NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
313 reports184,000 miles · Jul 3, 2016
Electrical System
NONE OF MY GAGES WORK AND A LOT OF MY DASH LIGHTS ARE ON. I HAVE NO IDEA HOW MUCH GAS I HAVE. MY SPEEDOMETER AND RPM GAGES WORK BUT NOTHING ELSE DOES. THIS HAS BEEN HAPPENING ON AND OFF FOR ABOUT 3 MONTHS BUT THEY WOULD ALWAYS GO BACK ON. BUT NOW IT HAS BEEN OFF FOR A WEEK WITHOUT GOING BACK TO NORMAL. TWICE LAST WEEK THE RADIO …
Read full complaint
NONE OF MY GAGES WORK AND A LOT OF MY DASH LIGHTS ARE ON. I HAVE NO IDEA HOW MUCH GAS I HAVE. MY SPEEDOMETER AND RPM GAGES WORK BUT NOTHING ELSE DOES. THIS HAS BEEN HAPPENING ON AND OFF FOR ABOUT 3 MONTHS BUT THEY WOULD ALWAYS GO BACK ON. BUT NOW IT HAS BEEN OFF FOR A WEEK WITHOUT GOING BACK TO NORMAL. TWICE LAST WEEK THE RADIO AND THE POWER WINDOWS STOPPED WORKING AS WELL. THIS HAPPENS WHILE DRIVING PARKED ALL THE TIME AND IT DOESNT GO BACK TO NORMAL. I HAVE SEEN A LOT OF COMPLAINTS ABOUT THIS SO I HAVE NO CLUE WHY THERE ISN'T A RECALL. IT IS NOT SAFE TO DRIVE MY TRAILBLAZER UNTIL THESE THINGS ARE FIXED. I WORK AT A CHEVROLET DEALERSHIP AND THEY COULDN'T FIGURE OUT HOW TO FIX THIS EITHER. GM NEEDS TO PUT OUT A RECALL TO GET THIS FIXED ASAP.
NHTSA ODI #10882369
Mileage unknown · Mar 30, 2016
Electrical System
THE GAS GAUGE STARTED MESSING UP/NOT READING RIGHT ESPECIALLY IN THE RAIN AND THEN SHORTLY AFTER THAT THE SPEEDOMETER STARTED DOING THE SAME THING. NOW NEITHER ONE WILL WORK AT ALL. THIS STARTED ABOUT TWO YEARS AGO AND QUIT WORKING ALL TOGETHER ABOUT 1 YEAR AGO. I HEARD THAT THIS IS HAPPENING TO ALOT OF TRAILBLAZERS. THIS STARTE…
Read full complaint
THE GAS GAUGE STARTED MESSING UP/NOT READING RIGHT ESPECIALLY IN THE RAIN AND THEN SHORTLY AFTER THAT THE SPEEDOMETER STARTED DOING THE SAME THING. NOW NEITHER ONE WILL WORK AT ALL. THIS STARTED ABOUT TWO YEARS AGO AND QUIT WORKING ALL TOGETHER ABOUT 1 YEAR AGO. I HEARD THAT THIS IS HAPPENING TO ALOT OF TRAILBLAZERS. THIS STARTED WHILE THE VEHICLE WAS IN MOTION.
NHTSA ODI #10852479
Mileage unknown · Dec 20, 2015
Power Train
I HAVE REPLACED THE FRONT DIFFERENTIAL TWICE IN 10 MONTHS. I BOUGHT NEW PARTS FOR IT NOT USED THAT WERE REDONE TO GET RID OF THE PROBLEMS IT HAD NOW IT HAS GONE AGAIN. THIS TIME I HAVEN'T EVEN USED THE FOUR WHEEL DRIVE YET SINCE THE LAST REPAIR. I HAVE RESEARCH IT AND I NOTICED A LOT OF PEOPLE WITH THE SAME PROBLEM.
NHTSA ODI #10811324
155,000 miles · Sep 16, 2015
Electrical SystemFuel/propulsion System
THE CHECK ENGINE LIGHT WENT ON AND THERE WAS A STRONG GAS ODOR. GAS HAD ALSO PREVIOUSLY SPILLED OUT WHEN FUELUNG.
NHTSA ODI #10764433
88,000 miles · Sep 5, 2015
Service Brakes
MY WIFE AND FIVE CHILDREN TRAVELING ON I-94 E AND EXITED THE FREEWAY AT THE 12 MILE EXIT IN ROSEVILLE MI. MY WIFE ATTEMPTED TO BRAKE AS THEY APPROACHED THE RED TRAFFIC SIGNAL ON THE 12 MILE EXIT RAMP AND THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR WITHOUT WARNING. SHE WAS UNABLE TO STOP THE VEHICLE AND PROCEEDED THROUGH THE …
Read full complaint
MY WIFE AND FIVE CHILDREN TRAVELING ON I-94 E AND EXITED THE FREEWAY AT THE 12 MILE EXIT IN ROSEVILLE MI. MY WIFE ATTEMPTED TO BRAKE AS THEY APPROACHED THE RED TRAFFIC SIGNAL ON THE 12 MILE EXIT RAMP AND THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR WITHOUT WARNING. SHE WAS UNABLE TO STOP THE VEHICLE AND PROCEEDED THROUGH THE RED LIGHT NARROWLY MISSING A HIGH SPEED COLLISION WITH BOTH EAST AND WEST BOUND TRAFFIC ON 12-MILE ROAD. SHE CONTINUED THROUGH THE INTERSECTION ON THE RED LIGHT AND WAS ABLE TO STOP THE SUV SEVERAL HUNDRED YARDS DOWN THE SERVICE DRIVE. SHE SLOWLY DROVE THE VEHICLE HOME AND I CHECKED THE BRAKES AND THE PEDAL WENT STRAIGHT TO THE FLOOR WITH NO BRAKE WARNING OR ANY OTHER INDICATORS ON THE DASH. I PUMPED THE BRAKES SEVERAL TIMES AND COULDN'T EVEN HOLD THE VEHICLE WHILE IDLING IN THE DRIVE POSITION. I ALSO NOTICED A LARGE PUDDLE OF FLUID UNDER THE DRIVER'S SIDE OF THE VEHICLE. I'M GOING TO LIMP THE VEHICLE TO MORAN CHEVROLET IN CLINTON TOWNSHIP, MI AND LEAVE IT WITH THOSE THAT SOLD ME THIS DEATHTRAP. ANOTHER AND PERHAPS EVEN GREATER SAFETY CONCERN I HAVE IS THE SUV'S TENDENCY TO MISBEHAVE WHILE IN AWD MODE. THE VEHICLE SOMETIMES GOES IN REVERSE WHILE DRIVE IS SELECTED AND VICE VERSA. ADDITIONALLY, THE VEHICLE WILL SOMETIMES PUT ITSELF IN NEUTRAL WHILE ENGAGED IN DRIVE MODE OR WHILE STOPPED AT TRAFFIC SIGNALS. OH AND LAST WEEK I REPLACED THE WINDSHIELD WIPER ASSEMBLY AFTER IT FAILED AND FOUND NO EVIDENCE THAT GM HAD COMPLETED THE RELATED RECALL WORK THAT SIGNED OFF AS BEING COMPLETE FOR THE WINDSHIELD MOTOR AND LINKAGE ASSEMBLY. I SEE I'M NOT ALONE IN HAVING SUFFERED CATASTROPHIC SAFETY RELATED FAILURES WITH THIS PARTICULAR SUV. PLEASE TAKE NOTICE AND FORCE GM TO RECALL TO FIX THIS CORROSION ISSUE WITH THE BRAKE SYSTEM. I ALMOST LOST MY FAMILY LAST EVENING AND WILL ASSUME IT WOULD HAVE MADE NATIONAL NEWS HAD THEY DIED IN AN ACCIDENT.
NHTSA ODI #10761751
Mileage unknown · Aug 30, 2015
Power TrainFire
I PURCHASED A 2003 TRAILBLAZER FROM AN INDIVIDUAL. THE FRONT DIFFERENTIAL HAD A HOLE IN IT. SO I PURCHASED A DIFFERENTIAL FROM A SCRAP YARD. 90 DAY WARRANTY. STILL HAD A NOISE . I STILL HAD A NOISE FRONT DIFFERENTIAL WAS OUT AGAIN. I PURCHASED THE THIRD DIFFERENTIAL FROM A DIFFERENT YARD TOOK IT APART . FOUND THE DRIVER SIDE B…
Read full complaint
I PURCHASED A 2003 TRAILBLAZER FROM AN INDIVIDUAL. THE FRONT DIFFERENTIAL HAD A HOLE IN IT. SO I PURCHASED A DIFFERENTIAL FROM A SCRAP YARD. 90 DAY WARRANTY. STILL HAD A NOISE . I STILL HAD A NOISE FRONT DIFFERENTIAL WAS OUT AGAIN. I PURCHASED THE THIRD DIFFERENTIAL FROM A DIFFERENT YARD TOOK IT APART . FOUND THE DRIVER SIDE BEARING BAD. IT SEEMS TO BE A VERY COMMON PROBLEM BECAUSE THE DRIVER SIDE DRIVERS CONSTANT. I WAS WONDERING IF THERE IS A RECALL. I SEE A LOT OF COMPLAINTS ONLINE. THANK YOU THERE WAS A FIRE THE DIFFERENTIAL GREASE BURNT BEARING WENT OUT AND CHARD MOTOR AND SURROUNDING AREA NO REAL DAMAGE. *TR
NHTSA ODI #10760210
131,000 miles · Jun 1, 2015
Electrical System
FIRST OIL PRESSURE GAUGE WENT AND NOW MY SPEEDOMETER IS ALSO GONE STUCK AT 50 MPH. CALLED CHEVY CAN'T GET STRAIGHT ANSWER FROM THEM AND ASK WHAT OTHER VEHICLES WITH THE SAME PROBLEM WITH GAUGE CLUSTER ADVISED CAN'T DISCLOSED ANY INFORMATION.
NHTSA ODI #10722806
56,000 miles · Jan 24, 2015
Fuel System, Gasoline
NHTSA ACTION NUMBER : PE07014 OCCURRED ON MY VEHICLE AROUND NOVEMBER 2014. THE PROBLEM PRESENTED AS P0442 CEL AND ODOR OF GAS AFTER PARKING IN GARAGE. GM HAS INDICATED BECAUSE THE SPECIAL CONSIDERATION ALLOWANCE HAS EXPIRED, DESPITE THE LOW MILEAGE THEY WILL DO NOTHING. THIS VEHICLE WAS PURCHASED NEW IN AUGUST 2003. I DO…
Read full complaint
NHTSA ACTION NUMBER : PE07014 OCCURRED ON MY VEHICLE AROUND NOVEMBER 2014. THE PROBLEM PRESENTED AS P0442 CEL AND ODOR OF GAS AFTER PARKING IN GARAGE. GM HAS INDICATED BECAUSE THE SPECIAL CONSIDERATION ALLOWANCE HAS EXPIRED, DESPITE THE LOW MILEAGE THEY WILL DO NOTHING. THIS VEHICLE WAS PURCHASED NEW IN AUGUST 2003. I DO NOT UNDERSTAND WHY GM WAS NOT COMPELLED TO ISSUE A SAFETY RECALL DUE TO THE RISK OF GAS LEAKING. I WOULD APPRECIATE ASSISTANCE TO GET GM TO MINIMALLY PROVIDE DEFECTIVE PARTS REPLACEMENT, DUE TO THE KNOW MANUFACTURING DEFECT IN THE GAS TANK. *TR
NHTSA ODI #10678685
120,000 miles · Jan 7, 2015
Air BagsCrashInjury
IT WAS SLEETING AND I LOST CONTROL ON A CURVE. I HAD BEEN DRIVING ABOUT 50 MPH, BUT BRAKE BEFORE THE CURVE AND BRAKE VERY HARD WHEN I TRIED TO REGAIN CONTROL OF THE VEHICLE, AS IT WAS SLIDING SIDEWAYS TOWARD THE CURVE. I WENT OFF THE CURVE AND HIT AN ELEVATED CROSSROAD, WHICH SENT THE VEHICLE AIRBORNE. I WAS AIRBORNE OVER MOS…
Read full complaint
IT WAS SLEETING AND I LOST CONTROL ON A CURVE. I HAD BEEN DRIVING ABOUT 50 MPH, BUT BRAKE BEFORE THE CURVE AND BRAKE VERY HARD WHEN I TRIED TO REGAIN CONTROL OF THE VEHICLE, AS IT WAS SLIDING SIDEWAYS TOWARD THE CURVE. I WENT OFF THE CURVE AND HIT AN ELEVATED CROSSROAD, WHICH SENT THE VEHICLE AIRBORNE. I WAS AIRBORNE OVER MOST OF THE SIDE ROAD, WITH THE REAR OF THE VEHICLE HITTING JUST THE LAST FEW INCHES OF PAVEMENT, WHICH THEN SENT THE VEHICLE NOSEDIVING INTO THE DITCH. THE EMBANKMENTS WERE 4-5 FEET TALL. I HAD TWO VERY HARD FRONT END IMPACTS AND HIT MY HEAD ON THE STEERING WHEEL TWICE. THE FRAME OF THE VEHICLE WAS BENT AND THERE WAS A LOT OF DAMAGE TO THE UNDER OF THE VEHICLE, BUT THE AIRBAGS DID NOT DEPLOY. THE VEHICLE HAS BEEN DEEMED A TOTAL LOSS BY MY INSURANCE COMPANY. I HAVE A LOT OF CONCERN WITH THE FACT THAT THE AIRBAGS DID NOT DEPLOY AND KNOW THAT THERE WERE OTHER VEHICLES OF MY YEAR AND TYPE THAT DID HAVE FAULTY AIRBAGS RECALLED, BUT MINE HAS NOT BEEN. *TR
NHTSA ODI #10670844
149,420 miles · Sep 16, 2014
Fuel/propulsion System
PLASTIC WELD CONNECTING FUEL FILL PIPE TO FUEL TANK HAS CRACKED.CONTACTED GM ABOUT THIS ISSUE & WAS INFORMED THAT THIS VEHICLE HAD JUST MISSED THE CAMPAIGN TO FIX THIS PROBLEM BY ONE MONTH. WHY IS THIS CAMPAIGN (07099) A LIMITED TSB & NOT A SAFETY RECALL? VEHICLE WOULD NOT PASS STATE EMISSIONS INSPECTION. TECHNICIAN REPAIRED LEA…
Read full complaint
PLASTIC WELD CONNECTING FUEL FILL PIPE TO FUEL TANK HAS CRACKED.CONTACTED GM ABOUT THIS ISSUE & WAS INFORMED THAT THIS VEHICLE HAD JUST MISSED THE CAMPAIGN TO FIX THIS PROBLEM BY ONE MONTH. WHY IS THIS CAMPAIGN (07099) A LIMITED TSB & NOT A SAFETY RECALL? VEHICLE WOULD NOT PASS STATE EMISSIONS INSPECTION. TECHNICIAN REPAIRED LEAK WITH EPOXY THAT SEALED LONG ENOUGH TO PREVENT VAPOR LEAKAGE TO PASS EMISSION TEST.NOW THAT HAS FAILED AND ONCE AGAIN VEHICLE WILL NOT PASS EMISSIONS. MORE IMPORTANTLY THE FUEL VAPORS EMITTING FROM VEHICLE MAKE IT UNSAFE AND IMPOSSIBLE TO PARK IN AN ENCLOSED AREA.THIS IS NOT DUE TO A WORN PART OR CORROSION,THIS IS DUE TO A FAULTY DESIGN THAT EVENTUALLY WILL CAUSE AN EXPLOSION.WORSE YET GM OFFERS NO DISCOUNT ON THIS VERY EXPENSIVE TANK ASSEMBLY TO CORRECT THIS PROBLEM.I CAN NOT THINK OF A MORE DANGEROUS CONDITION THAT HAS BEEN SO IGNORED.PERHAPS WHEN THE FIRES START THERE WILL BE ANOTHER CONGRESSIONAL HEARING ABOUT GM'S ABILITY TO RESPOND TO SUCH A SERIOUS AND POSSIBLY LOSS OF LIFE HAZARD THAT THEY REFUSE TO ASSIST OWNERS IN CORRECTING. *TR
NHTSA ODI #10633459
Official recalls
3Oct 27, 2005
CERTAIN SPORT UTILITY VEHICLES HAVE A REAR SIDE CLOSURE LATCH THAT MAY NOT LATCH OR UNLATCH DUE TO CORROSION CAUSED BY ROAD SPLASH, SUCH AS WATER AND ROAD SALT. THESE VEHICLES WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA.
Consequence & remedy
Consequence: IF THE DOOR IS NOT LATCHED PROPERLY AND IT GOES UNNOTICED, IT MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN UNBELTED OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A SEAL ALONG THE LOWER PART OF THE ROCKER PANEL TO PREVENT INTRUSION OF CORROSIVE MATERIAL, AND INSPECT THE REAR SIDE CLOSURE LATCHES. FUNCTIONAL LATCHES WILL BE CLEANED AND LUBRICATED. NON-FUNCTIONING LATCHES WILL BE REPLACED. THE RECALL BEGAN ON FEBRUARY 24, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR ISUZU AT 1-800-255-6727.
Nov 1, 2004
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Consequence & remedy
Consequence: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.
Consequence & remedy
Consequence: DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
EA07009 · Fuel Pump Module Leaks Gasoline
Opened Jul 10, 2007 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
DURING THE COURSE OF THIS EA INVESTIGATION, ODI OBSERVED THAT THE MAJORITY OF THE COMPLAINTS (88%) AND WARRANTY CLAIMS (94%) WERE REPORTED FOR VEHICLES THAT ARE REGISTERED FOR USE IN THE SALT BELT REGION OF THE US.THIS AREA INCLUDES 20 STATES IN THE NORTHEAST, MID ATLANTIC AND THE MIDWEST REGIONS AND THE DISTRICT OF COLUMBIA.CONSUMERS IN THE SALT BELT REGION REPORTED TO ODI THAT THEY COULD SMELL FUEL VAPORS IN THEIR VEHICLES WHILE DRIVING.UPON FURTHER EXAMINATION OF THEIR VEHICLES, THEY DISCOVERED THAT FUEL VAPORS WERE COMING OUT OF THE TOP OF THE FUEL TANK. THIS CONDITION IS CAUSED BY CORROSION OF THE RETURN AND SENDER LINES OF THE FUEL PUMP MODULE.WATER AND ROAD SALT COLLECT ON TOP OF THE FUEL PUMP LEADING TO SMALL PINHOLES APPEARING ON THE FUEL LINES.FUEL MAY LEAK AND COLLECT ON TOP OF THE MODULE AND/OR SPILL ONTO THE GROUND.THE DATA EVALUATED UNDER THIS INVESTIGATION REFLECT A RELATIVELY LOW FREQUENCY OF OCCURRENCE THAT LARGELY ARISES IN SALT BELT STATES.GM HAS EXTENDED THE WARRANTY ON THE SUBJECT COMPONENT TO TEN YEARS OR 120,000 MILES.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SELECT DOCUMENT SEARCH.
PE07014 · Fuel Tank Leak
Opened Mar 13, 2007 · Closed Jun 12, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE07013 · Fuel Pump Module Leaks Gasoline
Opened Mar 12, 2007 · Closed Jul 10, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
ODI HAS RECEIVED REPORTS THAT THE FUEL PUMP MODULE LEAKS FUEL AND OR VAPOR UNDERNEATH THE VEHICLE.GM STATES, THE FAILURE MECHANISM IS CORROSION OF THE FUEL PUMP MODULE FLANGE WHICH MAY LEAD TO A FUEL LEAK.CORROSION OF THE FUEL PUMP MODULE FLANGE IS THE RESULT OF THE VEHICLE OPERATING IN A CORROSIVE ENVIRONMENT.ODI HAS UPGRADED THIS PE TO ENGINEERING ANALYSIS (EA07-009) TO FURTHER ASSESS THIS ISSUE.
EA04021 · Brake Lamp Failure
Opened Aug 3, 2004 · Closed Nov 4, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
GM STATES THAT SOME BRAKE/TAIL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO MALFUNCTIONING BRAKE/TAIL LAMP SOCKETS.ON MARCH 2, 2004, GM INITIATED A 6-YEAR/72,000 MILE SPECIAL POLICY FOR 989,487 SUBJECT VEHICLES TO INSPECT AND REPLACE THE REAR BRAKE/TAIL LAMP BULB SOCKET ASSEMBLIES.ON APRIL 4, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-032) BASED ON CONSUMER COMPLAINTS ALLEGING BRAKE LIGHTS NOT OPERATING WHEN THE BRAKE PEDAL IS DEPRESSED.ON AUGUST 3, 2004 ODI UPGRADED PE04-032 TO AN ENGINEERING ANALYSIS (EA04-021).BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V527) COVERING SUBJECT VEHICLES THAT WERE NOT ALREADY REPAIRED UNDER GM'S SPECIAL POLICY.MY 2004 SUBJECT VEHICLES BUILT AFTER AUGUST 8, 2003 CONTAIN IMPROVED BRAKE LAMP ASSEMBLIES AND ARE NOT INCLUDED IN THE RECALL.GM DEALERS WILL INSTALL THE IMPROVED BRAKE LAMP ASSEMBLY ON SUBJECT VEHICLES BUILT ON AUGUST 8, 2003 AND EARLIER.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE04001 · Fuel Spillage During Refueling
Opened Jan 5, 2004 · Closed May 7, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (2)
Fuel System, Gasoline:storage
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Illustration