TL* THE CONTACT OWNS A 2005 CHEVROLET TRAILBLAZER. WHILE DRIVING 35 MPH, THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE DRIVER SUSTAINED VARIOUS INJURIES TO THE FACE, WHICH REQUIRED MEDICAL ATTENTION. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE …
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET TRAILBLAZER. WHILE DRIVING 35 MPH, THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE DRIVER SUSTAINED VARIOUS INJURIES TO THE FACE, WHICH REQUIRED MEDICAL ATTENTION. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS TOWED TO A TOW YARD AND WAS NOT DIAGNOSED FOR THE AIR BAG FAILURE. THE FAILURE MILEAGE WAS 140,000.
NHTSA ODI #10983668
Mileage unknown · Aug 8, 2016
Air BagsElectrical SystemFuel/propulsion System
SINCE 2011 I'VE BEEN HAVING WRONG READING OF GAS LEVELS CAUSING MY VEHICLE TO SHUTOFF. PLUS MY PASSAGER AIR BAG DISPLAYS ON WHEN NO ONE IS SITTING IN SEAT AND WHEN SOMEONE IS SITTING IN PASSAGER SEAT IT OCCASIONALLY FLICKER ON AND OFF. HOWEVER I HAVE NOT HAD A INCIDENT JUST YET BUT I'M VERY CONCERNED AND DON'T FEEL SAFE DRIVIN…
Read full complaint
SINCE 2011 I'VE BEEN HAVING WRONG READING OF GAS LEVELS CAUSING MY VEHICLE TO SHUTOFF. PLUS MY PASSAGER AIR BAG DISPLAYS ON WHEN NO ONE IS SITTING IN SEAT AND WHEN SOMEONE IS SITTING IN PASSAGER SEAT IT OCCASIONALLY FLICKER ON AND OFF. HOWEVER I HAVE NOT HAD A INCIDENT JUST YET BUT I'M VERY CONCERNED AND DON'T FEEL SAFE DRIVING WITH MY KIDS IN THIS VEHICLE.
NHTSA ODI #10894068
120,000 miles · Aug 8, 2016
Air BagsElectrical SystemVehicle Speed Control
AS OF 2011 (WHILE DRIVING ON FREEWAYS IN MULTIPLE OCCASIONS) I'VE BEEN HAVING ELECTRICAL ISSUES SUCH AS MY FUEL LEVEL GAGE WOULD READ FULL AND VEHICLE WOULD SHUT OFF CAUSE NO GAS IN TANK, AIR BAGS SENSOR WOULD SHOW IT ON WHEN NO ONE IS SITTING IN THE PASSENGER SEAT, AND THERE ARE SOME ELECTRICAL ISSUES ON DRIVER SEAT CONTROLS NO…
Read full complaint
AS OF 2011 (WHILE DRIVING ON FREEWAYS IN MULTIPLE OCCASIONS) I'VE BEEN HAVING ELECTRICAL ISSUES SUCH AS MY FUEL LEVEL GAGE WOULD READ FULL AND VEHICLE WOULD SHUT OFF CAUSE NO GAS IN TANK, AIR BAGS SENSOR WOULD SHOW IT ON WHEN NO ONE IS SITTING IN THE PASSENGER SEAT, AND THERE ARE SOME ELECTRICAL ISSUES ON DRIVER SEAT CONTROLS NOT WORKING, DASH BOARD GAGES NOT SHOWING READINGS WHILE VEHICLE IS IN MOTION (RMP, SPEEDOMETER, OIL, GAS).
NHTSA ODI #10894032
143,000 miles · Jul 16, 2016
Air BagsCrash
HEAD ON COLLISION BOTH VEHICLES TRAVELING ABOUT 30MPH ON IMPACT AND TRAILBLAZER AIR BAGS DID NOT DEPLOY. I HAD MY SEATBELT ON AND WAS NOT INJURED.
NHTSA ODI #10885198
128,000 miles · Jan 27, 2016
Air Bags
TL* THE CONTACT OWNS A 2005 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT WHILE DRIVING, THE SERVICE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V417000 (AIR BAGS). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIM…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT WHILE DRIVING, THE SERVICE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V417000 (AIR BAGS). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 128,000.
NHTSA ODI #10822560
50,000 miles · Oct 19, 2015
Air BagsFuel/propulsion SystemVisibility/wiper
FUEL GAGE IS NOT SHOWING THE FUEL LEVEL , SO IT LOOKS LIKE ITS EMPTY ALL THE TIME AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM IS MALFUNCTIONING AND ON WINDSHIELD URETHANE BEAD MAY NOT HAVE ADHERED TO THE BODY IN CERTAIN AREAS DURING THE CURE PROCESS.
NHTSA ODI #10783524
203,454 miles · May 23, 2015
Air BagsCrashInjury
2005 CHEVY TRAILBLAZER WAS DRIVEN BY MY GRANDDAUGHTER. SHE WAS TRYING TO ENTER ONTO I-10 INTERSTATE AND WAS GOING TOO FAST ON THE ENTRANCE RAMP. ROAD CONDITIONS WERE HAZARDOUS AS IT WAS A SEVERE RAIN STORM. SHE HYDROPLANED AND HIT A VEHICLE IN FRONT OF HER WHICH CAUSED HER TO SPIN INTO ONCOMING TRAFFIC. SHE WAS HIT ON THE DRIVER…
Read full complaint
2005 CHEVY TRAILBLAZER WAS DRIVEN BY MY GRANDDAUGHTER. SHE WAS TRYING TO ENTER ONTO I-10 INTERSTATE AND WAS GOING TOO FAST ON THE ENTRANCE RAMP. ROAD CONDITIONS WERE HAZARDOUS AS IT WAS A SEVERE RAIN STORM. SHE HYDROPLANED AND HIT A VEHICLE IN FRONT OF HER WHICH CAUSED HER TO SPIN INTO ONCOMING TRAFFIC. SHE WAS HIT ON THE DRIVER'S SIDE AND THE TRUCK SPUN AROUND SEVERAL TIMES BEFORE IT STOPPPED. THE AIRBAG DID NOT DEPLOY!!! THE POLICE OFFICER AND THE TOW COMPANY DRIVER SAID SHE WAS LUCKY TO BE ALIVE. MY CONCERN IS THIS COULD HAVE BEEN A FATAL ACCIDENT AND THE AIRBAG FAILED TO DEPLOY. THE TRAILBLAZER WAS TOTALED AS THE AXLE AND THE ENGINE WERE ON THE GROUND. THE DRIVER'S SIDE FRONT WHEEL CAME OFF. I HAVE ALWAYS LIKE CHEVY VEHICLES BUT AM NOW HESITANT TO PURCHASE ANOTHER ONE B/C OF THIS ISSUE WITH THE AIR BAG.
NHTSA ODI #10721128
178,300 miles · May 16, 2015
Air BagsElectrical SystemVehicle Speed Control
THE AIRBAGS WILL SHOW THAT THEY'RE NOT ENABLED EVEN WITH A PASSENGER SITTING IN THE SEAT.THEN IT WOULD COME ON AS BEING ON BUT NO PASSENGER IN SEAT. A LOT OF SENSORS HAVE POPPED UP IN THE ELECTRICAL PANEL, ON TOP OF THAT THE CAR KINDA SHUT DOWN ON ME AND STARTED GOING 10 MILES PER HOUR, AS I WAS GOING OUT IN TRAFFIC.
NHTSA ODI #10716811
128,000 miles · Mar 11, 2015
Air BagsUnknown Or Other
ODOMETER WORKS THEN JUST STOPS GOING DOWN THE ROAD AND AIRBAG LIGHT STAYS ON NOW ALSO IF I PLUG IN MY CELL CHARGER THE RADIO SHUTS OFF DID NOT DO THIS UNTIL ISSUES WITH ODOMETER. *TR
NHTSA ODI #10693708
Mileage unknown · Feb 20, 2015
Air BagsCrashInjury
TL* THE CONTACT OWNED A 2005 CHEVROLET TRAILBLAZER. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SLID AND CRASHED. THE DRIVER SIDE AIR BAG FAILED TO DEPLOY. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V417000 (AIR BAGS). THE CONTACT SUSTAINED LACERATIONS TO THE FACE, STITCHES UNDER THE EYEBROWS ON BOTH EYES, AND AN INJ…
Read full complaint
TL* THE CONTACT OWNED A 2005 CHEVROLET TRAILBLAZER. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SLID AND CRASHED. THE DRIVER SIDE AIR BAG FAILED TO DEPLOY. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V417000 (AIR BAGS). THE CONTACT SUSTAINED LACERATIONS TO THE FACE, STITCHES UNDER THE EYEBROWS ON BOTH EYES, AND AN INJURED NECK THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, 'WINDSHIELD MOUNTING.' THE WINDSHIELD URETHANE BEAD MAY NOT HAVE ADHERED TO THE BODY IN CERTAIN AREAS DURING THE CURE PROCESS.
Consequence & remedy
Consequence: IF A CRASH OCCURS, THE WINDSHIELD MAY NOT BE RETAINED, INCREASING THE RISK OF INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL REPLACE THE WINDSHIELD FREE OF CHARGE. THE RECALL BEGAN ON MARCH 10, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
DP10001 · Fuel Level Gauge System Failure
Opened Jan 7, 2010 · Closed May 23, 2011
Status: closed (inferred from source dates) · Fuel System, Other; Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Additional source detail variants (2)
Fuel System, Other
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
2005 Chevrolet Trailblazer Problems, Complaints & Recalls | Skip That Year
Illustration