NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
115 reportsClear category filterMileage unknown · Feb 23, 2020
Air Bags
IN 2016 WE WERE NOTIFIED ABOUT A RECALL ON OUR 2010 CHEVY TAHOE. THE RECALL WAS FOR THE TAKATA AIR BAGS. WE WOULD RECEIVE MORE DETAILS ON HOW TO FIX THIS AND HAVE RECEIVED NOTHING TO DATE. I HAVE GONE TO THE DEALERSHIP A COUPLE TIMES AND THERE IS STILL NO FIX. THEY DON'T EVEN KNOW WHEN THAT WILL HAPPEN. IN MEANTIME, I AM …
Read full complaint
IN 2016 WE WERE NOTIFIED ABOUT A RECALL ON OUR 2010 CHEVY TAHOE. THE RECALL WAS FOR THE TAKATA AIR BAGS. WE WOULD RECEIVE MORE DETAILS ON HOW TO FIX THIS AND HAVE RECEIVED NOTHING TO DATE. I HAVE GONE TO THE DEALERSHIP A COUPLE TIMES AND THERE IS STILL NO FIX. THEY DON'T EVEN KNOW WHEN THAT WILL HAPPEN. IN MEANTIME, I AM TAKING CHANCES DRIVING OUR VEHICLE SHOULD A CRASH HAPPENS AND AIRBAGS DEPLOY.
NHTSA ODI #11310907
Mileage unknown · Jan 21, 2020
Air Bags
TL* THE CONTACT OWNS A 2010 CHEVROLET TAHOE. THE CONTACT RECEIVED A NOTIFICATION IN THE MAIL FOR A RECALL UNDER NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS). THE CONTACT SPOKE WITH O'RIELLY CHEVROLET (6160 E BROADWAY BLVD, TUCSON, AZ 85711 (520) 829-3876) WHERE HE WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL. THE…
Read full complaint
TL* THE CONTACT OWNS A 2010 CHEVROLET TAHOE. THE CONTACT RECEIVED A NOTIFICATION IN THE MAIL FOR A RECALL UNDER NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS). THE CONTACT SPOKE WITH O'RIELLY CHEVROLET (6160 E BROADWAY BLVD, TUCSON, AZ 85711 (520) 829-3876) WHERE HE WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL. THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE RECALL. A FAILURE HAD NOT OCCURRED ON THE VEHICLE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #11300795
Mileage unknown · Jan 10, 2020
Air Bags
TL* THE CONTACT OWNS A 2010 CHEVROLET TAHOE. THE CONTACT STATED THAT THE AIR BAG WARING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VEHICLE WAS INCLUDED TO NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS) BUT THE PART WAS NOT AVAILABLE FOR THE RECALL REPAIR. NEITHER THE DEALER NOR THE MANUFACTURER WERE CONT…
Read full complaint
TL* THE CONTACT OWNS A 2010 CHEVROLET TAHOE. THE CONTACT STATED THAT THE AIR BAG WARING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VEHICLE WAS INCLUDED TO NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS) BUT THE PART WAS NOT AVAILABLE FOR THE RECALL REPAIR. NEITHER THE DEALER NOR THE MANUFACTURER WERE CONTACTED OR MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #11298388
Mileage unknown · Nov 25, 2019
Air Bags
TL* TAKATA RECALL. THE CONTACT OWNS A 2010 CHEVROLET TAHOE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS). THE CONTACT STATED THAT ALAMO CITY CHEVROLET (LOCATED AT 9400 SAN PEDRO AVE, SAN ANTONIO, TEXAS 78216, (210) 987-2134) EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUF…
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2010 CHEVROLET TAHOE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS). THE CONTACT STATED THAT ALAMO CITY CHEVROLET (LOCATED AT 9400 SAN PEDRO AVE, SAN ANTONIO, TEXAS 78216, (210) 987-2134) EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE PART WAS NOT AVAILABLE FOR THE REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #11282287
Mileage unknown · Oct 17, 2019
Air BagsUnknown Or Other
I PURCHASED MY 2010 IN 2011 AND THE DASH CRACKED IN 2012. I HAVE TAKEN IT TO MY LOCAL CHEVY DEALER TWICE AND CHEVY WILL STILL NOT ACCEPT RESPONSIBILITY FOR ITS POOR QUALITY AND MANUFACTURING. A VEHICLE THAT IS ONLY TWO YEARS OLD AND HAD NEVER BEEN INVOLVED IN AN ACCIDENT SHOULD NOT HAVE COSMETIC DAMAGE. THIS IS DEFINITELY A MANU…
Read full complaint
I PURCHASED MY 2010 IN 2011 AND THE DASH CRACKED IN 2012. I HAVE TAKEN IT TO MY LOCAL CHEVY DEALER TWICE AND CHEVY WILL STILL NOT ACCEPT RESPONSIBILITY FOR ITS POOR QUALITY AND MANUFACTURING. A VEHICLE THAT IS ONLY TWO YEARS OLD AND HAD NEVER BEEN INVOLVED IN AN ACCIDENT SHOULD NOT HAVE COSMETIC DAMAGE. THIS IS DEFINITELY A MANUFACTURERS PROBLEM AND SHOULD BE REPLACED BY THE COMPANY. MY TRUCK WAS WORTH 48,000 AT THE TIME AND I SHOULD NOT BE RESPONSIBLE FOR A REPAIR CAUSED BY POOR QUALITY OF THEIR MATERIALS. NOW MY VEHICLE IS 9 YEARS OLD AND THE AIR BAGS DEPLOYED OUT OF NOWHERE WHEN MY SON WAS DRIVING.... THERE WAS NO WRECK OR IMPACT WITH ANYTHING AND THEY DEPLOYED. THE QUALITY USED BY CHEVY IS TERRIBLE AND I DO NOT PLAN ON PURCHASING ANYTHING ELSE FROM A COMPANY THAT SELLS OVER PRICED VEHICLES WITH CHEAP AND FAULTY PARTS THAT THEY DON'T WANT TO ASSUME RESPONSIBILITY FOR.
NHTSA ODI #11269285
100,000 miles · Sep 20, 2019
Air BagsStructure
TL* THE CONTACT OWNS A 2010 CHEVROLET TAHOE. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS) EXCEEDED A REASONABLE AMOUNT OF TIME FOR REPAIR. THE CONTACT RECEIVED THE RECALL NOTIFICATION IN MAY OF 2015. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT TO PARK THE VEHICLE AND WAIT FOR THE PART TO BECOME …
Read full complaint
TL* THE CONTACT OWNS A 2010 CHEVROLET TAHOE. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS) EXCEEDED A REASONABLE AMOUNT OF TIME FOR REPAIR. THE CONTACT RECEIVED THE RECALL NOTIFICATION IN MAY OF 2015. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT TO PARK THE VEHICLE AND WAIT FOR THE PART TO BECOME AVAILABLE. THE CONTACT STATED THAT THE DASHBOARD WAS FRACTURED NEAR THE DRIVER AND PASSENGER AIR BAG AREAS. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 100,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #11256952
Mileage unknown · Sep 17, 2019
Air Bags
TL* TAKATA RECALL. THE CONTACT OWNS A 2010 CHEVROLET TAHOE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED MALCOLM CUNNINGHAM CHEVROLET (LOCATED AT 2175 MANSELL ROAD, ALPHARET…
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2010 CHEVROLET TAHOE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED MALCOLM CUNNINGHAM CHEVROLET (LOCATED AT 2175 MANSELL ROAD, ALPHARETTA, GA 30009, 706-508-4710) AND WAS INFORMED THAT GM HAD NOT PROVIDED A REMEDY. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #11256218
Mileage unknown · Sep 9, 2019
Air Bags
TL* THE CONTACT OWNS A 2010 CHEVROLET TAHOE. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS). WHEN THE CONTACT INITIALLY RECEIVED THE NOTICE, SHE CONTACTED WESTSIDE CHEVROLET (23001 KATY FWY, KATY, TX 77450, 281-394-1894) AND WAS INFORMED THAT THE PART WAS NOT AVAILABLE. THE MANUFACTURER WAS …
Read full complaint
TL* THE CONTACT OWNS A 2010 CHEVROLET TAHOE. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS). WHEN THE CONTACT INITIALLY RECEIVED THE NOTICE, SHE CONTACTED WESTSIDE CHEVROLET (23001 KATY FWY, KATY, TX 77450, 281-394-1894) AND WAS INFORMED THAT THE PART WAS NOT AVAILABLE. THE MANUFACTURER WAS CONTACTED AND STATED THAT THEY WERE CURRENTLY IN LITIGATION. THE VEHICLE WAS NOT REPAIRED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #11254151
Mileage unknown · Aug 20, 2019
Air Bags
TL* THE CONTACT OWNS A 2010 CHEVROLET TAHOE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS). THE PART FOR THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE…
Read full complaint
TL* THE CONTACT OWNS A 2010 CHEVROLET TAHOE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS). THE PART FOR THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND STATED THAT THE PART WAS NOT AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #11245346
185,000 miles · Apr 26, 2019
Air BagsSeats
DASH IS COMPLETELY CRACKED ABOVE THE AIRBAG WHICH COULD BE A SAFETY HAZARD OF FLYING DEBRIS IF THE AIRBAG SHOULD DEPLOY. ALSO THE MIDDLE BENCH SEAT 60 SIDE RANDOMLY CLOSES WHICH IS A HUGE HAZARD AS MY CHILDREN RIDE BACK THERE
NHTSA ODI #11204048
Official recalls
3Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2010 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2009 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 24, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328790.
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
DP15004 · Rollover Side Curtain Air Bags
Opened Jun 11, 2015 · Closed Mar 7, 2017
Status: closed (inferred from source dates) · Air Bags; Air Bags:side/window; Air Bags:side/window:curtain
In June 2015, the Office of Defects Investigation (ODI) opened this Defect Petition in response to a petition (see ODI 10568388) requesting a defect investigation of several alleged defects that can cause occupant ejections during rollover crashes in certain General Motors vehicles.The petition focused on a 2011 Texas crash involving a model year 2010 Chevrolet Tahoe, which allegedly resulted in multiple occupants to be ejected.One of the ejected occupants was fatally injured.In assessing the petitioner's request, ODI reviewed information from the petitioner, technical information related to rollover side curtain air bags from General Motors (note: ODI did not request GM's field incident data), NHTSA's prior testing and evaluation work related to FMVSS No. 226 Ejection Mitigation, and potentially relevant reports in the NHTSA complaint and crash databases.Based on the information available at the present time, NHTSA does not believe that a safety-related defect currently exists in the design of the rollover side curtain air bags in the model year 2010 Chevrolet Tahoe and other similarly designed Tahoe and Yukon vehicles.Therefore, the petition is denied.However, the agency will take further action if warranted by changing future circumstances.The official petition denial, as published in the Federal Register, is available in the document file for this petition.
Additional source detail variants (3)
Air Bags
In June 2015, the Office of Defects Investigation (ODI) opened this Defect Petition in response to a petition (see ODI 10568388) requesting a defect investigation of several alleged defects that can cause occupant ejections during rollover crashes in certain General Motors vehicles.The petition focused on a 2011 Texas crash involving a model year 2010 Chevrolet Tahoe, which allegedly resulted in multiple occupants to be ejected.One of the ejected occupants was fatally injured.In assessing the petitioner's request, ODI reviewed information from the petitioner, technical information related to rollover side curtain air bags from General Motors (note: ODI did not request GM's field incident data), NHTSA's prior testing and evaluation work related to FMVSS No. 226 Ejection Mitigation, and potentially relevant reports in the NHTSA complaint and crash databases.Based on the information available at the present time, NHTSA does not believe that a safety-related defect currently exists in the design of the rollover side curtain air bags in the model year 2010 Chevrolet Tahoe and other similarly designed Tahoe and Yukon vehicles.Therefore, the petition is denied.However, the agency will take further action if warranted by changing future circumstances.The official petition denial, as published in the Federal Register, is available in the document file for this petition.
Air Bags:side/window:curtain
In June 2015, the Office of Defects Investigation (ODI) opened this Defect Petition in response to a petition (see ODI 10568388) requesting a defect investigation of several alleged defects that can cause occupant ejections during rollover crashes in certain General Motors vehicles.The petition focused on a 2011 Texas crash involving a model year 2010 Chevrolet Tahoe, which allegedly resulted in multiple occupants to be ejected.One of the ejected occupants was fatally injured.In assessing the petitioner's request, ODI reviewed information from the petitioner, technical information related to rollover side curtain air bags from General Motors (note: ODI did not request GM's field incident data), NHTSA's prior testing and evaluation work related to FMVSS No. 226 Ejection Mitigation, and potentially relevant reports in the NHTSA complaint and crash databases.Based on the information available at the present time, NHTSA does not believe that a safety-related defect currently exists in the design of the rollover side curtain air bags in the model year 2010 Chevrolet Tahoe and other similarly designed Tahoe and Yukon vehicles.Therefore, the petition is denied.However, the agency will take further action if warranted by changing future circumstances.The official petition denial, as published in the Federal Register, is available in the document file for this petition.
Air Bags:side/window
In June 2015, the Office of Defects Investigation (ODI) opened this Defect Petition in response to a petition (see ODI 10568388) requesting a defect investigation of several alleged defects that can cause occupant ejections during rollover crashes in certain General Motors vehicles.The petition focused on a 2011 Texas crash involving a model year 2010 Chevrolet Tahoe, which allegedly resulted in multiple occupants to be ejected.One of the ejected occupants was fatally injured.In assessing the petitioner's request, ODI reviewed information from the petitioner, technical information related to rollover side curtain air bags from General Motors (note: ODI did not request GM's field incident data), NHTSA's prior testing and evaluation work related to FMVSS No. 226 Ejection Mitigation, and potentially relevant reports in the NHTSA complaint and crash databases.Based on the information available at the present time, NHTSA does not believe that a safety-related defect currently exists in the design of the rollover side curtain air bags in the model year 2010 Chevrolet Tahoe and other similarly designed Tahoe and Yukon vehicles.Therefore, the petition is denied.However, the agency will take further action if warranted by changing future circumstances.The official petition denial, as published in the Federal Register, is available in the document file for this petition.
Illustration