NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
80 reportsClear category filter69,000 miles · Nov 6, 2009
Fuel System, Gasoline
THE SERVICE ENGINE LIGHT WAS COMING ON AND WE HAD DIAGNOSTIC DONE AND WAS TOLD THAT IT WAS THE GAS CAP. WE REPLACED SEVERAL TIME. EVERYTIME I DROVE OR RODE IN MY VEHICLE I SMELLED GAS AND I WOULD GET A HORRIBLE HEADACHE. MY HUSBAND TOOK MY VEHICLE TO GET AN EMISSION TEST DONE WE WERE TOLD THE FUEL TANK WAS CRACKED AT THE NECK …
Read full complaint
THE SERVICE ENGINE LIGHT WAS COMING ON AND WE HAD DIAGNOSTIC DONE AND WAS TOLD THAT IT WAS THE GAS CAP. WE REPLACED SEVERAL TIME. EVERYTIME I DROVE OR RODE IN MY VEHICLE I SMELLED GAS AND I WOULD GET A HORRIBLE HEADACHE. MY HUSBAND TOOK MY VEHICLE TO GET AN EMISSION TEST DONE WE WERE TOLD THE FUEL TANK WAS CRACKED AT THE NECK AND LEAKING GAS. WE HAD IT REPAIRED NOV 6, 2009 AFTER WE HAD BEEN TOLD OF THIS. THE SHOP THAT REPAIRED MY VEHICLE SAID THEY WERE SHOCKED IT HAD NOT CAUGHT ON FIRE. THERE WAS EVIDENCE THIS HAD BEEN GOING ON FOR A WHILE. PROBABLY WHEN WE WERE TOLD THE GAS CAP WAS LOOSE IS WHEN IT STARTED, AND THAT HAD BEEN OVER A YEAR BEFORE. *TR
NHTSA ODI #10291261
Mileage unknown · Oct 30, 2009
Fuel System, Gasoline
SMELL OF GAS DEVELOPED AROUND VEHICLE AT ALL TIMES. HAD IT LOOKED AT AND NOTHING WAS FOUND. BROUGHT IT TO ANOTHER SHOP AND THEY DROPPED OUT THE FUEL TANK, FINDING THE TOP OF THE TANK WET WITH FUEL AND THE CONNECTION RUSTED. THE SOLUTION WAS TO REPLACE THE FUEL PUMP AND PARTS. *TR
NHTSA ODI #10290380
155,000 miles · Oct 29, 2009
Fuel System, Gasoline
I AM THE OWNER OF A 2003 CHEVROLET TRAILBLAZER EXT, I PURCHASED THE VEHICLE NEW FROM GM. IN THE LAST YEAR MY SES LIGHT HAS BEEN COMING ON, I TOOK MY VEHICLE TO AN AUTO PARTS STORE AND THEY ANALYZED MY VEHICLE TO READ THE CODE CAUSING THE SES LIGHT TO COME ON. I HAD A LEAK IN MY FUEL TANK EMISSIONS SYSTEM. THEY RECOMMENDED I REPL…
Read full complaint
I AM THE OWNER OF A 2003 CHEVROLET TRAILBLAZER EXT, I PURCHASED THE VEHICLE NEW FROM GM. IN THE LAST YEAR MY SES LIGHT HAS BEEN COMING ON, I TOOK MY VEHICLE TO AN AUTO PARTS STORE AND THEY ANALYZED MY VEHICLE TO READ THE CODE CAUSING THE SES LIGHT TO COME ON. I HAD A LEAK IN MY FUEL TANK EMISSIONS SYSTEM. THEY RECOMMENDED I REPLACE MY FUEL CAP TO FIX THE PROBLEM. OVER THE PAST YEAR AND AFTER REPLACING THE FUEL CAP, THE PROBLEM WOULD GO AWAY FOR A MONTH OR SO AND THEY REOCCUR. I TOOK MY VEHICLE IN FOR A SYSTEM CHECK OF THE FUEL SYSTEM. MY MECHANIC PERFORMED A SMOKE TEST ON THE FUEL SYSTEM, THEY TOLD ME THEY FOUND A FRACTURE ON A WELD WITH THE FUEL TANK, FURTHERMORE THEY SAID THERE WAS PROBLEMS WITH THE CHEVROLET TRAILBLAZERS WITH FAULTY WELDS ON THE FUEL TANK. I SEARCHED THE INTERNET AND FOUND AUTO FORUM BOARD STATING GM HAS KNOWN ABOUT THIS PROBLEM FOR A WHILE. TALKING WITH A CO-WORKER ABOUT MY PROBLEM, HE STATED HE OWNED A 2003 TRAILBLAZER AND RECALLED RECEIVING A NOTICE FROM GM ABOUT THIS PROBLEM, HE GAVE ME A COPY OF HIS NOTICE WHERE THE NOTICE TALKS ABOUT FRACTURE OF A WELD ON THE FUEL TANK AND CHEVROLET PROVIDING OWNERS WITH AN EXTENSION OF REPAIRS FOR 10 YEARS OF OWNERSHIP OR 150,000 MILES. I NEVER RECEIVED A NOTICE FROM CHEVROLET ABOUT THIS PROGRAM. I CALLED THE CHEVROLET CUSTOMER ASSISTANCE CENTER, WHERE I TOLD THEM WHAT HAPPENED WITH MY VEHICLE; I ALSO TOLD THEM I HAD 167,000 MILE ON MY VEHICLE. THEY TOLD ME THEY FIRST NEEDED TO VERIFY THE CRACK BY A GM DEALERSHIP MECHANIC. THEY ALSO TOLD ME I HAD TO PAY FOR THE FUEL SYSTEM TO BE CHECK AND THERE MIGHT BE SOME CONSIDERATION FOR THEM TO PAY FOR THE REPAIR IF IT WAS INDEED A CRACK IN THE FUEL SYSTEM. THE CRACK WAS CONFIRMED BY THE CHEVROLET DEALER, BUT THEY TOLD ME SINCE MY VEHICLE HAD OVER 150,000 MILES THEY WOULD NOT PAY FOR THE REPAIR OF MY VEHICLE. THE FUEL TANK IS A STATIC SYSTEM, IT SHOULD NOT WEAR OUT, I FEEL GM DESIGNED A FAULTY PRODUCT AND SHOULD REPAIR THIS CRACK AT THEIR COST. PLEASE HELP ME. *TR
NHTSA ODI #10290241
56,000 miles · Aug 24, 2009
Fuel System, Gasoline
CHECK ENGINE LIGHT CAME ON AT APPROXIMATELY 56,000 MILES, DIAGNOSTIC CHECK WAS PERFORMED BY THE DEALER. FINDINGS: GAS VAPOR POURING FROM THE SEAL, CORROSION AND MOISTURE. NEED TO REPLACE THE GAS TANK. *TR
NHTSA ODI #10281615
94,000 miles · Jun 29, 2009
Fuel System, Gasoline
SERVICE ENGINE SOON LIGHT ON WHEN WE BOUGHT IT. HAD IT CHECKED INTO, ERROR CODE INDICATED A LEAK IN FUEL SYSTEM. SUGGESTED A NEW GAS CAP. THAT WAS NOT THE PROBLEM. THERE IS A CRACK IN THE NIPPLE ON THE GAS TANK WHERE THE FILL PIPE HOSE CONNECTS. NEED TO REPLACE THE WHOLE TANK. APPR. COST JUST FOR THE TANK $500 PLUS LABOR. …
Read full complaint
SERVICE ENGINE SOON LIGHT ON WHEN WE BOUGHT IT. HAD IT CHECKED INTO, ERROR CODE INDICATED A LEAK IN FUEL SYSTEM. SUGGESTED A NEW GAS CAP. THAT WAS NOT THE PROBLEM. THERE IS A CRACK IN THE NIPPLE ON THE GAS TANK WHERE THE FILL PIPE HOSE CONNECTS. NEED TO REPLACE THE WHOLE TANK. APPR. COST JUST FOR THE TANK $500 PLUS LABOR. *TR
NHTSA ODI #10275295
Mileage unknown · Apr 20, 2009
Fuel System, Gasoline
FUEL LEAK. *TR
NHTSA ODI #10266138
99,000 miles · Apr 2, 2009
Fuel System, Gasoline
I HAVE INTERMITTENT SMELL OF FUEL COMING FROM VEHICLE; CONSISTENTLY DECLINING MPG; SES LIGHT COMING ON; TAKEN IT TO THE DEALERSHIP AFTER HAVING RECEIVED A LETTER STATING THAT THERE WAS A FUEL TANK OR PUMP ISSUE; THEY DIAGNOSED THAT THE FILLER NECK WAS CRACKED A ND LEAKING BUT STATED THAT IT WASN'T PART OF THE REPAIRS FROM THE LE…
Read full complaint
I HAVE INTERMITTENT SMELL OF FUEL COMING FROM VEHICLE; CONSISTENTLY DECLINING MPG; SES LIGHT COMING ON; TAKEN IT TO THE DEALERSHIP AFTER HAVING RECEIVED A LETTER STATING THAT THERE WAS A FUEL TANK OR PUMP ISSUE; THEY DIAGNOSED THAT THE FILLER NECK WAS CRACKED A ND LEAKING BUT STATED THAT IT WASN'T PART OF THE REPAIRS FROM THE LETTER AND SAID IT WOULD COST A $1000 TO REPLACE MY FUEL TNK AND THEN THEY WOULD REPLACE THE FUEL PUMP MODULE FOR FREE. *TR
NHTSA ODI #10263953
142,000 miles · Mar 27, 2009
Fuel System, Gasoline
ABOUT A MONTH AGO I STARTED TO SMELL GAS VAPORS WHEN I DROVE MY CAR. ONE DAY I WAS ON THE HIGHWAY AND A PERSON NEXT TO ME HONKED HIS HORN AND TOLD ME THAT HE SAW GAS LEAKING UNDER MY CAR. I WAS NEAR PEP BOYS AND PULLED IN THE PARKING LOT. I SHUT MY CAR OFF AND LOOKED UNDERNEATH IT. I SAW A LOT OF GAS DRIPPING FROM UNDER MY FUEL…
Read full complaint
ABOUT A MONTH AGO I STARTED TO SMELL GAS VAPORS WHEN I DROVE MY CAR. ONE DAY I WAS ON THE HIGHWAY AND A PERSON NEXT TO ME HONKED HIS HORN AND TOLD ME THAT HE SAW GAS LEAKING UNDER MY CAR. I WAS NEAR PEP BOYS AND PULLED IN THE PARKING LOT. I SHUT MY CAR OFF AND LOOKED UNDERNEATH IT. I SAW A LOT OF GAS DRIPPING FROM UNDER MY FUEL TANK AND FALLING ONTO THE GROUND. I WENT INSIDE PEP BOYS AND TOLD THEM THE PROBLEM. IT WAS NEARLY CLOSING TIME SO I LEFT THE CAR OVERNIGHT AND CALLED FOR A RIDE HOME. PEP BOYS CALLED ME THE NEXT MORNING AND GAVE ME AN ESTIMATE OF $270 JUST TO DROP THE TANK AND LOOK AT WHAT MAY HAVE CAUSED THE LEAK. THEY SAID IT WAS LIKELY A BAD FUEL PUMP OR BAD FUEL LINES. I ASKED THEM ANOTHER ESTIMATE ON HOW MUCH IT WOULD COST TO FIX MY GAS LEAK. THEY SAID IT WOULD COST AROUND $600 TO $800 TO FIX MY CAR IF THE FUEL PUMP OR BAD FUEL LINES WERE REALLY THE PROBLEM. I TOLD THEM TO NOT WORK ON THE CAR AND SAID THAT I WOULD PICK IT UP. SO I TOWED THE CAR BACK HOME AND PULLED IT INTO THE GARAGE. THIS IS THE FIRST TIME THAT MY CAR HAS LEAKED GAS. THE NEXT DAY I TOOK OFF THE FUEL TANK TO CHECK WHERE THE LEAK WAS COMING FROM. WHEN I LOOKED AT THE TOP OF THE TANK, THE FUEL PUMP WAS CORRODED AND THERE WAS GAS ON THE OUTSIDE OF THE PUMP. ALSO WHEN I TOOK THE TANK OFF, THE FILLER NECK HOSE WAS CRACKED AND WAS NOT CONNECTED TO THE GAS TANK. I CALLED A JUNK YARD AND ORDERED A FUEL PUMP FOR $150. I ALSO CALLED MY LOCAL DEALER AND TOLD THEM MY ISSUE. THEY SAID THAT MY CAR HAD TOO MANY MILES ON IT AND WAS NOT COVERED BY WARRANTY ANYMORE. SINCE THE DEALER COULD NOT HELP ME, I CALLED GENERAL MOTORS CUSTOMER SERVICE AND ISSUED A SAFETY DEFECT ON MY VEHICLE. THEY SAID THAT THERE WAS A EXTENDED SPECIAL COVERAGE ON MY VEHICLE THAT MIGHT COVER THE REPAIR. I CALLED ANOTHER DEALERSHIP AND I AM WAITING FOR THEM TO CALL ME BACK. RIGHT NOW MY CAR HAS BEEN IN THE GARAGE FOR ALMOST A MONTH. THE ONLY WAY TO FIX IT IS TO BUY A NEW GAS TANK FOR $500. *TR
NHTSA ODI #10263250
55,000 miles · Jan 28, 2009
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER EXT. THE CONTACT STATED THAT WHENEVER THE VEHICLE IS FILLED WITH FUEL, THE SENSOR THAT INDICATES THE TANK IS FULL FAILS TO WORK. AS A RESULT, GASOLINE OVERFLOWS AND LEAKS FROM THE TANK OUTSIDE OF THE VEHICLE. SINCE DECEMBER OF 2008, THE VEHICLE HAS BEEN REPAIRED FOUR TIMES, WHI…
Read full complaint
TL*THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER EXT. THE CONTACT STATED THAT WHENEVER THE VEHICLE IS FILLED WITH FUEL, THE SENSOR THAT INDICATES THE TANK IS FULL FAILS TO WORK. AS A RESULT, GASOLINE OVERFLOWS AND LEAKS FROM THE TANK OUTSIDE OF THE VEHICLE. SINCE DECEMBER OF 2008, THE VEHICLE HAS BEEN REPAIRED FOUR TIMES, WHICH INCLUDED A FUEL TANK ASSEMBLY AND TANK REPLACEMENT. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 55,000.
NHTSA ODI #10256637
122,482 miles · Oct 19, 2008
Fuel System, Gasoline
GASOLINE SMELL WHEN CAR IS RUNNING. POSSIBLY RELATED TO FUEL TANK CONNECTORS. *TR
NHTSA ODI #10246035
Official recalls
3Oct 27, 2005
CERTAIN SPORT UTILITY VEHICLES HAVE A REAR SIDE CLOSURE LATCH THAT MAY NOT LATCH OR UNLATCH DUE TO CORROSION CAUSED BY ROAD SPLASH, SUCH AS WATER AND ROAD SALT. THESE VEHICLES WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA.
Consequence & remedy
Consequence: IF THE DOOR IS NOT LATCHED PROPERLY AND IT GOES UNNOTICED, IT MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN UNBELTED OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A SEAL ALONG THE LOWER PART OF THE ROCKER PANEL TO PREVENT INTRUSION OF CORROSIVE MATERIAL, AND INSPECT THE REAR SIDE CLOSURE LATCHES. FUNCTIONAL LATCHES WILL BE CLEANED AND LUBRICATED. NON-FUNCTIONING LATCHES WILL BE REPLACED. THE RECALL BEGAN ON FEBRUARY 24, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR ISUZU AT 1-800-255-6727.
Nov 1, 2004
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Consequence & remedy
Consequence: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.
Consequence & remedy
Consequence: DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
EA07009 · Fuel Pump Module Leaks Gasoline
Opened Jul 10, 2007 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
DURING THE COURSE OF THIS EA INVESTIGATION, ODI OBSERVED THAT THE MAJORITY OF THE COMPLAINTS (88%) AND WARRANTY CLAIMS (94%) WERE REPORTED FOR VEHICLES THAT ARE REGISTERED FOR USE IN THE SALT BELT REGION OF THE US.THIS AREA INCLUDES 20 STATES IN THE NORTHEAST, MID ATLANTIC AND THE MIDWEST REGIONS AND THE DISTRICT OF COLUMBIA.CONSUMERS IN THE SALT BELT REGION REPORTED TO ODI THAT THEY COULD SMELL FUEL VAPORS IN THEIR VEHICLES WHILE DRIVING.UPON FURTHER EXAMINATION OF THEIR VEHICLES, THEY DISCOVERED THAT FUEL VAPORS WERE COMING OUT OF THE TOP OF THE FUEL TANK. THIS CONDITION IS CAUSED BY CORROSION OF THE RETURN AND SENDER LINES OF THE FUEL PUMP MODULE.WATER AND ROAD SALT COLLECT ON TOP OF THE FUEL PUMP LEADING TO SMALL PINHOLES APPEARING ON THE FUEL LINES.FUEL MAY LEAK AND COLLECT ON TOP OF THE MODULE AND/OR SPILL ONTO THE GROUND.THE DATA EVALUATED UNDER THIS INVESTIGATION REFLECT A RELATIVELY LOW FREQUENCY OF OCCURRENCE THAT LARGELY ARISES IN SALT BELT STATES.GM HAS EXTENDED THE WARRANTY ON THE SUBJECT COMPONENT TO TEN YEARS OR 120,000 MILES.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SELECT DOCUMENT SEARCH.
PE07014 · Fuel Tank Leak
Opened Mar 13, 2007 · Closed Jun 12, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE07013 · Fuel Pump Module Leaks Gasoline
Opened Mar 12, 2007 · Closed Jul 10, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
ODI HAS RECEIVED REPORTS THAT THE FUEL PUMP MODULE LEAKS FUEL AND OR VAPOR UNDERNEATH THE VEHICLE.GM STATES, THE FAILURE MECHANISM IS CORROSION OF THE FUEL PUMP MODULE FLANGE WHICH MAY LEAD TO A FUEL LEAK.CORROSION OF THE FUEL PUMP MODULE FLANGE IS THE RESULT OF THE VEHICLE OPERATING IN A CORROSIVE ENVIRONMENT.ODI HAS UPGRADED THIS PE TO ENGINEERING ANALYSIS (EA07-009) TO FURTHER ASSESS THIS ISSUE.
EA04021 · Brake Lamp Failure
Opened Aug 3, 2004 · Closed Nov 4, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
GM STATES THAT SOME BRAKE/TAIL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO MALFUNCTIONING BRAKE/TAIL LAMP SOCKETS.ON MARCH 2, 2004, GM INITIATED A 6-YEAR/72,000 MILE SPECIAL POLICY FOR 989,487 SUBJECT VEHICLES TO INSPECT AND REPLACE THE REAR BRAKE/TAIL LAMP BULB SOCKET ASSEMBLIES.ON APRIL 4, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-032) BASED ON CONSUMER COMPLAINTS ALLEGING BRAKE LIGHTS NOT OPERATING WHEN THE BRAKE PEDAL IS DEPRESSED.ON AUGUST 3, 2004 ODI UPGRADED PE04-032 TO AN ENGINEERING ANALYSIS (EA04-021).BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V527) COVERING SUBJECT VEHICLES THAT WERE NOT ALREADY REPAIRED UNDER GM'S SPECIAL POLICY.MY 2004 SUBJECT VEHICLES BUILT AFTER AUGUST 8, 2003 CONTAIN IMPROVED BRAKE LAMP ASSEMBLIES AND ARE NOT INCLUDED IN THE RECALL.GM DEALERS WILL INSTALL THE IMPROVED BRAKE LAMP ASSEMBLY ON SUBJECT VEHICLES BUILT ON AUGUST 8, 2003 AND EARLIER.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE04001 · Fuel Spillage During Refueling
Opened Jan 5, 2004 · Closed May 7, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (2)
Fuel System, Gasoline:storage
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Illustration