN GAUGE FOR NO APPARENT REASON WHEN APPLING THE BRAKES. IT HAPPENS WHEN I AM BACKING OUT OF MY DRIVEWAY, COMING TO A STOP OR JUST APPLYING THE BRAKES TO SLOW DOWN. IT HAPPENS ON ALL TYPE OF ROAD SURFACES. THIS HAPPENS WHEN IT IS BRIGHT AND SUNNY OUTSIDE, ON DRY ROADS, HIGHWAYS, STREETS, DIRT ROADS AND DAY OR NIGHT. IT DOES IT AT FAST SPEEDS AND VERY LOW SPEEDS. IT MAKES A STRANGE NOISE WHEN THIS HAPPENS HOWEVER THE STABILITRAK DOESN'T FULLY IN GAUGE. THE REPAIR SHOP LOOKED AT IT AND TOLD ME THAT THEY THINK THE COMPUTER MODAL IS NOT COMMUNICATING WITH THE STABILITRAK SYSTEM. THIS STARTED A FEW WEEKS AGO. SO I'M NOT SURE HOW THIS WILL AFFECT THE BRAKES WHEN DRIVING ON THE SNOW AND ICY ROADS. I HAVE SEEN OTHER COMPLAINTS ON THE SAME TYPE OF ISSUES.
I WAS PULLING OUT OF MY DRIVEWAY TURING LEFT AND THE STABLIZER LIGHT ON THE DASHBOARD CAME ON . I PULLED OVER SHUT MY CAR DOWN . AND STARTED BACK UP THE LIGHT WAS GONE WHEN EVER I DRIVE AND I GO 60 MPH MY STERRING WHEEL STARTS SHAKING AND MY STABLIZER LIGHT COMES ON AND THE VEC. SHUTS DOWN. ALL I HAVE TO DO IS MAKE A TURN NO…
Read full complaint
I WAS PULLING OUT OF MY DRIVEWAY TURING LEFT AND THE STABLIZER LIGHT ON THE DASHBOARD CAME ON . I PULLED OVER SHUT MY CAR DOWN . AND STARTED BACK UP THE LIGHT WAS GONE WHEN EVER I DRIVE AND I GO 60 MPH MY STERRING WHEEL STARTS SHAKING AND MY STABLIZER LIGHT COMES ON AND THE VEC. SHUTS DOWN. ALL I HAVE TO DO IS MAKE A TURN NOT EVEN QUICKLY AND THE LIGHT COMES ON.
HEAD LAMPS GO OFF AT NIGHT WHILE DRIVING WON'T COME BACK ON , STABILITRACK SHUTS OFF AN WARNING BELLS GO OFF FOR NO REASON. NOW OUT OF THE BLUE TRANSMISSION WILL NOT WORK. ONLY HAS 1ST AND 2ND, WHILE DRIVING ON ANY ROAD IN TOWN OR ON. HIGHWAY.
STEERING WHEEL POSITION SENSOR FAILURE OF THIS SENSOR CAN CAUSE ASSIST PROBLEMS... I BELONG TO A TRAILVOY CLUB FOR TRAILBLAZER'S AND HAVE READ THAT THERE IS SEVERAL MEMBERS THAT HAVE REPORTED PROBLEMS WITH THIS STEERING WHEEL POSITION SENSOR...A QUOTE FOR REPAIR IS AROUND $200 WITH THE SENSOR COST OF ANOTHER $100, TOTAL BILL OF …
Read full complaint
STEERING WHEEL POSITION SENSOR FAILURE OF THIS SENSOR CAN CAUSE ASSIST PROBLEMS... I BELONG TO A TRAILVOY CLUB FOR TRAILBLAZER'S AND HAVE READ THAT THERE IS SEVERAL MEMBERS THAT HAVE REPORTED PROBLEMS WITH THIS STEERING WHEEL POSITION SENSOR...A QUOTE FOR REPAIR IS AROUND $200 WITH THE SENSOR COST OF ANOTHER $100, TOTAL BILL OF $300 AND WHEN THE LIGHT STABILITY CONTROL COMES ON IT CAN CAUSE THE STEERING TO BE ERACTIC, WHICH NOT ONLY IN DANGERS YOUR LIFE BUT EVERYONE AND EVERY THING IN YOU PATH!
WINDOW SWITCH RECALL TAILLIGHT SHORT MELTED WIRES HARNESS ENGINE LIGHT INDICATOR STAYS ON ROAD GRIP TIRES LIGHT COMES ON WILL STAY ON FOR DAYS POWER STEERING IS USING FLUID AND NOW FUEL TANK WILL NOT TAKE MORE THAN 5 GALLONS AT A TIME AND SPRAYS GAS BACK IF TANK IS FULL FUEL LEVEL INDICATOR WANT REGISTER STAY BELOW EMPTY AN…
Read full complaint
WINDOW SWITCH RECALL TAILLIGHT SHORT MELTED WIRES HARNESS ENGINE LIGHT INDICATOR STAYS ON ROAD GRIP TIRES LIGHT COMES ON WILL STAY ON FOR DAYS POWER STEERING IS USING FLUID AND NOW FUEL TANK WILL NOT TAKE MORE THAN 5 GALLONS AT A TIME AND SPRAYS GAS BACK IF TANK IS FULL FUEL LEVEL INDICATOR WANT REGISTER STAY BELOW EMPTY AND WINDSHIELD LEAKS DOWN INTO DASH
Official recalls
815V599000 · Visibility:power Window Devices And Controls
Sep 24, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Buick Rainier, Chevrolet Trailblazer and GMC Envoy vehicles, and 2006 GMC Envoy XL and Chevrolet Trailblazer EXT vehicles. Fluid may enter into the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board, causing window switches to become inoperative. Previously, the affected vehicles may have had their master power window switch module treated with a protective coating, instead of having it replaced.
Consequence & remedy
Consequence: The protective coating may not eliminate the risk that the circuit board could short and result in a fire, even while the vehicle is unattended.
Remedy: GM will notify owners, and dealers will install a new driver's door switch module, free of charge. The recall began on November 2, 2015. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is 15700.
15V519000 · Exterior Lighting:headlights
Aug 14, 2015
General Motors LLC (GM) is recalling certain model year 2007 Pontiac Grand Prix, 2006-2009 Buick LaCrosse, 2006-2007 Buick Rainier, Chevrolet Trailblazer, GMC Envoy, 2006 Chevrolet Trailblazer EXT, GMC Envoy XL, 2006-2008 Isuzu Ascender, and Saab 9-7x vehicles. In the affected vehicles, the headlamp driver module (HDM) may overheat and fail, causing the headlamps and daytime running lights to not illuminate.
Consequence & remedy
Consequence: Headlamps that do not illuminate reduce the driver's ability to see the roadway and reduce the vehicle's visibility to oncoming vehicles, both of which increase the risk of a vehicle crash.
Remedy: GM will notify owners, and dealers will replace the HDM, free of charge. The recall began on May 17, 2016. Owners may contact Buick customer service at 1-800-521-7300 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14291.
14V404000 · Visibility:power Window Devices And Controls
Jul 2, 2014
General Motors LLC (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.
Consequence & remedy
Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Remedy: GM will notify owners, and dealers will inspect the part number on the door module, and install a new door module if necessary, free of charge. Parts for the remedy are not currently available. An interim letter was mailed to owners in August 2014. A second owner letter will be mailed when parts are available. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), 1-800-462-8782 (GMC), 1-800-955-9007 (SAAB), and 1-800-255-6727 (Isuzu). GM's number for this recall is 14309. NOTE: This recall provides a new remedy for all vehicles covered by recall 13V-248. Vehicles whose modules were modified but not replaced as part of the previous recall remedy must have their vehicles remedied again under this campaign.
13V248000 · Electrical System; Visibility:power Window Devices And Controls
Jun 13, 2013
General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.
Consequence & remedy
Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and Saab will contact their respective owners. The recall began on August 2, 2013. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, GMC owners at 1-866-996-9463, Isuzu owners at 1-800-255-6727, and Saab owners at 1-800-955-9007. GM's campaign number is 12180. This recall is an expansion of recall 12V-406.
Additional source detail variants (2)
Visibility:power Window Devices And Controls
General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.
Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and Saab will contact their respective owners. The recall began on August 2, 2013. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, GMC owners at 1-866-996-9463, Isuzu owners at 1-800-255-6727, and Saab owners at 1-800-955-9007. GM's campaign number is 12180. This recall is an expansion of recall 12V-406.
Electrical System
General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.
Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and Saab will contact their respective owners. The recall began on August 2, 2013. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, GMC owners at 1-866-996-9463, Isuzu owners at 1-800-255-6727, and Saab owners at 1-800-955-9007. GM's campaign number is 12180. This recall is an expansion of recall 12V-406.
12V406000 · Electrical System; Visibility:power Window Devices And Controls
Aug 16, 2012
General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.
Consequence & remedy
Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Remedy: Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, and GMC owners at 1-866-996-9463. Isuzu owners will be notified by Isuzu Motors when parts are available. Owners may contact Isuzu customer service at 1-800-255-6727. SAAB owners will be notified by SAAB Cars North America when parts are available and for inquiries, owners may call SAAB customer service at 1-800-955-9007.
Additional source detail variants (2)
Visibility:power Window Devices And Controls
General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.
Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Remedy: Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, and GMC owners at 1-866-996-9463. Isuzu owners will be notified by Isuzu Motors when parts are available. Owners may contact Isuzu customer service at 1-800-255-6727. SAAB owners will be notified by SAAB Cars North America when parts are available and for inquiries, owners may call SAAB customer service at 1-800-955-9007.
Electrical System
General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.
Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Remedy: Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, and GMC owners at 1-866-996-9463. Isuzu owners will be notified by Isuzu Motors when parts are available. Owners may contact Isuzu customer service at 1-800-255-6727. SAAB owners will be notified by SAAB Cars North America when parts are available and for inquiries, owners may call SAAB customer service at 1-800-955-9007.
06V417000 · Air Bags:frontal
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
05V552000 · Equipment:other:labels
Dec 7, 2005
CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
Consequence & remedy
Consequence: A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.
05V455000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Oct 5, 2005
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
EA12004 · Driver's Master Power Window Switch
Opened Jun 11, 2012 · Closed Jun 21, 2013
Status: closed (inferred from source dates) · Electrical System; Visibility:power Window Devices And Controls
On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Additional source detail variants (4)
Electrical System
On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Electrical System
On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Visibility:power Window Devices And Controls
On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Visibility:power Window Devices And Controls
On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
PE12003 · Driver's Master Power Window Switch
Opened Feb 9, 2012 · Closed Jun 11, 2012
Status: closed (inferred from source dates) · Electrical System; Visibility:power Window Devices And Controls
The Office of Defects Investigation (ODI) opened this investigation on February 9, 2012 in response to complaints alleging driver door module melting and/or burning in MY 2006-2007 Chevrolet Trailblazers. In response to ODI's Information Request letter, General Motors presented 167 reports and 698 warranty claims that related to the alleged problem. ODI has received a total of 83 complaints, 66 alleging the door module had melted or burned, and the remaining 17 stating that the window switches acted erratically or were inoperative. Twenty-eight of the reports received have led to driver door fires, some of which allege the vehicle was keyed off and unattended. Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA12-004) to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The vehicle models and production dates of affected vehicles will be evaluated, particularly other GMT360 vehicles. The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10247838, 10260600, 10274337, 10275626, 10284010, 10396958, 10406203, 10409023, 10414691, 10417938, 10423865, 10426281, 10434446, 10445657, 10447754, 10447757, 10447770, 10447788, 10447813, 10447831, 10447865, 10447880, 10447892, 10447938, 10447994, 10447996, 10447997, 10448028, 10448086, 10448138, 10448176, 10448201, 10448337, 10448455, 10448464, 10448478, 10448540, 10448900, 10448941, 10449150, 10449166, 10449169, 10449236, 10449722, 10450055, 10450202, 10450284, 10451584, 10451878, 10451918, 10452197, 10452301, 10452586, 10452743, 10452895, 10453161, 10453227, 10453261, 10453578, 10453746, 10453951, 10454196, 10454211, 10454539, 10454673, 10455122, 10455150, 10455279, 10455469, 10456285, 10456529, 10457116, 10457644, 10457811, 10458224, 10458485, 10458599, 10458743, 10458846, 10460062, 10460141, 10460732, 10460843
Additional source detail variants (2)
Electrical System
The Office of Defects Investigation (ODI) opened this investigation on February 9, 2012 in response to complaints alleging driver door module melting and/or burning in MY 2006-2007 Chevrolet Trailblazers. In response to ODI's Information Request letter, General Motors presented 167 reports and 698 warranty claims that related to the alleged problem. ODI has received a total of 83 complaints, 66 alleging the door module had melted or burned, and the remaining 17 stating that the window switches acted erratically or were inoperative. Twenty-eight of the reports received have led to driver door fires, some of which allege the vehicle was keyed off and unattended. Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA12-004) to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The vehicle models and production dates of affected vehicles will be evaluated, particularly other GMT360 vehicles. The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10247838, 10260600, 10274337, 10275626, 10284010, 10396958, 10406203, 10409023, 10414691, 10417938, 10423865, 10426281, 10434446, 10445657, 10447754, 10447757, 10447770, 10447788, 10447813, 10447831, 10447865, 10447880, 10447892, 10447938, 10447994, 10447996, 10447997, 10448028, 10448086, 10448138, 10448176, 10448201, 10448337, 10448455, 10448464, 10448478, 10448540, 10448900, 10448941, 10449150, 10449166, 10449169, 10449236, 10449722, 10450055, 10450202, 10450284, 10451584, 10451878, 10451918, 10452197, 10452301, 10452586, 10452743, 10452895, 10453161, 10453227, 10453261, 10453578, 10453746, 10453951, 10454196, 10454211, 10454539, 10454673, 10455122, 10455150, 10455279, 10455469, 10456285, 10456529, 10457116, 10457644, 10457811, 10458224, 10458485, 10458599, 10458743, 10458846, 10460062, 10460141, 10460732, 10460843
Visibility:power Window Devices And Controls
The Office of Defects Investigation (ODI) opened this investigation on February 9, 2012 in response to complaints alleging driver door module melting and/or burning in MY 2006-2007 Chevrolet Trailblazers. In response to ODI's Information Request letter, General Motors presented 167 reports and 698 warranty claims that related to the alleged problem. ODI has received a total of 83 complaints, 66 alleging the door module had melted or burned, and the remaining 17 stating that the window switches acted erratically or were inoperative. Twenty-eight of the reports received have led to driver door fires, some of which allege the vehicle was keyed off and unattended. Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA12-004) to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The vehicle models and production dates of affected vehicles will be evaluated, particularly other GMT360 vehicles. The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10247838, 10260600, 10274337, 10275626, 10284010, 10396958, 10406203, 10409023, 10414691, 10417938, 10423865, 10426281, 10434446, 10445657, 10447754, 10447757, 10447770, 10447788, 10447813, 10447831, 10447865, 10447880, 10447892, 10447938, 10447994, 10447996, 10447997, 10448028, 10448086, 10448138, 10448176, 10448201, 10448337, 10448455, 10448464, 10448478, 10448540, 10448900, 10448941, 10449150, 10449166, 10449169, 10449236, 10449722, 10450055, 10450202, 10450284, 10451584, 10451878, 10451918, 10452197, 10452301, 10452586, 10452743, 10452895, 10453161, 10453227, 10453261, 10453578, 10453746, 10453951, 10454196, 10454211, 10454539, 10454673, 10455122, 10455150, 10455279, 10455469, 10456285, 10456529, 10457116, 10457644, 10457811, 10458224, 10458485, 10458599, 10458743, 10458846, 10460062, 10460141, 10460732, 10460843
DP10001 · Fuel Level Gauge System Failure
Opened Jan 7, 2010 · Closed May 23, 2011
Status: closed (inferred from source dates) · Fuel System, Other; Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Additional source detail variants (2)
Fuel System, Other
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.