NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
285 reportsClear category filter124,000 miles · Mar 11, 2018
Electrical System
FOR THE LAST 3 YEARS, EVERY PART OF MY INSTRUMENT PANEL SEEMS TO WORK INTERMITTENTLY. AT TIMES WHILE DRIVING, THE SPEEDOMETER WILL SHOW ME DOING 40 MPH OVER MY ACTUAL SPEED, OR WILL SHOW ME DOING 120 WHILE I AM SITTING STILL. THE OIL PRESSURE WILL SOMETIMES SHOW THAT THERE IS NO PRESSURE AT ALL, OR THE TEMP IS AS FAR AS IT CAN…
Read full complaint
FOR THE LAST 3 YEARS, EVERY PART OF MY INSTRUMENT PANEL SEEMS TO WORK INTERMITTENTLY. AT TIMES WHILE DRIVING, THE SPEEDOMETER WILL SHOW ME DOING 40 MPH OVER MY ACTUAL SPEED, OR WILL SHOW ME DOING 120 WHILE I AM SITTING STILL. THE OIL PRESSURE WILL SOMETIMES SHOW THAT THERE IS NO PRESSURE AT ALL, OR THE TEMP IS AS FAR AS IT CAN GO ON THE HOT SIDE. ALL OF THESE ISSUES DISAPPEAR AFTER A WHILE, AND THEN FUNCTION NORMALLY. THEY DO NOT SEEM TO BE TIED TOGETHER, BECAUSE AT TIMES SEVERAL INSTRUMENTS ARE WORKING FINE, BUT 2 OTHERS ARE NOT.
NHTSA ODI #11078560
55,000 miles · Nov 26, 2017
Electrical SystemVehicle Speed Control
MULTIPLE GAUGES ON THE INSTRUMENT PANEL ARE MALFUNCTIONING. THE TACHOMETER IS READING 5,000 RPM WHEN THE VEHICLE WAS IN PARK, AND 7,000 RPM WHEN GOING 15 MPH. WHEN I TURN THE CAR OFF THE GAUGE SITS AT 2,000. THE SPEEDOMETER IS CLICKING UP (NOT A SMOOTH TRANSITION TO THE CORRECT SPEED). AND IT SHOWING A LESSER SPEED THEN I AM GOI…
Read full complaint
MULTIPLE GAUGES ON THE INSTRUMENT PANEL ARE MALFUNCTIONING. THE TACHOMETER IS READING 5,000 RPM WHEN THE VEHICLE WAS IN PARK, AND 7,000 RPM WHEN GOING 15 MPH. WHEN I TURN THE CAR OFF THE GAUGE SITS AT 2,000. THE SPEEDOMETER IS CLICKING UP (NOT A SMOOTH TRANSITION TO THE CORRECT SPEED). AND IT SHOWING A LESSER SPEED THEN I AM GOING. WHEN I TURN THE CAR OFF THE SPEEDOMETER SHOWS IT IS GOING 10 MILES PER HOUR BUT WILL SLOWLY DROP DOWN TO ZERO. BOTH OF THESE MALFUNCTIONS COULD ARE A HUGE SAFETY CONCERN. I HAD TO PULL OVER ON THE HIGHWAY WHILE THE INSTRUMENT PANEL WAS SHOWING 7,000 RPM, AFRAID I WAS GOING TO BREAK DOWN AND RUIN MY CAR.
NHTSA ODI #11048474
203,000 miles · Jun 8, 2017
Electrical System
TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER. WHILE ATTEMPTING TO START THE VEHICLE, THE IGNITION FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE IGNITION SWITCH FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER STATED THAT THERE WERE NO RECALLS …
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER. WHILE ATTEMPTING TO START THE VEHICLE, THE IGNITION FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE IGNITION SWITCH FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER STATED THAT THERE WERE NO RECALLS ON THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 203,000.
NHTSA ODI #10993940
193,000 miles · Jun 6, 2017
Electrical System
TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER. WHEN THE VEHICLE WAS STARTED, THE INSTRUMENT CLUSTER FAILED TO ILLUMINATE. THE CONTACT STATED THAT THE ABS, BATTERY, AND TRACTION CONTROL WARNING INDICATORS ILLUMINATED. ADDITIONALLY, THE CONTACT WAS UNABLE TO TURN THE VEHICLE OFF. THE CONTACT STATED THAT THE BATTERY WAS DISCONN…
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER. WHEN THE VEHICLE WAS STARTED, THE INSTRUMENT CLUSTER FAILED TO ILLUMINATE. THE CONTACT STATED THAT THE ABS, BATTERY, AND TRACTION CONTROL WARNING INDICATORS ILLUMINATED. ADDITIONALLY, THE CONTACT WAS UNABLE TO TURN THE VEHICLE OFF. THE CONTACT STATED THAT THE BATTERY WAS DISCONNECTED TO TURN OFF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED THE CONTACT WITH CASE NUMBER: 8-3011452393. THE APPROXIMATE FAILURE MILEAGE WAS 193,000.
NHTSA ODI #10993426
150,000 miles · May 11, 2017
Electrical System
SPEEDOMETER AND GAUGES DO NOT WORK.
NHTSA ODI #10984979
130,000 miles · Dec 17, 2016
Electrical System
ALL OF MY GAUGES INCLUDING FUEL GAUGE, TACHOMETER, AND SPEEDOMETER HAVE STOPPED WORKING. THEY WILL WORK SOME DAYS AND THEN OTHERS THE GAUGES ARE ALL OUT OF WHACK. IT SEEMS TO OCCUR ESPECIALLY WHEN IT IS COLD OUT. I AM VERY FRUSTRATED THAT THIS IS HAPPENING. I REALIZE THAT MY VEHICLE IS OLDER, BUT I DO APPRECIATE WORKING GAUGES!!…
Read full complaint
ALL OF MY GAUGES INCLUDING FUEL GAUGE, TACHOMETER, AND SPEEDOMETER HAVE STOPPED WORKING. THEY WILL WORK SOME DAYS AND THEN OTHERS THE GAUGES ARE ALL OUT OF WHACK. IT SEEMS TO OCCUR ESPECIALLY WHEN IT IS COLD OUT. I AM VERY FRUSTRATED THAT THIS IS HAPPENING. I REALIZE THAT MY VEHICLE IS OLDER, BUT I DO APPRECIATE WORKING GAUGES!!!
NHTSA ODI #10935995
185,000 miles · Oct 9, 2016
Electrical System
THE DASHBOARD CLUSTER MALFUNCTIONS. THE FIRST TIME IT WENT OUT, THE FUEL GUAGE AND OIL PRESSURE GUAGE STOPPED WORKING AND ALL OTHER GUAGES WENT OUT ONE BY ONE SOON AFTER. WE HAD A NEW GM CLUSTER INSTALLED BY THE GM DEALERSHIP AT A COST OF $600. THIS TIME, ALL GUAGES STOPPED WORKING AND THE ALERT LIGHTS STAY ON. (I.…
Read full complaint
THE DASHBOARD CLUSTER MALFUNCTIONS. THE FIRST TIME IT WENT OUT, THE FUEL GUAGE AND OIL PRESSURE GUAGE STOPPED WORKING AND ALL OTHER GUAGES WENT OUT ONE BY ONE SOON AFTER. WE HAD A NEW GM CLUSTER INSTALLED BY THE GM DEALERSHIP AT A COST OF $600. THIS TIME, ALL GUAGES STOPPED WORKING AND THE ALERT LIGHTS STAY ON. (I.E. SERVICE 4WD, SEAT BELT, SERVICE ENGINE, BRAKE AND ABS) OTHER GM VEHICLES WITH THIS SAME CLUSTER HAVE BEEN RECALLED BUT NOT THE 2003TRAILBLAZER.
NHTSA ODI #10914922
Mileage unknown · May 27, 2016
Electrical SystemExterior LightingUnknown Or Other
"TAKATA RECALL" WE JUST PURCHASED THIS CAR FROM MY HUSBAND'S DECEASED MOTHER'S ESTATE AND IT HAD A RECALL ON THE LIGHTING INSIDE AND OUTSIDE TAIL LIGHTS. THE VEHICLE HAS 83 THOUSAND MILES ON IT AND THE VEHICLE REAR LIGHTS ARE NOT WORKING WHEN I BRAKE ONLY ONE THAT IS THE THIRD LIGHT ON TOP OF CAR. GM (CHEVROLET) I LIVE ON A…
Read full complaint
"TAKATA RECALL" WE JUST PURCHASED THIS CAR FROM MY HUSBAND'S DECEASED MOTHER'S ESTATE AND IT HAD A RECALL ON THE LIGHTING INSIDE AND OUTSIDE TAIL LIGHTS. THE VEHICLE HAS 83 THOUSAND MILES ON IT AND THE VEHICLE REAR LIGHTS ARE NOT WORKING WHEN I BRAKE ONLY ONE THAT IS THE THIRD LIGHT ON TOP OF CAR. GM (CHEVROLET) I LIVE ON A VERY LIMITED INCOME AND DUE TO DISABILITY AS WELL. MY INCOME IS 1330 A MONTH. HOW CAN I GET THIS FIXED? THEY WANT TO CHARGE ME FOR DIAGNOSTICS, AS I STATED WE FIXED IT ONCE IT SEEMS TO BE THAT IT MAY GET HOT AND BLOWS FUSES AND THEN I HAVE NO IDEA I HAVE NO TAIL LIGHTS THIS IS VERY DANGEROUS AND SOMEONE COULD REAR END ME AND KILL THEMSELVES AND OR MYSELF. PLEASE HELP ME IN UNDERSTANDING ARE THEY RESPONSIBLE TO FIX THEIR DEFECTS AS THEY DID IT ONCE WHEN IT WAS RECALLED AND WE ALSO JUST BOUGHT THIS CAR. PAID ABOUT 5 THOUSAND FOR IT. EXCELLENT CONDITION. OTHER THAN THE LIGHTING SYSTEM NOT WORKING ONLY ON AND OFF. I HAVE NOT HAD AN ACCIDENT BUT I DO NOT WANT TO HAVE A ACCIDENT. I FIND IT UNFAIR THAT THEY DON'T WANT TO FIX THE PROBLEM UNLESS THEY ARE PAID BECAUSE APPARENTLY IT IS A PROBLEM THAT IS AND WILL RECUR. WE HAVE ACTUALLY FIXED THE PROBLEM ONCE BUT APPARENTLY SOMETHING IS WRONG THAT WE CANNOT SECURE THE ISSUE PROPERLY. KINDEST REGARDS [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10871249
Mileage unknown · May 16, 2016
Electrical System
INSTRUMENT CLUSTER GADGE STEPPER MOTORS ALL ARE BAD. HAVE READ HUNDREDS OF OTHER TRAILBLAZER OWNERS COMPLAIN OF THE SAME. ALSO THE IGNITION SWITCHES ARE VERY FAULTY.
NHTSA ODI #10865296
154,075 miles · May 7, 2016
Electrical System
TRAVELLING TO WORK ON 5/5/2016 @ 30MPH VEHICLE COMPLETELY SHUT DOWN. LUCKILY PULLED TO SIDE ROAD. WAS UNABLE TO START NO POWER TO IGNITION CIRCUIT, LOCKED IN PARK. TOWED TO REPAIR SHOP & REPLACED FAULTY IGNITION SWITCH @ COST OF $300.00. VERY DANGEROUS SITUATION!
NHTSA ODI #10863714
Official recalls
8May 5, 2005
ON CERTAIN TRUCKS AND SPORT UTILITY VEHICLES, THE DRIVER WISHING TO SIGNAL A TURN BY MOVING THE DIRECTIONAL SIGNAL LEVER, (UP OR DOWN) MAY CAUSE THE FRONT MARKER/TURN LIGHTS AND REAR TURN LIGHTS TO FLASH IN A MANNER SIMILAR TO HAZARD WARNING, RATHER THAN FLASHING ON THE DESIRED SIDE ONLY.
Consequence & remedy
Consequence: THE DRIVER MAY NOT BE ABLE TO CLEARLY SIGNAL THEIR INTENTIONS TO TURN, CHANGE TRAVEL LANES, OR POTENTIALLY WARN OTHERS OF AN IMPAIRED VEHICLE OPERATING CONDITION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SUSPECT FLASHER MODULES WITH A NEW FLASHER MODULE DESIGNED WITH SEALED RELAYS AND MORE DURABLE CONTACT MATERIAL INSIDE OF THE RELAYS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2005. ISUZU BEGAN MAILING OWNER LETTERS ON AUGUST 4, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727, BUICK AT 1-866-608-8080, AND OLDSMOBILE AT 1-800-630-6537.
Nov 1, 2004
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Consequence & remedy
Consequence: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.
Consequence & remedy
Consequence: DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR GMC AT 1-866-996-9463.
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Apr 23, 2003
CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH A LEFT-FRONT BRAKE PIPE WITH A CIRCUMFERENTIAL SCORE AT A RANDOM LOCATION ALONG THE LENGTH OF THE PIPE AS THE RESULT OF THE MANUFACTURING PROCESS. IF THE BRAKE PIPE PARTIALLY OR FULLY FRACTURED, BRAKE PEDAL TRAVEL WOULD IMMEDIATELY INCREASE AND FRONT BRAKE PERFORMANCE WOULD BE REDUCED.
Consequence & remedy
Consequence: IF BRAKING PERFORMANCE IS REDUCED, A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE LEFT-FRONT BRAKE PIPE. OWNER NOTIFICATION BEGAN ON MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-8006.
Mar 6, 2003
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, "THEFT PROTECTION." THESE VEHICLES ARE EQUIPPED WITH A MECHANICAL OVERRIDE THAT COULD ALLOW THE IGNITION KEY TO BE REMOVED WITH THE SHIFT LEVER IN A POSITION OTHER THAN PARK. IN ADDITION, THESE VEHICLES HAVE AN OVERRIDE THAT CAN ALLOW THE TRANSMISSION TO BE SHIFTED OUT OF PARK WITH THE IGNITION IN THE OFF POSITION.
Consequence & remedy
Consequence: THESE OVERRIDES ARE NOT PERMITTED UNLESS THE VEHICLE HAS A LOCKING STEERING COLUMN.
Remedy: DEALERS WILL ELIMINATE THESE CONDITIONS BY DISABLING THE OVERRIDES. OWNER NOTIFICATION BEGAN ON MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR HUMMER AT 1-866-486-6376.
Feb 14, 2003
ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.
Consequence & remedy
Consequence: THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.
Remedy: DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
EA07009 · Fuel Pump Module Leaks Gasoline
Opened Jul 10, 2007 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
DURING THE COURSE OF THIS EA INVESTIGATION, ODI OBSERVED THAT THE MAJORITY OF THE COMPLAINTS (88%) AND WARRANTY CLAIMS (94%) WERE REPORTED FOR VEHICLES THAT ARE REGISTERED FOR USE IN THE SALT BELT REGION OF THE US.THIS AREA INCLUDES 20 STATES IN THE NORTHEAST, MID ATLANTIC AND THE MIDWEST REGIONS AND THE DISTRICT OF COLUMBIA.CONSUMERS IN THE SALT BELT REGION REPORTED TO ODI THAT THEY COULD SMELL FUEL VAPORS IN THEIR VEHICLES WHILE DRIVING.UPON FURTHER EXAMINATION OF THEIR VEHICLES, THEY DISCOVERED THAT FUEL VAPORS WERE COMING OUT OF THE TOP OF THE FUEL TANK. THIS CONDITION IS CAUSED BY CORROSION OF THE RETURN AND SENDER LINES OF THE FUEL PUMP MODULE.WATER AND ROAD SALT COLLECT ON TOP OF THE FUEL PUMP LEADING TO SMALL PINHOLES APPEARING ON THE FUEL LINES.FUEL MAY LEAK AND COLLECT ON TOP OF THE MODULE AND/OR SPILL ONTO THE GROUND.THE DATA EVALUATED UNDER THIS INVESTIGATION REFLECT A RELATIVELY LOW FREQUENCY OF OCCURRENCE THAT LARGELY ARISES IN SALT BELT STATES.GM HAS EXTENDED THE WARRANTY ON THE SUBJECT COMPONENT TO TEN YEARS OR 120,000 MILES.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SELECT DOCUMENT SEARCH.
PE07013 · Fuel Pump Module Leaks Gasoline
Opened Mar 12, 2007 · Closed Jul 10, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
ODI HAS RECEIVED REPORTS THAT THE FUEL PUMP MODULE LEAKS FUEL AND OR VAPOR UNDERNEATH THE VEHICLE.GM STATES, THE FAILURE MECHANISM IS CORROSION OF THE FUEL PUMP MODULE FLANGE WHICH MAY LEAD TO A FUEL LEAK.CORROSION OF THE FUEL PUMP MODULE FLANGE IS THE RESULT OF THE VEHICLE OPERATING IN A CORROSIVE ENVIRONMENT.ODI HAS UPGRADED THIS PE TO ENGINEERING ANALYSIS (EA07-009) TO FURTHER ASSESS THIS ISSUE.
EA04021 · Brake Lamp Failure
Opened Aug 3, 2004 · Closed Nov 4, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
GM STATES THAT SOME BRAKE/TAIL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO MALFUNCTIONING BRAKE/TAIL LAMP SOCKETS.ON MARCH 2, 2004, GM INITIATED A 6-YEAR/72,000 MILE SPECIAL POLICY FOR 989,487 SUBJECT VEHICLES TO INSPECT AND REPLACE THE REAR BRAKE/TAIL LAMP BULB SOCKET ASSEMBLIES.ON APRIL 4, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-032) BASED ON CONSUMER COMPLAINTS ALLEGING BRAKE LIGHTS NOT OPERATING WHEN THE BRAKE PEDAL IS DEPRESSED.ON AUGUST 3, 2004 ODI UPGRADED PE04-032 TO AN ENGINEERING ANALYSIS (EA04-021).BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V527) COVERING SUBJECT VEHICLES THAT WERE NOT ALREADY REPAIRED UNDER GM'S SPECIAL POLICY.MY 2004 SUBJECT VEHICLES BUILT AFTER AUGUST 8, 2003 CONTAIN IMPROVED BRAKE LAMP ASSEMBLIES AND ARE NOT INCLUDED IN THE RECALL.GM DEALERS WILL INSTALL THE IMPROVED BRAKE LAMP ASSEMBLY ON SUBJECT VEHICLES BUILT ON AUGUST 8, 2003 AND EARLIER.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE04032 · Brake Lamp Failure
Opened Apr 6, 2004 · Closed Aug 3, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION ON MODEL YEAR (MY) 2002-04 CHEVROLET TRAILBLAZER VEHICLES.GM REPORTS THAT OTHER VEHICLES SHARING THIS PLATFORM AND BRAKE LAMP DESIGN ARE THE MY 2002-2004 CHEVROLET TRAILBLAZER EXT; GMC ENVOY, XL, XUV; OLDSMOBILE BRAVADA AND 2004 BUICK RAINIER.COMPLAINTS ALLEGE THAT THE REAR BRAKE LAMP DOES NOT OPERATE WHEN THE BRAKE PEDAL IS DEPRESSED.THERE IS NO INDICATION TO THE DRIVER FROM INSIDE THE VEHICLE THAT ONE OR MORE BRAKE LAMPS BULBS ARE NOT FUNCTIONING.GM FOUND THAT HEAT FROM THE BULB COULD DEFORM THE LAMP SOCKET, PRODUCE ELECTRICAL ARCING AND AN INOPERATIVE BULB.TO CORRECT THE CONDITION, GM CHANGED THE BULB TO A BULB THAT TRANSMITS LESS HEAT TO THE SOCKET AND CHANGED THE SOCKET TO A THERMOPLASTIC POLYMER TO IMPROVE THERMAL STABILITY.THESE CHANGES WERE IMPLEMENTED INTO PRODUCTION VEHICLES ON OCTOBER 1, 2003.GM IMPLEMENTED A SPECIAL POLICY BY NOTIFYING CONSUMERS THAT IF THEY SHOULD EXPERIENCE A BRAKE LAMP FAILURE TO GO TO THEIR GM DEALERSHIP TO HAVE THE CIRCUIT BOARD CONTAINING THE BRAKE LAMP REPLACED ALONG WITH NEW BULBS.THIS POLICY IS GOOD FOR THE FIRST 6 YEARS OR 72,000 MILES OF THE LIFE OF THE VEHICLE.ODI WILL UPGRADE THIS INVESTIGATION TO EA 04-021 AND INCLUDE THE ABOVE MENTIONED VEHICLES.
EA04002 · Windshield Wiper Failure
Opened Jan 6, 2004 · Closed Feb 10, 2004
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:motor
ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON JANUARY 6, 2004, AND THE SCOPE WAS EXPANDED TO INCLUDE CERTAIN MY 2003 ISUZU ASCENDER VEHICLES.ALL SUBJECT VEHICLES ARE BUILT ON GENERAL MOTORS? GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE FAMILY DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).WATER ENTERS THE WINDSHIELD WIPER MODULE CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.IN NOVEMBER 2002, GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) TO BETTER CONTROL WATER INTRUSION.ODI HAS RECEIVED A TOTAL OF 1,179 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.BY LETTER DATED FEBRUARY 2, 2004, GM HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 04V-046).ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Visibility:windshield Wiper/washer
ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON JANUARY 6, 2004, AND THE SCOPE WAS EXPANDED TO INCLUDE CERTAIN MY 2003 ISUZU ASCENDER VEHICLES.ALL SUBJECT VEHICLES ARE BUILT ON GENERAL MOTORS? GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE FAMILY DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).WATER ENTERS THE WINDSHIELD WIPER MODULE CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.IN NOVEMBER 2002, GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) TO BETTER CONTROL WATER INTRUSION.ODI HAS RECEIVED A TOTAL OF 1,179 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.BY LETTER DATED FEBRUARY 2, 2004, GM HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 04V-046).ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Visibility:windshield Wiper/washer
ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON JANUARY 6, 2004, AND THE SCOPE WAS EXPANDED TO INCLUDE CERTAIN MY 2003 ISUZU ASCENDER VEHICLES.ALL SUBJECT VEHICLES ARE BUILT ON GENERAL MOTORS? GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE FAMILY DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).WATER ENTERS THE WINDSHIELD WIPER MODULE CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.IN NOVEMBER 2002, GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) TO BETTER CONTROL WATER INTRUSION.ODI HAS RECEIVED A TOTAL OF 1,179 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.BY LETTER DATED FEBRUARY 2, 2004, GM HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 04V-046).ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Visibility:windshield Wiper/washer:motor
ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON JANUARY 6, 2004, AND THE SCOPE WAS EXPANDED TO INCLUDE CERTAIN MY 2003 ISUZU ASCENDER VEHICLES.ALL SUBJECT VEHICLES ARE BUILT ON GENERAL MOTORS? GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE FAMILY DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).WATER ENTERS THE WINDSHIELD WIPER MODULE CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.IN NOVEMBER 2002, GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) TO BETTER CONTROL WATER INTRUSION.ODI HAS RECEIVED A TOTAL OF 1,179 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.BY LETTER DATED FEBRUARY 2, 2004, GM HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 04V-046).ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Visibility:windshield Wiper/washer:motor
ON SEPTEMBER 17, 2003, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE03-042) TO INVESTIGATE ALLEGED WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 2002 AND 2003 CHEVROLET TRAILBLAZER AND TRAILBLAZER EXT, GMC ENVOY AND ENVOY XL, AND OLDSMOBILE BRAVADA VEHICLES.THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON JANUARY 6, 2004, AND THE SCOPE WAS EXPANDED TO INCLUDE CERTAIN MY 2003 ISUZU ASCENDER VEHICLES.ALL SUBJECT VEHICLES ARE BUILT ON GENERAL MOTORS? GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE FAMILY DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).WATER ENTERS THE WINDSHIELD WIPER MODULE CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.IN NOVEMBER 2002, GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) TO BETTER CONTROL WATER INTRUSION.ODI HAS RECEIVED A TOTAL OF 1,179 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.BY LETTER DATED FEBRUARY 2, 2004, GM HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 04V-046).ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE04001 · Fuel Spillage During Refueling
Opened Jan 5, 2004 · Closed May 7, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (2)
Fuel System, Gasoline:storage
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
PE03042 · Windshield Wiper Failure
Opened Sep 17, 2003 · Closed Jan 6, 2004
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:motor
THE SUBJECT VEHICLES (CHEVROLET TRAILBLAZER (EXT), GMC ENVOY (XL), AND OLDSMOBILE BRAVADA) ARE BUILT ON THE GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?FAMILY? DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).THE WINDSHIELD WIPER ASSEMBLY IS LOCATED INSIDE THE PLENUM AT THE BASE OF THE WINDSHIELD AND IS MOUNTED ON AN INCLINE APPROXIMATELY EQUAL TO THE RAKE OF THE WINDSHIELD.GM REPORTS THAT VEHICLES ARE SUBJECT TO A QUALITY ASSURANCE WATER TEST AT THE ASSEMBLY PLANT.THE TEST EXPOSES THE VEHICLES TO AN AMOUNT OF WATER THAT EXCEEDS THE PLENUM?S CAPABILITY TO DIVERT WATER AWAY FROM THE WIPER MODULE, ALLOWING WATER TO RISE TO A LEVEL THAT EXCEEDS THE HEIGHT OF THE WINDSHIELD WIPER MOTOR COVER VENT HOLE.WATER ENTERS THROUGH THE VENT HOLE THEN FLOWS DOWN TO THE BOTTOM OF THE MODULE AND POOLS CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.ON NOVEMBER 2, 2002 GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) THAT USES A POLYTETRAFLUOROETHYLENE MEMBRANE COVERED VENT HOLE TO CONTROL WATER INTRUSION.THERE ARE A TOTAL OF 1,172 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE, TWO VEHICLE CRASHES ALLEGEDLY CAUSED BY WINDSHIELD WIPER FAILURE, AND 43,219 WARRANTY CLAIMS FOR WINDSHIELD WIPER ASSEMBLY OR WIPER CONTROL MODULE REPLACEMENT ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-002) TO FURTHER STUDY THE SCOPE AND SAFETY CONSEQUENCES OF THIS ISSUE.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
THE SUBJECT VEHICLES (CHEVROLET TRAILBLAZER (EXT), GMC ENVOY (XL), AND OLDSMOBILE BRAVADA) ARE BUILT ON THE GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?FAMILY? DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).THE WINDSHIELD WIPER ASSEMBLY IS LOCATED INSIDE THE PLENUM AT THE BASE OF THE WINDSHIELD AND IS MOUNTED ON AN INCLINE APPROXIMATELY EQUAL TO THE RAKE OF THE WINDSHIELD.GM REPORTS THAT VEHICLES ARE SUBJECT TO A QUALITY ASSURANCE WATER TEST AT THE ASSEMBLY PLANT.THE TEST EXPOSES THE VEHICLES TO AN AMOUNT OF WATER THAT EXCEEDS THE PLENUM?S CAPABILITY TO DIVERT WATER AWAY FROM THE WIPER MODULE, ALLOWING WATER TO RISE TO A LEVEL THAT EXCEEDS THE HEIGHT OF THE WINDSHIELD WIPER MOTOR COVER VENT HOLE.WATER ENTERS THROUGH THE VENT HOLE THEN FLOWS DOWN TO THE BOTTOM OF THE MODULE AND POOLS CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.ON NOVEMBER 2, 2002 GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) THAT USES A POLYTETRAFLUOROETHYLENE MEMBRANE COVERED VENT HOLE TO CONTROL WATER INTRUSION.THERE ARE A TOTAL OF 1,172 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE, TWO VEHICLE CRASHES ALLEGEDLY CAUSED BY WINDSHIELD WIPER FAILURE, AND 43,219 WARRANTY CLAIMS FOR WINDSHIELD WIPER ASSEMBLY OR WIPER CONTROL MODULE REPLACEMENT ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-002) TO FURTHER STUDY THE SCOPE AND SAFETY CONSEQUENCES OF THIS ISSUE.
Visibility:windshield Wiper/washer:motor
THE SUBJECT VEHICLES (CHEVROLET TRAILBLAZER (EXT), GMC ENVOY (XL), AND OLDSMOBILE BRAVADA) ARE BUILT ON THE GMT360 AND GMT370 PLATFORMS AND WERE ORIGINALLY EQUIPPED WITH A WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?FAMILY? DESIGN MODULE (P/N 15171306 BASE, P/N 15171307 FOR VEHICLES EQUIPPED WITH RAINSENSE AUTOMATIC MOISTURE SENSITIVE WIPERS).THE WINDSHIELD WIPER ASSEMBLY IS LOCATED INSIDE THE PLENUM AT THE BASE OF THE WINDSHIELD AND IS MOUNTED ON AN INCLINE APPROXIMATELY EQUAL TO THE RAKE OF THE WINDSHIELD.GM REPORTS THAT VEHICLES ARE SUBJECT TO A QUALITY ASSURANCE WATER TEST AT THE ASSEMBLY PLANT.THE TEST EXPOSES THE VEHICLES TO AN AMOUNT OF WATER THAT EXCEEDS THE PLENUM?S CAPABILITY TO DIVERT WATER AWAY FROM THE WIPER MODULE, ALLOWING WATER TO RISE TO A LEVEL THAT EXCEEDS THE HEIGHT OF THE WINDSHIELD WIPER MOTOR COVER VENT HOLE.WATER ENTERS THROUGH THE VENT HOLE THEN FLOWS DOWN TO THE BOTTOM OF THE MODULE AND POOLS CAUSING THE ELECTRICAL COMPONENTS ON THE CONTROL CIRCUIT BOARD TO CORRODE AND SHORT OUT, THUS RENDERING THE WIPER MOTOR/MODULE INOPERATIVE.ON NOVEMBER 2, 2002 GM INTRODUCED INTO VEHICLE PRODUCTION A REDESIGNED WINDSHIELD WIPER ASSEMBLY REFERRED TO AS THE ?GLOBAL? DESIGN MODULE (P/N 15094704 BASE, P/N 15094705 FOR VEHICLES EQUIPPED WITH RAINSENSE) THAT USES A POLYTETRAFLUOROETHYLENE MEMBRANE COVERED VENT HOLE TO CONTROL WATER INTRUSION.THERE ARE A TOTAL OF 1,172 NON-DUPLICATIVE OWNER AND FIELD REPORTS ALLEGING WINDSHIELD WIPER FAILURE, TWO VEHICLE CRASHES ALLEGEDLY CAUSED BY WINDSHIELD WIPER FAILURE, AND 43,219 WARRANTY CLAIMS FOR WINDSHIELD WIPER ASSEMBLY OR WIPER CONTROL MODULE REPLACEMENT ON VEHICLES ORIGINALLY EQUIPPED WITH THE ?FAMILY? DESIGN MODULE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-002) TO FURTHER STUDY THE SCOPE AND SAFETY CONSEQUENCES OF THIS ISSUE.
Illustration