NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
80 reportsClear category filter56,000 miles · Jan 24, 2015
Fuel System, Gasoline
NHTSA ACTION NUMBER : PE07014 OCCURRED ON MY VEHICLE AROUND NOVEMBER 2014. THE PROBLEM PRESENTED AS P0442 CEL AND ODOR OF GAS AFTER PARKING IN GARAGE. GM HAS INDICATED BECAUSE THE SPECIAL CONSIDERATION ALLOWANCE HAS EXPIRED, DESPITE THE LOW MILEAGE THEY WILL DO NOTHING. THIS VEHICLE WAS PURCHASED NEW IN AUGUST 2003. I DO…
Read full complaint
NHTSA ACTION NUMBER : PE07014 OCCURRED ON MY VEHICLE AROUND NOVEMBER 2014. THE PROBLEM PRESENTED AS P0442 CEL AND ODOR OF GAS AFTER PARKING IN GARAGE. GM HAS INDICATED BECAUSE THE SPECIAL CONSIDERATION ALLOWANCE HAS EXPIRED, DESPITE THE LOW MILEAGE THEY WILL DO NOTHING. THIS VEHICLE WAS PURCHASED NEW IN AUGUST 2003. I DO NOT UNDERSTAND WHY GM WAS NOT COMPELLED TO ISSUE A SAFETY RECALL DUE TO THE RISK OF GAS LEAKING. I WOULD APPRECIATE ASSISTANCE TO GET GM TO MINIMALLY PROVIDE DEFECTIVE PARTS REPLACEMENT, DUE TO THE KNOW MANUFACTURING DEFECT IN THE GAS TANK. *TR
NHTSA ODI #10678685
77,000 miles · Aug 2, 2014
Fuel System, Gasoline
SES LIGHT CAME ON. DEALERSHIP HAD NO APPS BROUGHT TO MECHANIC. CODE WAS FOR FUEL EMISSION LEAK. REPLACE GAS CAP. WEEK LATER CODE SES CAME ON AGAIN. BROUGHT BACK TO THE MECHANIC, SAID FUEL TANK IS CRACKED. CALLED CHEVY AND WAS TOLD THERE WAS A RECALL BUT NOT MY VIN..... *TR
NHTSA ODI #10618346
140,000 miles · Jun 23, 2014
Fuel System, GasolinePower Train
THERE IS A STRONG ODOR OF GASOLINE VAPORS COMING FROM THE REAR OF THE VEHICLE, A CRACK CAN BE SEEN IN THE NECK OF THE FUEL TANK. WHEN FILLING THE VEHICLE, FUEL SPILLS OUT OF THE TANK FROM THE CRACK. THE FUEL GAUGE CLUSTER IN THE DASH DOESN'T WORK. THE BLOWER ON THE A/C UNIT DOESN'T WORK ON THE HIGHEST (5) LEVEL. ALSO, THE FAN CL…
Read full complaint
THERE IS A STRONG ODOR OF GASOLINE VAPORS COMING FROM THE REAR OF THE VEHICLE, A CRACK CAN BE SEEN IN THE NECK OF THE FUEL TANK. WHEN FILLING THE VEHICLE, FUEL SPILLS OUT OF THE TANK FROM THE CRACK. THE FUEL GAUGE CLUSTER IN THE DASH DOESN'T WORK. THE BLOWER ON THE A/C UNIT DOESN'T WORK ON THE HIGHEST (5) LEVEL. ALSO, THE FAN CLUTCH WENT OUT CAUSING THE CAR TO OVERHEAT SEVERELY. THE FAN DOES NOT ENGAGE, CAUSING THE WATER PUMP SHAFT TO BECOME DAMAGED. ALSO, THE REAR DRIVER SIDE WINDOW QUIT FUNCTIONING, DESPITE BUYING AN EXPENSIVE NEW REGULATOR AND REPLACING IT. HAVING RESEARCHED THE ISSUES, I FIND THAT I AM AMONG HUNDREDS, POSSIBLY THOUSANDS OF UNSATISFIED PEOPLE WITH THE SAME PROBLEMS. *TR
NHTSA ODI #10605390
130,000 miles · Apr 18, 2014
Fuel System, Gasoline
WHERE THE GAS FILLER NECK CONNECTS TO THE GAD TANK THIS AREA DEVELOPS A CRACK ALLOWING GAS TO LEAK FROM THE VEHICLE AND DURING FILLING UP TO A COUPLE QUARTS OF GAS CAN RUN ONTO CEMENT BY THE PUMP, ALSO STRONG GAS SMELL IN THE GARAGE.. THIS ALSO TRIGGERS THE CHECK MOTOR LIGHT. ACCORDING TO INTERNET POSTINGS OTHER TRAIL BLAZER OWN…
Read full complaint
WHERE THE GAS FILLER NECK CONNECTS TO THE GAD TANK THIS AREA DEVELOPS A CRACK ALLOWING GAS TO LEAK FROM THE VEHICLE AND DURING FILLING UP TO A COUPLE QUARTS OF GAS CAN RUN ONTO CEMENT BY THE PUMP, ALSO STRONG GAS SMELL IN THE GARAGE.. THIS ALSO TRIGGERS THE CHECK MOTOR LIGHT. ACCORDING TO INTERNET POSTINGS OTHER TRAIL BLAZER OWNERS ARE EXPERIENCING THE SAME PROBLEM. *TR
NHTSA ODI #10583542
105,000 miles · Mar 26, 2014
Fuel System, Gasoline
THIS IS MY SECOND COMPLAINT DUE TO A SECOND PROBLEM WITH THE FUEL SYSTEM. VEHICLE WAS TAKEN TO DEALERSHIP FOR GAS LEAK, WHICH TURNED OUT TO BE CAUSED BY 2 DIFFERENT, WELL-KNOWN FUEL SYSTEM PROBLEMS. GM OFFERED NO SOLUTION TO EITHER PROBLEM BECAUSE I'M 3 MONTHS OUTSIDE OF THE EXTENDED WARRANTY. MY TOTAL BILL FOR BOTH LEAKS WAS $1…
Read full complaint
THIS IS MY SECOND COMPLAINT DUE TO A SECOND PROBLEM WITH THE FUEL SYSTEM. VEHICLE WAS TAKEN TO DEALERSHIP FOR GAS LEAK, WHICH TURNED OUT TO BE CAUSED BY 2 DIFFERENT, WELL-KNOWN FUEL SYSTEM PROBLEMS. GM OFFERED NO SOLUTION TO EITHER PROBLEM BECAUSE I'M 3 MONTHS OUTSIDE OF THE EXTENDED WARRANTY. MY TOTAL BILL FOR BOTH LEAKS WAS $1,500. BOTH LEAKS ARE KNOWN SAFETY PROBLEMS, AS REFERENCED IN BULLETINS 07099 AND 07076. I WAS TOLD THE VEHICLE SHOULD NOT BE DRIVEN BECAUSE OF THE LEAKS. GAS TANK REPLACEMENT IS NOT WHAT I CONSIDER NORMAL A MAINTENANCE ITEM. IT IS A KNOWN PROBLEM AND THESE TANKS NEED TO BE RECALLED. *TR
NHTSA ODI #10574973
105,000 miles · Mar 20, 2014
Fuel System, Gasoline
FUEL LEAK ON TOP OF FUEL TANK. THIS IS A KNOWN SAFETY ISSUE, AND AN EXTENDED SERVICE/WARRANTY WAS ADDED TO FIX THIS PROBLEM. THE DEALERSHIP SAID THE VEHICLE SHOULD NOT BE DRIVEN AS-IS. I DID NOT RECEIVE NOTICE OF THIS WARRANTY. GM REFUSES TO OFFER ANY MORE THAN A 10% DISCOUNT, EVEN THOUGH 3 MONTHS PRIOR THIS SAME DEFECT WOULD HA…
Read full complaint
FUEL LEAK ON TOP OF FUEL TANK. THIS IS A KNOWN SAFETY ISSUE, AND AN EXTENDED SERVICE/WARRANTY WAS ADDED TO FIX THIS PROBLEM. THE DEALERSHIP SAID THE VEHICLE SHOULD NOT BE DRIVEN AS-IS. I DID NOT RECEIVE NOTICE OF THIS WARRANTY. GM REFUSES TO OFFER ANY MORE THAN A 10% DISCOUNT, EVEN THOUGH 3 MONTHS PRIOR THIS SAME DEFECT WOULD HAVE BEEN FIXED AT NO COST UNDER THE SPECIAL WARRANTY COVERAGE. I WAS WILLING TO SPLIT THE COST 50/50, BUT NO OTHER OPTIONS WERE DEEMED ACCEPTABLE BY GM. MY VEHICLE IS UNDER THE 120,000 MILE CUTOFF AS SPECIFIED IN THE EXTENDED SERVICE, BUT 3 MONTHS OUT OF DATE. BEING THIS IS A KNOWN PROBLEM AND SEVERE FIRE HAZARD, I FEEL GM SHOULD OFFER A BETTER SOLUTION AND AT THE MINIMUM A REDUCED COST REPAIR. *TR
NHTSA ODI #10573836
135,000 miles · Feb 4, 2014
Fuel System, Gasoline
IN THE PAST 3 YEARS VEHICLE HAD GAS ODOR UPON EXITING VEHICLE UPON USE. UNTIL RECENTLY, FUEL STARTED LEAKING PROFUSELY WHEN VEHICLE WAS RUNNING. GENERAL MOTORS ISSUED EXTENDED WARRANTY DUE TO MANY COMPLAINTS REGARDING THIS ISSUE. WE BEING THE ORIGINAL OWNER OF THE VEHICLE WERE NEVER SENT ANY INFORMATION REGARDING THE EXTEN…
Read full complaint
IN THE PAST 3 YEARS VEHICLE HAD GAS ODOR UPON EXITING VEHICLE UPON USE. UNTIL RECENTLY, FUEL STARTED LEAKING PROFUSELY WHEN VEHICLE WAS RUNNING. GENERAL MOTORS ISSUED EXTENDED WARRANTY DUE TO MANY COMPLAINTS REGARDING THIS ISSUE. WE BEING THE ORIGINAL OWNER OF THE VEHICLE WERE NEVER SENT ANY INFORMATION REGARDING THE EXTENSION OF ANY FACTORY WARRANTY REGARDING THIS ISSUE. AFTER CONTACTING GENERAL MOTORS ABOUT THIS ISSUE, THEY STATED THAT THE VEHICLE IS BEYOND THE YEAR AND MILEAGE OF THE EXTENDED WARRANTY. IF WE WOULD OF BEEN NOTIFIED BY GM ABOUT THIS PROBLEM WITH LEAKING FUEL TANKS WE WOULD OF RESOLVED THIS ISSUE WHEN WE STARTED SMELLING THE FUMES A FEW YEARS BACK WHEN THE EXTENDED WARRANTY WOULD OF BEEN IN EFFECT. AFTER CONTACTING GM AND SPEAKING WITH A REPRESENTATIVE, THEY REFUSED TO HONOR THE WARRANTY. GM NEGLECTED TO CONTACT AND INFORM US OF ANY EXTENDED WARRANTY THAT APPLIED TO OUR VEHICLE REGARDING THIS ISSUE. WE FEEL THAT THIS PROBLEM WITH THE FUEL TANK IS A SAFETY ISSUE THAT COULD BE A POTENTIAL FIRE HAZARD CAUSING SERIOUS INJURY TO ANYONE INSIDE OR AROUND THE VEHICLE. WE ARE GOING TO FILE A WRITTEN COMPLAINT WITH GENERAL MOTORS. PLEASE LET ME KNOW HOW YOU FEEL ABOUT THIS SITUATION. THANK YOU. *TR
NHTSA ODI #10562856
185,000 miles · Jul 23, 2012
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER EXT. THE CONTACT STATED THERE WAS A MASSIVE FUEL LEAK COMING FROM UNDER THE VEHICLE. THE CONTACT NOTICED THE LEAK AS THE VEHICLE WAS IDLING. THE CONTACT TURNED THE VEHICLE OFF AND HAD IT TOWED TO THE DEALER. THE CONTACT STATED THAT THE VEHICLE WAS AT THE DEALER BUT HE HAD NOT SPO…
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER EXT. THE CONTACT STATED THERE WAS A MASSIVE FUEL LEAK COMING FROM UNDER THE VEHICLE. THE CONTACT NOTICED THE LEAK AS THE VEHICLE WAS IDLING. THE CONTACT TURNED THE VEHICLE OFF AND HAD IT TOWED TO THE DEALER. THE CONTACT STATED THAT THE VEHICLE WAS AT THE DEALER BUT HE HAD NOT SPOKEN WITH THE DEALER TO DETERMINE THE DIAGNOSIS OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED WHO ADVISED THAT WHEN THE DEALER INSPECTED THE VEHICLE, THEN THEY WOULD CONTACT HIM. THE CONTACT FILED A COMPLAINT WITH THE MANUFACTURER. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 185,000. THE CONSUMER STATED THE FUEL TANK, FUEL MOUNT, AND FUEL LINES WERE ALL REPLACED FOR $2000.00. IF THE VEHICLE HAD SET ON FIRE IT WOULD HAVE EXPLODED UNDER THE DRIVER'S SEAT. UPDATED 08/20/2012 *JS
NHTSA ODI #10466985
177,000 miles · Feb 5, 2012
Fuel System, Gasoline
HAD TO REPLACE FUEL TANK BECAUSE FILLER NECK CRACKED DUE TO BEING BRITTLE HAD TO REPLACE FUEL PUMP DUE TO TOP RUSTING OUT AND CAUSING A GAS LEAK I RECEIVED A LARGE BILL TO REPLACE THESE PARTS AND EXPECTED THEM TO LAST LONGER THEN 8 YEARS. *TR
NHTSA ODI #10446741
Mileage unknown · Dec 25, 2011
Electrical SystemFuel System, GasolineVehicle Speed Control
I, ALONG WITH MANY OTHERS ARE EXPERIENCING MAJOR PROBLEMS WITH THE INSTRUMENT PANELS ON OUR CHEVROLET TRAILBLAZER. MY MOTHER TRADED HERS IN BECAUSE HER SPEEDOMETER WAS GOING OUT. BUT MY PROBLEM IS MUCH WORSE, MY WHOLE ENTIRE DASHBOARD IS OUT. MY GAS GAUGE DOESN'T WORK, MY SPEEDOMETER DOESN'T WORK, MY OIL PRESSURE DOESN'T WORK, M…
Read full complaint
I, ALONG WITH MANY OTHERS ARE EXPERIENCING MAJOR PROBLEMS WITH THE INSTRUMENT PANELS ON OUR CHEVROLET TRAILBLAZER. MY MOTHER TRADED HERS IN BECAUSE HER SPEEDOMETER WAS GOING OUT. BUT MY PROBLEM IS MUCH WORSE, MY WHOLE ENTIRE DASHBOARD IS OUT. MY GAS GAUGE DOESN'T WORK, MY SPEEDOMETER DOESN'T WORK, MY OIL PRESSURE DOESN'T WORK, MY THERMOSTAT DOESN'T WORK, NOTHING WORKS. MY CRUISE CONTROL ACTS UP TOO. *TR
NHTSA ODI #10441192
Official recalls
3Oct 27, 2005
CERTAIN SPORT UTILITY VEHICLES HAVE A REAR SIDE CLOSURE LATCH THAT MAY NOT LATCH OR UNLATCH DUE TO CORROSION CAUSED BY ROAD SPLASH, SUCH AS WATER AND ROAD SALT. THESE VEHICLES WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA.
Consequence & remedy
Consequence: IF THE DOOR IS NOT LATCHED PROPERLY AND IT GOES UNNOTICED, IT MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN UNBELTED OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A SEAL ALONG THE LOWER PART OF THE ROCKER PANEL TO PREVENT INTRUSION OF CORROSIVE MATERIAL, AND INSPECT THE REAR SIDE CLOSURE LATCHES. FUNCTIONAL LATCHES WILL BE CLEANED AND LUBRICATED. NON-FUNCTIONING LATCHES WILL BE REPLACED. THE RECALL BEGAN ON FEBRUARY 24, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR ISUZU AT 1-800-255-6727.
Nov 1, 2004
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Consequence & remedy
Consequence: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.
Consequence & remedy
Consequence: DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
EA07009 · Fuel Pump Module Leaks Gasoline
Opened Jul 10, 2007 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
DURING THE COURSE OF THIS EA INVESTIGATION, ODI OBSERVED THAT THE MAJORITY OF THE COMPLAINTS (88%) AND WARRANTY CLAIMS (94%) WERE REPORTED FOR VEHICLES THAT ARE REGISTERED FOR USE IN THE SALT BELT REGION OF THE US.THIS AREA INCLUDES 20 STATES IN THE NORTHEAST, MID ATLANTIC AND THE MIDWEST REGIONS AND THE DISTRICT OF COLUMBIA.CONSUMERS IN THE SALT BELT REGION REPORTED TO ODI THAT THEY COULD SMELL FUEL VAPORS IN THEIR VEHICLES WHILE DRIVING.UPON FURTHER EXAMINATION OF THEIR VEHICLES, THEY DISCOVERED THAT FUEL VAPORS WERE COMING OUT OF THE TOP OF THE FUEL TANK. THIS CONDITION IS CAUSED BY CORROSION OF THE RETURN AND SENDER LINES OF THE FUEL PUMP MODULE.WATER AND ROAD SALT COLLECT ON TOP OF THE FUEL PUMP LEADING TO SMALL PINHOLES APPEARING ON THE FUEL LINES.FUEL MAY LEAK AND COLLECT ON TOP OF THE MODULE AND/OR SPILL ONTO THE GROUND.THE DATA EVALUATED UNDER THIS INVESTIGATION REFLECT A RELATIVELY LOW FREQUENCY OF OCCURRENCE THAT LARGELY ARISES IN SALT BELT STATES.GM HAS EXTENDED THE WARRANTY ON THE SUBJECT COMPONENT TO TEN YEARS OR 120,000 MILES.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SELECT DOCUMENT SEARCH.
PE07014 · Fuel Tank Leak
Opened Mar 13, 2007 · Closed Jun 12, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE07013 · Fuel Pump Module Leaks Gasoline
Opened Mar 12, 2007 · Closed Jul 10, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
ODI HAS RECEIVED REPORTS THAT THE FUEL PUMP MODULE LEAKS FUEL AND OR VAPOR UNDERNEATH THE VEHICLE.GM STATES, THE FAILURE MECHANISM IS CORROSION OF THE FUEL PUMP MODULE FLANGE WHICH MAY LEAD TO A FUEL LEAK.CORROSION OF THE FUEL PUMP MODULE FLANGE IS THE RESULT OF THE VEHICLE OPERATING IN A CORROSIVE ENVIRONMENT.ODI HAS UPGRADED THIS PE TO ENGINEERING ANALYSIS (EA07-009) TO FURTHER ASSESS THIS ISSUE.
EA04021 · Brake Lamp Failure
Opened Aug 3, 2004 · Closed Nov 4, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
GM STATES THAT SOME BRAKE/TAIL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO MALFUNCTIONING BRAKE/TAIL LAMP SOCKETS.ON MARCH 2, 2004, GM INITIATED A 6-YEAR/72,000 MILE SPECIAL POLICY FOR 989,487 SUBJECT VEHICLES TO INSPECT AND REPLACE THE REAR BRAKE/TAIL LAMP BULB SOCKET ASSEMBLIES.ON APRIL 4, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-032) BASED ON CONSUMER COMPLAINTS ALLEGING BRAKE LIGHTS NOT OPERATING WHEN THE BRAKE PEDAL IS DEPRESSED.ON AUGUST 3, 2004 ODI UPGRADED PE04-032 TO AN ENGINEERING ANALYSIS (EA04-021).BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V527) COVERING SUBJECT VEHICLES THAT WERE NOT ALREADY REPAIRED UNDER GM'S SPECIAL POLICY.MY 2004 SUBJECT VEHICLES BUILT AFTER AUGUST 8, 2003 CONTAIN IMPROVED BRAKE LAMP ASSEMBLIES AND ARE NOT INCLUDED IN THE RECALL.GM DEALERS WILL INSTALL THE IMPROVED BRAKE LAMP ASSEMBLY ON SUBJECT VEHICLES BUILT ON AUGUST 8, 2003 AND EARLIER.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE04001 · Fuel Spillage During Refueling
Opened Jan 5, 2004 · Closed May 7, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (2)
Fuel System, Gasoline:storage
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
THIS INVESTIGATION WAS OPENED ON THE MODEL YEAR (MY) 2003 CHEVROLET TRAILBLAZER.BASED ON GM'S INFORMATION REQUEST (IR) RESPONSE, ODI ADDED TO ITS ANALYSIS THE MY 2003 GMC ENVOY AND OLDSMOBILE BRAVADA VEHICLES.THESE VEHICLES SHARE THE SAME VEHICLE PLATFORM (GM 360/370) AND FUEL FILL COMPONENTS.INCIDENT SUMMARY NUMBERS REPORTED ABOVE INCLUDE THESE VEHICLES.EPA REGULATES THE FUEL DISPENSING RATES AT FILLING STATIONS AND GM STATES THAT THE REPORTS OF SPITBACK FOR THE SUBJECT VEHICLES ARE PRINCIPALLY CAUSED BY FUEL DISPENSING PUMPS EXCEEDING THE RATE SPECIFIED BY EPA.ODI FINDS THAT THE RATE OF COMPLAINTS, FIELD REPORTS AND WARRANTY IS LOW COMPARED TO OTHER VEHICLES THAT HAVE BEEN RECALLED FOR A SPITBACK ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Illustration