IllustrationCRACKED DASHBOARD. THE DASHBOARD IS CRACKED ON THE PASSENGER SIDE FROM THE AIRBAG TOWARDS THE WINDSHIELD AND ON THE DRIVERS SIDE STARTED AT THE SEAM AND IS CREEPING TOWARD THE STEERING WHEEL ABOVE THE SPEEDOMETER.
2011 Chevrolet Tahoe
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2011 Chevrolet Tahoe do not stand out strongly from the model-year median of 246.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tahoe years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
6025–50K
8550–75K
6175–100K
44100–150K
9150K+
274 reports with mileage · 172 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 185 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports2 fire reports3 injury reports
What owners actually said
446 reportsTL* THE CONTACT OWNS A 2011 CHEVROLET TAHOE. THE CONTACT STATED THAT THE PASSENGER SIDE DASHBOARD WAS CRACKED IN FOUR PLACES. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 130,403.
MY VEHICLE HAS A CRACKED DASH DIRECTLY ABOVE THE INSTRUMENT PANEL AND OVER TO THE PASSENGER SIDE AIRBAG. I HEARD A "POP" WHILE THE VEHICLE WAS IN MOTION ON HWY 41 IN KENNESAW, GA AND SPOTTED THE CRACK AFTER STOPPING TO INVESTIGATE.
A AIRBAG RECALL ISSUED MAY 27, 2016 AND RECORDS SHOW THERE IS STILL NOT A REMEDY FOR THIS RECALL
THE DASHBOARD HAS DEVELOPED A CRACK NEXT TO THE PASSENGER AIRBAG COVER. THIS IS A WIDESPREAD MANUFACTURER'S DEFECT FOR THIS TYPE OF GM VEHICLE. HOWEVER, GM REFUSES TO INSTATE A RECALL TO ADDRESS IT'S CUSTOMER'S CONCERNS. WITH THE PLASTIC OF THE DASHBOARD COMPROMISED, A DEPLOYMENT OF THE AIRBAG COULD SEND FRAGMENTS OF PLASTIC …
Read full complaint
THE DASHBOARD HAS DEVELOPED A CRACK NEXT TO THE PASSENGER AIRBAG COVER. THIS IS A WIDESPREAD MANUFACTURER'S DEFECT FOR THIS TYPE OF GM VEHICLE. HOWEVER, GM REFUSES TO INSTATE A RECALL TO ADDRESS IT'S CUSTOMER'S CONCERNS. WITH THE PLASTIC OF THE DASHBOARD COMPROMISED, A DEPLOYMENT OF THE AIRBAG COULD SEND FRAGMENTS OF PLASTIC INTO THE CABIN.
MY DASH CRACKED OUT OF THE BLUE ONE DAY ABOUT TWO WEEKS AGO. IT STARTED OUT AS TWO SMALL CRACKS ON EACH SIDE OF THE TOP CENTER VENT BY THE WINDSHIELD. I HAVE THE 2011 CHEVY TAHOE LTZ VERSION WITH A SPEAKER IN THE MIDDLE OF THE DASH. THE SPEAKER DOESN'T APPEAR TO HAVE ANY SUPPORT FOR THE WEIGHT OF THE SPEAKER AND THE DASH CRACKS …
Read full complaint
MY DASH CRACKED OUT OF THE BLUE ONE DAY ABOUT TWO WEEKS AGO. IT STARTED OUT AS TWO SMALL CRACKS ON EACH SIDE OF THE TOP CENTER VENT BY THE WINDSHIELD. I HAVE THE 2011 CHEVY TAHOE LTZ VERSION WITH A SPEAKER IN THE MIDDLE OF THE DASH. THE SPEAKER DOESN'T APPEAR TO HAVE ANY SUPPORT FOR THE WEIGHT OF THE SPEAKER AND THE DASH CRACKS HAVE NOW GROWN TOWARDS THE INSTRUMENT PANEL AND ALSO BY THE DRIVER SIDE AIRBAG. THE CRACKS ARE ON BOTH SIDES OF THE CENTER SPEAKER AND NOW THE SPEAKER JUST CONSTANTLY FLOPS UP AND DOWN WITH NORMAL DRIVING. THE FLOPPING SPEAKER WITH NO (SUPPORT) IS CAUSING THE CRACK TO GET WORSE AND WORSE. THE CRACKS ARE SPIDER WEBBING NOW AND GETTING MUCH LONGER EVERYDAY I DRIVE IT TO WORK. WHILE RESEARCHING WHAT TO DO ABOUT THIS ISSUE I DISCOVERED THAT SEVERAL THOUSAND COMPLAINTS HAVE BEEN MADE ABOUT MULTIPLE GM MODEL VEHICLES HAVING CRACKED DASH BOARDS BETWEEN THE YEARS OF 2007 AND 2014. THE DASH COVER OPTION BEING SUGGESTED TO HIDE THE CRACKS IS IN NO WAY A SAFE AND RELIABLE SOLUTION TO THIS ISSUE BECAUSE IT INTERFERES WITH THE MANUFACTURERS AIRBAG SAFETY DESIGN AND AND SPECIFIED ASSURED CLEARANCE FOR DEPLOYMENT. THE COVERS DO NOT ADHERE TO THE RATED SPECIFICATION OF THE AIR BAG. ANYONE WHO HAS EVER WORKED IN A PLANT WHERE THE AIR BAGS ARE MANUFACTURED KNOWS HOW PRECISE AND SPECIFIC THESE STRICT GUIDELINES AND SPECIFICATIONS ARE HELD TO.
TAKATA RECALL I RECEIVED A SAFETY RECALL NOTICE JULY 2016. RECENTLY WENT TO AIRBAGRECALL.COM SITE AND IT SAID "NO REMEDY AVAILABLE". WHAT SHOULD I DO NEXT? THANKS.
TAKATA RECALL- MY SERVICE AIRBAG LIGHT RECENTLY CAME ON SHORTLY AFTER STARTING THE VEHICLE. THIS IS THE SECOND TIME THIS PROBLEM HAS OCCURRED OVER THE PAST TWO SUMMERS. THE FIRST TIME THIS PROBLEM OCCURRED I BROUGHT MY VEHICLE TO THE DEALERSHIP WHERE THEY PREFORMED A AIRBAG SCAN. I WAS TOLD NO CODES WERE PRESENT. THE AIRBAG LIGH…
Read full complaint
TAKATA RECALL- MY SERVICE AIRBAG LIGHT RECENTLY CAME ON SHORTLY AFTER STARTING THE VEHICLE. THIS IS THE SECOND TIME THIS PROBLEM HAS OCCURRED OVER THE PAST TWO SUMMERS. THE FIRST TIME THIS PROBLEM OCCURRED I BROUGHT MY VEHICLE TO THE DEALERSHIP WHERE THEY PREFORMED A AIRBAG SCAN. I WAS TOLD NO CODES WERE PRESENT. THE AIRBAG LIGHT WAS THEN RESET AND I HAVEN'T HAD ANY ISSUES UNTIL RECENTLY. I HAVE READ ABOUT THE KNOWN POTENTIALLY DEADLY ISSUES ASSOCIATED WITH THE PASSENGER AIRBAG DEFLATORS. I LIVE IN HOUSTON TX WHERE THE SUMMERS HOT AND HUMID. I HAVE READ THAT THESE AREAS ARE AT GREATER RISK DUE TO ISSUES ARISING IN HOT AND HUMID CLIMATES. I PLAN ON BRINGING MY CAR BACK TO THE DEALERSHIP SOON. I'M SURE I WILL BE TOLD THAT SINCE THE RECALL IS PENDING I WILL BE RESPONSIBLE FOR PAYING FOR THE REPAIRS. I'M A FATHER OF TWO... DOES TAKATA WANT FAMILIES TO ROLE THE DICE WITH LOVED ONES LIVES WHILE PAPERWORK IS FILED OR PARTS BECOME AVAILABLE??? HOW MANY LIVES HAVE TO BE LOST BEFORE THERE IS A SOLUTION TO THIS RECALL?
TL* THE CONTACT OWNS A 2011 CHEVROLET TAHOE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. SMITH CHEVROLET CADILLAC (1601 AUTO MALL DR, TURLO…
Read full complaint
TL* THE CONTACT OWNS A 2011 CHEVROLET TAHOE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. SMITH CHEVROLET CADILLAC (1601 AUTO MALL DR, TURLOCK, CALIFORNIA 95382) WAS MADE AWARE OF THE FAILURE AND STATED THAT THE PARTS WERE UNAVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT STATED THAT THE AIR BAG INDICATOR ILLUMINATED WITHOUT WARNING, WHICH WAS A SAFETY CONCERN. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
" TAKATA'S RECALL" MY DEALERSHIP KEEPS TELLING ME MY GM 2011 CHEVROLET TAHOE IS NOT INCLUDED IN RECALL, BUT I'M REALLY SURE IT IS. THEY KEEP TELLING ME FOR YEARS NOW IT IS SAFE. I'M AFRAID TO DRIVE IT MUCH. CAN YOU TELL ME THE STATUS OF THIS SITUATION. THANKS, (XXXX) PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT …
Read full complaint
" TAKATA'S RECALL" MY DEALERSHIP KEEPS TELLING ME MY GM 2011 CHEVROLET TAHOE IS NOT INCLUDED IN RECALL, BUT I'M REALLY SURE IT IS. THEY KEEP TELLING ME FOR YEARS NOW IT IS SAFE. I'M AFRAID TO DRIVE IT MUCH. CAN YOU TELL ME THE STATUS OF THIS SITUATION. THANKS, (XXXX) PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Official recalls
521V050000 · Air Bags:frontal:passenger Side:inflator Module
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.
21V054000 · Air Bags:frontal:passenger Side:inflator Module
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.
14V827000 · Electrical System:ignition
Dec 30, 2014
General Motors LLC (GM) is recalling certain model year 2011-2012 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado HD, Silverado LD, Suburban, Tahoe, GMC Sierra LD, Sierra HD, Yukon, and Yukon XL vehicles. In the affected vehicles, the ignition lock actuator may bind, making turning the key difficult or causing the ignition to get stuck in the "Start" position.
Consequence & remedy
Consequence: If stuck in the "Start" position, the ignition may suddenly snap back into the "Accessory" position, causing a loss of engine, steering, and braking power, increasing the risk of a vehicle crash. If the vehicle is in a crash, the air bags may not deploy, increasing the risk of occupant injury.
Remedy: GM will notify owners, and dealers will inspect and replace the ignition lock housing, as necessary, free of charge. The recall began on February 12, 2015. Owners may contact GM customer service at 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14696 for the original equipment, and 14912 for the service replacement parts.
11V339000 · Steering:linkages
Jun 28, 2011
GM IS RECALLING CERTAIN MODEL YEAR 2011CADILLAC ESCALADE, ESCALADE ESV; CHEVROLET SILVERADO HD, SILVERADO LD, SUBURBAN, TAHOE; AND GMC SIERRA HD, SIERRA LD, YUKON, AND YUKON XL VEHICLES. THE INTERMEDIATE STEERING SHAFT ATTACHING BOLTS MAY NOT HAVE BEEN TIGHTENED TO THE PROPER SPECIFICATION.
Consequence & remedy
Consequence: THIS COULD ALLOW THE JOINTS TO SEPARATE, AND THE DRIVER COULD EXPERIENCE LOSS OF STEERING INCREASING THE RISK OF A CRASH.
Remedy: GM DEALERS WILL INSPECT AND ENSURE THAT THE INTERMEDIATE STEERING SHAFT BOLTS ARE TIGHTENED TO THE PROPER SPECIFICATION. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JULY 13, 2011. OWNERS MAY CONTACT CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.
11V007000 · Suspension:rear:axle:spindle
Jan 6, 2011
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, COLORADO, EXPRESS, SILVERADO, SUBURBAN, TAHOE; AND GMC CANYON, SIERRA, SAVANA, YUKON AND YUKON XL VEHICLES. THE REAR AXLE CROSS PINS WERE NOT PROPERLY HEAT TREATED AND COULD FRACTURE AND BECOME DISPLACED WITHIN THE REAR AXLE. SHOULD THE PIN SHIFT OUT OF POSITION, IT COULD CREATE AN INTERFERENCE CONDITION AND CAUSE THE REAR AXLE TO LOCK.
Consequence & remedy
Consequence: THE DRIVER MAY NOT BE ABLE TO MAINTAIN DIRECTIONAL CONTROL OF THE VEHICLE AND A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW REAR AXLE CROSS PIN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.