← New search

2006 Chevrolet Trailblazer

Owner reports · Recalls · Investigations

More warning signs than most Trailblazer years

Owner complaints for the 2006 Chevrolet Trailblazer are substantially higher than the model-year median of 87.5.

About this comparison →

When problems were reported

Mileage at the reported incident

929 reports with mileage · 179 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Fuel System, Gasoline. Review the 437 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 251 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Exterior Lighting. Review the 112 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

29 crash reports59 fire reports23 injury reports

Electrical System complaints

251 reports
Clear category filter
95,000 miles · Aug 2, 2011
Electrical SystemFuel System, Other

THERE WAS A BURNING SMELL IN THE CAR AND THEN THE HIGH SETTING ON THE AIR FAN SPEED STOPPED WORKING. THEN ABOUT A MONTH LATER THE SECOND TO HIGHEST SPEED STOPPED WORKING ALSO. I OPENED MY GLOVE WHEN MY WIFE WAS DRIVING AND THEN THE HIGHEST SETTING STARTED WORKING AGAIN, THEN STOPPED WORKING A FEW MINUTES LATER. I LOOKED IN THE D…

Read full complaint

THERE WAS A BURNING SMELL IN THE CAR AND THEN THE HIGH SETTING ON THE AIR FAN SPEED STOPPED WORKING. THEN ABOUT A MONTH LATER THE SECOND TO HIGHEST SPEED STOPPED WORKING ALSO. I OPENED MY GLOVE WHEN MY WIFE WAS DRIVING AND THEN THE HIGHEST SETTING STARTED WORKING AGAIN, THEN STOPPED WORKING A FEW MINUTES LATER. I LOOKED IN THE DASH BEHIND THE GLOVE BOX AND FOUND THAT THERE WAS A CONNECTOR FOR THE FAN MOTOR CONTROLLER WAS HEATING UP AND STARTED MELTING. I CHECKED THE CONNECTION AND INSIDE THE CONNECTOR WAS BURNT AND BLACKENED. I CONTACTED GENERAL MOTORS ABOUT MY 2006 CHEVROLET TRAILBLAZER. THEY SETUP AN APPOINTMENT AT THE NEAREST CHEVROLET DEALER AND HAD IT CHECKED. THEY FOUND THAT THE FAN MOTOR CONNECTOR WAS BAD AND THAT THE FAN MOTOR CONTROLLER WAS BAD ALSO, THEY CONTACTED GENERAL MOTORS AND TOLD THEM IT WASN'T A DEFECT AND IT WAS NOT A SAFETY HAZARD. I CANNOT BELIEVE THAT THE CONNECTOR ALMOST CATCHING FIRE IS NOT A FIRE HAZARD OR A DEFECT. THEY WANTED TO REPLACE THE CONNECTOR AND THE MOTOR CONTROLLER. I DENIED THE SERVICE BECAUSE THEY WANTED TO CHARGE ME $365.00 TO DO SO. WHEN I FOUND THE PARTS ELSEWHERE FOR $75.00 AND IM GOING TO DO THE REPAIRS MYSELF. I HAVE PICTURES OF THE BURNT CONNECTOR AND FAN MOTOR CONTROLLER. I WILL BE REPAIRING THE ISSUE ONCE THE PARTS ARE DELIVERED. I AM ALSO EXPERIENCING THE FUEL LEVEL PROBLEM ALSO , THE FUEL GAUGE SAYS ITS EMPTY WHEN I FILL IT UP. *KB

NHTSA ODI #10416755

93,600 miles · Jun 27, 2011
Electrical SystemFuel System, GasolineFire

TL* THE CONTACT OWNS A 2006 CHEVROLET TRAILBLAZER LS. THE CONTACT STATED THAT WHILE ROLLING DOWN THE FRONT DRIVERS SIDE WINDOW, SMOKE BEGAN TO RISE FROM THE DOOR PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE CONTROL MODULE IN THE FRONT DRIVERS SIDE DOOR MELTED AND NEEDED TO BE RE…

Read full complaint

TL* THE CONTACT OWNS A 2006 CHEVROLET TRAILBLAZER LS. THE CONTACT STATED THAT WHILE ROLLING DOWN THE FRONT DRIVERS SIDE WINDOW, SMOKE BEGAN TO RISE FROM THE DOOR PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE CONTROL MODULE IN THE FRONT DRIVERS SIDE DOOR MELTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE CONTACT ALSO STATED THAT THE FUEL GAUGE WOULD DISPLAY IMPROPER READINGS AFTER REFUELING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE FUEL SENDING UNIT FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 93,600.

NHTSA ODI #10409023

20,000 miles · Jun 21, 2011
Electrical System

TL* THE CONTACT OWNS A 2006 CHEVROLET TRAIL BLAZER. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER DIAGNOSED THAT THE SENSOR IGNITION WAS DEFECTIVE AND THE VEHICLE WAS REPAIRED NUMEROUS TIMES, BUT THE FAILURE CONTINUOUSLY RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE …

Read full complaint

TL* THE CONTACT OWNS A 2006 CHEVROLET TRAIL BLAZER. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER DIAGNOSED THAT THE SENSOR IGNITION WAS DEFECTIVE AND THE VEHICLE WAS REPAIRED NUMEROUS TIMES, BUT THE FAILURE CONTINUOUSLY RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 27,000.

NHTSA ODI #10407715

52,000 miles · Jun 15, 2011
Electrical SystemFuel System, Gasoline

CAR FUEL GAUGE FAILED TO SHOW ACCURATE AMOUNT OF FUEL. SPORADIC READINGS

NHTSA ODI #10407969

75,000 miles · Jun 3, 2011
Electrical System

TL* THE CONTACT OWNS A 2006 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT THE FUEL GAUGE MALFUNCTIONED. AFTER REFILLING THE FUEL TANK, THE FUEL LEVEL GAUGE WOULD READ EMPTY. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC AND THEY ADVISED HIM THAT THERE WAS AN ELECTRICAL FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE MANUF…

Read full complaint

TL* THE CONTACT OWNS A 2006 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT THE FUEL GAUGE MALFUNCTIONED. AFTER REFILLING THE FUEL TANK, THE FUEL LEVEL GAUGE WOULD READ EMPTY. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC AND THEY ADVISED HIM THAT THERE WAS AN ELECTRICAL FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000. THE VIN WAS UNAVAILABLE.

NHTSA ODI #10404357

71,000 miles · May 30, 2011
Electrical SystemFuel System, Gasoline

WHEN I FILLED MY CAR UP IT WOULD SUDDENLY SHOW IT WAS EMPTY & A CHECK ENGINE ICON SHOWED UP & YELLOW LOW ON GAS WARNING LIGHT STARTED DINGING LAST FALL 2010. WHEN I DROVE APPROX 25 TO 30 MILES IT WOULD REGISTER GAS NORMALLY & ENGINE LIGHT WOULD GO AWAY. I FILL UP EVERY 2- 3 WEEKS NORMALLY. THEN THIS PAST FEBRUARY IT WENT HAYWIRE…

Read full complaint

WHEN I FILLED MY CAR UP IT WOULD SUDDENLY SHOW IT WAS EMPTY & A CHECK ENGINE ICON SHOWED UP & YELLOW LOW ON GAS WARNING LIGHT STARTED DINGING LAST FALL 2010. WHEN I DROVE APPROX 25 TO 30 MILES IT WOULD REGISTER GAS NORMALLY & ENGINE LIGHT WOULD GO AWAY. I FILL UP EVERY 2- 3 WEEKS NORMALLY. THEN THIS PAST FEBRUARY IT WENT HAYWIRE & WHEN I FILL UP IT GOES TO THE EMPTY SIDE, ENGINE ICON SHOWS UP & LOW ON GAS LIGHT DINGS & IT NEVER REGISTERS CORRECTLY AT ALL, THE GAS HAND IS ALL OVER AND I HAVE BEEN HAVING TO USE THE MILEAGE GAUGE TO EVEN KNOW HOW MUCH I MIGHT HAVE. IT LOW GAS WARNING WILL STAR DINGING & I AM DRIVING DOWN THE ROAD OR INTERSTATE FOR NO REASON & STARTLE ME. IT HAS CAUSED ME TO SUDDENLY JERK THE STEERING WHEEL BECAUSE I AM STARTLED & THAT IS DANGEROUS IN ITSELF. OUR FAMILY HAS BEEN OWNED GM CARS FROM THE MID 1990'S ON AND THIS HAS CAUSED A VERY UNSAFE FEELING FOR ME. I HAVE CHILDREN & GRANDCHILDREN WITH ME AND I FEEL VERY UNSAFE FOR THE 1ST TIME IN THIS VEHICLE I AM SO NERVOUS JUST DRIVING TO WORK & BACK & MY EYES ARE CONSTANTLY MONITORING THE PANEL WHEN I NEED TO KEEP FOCUSED ON MY DRIVE. I AM SO CONCERNED THAT SINCE THE GAS GAGES ARE SO WRONG WHAT WOULD JUST KEEP IT FROM "SENSING" THERE IS NO GAS AND SUDDENLY STOP! I WOULD HATE FOR IT TO TAKE A DEATH TO PUSH THIS PROBLEM TO BE A RECALL. I AM ALSO A CONSUMERS REPORT PANELIST AND THIS WILL BE ON THEIR REPORT THIS YEAR FOR SURE. I HAVE DEALT WITH THE NOISE ISSUES AS YOU DRIVE & SMALL THINGS THAT HAPPEN AS TIME GOES ON, BUT THIS IS DEFINITELY AN ISSUE FOR RECALL. I NEED A SAFE VEHICLE AND TO TRADE IS NOT THE ANSWER YET AS I WOULD NOT BE HONEST IN SOMETHING ELSE BUYING THIS CAR AND MAYBE LOSING THEIR LIFE PLEASE I BEG LISTEN TO THE NOTICES YOU HAVE RECEIVED CONCERNING THIS, THESE ARE REAL AS I HAVE SENSED MYSELF IN THEIR CONCERNS & COMPLAINTS.

NHTSA ODI #10404714

36,000 miles · May 24, 2011
Electrical SystemFuel System, Gasoline

2006 CHEVROLET TRAILBLAZER, 4DR, LT, 4WD. FUEL GAUGE STOPPED WORKING. FILL UP TANK, GAUGE GOES UP TO FULL, BUT THEN FALLS BACK DOWN TO EMPTY. I DO NOT KNOW THE LEVEL OF FUEL IN MY VEHICLE. APPEARS TO BE A COMMON PROBLEM AMONG 2003-2006 TRAILBLAZERS. HAVE RAN OUT OF FUEL ON THE ROAD. MOST LIKELY FUEL SENSOR OR CLUSTER. *…

Read full complaint

2006 CHEVROLET TRAILBLAZER, 4DR, LT, 4WD. FUEL GAUGE STOPPED WORKING. FILL UP TANK, GAUGE GOES UP TO FULL, BUT THEN FALLS BACK DOWN TO EMPTY. I DO NOT KNOW THE LEVEL OF FUEL IN MY VEHICLE. APPEARS TO BE A COMMON PROBLEM AMONG 2003-2006 TRAILBLAZERS. HAVE RAN OUT OF FUEL ON THE ROAD. MOST LIKELY FUEL SENSOR OR CLUSTER. *TR

NHTSA ODI #10402501

Mileage unknown · Mar 16, 2011
Electrical SystemEngine And Engine CoolingExterior Lighting

2006 CHEVROLET TRAILBLAZER. CONSUMER STATES PROBLEM WITH BRAKES AND TRACTION CONTROL LIGHT ILLUMINATING. *TGW THE CONSUMER THE ABS WOULD ACTIVATE WHEN MAKING RIGHT TURNS. SEVERAL COMPONENTS WERE REPLACED, BUT THE CONSUMER CONTINUED TO EXPERIENCE PROBLEMS. THE BLOWER RESISTOR WAS REPLACED DUE TO IT ONLY WORKING ON HIGH. THE ENGI…

Read full complaint

2006 CHEVROLET TRAILBLAZER. CONSUMER STATES PROBLEM WITH BRAKES AND TRACTION CONTROL LIGHT ILLUMINATING. *TGW THE CONSUMER THE ABS WOULD ACTIVATE WHEN MAKING RIGHT TURNS. SEVERAL COMPONENTS WERE REPLACED, BUT THE CONSUMER CONTINUED TO EXPERIENCE PROBLEMS. THE BLOWER RESISTOR WAS REPLACED DUE TO IT ONLY WORKING ON HIGH. THE ENGINE LIGHT ILLUMINATED, THE FUEL SENSOR WAS NOT WORKING, THE HEAT WAS INOPERATIVE, THERE WERE NOISE/CREAKS COMING FROM THE STEERING WHEEL WHEN DRIVING SLOW AND MAKING TURNS, THE POWER WINDOWS AND HEATED SEATS STOPPED WORKING, THE FUEL GAUGE WAS INACCURATE, THE 4-WHEEL DRIVE SWITCH HAD TO REPLACED, THE SEAT BELT WAS DIFFICULT TO FASTEN, THE HEAD LIGHTS AND TAIL LIGHTS SOCKETS BURNED OUT, THE FAN FOR THE HEATER AND DEFROSTER STOPPED WORKING, THE TRANSMISSION WOULD NOT DOWN SHIFT PROPERLY AND EVENTUALLY HAD TO BE REPLACED, THE IGNITION SWITCH DIDN'T ALWAYS WORK AND THE KEY WOULD SOMETIMES GET STUCK. *JB

NHTSA ODI #10391008

85,000 miles · Mar 14, 2011
Electrical SystemFuel System, Gasoline

THE FUEL SENDING UNIT ON MY TRAILBALZER HAS FAILED AND I HAVE RUN OUT OF GAS SEVERAL TIMES CAUSING DANGEROUS SITUATIONS. I HAVE HAD TO CALL AAA SEVERAL TIMES. THE REPAIR JOB WILL COST ABOUT $800 AND I CANNOT AFFORD TO DO IT. THE GAS TANK MUST BE PULLED DOWN AND THE ENTIRE FUEL PUMP/SENDING UNIT MUST BE REPLACED BY A MECHANIC. IT…

Read full complaint

THE FUEL SENDING UNIT ON MY TRAILBALZER HAS FAILED AND I HAVE RUN OUT OF GAS SEVERAL TIMES CAUSING DANGEROUS SITUATIONS. I HAVE HAD TO CALL AAA SEVERAL TIMES. THE REPAIR JOB WILL COST ABOUT $800 AND I CANNOT AFFORD TO DO IT. THE GAS TANK MUST BE PULLED DOWN AND THE ENTIRE FUEL PUMP/SENDING UNIT MUST BE REPLACED BY A MECHANIC. IT IS A DANGEROUS JOB. I THINK GENERAL MOTORS SHOULD ISSUE A RECALL AND REPAIR FREE TO THE OWNERS I KNOW OF SEVERAL OTHERS RUNNING WITH THE SAME CONDITION. IT WILL NOT PASS NEW YORK STATE INSPECTION WITH THIS CONDITION...THANK YOU.

NHTSA ODI #10391628

Mileage unknown · Mar 10, 2011
Electrical System

ABOUT 1 YEAR AGO THE GAS LIGHT CAME ON AND WOULD NOT GO OFF, A COUPLE OF MONTH'S LATER THE DRIVER DOOR CONTROLS WOULD WORK THEN DIDN'T THEN DID NOW IT IS COMPLETELY OUT THE INTERIOR LIGHTS WOULD COME ON BE VERY DIM THEN WOULD NOT GO OFF THEY ARE OFF NOW. THESE ARE THE CONCERNS I HAVE, THINGS THAT HAPPEN WHILE DRIVING THE CAR, IT…

Read full complaint

ABOUT 1 YEAR AGO THE GAS LIGHT CAME ON AND WOULD NOT GO OFF, A COUPLE OF MONTH'S LATER THE DRIVER DOOR CONTROLS WOULD WORK THEN DIDN'T THEN DID NOW IT IS COMPLETELY OUT THE INTERIOR LIGHTS WOULD COME ON BE VERY DIM THEN WOULD NOT GO OFF THEY ARE OFF NOW. THESE ARE THE CONCERNS I HAVE, THINGS THAT HAPPEN WHILE DRIVING THE CAR, IT SHUT COMPLETELY OFF. UPDATED 08/03/11 *BF

NHTSA ODI #10391448

Official recalls

8

15V599000 · Visibility:power Window Devices And Controls

Sep 24, 2015

General Motors LLC (GM) is recalling certain model year 2006-2007 Buick Rainier, Chevrolet Trailblazer and GMC Envoy vehicles, and 2006 GMC Envoy XL and Chevrolet Trailblazer EXT vehicles. Fluid may enter into the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board, causing window switches to become inoperative. Previously, the affected vehicles may have had their master power window switch module treated with a protective coating, instead of having it replaced.

Consequence & remedy

Consequence: The protective coating may not eliminate the risk that the circuit board could short and result in a fire, even while the vehicle is unattended.

Remedy: GM will notify owners, and dealers will install a new driver's door switch module, free of charge. The recall began on November 2, 2015. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is 15700.

15V519000 · Exterior Lighting:headlights

Aug 14, 2015

General Motors LLC (GM) is recalling certain model year 2007 Pontiac Grand Prix, 2006-2009 Buick LaCrosse, 2006-2007 Buick Rainier, Chevrolet Trailblazer, GMC Envoy, 2006 Chevrolet Trailblazer EXT, GMC Envoy XL, 2006-2008 Isuzu Ascender, and Saab 9-7x vehicles. In the affected vehicles, the headlamp driver module (HDM) may overheat and fail, causing the headlamps and daytime running lights to not illuminate.

Consequence & remedy

Consequence: Headlamps that do not illuminate reduce the driver's ability to see the roadway and reduce the vehicle's visibility to oncoming vehicles, both of which increase the risk of a vehicle crash.

Remedy: GM will notify owners, and dealers will replace the HDM, free of charge. The recall began on May 17, 2016. Owners may contact Buick customer service at 1-800-521-7300 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14291.

14V404000 · Visibility:power Window Devices And Controls

Jul 2, 2014

General Motors LLC (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence & remedy

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: GM will notify owners, and dealers will inspect the part number on the door module, and install a new door module if necessary, free of charge. Parts for the remedy are not currently available. An interim letter was mailed to owners in August 2014. A second owner letter will be mailed when parts are available. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), 1-800-462-8782 (GMC), 1-800-955-9007 (SAAB), and 1-800-255-6727 (Isuzu). GM's number for this recall is 14309. NOTE: This recall provides a new remedy for all vehicles covered by recall 13V-248. Vehicles whose modules were modified but not replaced as part of the previous recall remedy must have their vehicles remedied again under this campaign.

13V248000 · Electrical System; Visibility:power Window Devices And Controls

Jun 13, 2013

General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence & remedy

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and Saab will contact their respective owners. The recall began on August 2, 2013. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, GMC owners at 1-866-996-9463, Isuzu owners at 1-800-255-6727, and Saab owners at 1-800-955-9007. GM's campaign number is 12180. This recall is an expansion of recall 12V-406.

Additional source detail variants (2)

Visibility:power Window Devices And Controls

General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and Saab will contact their respective owners. The recall began on August 2, 2013. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, GMC owners at 1-866-996-9463, Isuzu owners at 1-800-255-6727, and Saab owners at 1-800-955-9007. GM's campaign number is 12180. This recall is an expansion of recall 12V-406.

Electrical System

General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and Saab will contact their respective owners. The recall began on August 2, 2013. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, GMC owners at 1-866-996-9463, Isuzu owners at 1-800-255-6727, and Saab owners at 1-800-955-9007. GM's campaign number is 12180. This recall is an expansion of recall 12V-406.

12V406000 · Electrical System; Visibility:power Window Devices And Controls

Aug 16, 2012

General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence & remedy

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, and GMC owners at 1-866-996-9463. Isuzu owners will be notified by Isuzu Motors when parts are available. Owners may contact Isuzu customer service at 1-800-255-6727. SAAB owners will be notified by SAAB Cars North America when parts are available and for inquiries, owners may call SAAB customer service at 1-800-955-9007.

Additional source detail variants (2)

Visibility:power Window Devices And Controls

General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, and GMC owners at 1-866-996-9463. Isuzu owners will be notified by Isuzu Motors when parts are available. Owners may contact Isuzu customer service at 1-800-255-6727. SAAB owners will be notified by SAAB Cars North America when parts are available and for inquiries, owners may call SAAB customer service at 1-800-955-9007.

Electrical System

General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, and GMC owners at 1-866-996-9463. Isuzu owners will be notified by Isuzu Motors when parts are available. Owners may contact Isuzu customer service at 1-800-255-6727. SAAB owners will be notified by SAAB Cars North America when parts are available and for inquiries, owners may call SAAB customer service at 1-800-955-9007.

06V417000 · Air Bags:frontal

Oct 31, 2006

CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.

Consequence & remedy

Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.

Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.

05V552000 · Equipment:other:labels

Dec 7, 2005

CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.

Consequence & remedy

Consequence: A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.

Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.

05V455000 · Steering:hydraulic Power Assist:hose, Piping, And Connections

Oct 5, 2005

CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.

Consequence & remedy

Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.

Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

RQ17002 · Loss Of Headlights

Opened Apr 24, 2017 · Closed Mar 29, 2021

Status: closed (inferred from source dates) · Exterior Lighting:headlights

The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.

EA12004 · Driver's Master Power Window Switch

Opened Jun 11, 2012 · Closed Jun 21, 2013

Status: closed (inferred from source dates) · Electrical System; Visibility:power Window Devices And Controls

On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

Additional source detail variants (4)

Electrical System

On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

Electrical System

On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

Visibility:power Window Devices And Controls

On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

Visibility:power Window Devices And Controls

On August 15, 2012 General Motors (GM) announced a regional recall action (12V-406) involving model year (MY) 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, Isuzu Ascender and MY2005-2007 SAAB 9-7x vehicles originally sold or currently registered in the salt belt states of Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. The recall remedy requires the inspection and repair or replacement of the master power window switch, which GM refers to as a driver door module (DDM). At the same time, GM implemented a special coverage program to replace failed DDMs for vehicles registered outside of these states. ODI was not satisfied with GM's exclusion of non-salt belt vehicles and continued its investigation. On June 13, 2013, GM submitted a related recall notification (13V-248) to reclassify the initial special coverage program into a safety recall for vehicles that were not previously repaired under special coverage.The Office of Defects Investigation (ODI) opened Engineering Analysis EA12-004 on June 11, 2012 to further investigate allegations of DDM thermal incidents in model year (MY) 2006-2007 Chevrolet Trailblazer vehicles. Thermal incidents involve cases where fire-related events such as smoke and melt are present. ODI has received 170 reports alleging a thermal event occurred. Complainants stated that the DDM melted and in some cases produced odor and/or smoke. Fourteen of these incidents led to a fire where visible flames were reported or the damage extended significantly beyond the DDM. In addition to the 170 reports listed above, ODI received 63 reports alleging the DDM acted erratically or became inoperative. In response to ODI's Information Request (IR), GM provided 619 unique consumer complaints that related to the alleged problem. Seventy-seven of those reports led to a fire with flame, and 4 reported injuries of smoke inhalation and/or slight burns from contact with hot switches. GM also submitted 20,400 warranty claims for replacement of the DDM, most of which involved inoperative switches. The problem condition is caused by fluids, such as rain water, entering the driver's door module and subsequently causing corrosion that could result in an electrical short in the printed circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. However, the electrical short may also cause overheating that could melt components of the door module, producing odor, smoke or in some cases fire with flame. The circuit board was redesigned and GM implemented the new design into vehicle production on May 14, 2007. All failures cited above occurred in vehicles produced before this build date (i.e., with the original design DDM). GM also reported that all MY 2006-2007 GMT360/370 platform vehicles and MY 2005 SAAB 9-7x vehicles utilized the same DDM and therefore ODI expanded the subject population to include these vehicles.This investigation is closed on the basis of GM's announcement of safety recalls 12V-406 and 13V-248. The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.

PE12003 · Driver's Master Power Window Switch

Opened Feb 9, 2012 · Closed Jun 11, 2012

Status: closed (inferred from source dates) · Electrical System; Visibility:power Window Devices And Controls

The Office of Defects Investigation (ODI) opened this investigation on February 9, 2012 in response to complaints alleging driver door module melting and/or burning in MY 2006-2007 Chevrolet Trailblazers. In response to ODI's Information Request letter, General Motors presented 167 reports and 698 warranty claims that related to the alleged problem. ODI has received a total of 83 complaints, 66 alleging the door module had melted or burned, and the remaining 17 stating that the window switches acted erratically or were inoperative. Twenty-eight of the reports received have led to driver door fires, some of which allege the vehicle was keyed off and unattended. Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA12-004) to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The vehicle models and production dates of affected vehicles will be evaluated, particularly other GMT360 vehicles. The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10247838, 10260600, 10274337, 10275626, 10284010, 10396958, 10406203, 10409023, 10414691, 10417938, 10423865, 10426281, 10434446, 10445657, 10447754, 10447757, 10447770, 10447788, 10447813, 10447831, 10447865, 10447880, 10447892, 10447938, 10447994, 10447996, 10447997, 10448028, 10448086, 10448138, 10448176, 10448201, 10448337, 10448455, 10448464, 10448478, 10448540, 10448900, 10448941, 10449150, 10449166, 10449169, 10449236, 10449722, 10450055, 10450202, 10450284, 10451584, 10451878, 10451918, 10452197, 10452301, 10452586, 10452743, 10452895, 10453161, 10453227, 10453261, 10453578, 10453746, 10453951, 10454196, 10454211, 10454539, 10454673, 10455122, 10455150, 10455279, 10455469, 10456285, 10456529, 10457116, 10457644, 10457811, 10458224, 10458485, 10458599, 10458743, 10458846, 10460062, 10460141, 10460732, 10460843

Additional source detail variants (2)

Electrical System

The Office of Defects Investigation (ODI) opened this investigation on February 9, 2012 in response to complaints alleging driver door module melting and/or burning in MY 2006-2007 Chevrolet Trailblazers. In response to ODI's Information Request letter, General Motors presented 167 reports and 698 warranty claims that related to the alleged problem. ODI has received a total of 83 complaints, 66 alleging the door module had melted or burned, and the remaining 17 stating that the window switches acted erratically or were inoperative. Twenty-eight of the reports received have led to driver door fires, some of which allege the vehicle was keyed off and unattended. Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA12-004) to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The vehicle models and production dates of affected vehicles will be evaluated, particularly other GMT360 vehicles. The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10247838, 10260600, 10274337, 10275626, 10284010, 10396958, 10406203, 10409023, 10414691, 10417938, 10423865, 10426281, 10434446, 10445657, 10447754, 10447757, 10447770, 10447788, 10447813, 10447831, 10447865, 10447880, 10447892, 10447938, 10447994, 10447996, 10447997, 10448028, 10448086, 10448138, 10448176, 10448201, 10448337, 10448455, 10448464, 10448478, 10448540, 10448900, 10448941, 10449150, 10449166, 10449169, 10449236, 10449722, 10450055, 10450202, 10450284, 10451584, 10451878, 10451918, 10452197, 10452301, 10452586, 10452743, 10452895, 10453161, 10453227, 10453261, 10453578, 10453746, 10453951, 10454196, 10454211, 10454539, 10454673, 10455122, 10455150, 10455279, 10455469, 10456285, 10456529, 10457116, 10457644, 10457811, 10458224, 10458485, 10458599, 10458743, 10458846, 10460062, 10460141, 10460732, 10460843

Visibility:power Window Devices And Controls

The Office of Defects Investigation (ODI) opened this investigation on February 9, 2012 in response to complaints alleging driver door module melting and/or burning in MY 2006-2007 Chevrolet Trailblazers. In response to ODI's Information Request letter, General Motors presented 167 reports and 698 warranty claims that related to the alleged problem. ODI has received a total of 83 complaints, 66 alleging the door module had melted or burned, and the remaining 17 stating that the window switches acted erratically or were inoperative. Twenty-eight of the reports received have led to driver door fires, some of which allege the vehicle was keyed off and unattended. Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA12-004) to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The vehicle models and production dates of affected vehicles will be evaluated, particularly other GMT360 vehicles. The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers: 10247838, 10260600, 10274337, 10275626, 10284010, 10396958, 10406203, 10409023, 10414691, 10417938, 10423865, 10426281, 10434446, 10445657, 10447754, 10447757, 10447770, 10447788, 10447813, 10447831, 10447865, 10447880, 10447892, 10447938, 10447994, 10447996, 10447997, 10448028, 10448086, 10448138, 10448176, 10448201, 10448337, 10448455, 10448464, 10448478, 10448540, 10448900, 10448941, 10449150, 10449166, 10449169, 10449236, 10449722, 10450055, 10450202, 10450284, 10451584, 10451878, 10451918, 10452197, 10452301, 10452586, 10452743, 10452895, 10453161, 10453227, 10453261, 10453578, 10453746, 10453951, 10454196, 10454211, 10454539, 10454673, 10455122, 10455150, 10455279, 10455469, 10456285, 10456529, 10457116, 10457644, 10457811, 10458224, 10458485, 10458599, 10458743, 10458846, 10460062, 10460141, 10460732, 10460843

DP10001 · Fuel Level Gauge System Failure

Opened Jan 7, 2010 · Closed May 23, 2011

Status: closed (inferred from source dates) · Fuel System, Other; Fuel System, Other:storage:fuel Gauge System

The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.

Additional source detail variants (2)

Fuel System, Other

The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.

Fuel System, Other:storage:fuel Gauge System

The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.