NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
314 reports56,639 miles · Mar 7, 2019
Air Bags
TL* TAKATA RECALL. THE CONTACT OWNS A 2010 CHEVROLET TAHOE. THE CONTACT NOTICED A CRACK ON THE DASHBOARD NEAR THE AIR BAG. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS); HOWEVER, THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMO…
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2010 CHEVROLET TAHOE. THE CONTACT NOTICED A CRACK ON THE DASHBOARD NEAR THE AIR BAG. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS); HOWEVER, THE PART NEEDED FOR THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED CHEVROLET OF STEVENS CREEK AT (408) 490-0013 (LOCATED AT 3640 STEVENS CREEK BLVD, SAN JOSE, CA 95117) AND WAS INFORMED THAT THE PART WAS NOT AVAILABLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED CASE NUMBER: 8-4829476714. THE APPROXIMATE FAILURE MILEAGE WAS 56,639. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #11184894
135,000 miles · Mar 6, 2019
Steering
VEHICLE LOSES POWER STEERING INTERMITTENTLY WHILE MAKING TURNS ON CITY STREETS
NHTSA ODI #11184519
Mileage unknown · Mar 1, 2019
Unknown Or OtherInjury
'TAKATA RECALL' IT'S BEEN A CONSISTENT DOWN FALL OF MY DASH AROUND MY AIR BAG. THEIR IS A GAPING HOLE ABOVE MY AIRBAG NOW. THE SERVICE GENTLEMAN AT AUTONATION STATED IF THE SHRAPNEL FROM THE AIR BAG DOES NOT GET YOU, YOUR DASH BOARD SHRAPNEL WILL! LAST JANUARY I SIMPLY WIPING MY DASH DOWN SLICED OPEN MY HAND REQUIRING STITCHES.…
Read full complaint
'TAKATA RECALL' IT'S BEEN A CONSISTENT DOWN FALL OF MY DASH AROUND MY AIR BAG. THEIR IS A GAPING HOLE ABOVE MY AIRBAG NOW. THE SERVICE GENTLEMAN AT AUTONATION STATED IF THE SHRAPNEL FROM THE AIR BAG DOES NOT GET YOU, YOUR DASH BOARD SHRAPNEL WILL! LAST JANUARY I SIMPLY WIPING MY DASH DOWN SLICED OPEN MY HAND REQUIRING STITCHES. I MADE A APPOINTMENT FOR MY AIRBAG REPLACEMENT THEY KNEW EXACTLY WHY I WAS DRIVING THERE TO DROP MY VEHICLE OFF BUT ONCE I ARRIVED I WAS TOLD THERE IS STILL NO PART AVAILABLE. THE TECHNICIANS ARE NOT ALLOWED TO DISARM THE ARM BAGS. IN MOTION THE ENTIRE DASH VIBRATES, THE SMALLEST BUMP CAUSED PIECES TO FALL OFF, GOING OVER RAILROAD TRACKS A CHUNK BROKE OFF AND HIT ME IN MY RIGHT EYE. I FEAR FOR THE SAFETY OF MY CHILDREN WHICH MY 4 YEAR OLD ALSO CUT THE SIDE OF HER ARM ON MY DASH. THE DATE BELOW IF AROUND WHEN I RECIEVED THE AIRBAG RECALL.
NHTSA ODI #11183333
86,168 miles · Feb 25, 2019
Unknown Or Other
MY DASH STARTED CRACKING SMALL AT FIRST, BUMPS AND VIBRATIONS WOULD INCREASE THE LENGTH AND SEVERITY OF THE CRACKS, ALL THE CLIPS BROKE OFF, SIMPLY WIPING THE DASH OFF WOULD BREAK CHUNKS OFF. IN 2017 WHILE CLEANING MY TAHOE I WAS WIPING THE DASH AND A SHARD CAUGHT THE SIDE OF MY HAND REQUIRING STITCHES. WHILE DRIVING THE DASH HA…
Read full complaint
MY DASH STARTED CRACKING SMALL AT FIRST, BUMPS AND VIBRATIONS WOULD INCREASE THE LENGTH AND SEVERITY OF THE CRACKS, ALL THE CLIPS BROKE OFF, SIMPLY WIPING THE DASH OFF WOULD BREAK CHUNKS OFF. IN 2017 WHILE CLEANING MY TAHOE I WAS WIPING THE DASH AND A SHARD CAUGHT THE SIDE OF MY HAND REQUIRING STITCHES. WHILE DRIVING THE DASH HAS NO SUPPORT AND VIBRATES. DEPENDING ON THE TYPE OF ROAD THE VIBRATIONS ARE STRONG ENOUGH TO BREAK CHUNKS OFF THE DASH OFF THAT FALL DOWN INTO THE CONSOLE. MY DASH IS BUSTED FROM THE DRIVERS SIDE ALL THE WAY TO THE PASSENGER SIDE. MY FEAR IS THAT A FRONT IMPACT CAR WRECK WILL TURN MY BRITTLE DASH INTO SHRAPNEL CAUSING INJURY TO FIVE KIDS, MYSELF AND MY HUSBAND. IT CONTINUOUSLY JUST GETS WORSE. I HAVE SAVED ALL THE PIECES THAT I FIND. IT'S HORRIBLE TO THINK THAT IF A SHARD CAN CUT MY DEEP ENOUGH TO REQUIRE STITCHES WHAT COULD THEY DO IN THE EVEN OF A WRECK?
NHTSA ODI #11182304
74,000 miles · Feb 18, 2019
Air Bags
I HAVE A CRACKED DASH NEAR THE PASSENGER AIR BAG, I'VE CONTACTED SEVERAL ENTITIES ABOUT THIS ISSUE AND WAS TOLD IT COULDN'T BE REPAIRED DUE TO PROXIMITY TO THE AIR BAG, I THEN SEARCHED ONLINE AND DISCOVERED THAT THERE IS A CLASS ACTION LAWSUIT AGAINST GM DUE TO FAULTY INTERIOR DASH, IF THIS IS A SAFETY ISSUE, UTMOST DEFINITEL…
Read full complaint
I HAVE A CRACKED DASH NEAR THE PASSENGER AIR BAG, I'VE CONTACTED SEVERAL ENTITIES ABOUT THIS ISSUE AND WAS TOLD IT COULDN'T BE REPAIRED DUE TO PROXIMITY TO THE AIR BAG, I THEN SEARCHED ONLINE AND DISCOVERED THAT THERE IS A CLASS ACTION LAWSUIT AGAINST GM DUE TO FAULTY INTERIOR DASH, IF THIS IS A SAFETY ISSUE, UTMOST DEFINITELY NEEDS TO BE CORRECTED.
NHTSA ODI #11180850
178,000 miles · Feb 8, 2019
Electronic Stability Control (esc)EngineUnknown Or Other
DRIVING DOWN HIGHWAY TRACTION CONTROL LIGHT, CHECK ENGINE LIGHT, STABILITRAX OFF, SERVICE STABILITRAX, ENGINE POWER REDUCED LIGHTS CAME ON. ENGINE ALSO IDLED ERRATICALLY AND WOULD TRY TO JUMP THE CAR FORWARD WHEN SLOWING DOWN TO A STOP. COULD TURN OFF CAR FOR A FEW MINS AND IT WOULD RESET AND TURN BACK ON AND DRIVE NORMAL FOR A …
Read full complaint
DRIVING DOWN HIGHWAY TRACTION CONTROL LIGHT, CHECK ENGINE LIGHT, STABILITRAX OFF, SERVICE STABILITRAX, ENGINE POWER REDUCED LIGHTS CAME ON. ENGINE ALSO IDLED ERRATICALLY AND WOULD TRY TO JUMP THE CAR FORWARD WHEN SLOWING DOWN TO A STOP. COULD TURN OFF CAR FOR A FEW MINS AND IT WOULD RESET AND TURN BACK ON AND DRIVE NORMAL FOR A FEW MILES WITH CHECK ENGINE LIGHT ON, THEN DO IT AGAIN. USED HEET BECAUSE THOUGHT IT WAS BAD FUEL BUT CONTINUED DOING IT.
NHTSA ODI #11175794
115,000 miles · Feb 5, 2019
Structure
DASH HAS MULTIPLE CRACKS
NHTSA ODI #11174590
31,000 miles · Jan 12, 2019
Unknown Or Other
THE DASH RIGHT BY THE INSTRUMENT CLUSTER ON THE DRIVERS SIDE CRACKED FOR NO APPARENT REASON OTHER THAN DEFECTIVE MATERIALS USED BY GM AFTER RESEARCHING THE PROBLEM . THE VEHICLE HAS 31000 MILES AND IS GARAGE KEPT 95 % OF THE TIME. I SPOKE TO MY LOCAL DEALER THEY HAVE NEVER HEARD OF THE PROBLEM SO THE COST WOULD BE ON ME TO REPL…
Read full complaint
THE DASH RIGHT BY THE INSTRUMENT CLUSTER ON THE DRIVERS SIDE CRACKED FOR NO APPARENT REASON OTHER THAN DEFECTIVE MATERIALS USED BY GM AFTER RESEARCHING THE PROBLEM . THE VEHICLE HAS 31000 MILES AND IS GARAGE KEPT 95 % OF THE TIME. I SPOKE TO MY LOCAL DEALER THEY HAVE NEVER HEARD OF THE PROBLEM SO THE COST WOULD BE ON ME TO REPLACE AT $1000.00....GM SHOULD FIX THESE AFTER ALL THE VEHICLE ONLY COST 54,000 NEW .
NHTSA ODI #11166644
Mileage unknown · Dec 20, 2018
Air Bags
TRIED TO GET TAKATA AIRBAGS REPLACED, AND DEALERSHIP REFUSES TO HELP.
NHTSA ODI #11162865
Mileage unknown · Dec 20, 2018
Electrical SystemStructureUnknown Or Other
AFTER HEAVY RAIN I NOTICED THAT BOTH OF MY BACK DOORS SOUNDED LIKE THERE WAS A GALLON OF WATER INSIDE OF THEM. I READ THAT THIS IS A VERY COMMON ISSUE! I CAN ONLY IMAGINE THE AMOUNT OF RUSTING HAPPENING INSIDE OF THERE AS WELL AS ELECTRICAL DAMAGE & RISKS OF HAVING WET SPEAKERS & WIRING INSIDE THE DOOR. UNACCEPTABLE. THIS SHOULD…
Read full complaint
AFTER HEAVY RAIN I NOTICED THAT BOTH OF MY BACK DOORS SOUNDED LIKE THERE WAS A GALLON OF WATER INSIDE OF THEM. I READ THAT THIS IS A VERY COMMON ISSUE! I CAN ONLY IMAGINE THE AMOUNT OF RUSTING HAPPENING INSIDE OF THERE AS WELL AS ELECTRICAL DAMAGE & RISKS OF HAVING WET SPEAKERS & WIRING INSIDE THE DOOR. UNACCEPTABLE. THIS SHOULD BE A RECALL.
NHTSA ODI #11162634
Official recalls
3Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2010 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2009 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 24, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328790.
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
DP15004 · Rollover Side Curtain Air Bags
Opened Jun 11, 2015 · Closed Mar 7, 2017
Status: closed (inferred from source dates) · Air Bags; Air Bags:side/window; Air Bags:side/window:curtain
In June 2015, the Office of Defects Investigation (ODI) opened this Defect Petition in response to a petition (see ODI 10568388) requesting a defect investigation of several alleged defects that can cause occupant ejections during rollover crashes in certain General Motors vehicles.The petition focused on a 2011 Texas crash involving a model year 2010 Chevrolet Tahoe, which allegedly resulted in multiple occupants to be ejected.One of the ejected occupants was fatally injured.In assessing the petitioner's request, ODI reviewed information from the petitioner, technical information related to rollover side curtain air bags from General Motors (note: ODI did not request GM's field incident data), NHTSA's prior testing and evaluation work related to FMVSS No. 226 Ejection Mitigation, and potentially relevant reports in the NHTSA complaint and crash databases.Based on the information available at the present time, NHTSA does not believe that a safety-related defect currently exists in the design of the rollover side curtain air bags in the model year 2010 Chevrolet Tahoe and other similarly designed Tahoe and Yukon vehicles.Therefore, the petition is denied.However, the agency will take further action if warranted by changing future circumstances.The official petition denial, as published in the Federal Register, is available in the document file for this petition.
Additional source detail variants (3)
Air Bags
In June 2015, the Office of Defects Investigation (ODI) opened this Defect Petition in response to a petition (see ODI 10568388) requesting a defect investigation of several alleged defects that can cause occupant ejections during rollover crashes in certain General Motors vehicles.The petition focused on a 2011 Texas crash involving a model year 2010 Chevrolet Tahoe, which allegedly resulted in multiple occupants to be ejected.One of the ejected occupants was fatally injured.In assessing the petitioner's request, ODI reviewed information from the petitioner, technical information related to rollover side curtain air bags from General Motors (note: ODI did not request GM's field incident data), NHTSA's prior testing and evaluation work related to FMVSS No. 226 Ejection Mitigation, and potentially relevant reports in the NHTSA complaint and crash databases.Based on the information available at the present time, NHTSA does not believe that a safety-related defect currently exists in the design of the rollover side curtain air bags in the model year 2010 Chevrolet Tahoe and other similarly designed Tahoe and Yukon vehicles.Therefore, the petition is denied.However, the agency will take further action if warranted by changing future circumstances.The official petition denial, as published in the Federal Register, is available in the document file for this petition.
Air Bags:side/window:curtain
In June 2015, the Office of Defects Investigation (ODI) opened this Defect Petition in response to a petition (see ODI 10568388) requesting a defect investigation of several alleged defects that can cause occupant ejections during rollover crashes in certain General Motors vehicles.The petition focused on a 2011 Texas crash involving a model year 2010 Chevrolet Tahoe, which allegedly resulted in multiple occupants to be ejected.One of the ejected occupants was fatally injured.In assessing the petitioner's request, ODI reviewed information from the petitioner, technical information related to rollover side curtain air bags from General Motors (note: ODI did not request GM's field incident data), NHTSA's prior testing and evaluation work related to FMVSS No. 226 Ejection Mitigation, and potentially relevant reports in the NHTSA complaint and crash databases.Based on the information available at the present time, NHTSA does not believe that a safety-related defect currently exists in the design of the rollover side curtain air bags in the model year 2010 Chevrolet Tahoe and other similarly designed Tahoe and Yukon vehicles.Therefore, the petition is denied.However, the agency will take further action if warranted by changing future circumstances.The official petition denial, as published in the Federal Register, is available in the document file for this petition.
Air Bags:side/window
In June 2015, the Office of Defects Investigation (ODI) opened this Defect Petition in response to a petition (see ODI 10568388) requesting a defect investigation of several alleged defects that can cause occupant ejections during rollover crashes in certain General Motors vehicles.The petition focused on a 2011 Texas crash involving a model year 2010 Chevrolet Tahoe, which allegedly resulted in multiple occupants to be ejected.One of the ejected occupants was fatally injured.In assessing the petitioner's request, ODI reviewed information from the petitioner, technical information related to rollover side curtain air bags from General Motors (note: ODI did not request GM's field incident data), NHTSA's prior testing and evaluation work related to FMVSS No. 226 Ejection Mitigation, and potentially relevant reports in the NHTSA complaint and crash databases.Based on the information available at the present time, NHTSA does not believe that a safety-related defect currently exists in the design of the rollover side curtain air bags in the model year 2010 Chevrolet Tahoe and other similarly designed Tahoe and Yukon vehicles.Therefore, the petition is denied.However, the agency will take further action if warranted by changing future circumstances.The official petition denial, as published in the Federal Register, is available in the document file for this petition.
Illustration