Illustration1. NORMAL DAILY DRIVING 2. THE SPEEDOMETER STOPPED WORKING AS DID THE TACHOMETER, BATTERY GAUGE AND OIL PRESSURE GAUGE. 3. NOTHING WAS DONE. NOT A RECALL NOT UNDER WARRANTY. *TR
2004 Chevrolet Tahoe
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Chevrolet Tahoe do not stand out strongly from the model-year median of 246.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tahoe years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
370–25K
7425–50K
9450–75K
6875–100K
79100–150K
36150K+
388 reports with mileage · 79 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 214 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports7 fire reports14 injury reports
Electrical System complaints
214 reportsSPEEDOMETER DOES NOT INDICATE CORRECT SPEED. SPEEDOMETER DOES NOT RETURN TO ZERO MPH WHEN VEHICLE STOPPED. SPEEDOMETER IS INTERMITTENT. *TR
THE VOLTAGE METER BOTTOMED OUT WHILE DRIVING BACK IN 2008. IT ALTERNATED BETWEEN REGISTERING CORRECTLY AND THEN INCORRECTLY UNTIL DEC 2009 WHEN IT BOTTOMED OUT AND STAYED. I HAVE NO IDEA WHAT STATE MY BATTERY IS IN BECAUSE OF THIS. I'VE HAD IT CHECKED OUT TWICE BY THE DEALER. THE FIRST TIME, IN DEC 2008, THE METER WORKED JUS…
Read full complaint
THE VOLTAGE METER BOTTOMED OUT WHILE DRIVING BACK IN 2008. IT ALTERNATED BETWEEN REGISTERING CORRECTLY AND THEN INCORRECTLY UNTIL DEC 2009 WHEN IT BOTTOMED OUT AND STAYED. I HAVE NO IDEA WHAT STATE MY BATTERY IS IN BECAUSE OF THIS. I'VE HAD IT CHECKED OUT TWICE BY THE DEALER. THE FIRST TIME, IN DEC 2008, THE METER WORKED JUST FINE AND THE REPAIRMAN COULD NOT GET IT TO BOTTOM OUT DURING AN 18 MILE TEST DRIVE. THE NEXT DAY, IT DROPPED BELOW THE LAST READING POSSIBLE ON THE GAUGE AND I DROVE IT RIGHT BACK TO THE DEALER. THEY TOLD ME THAT THE ENTIRE INSTRUMENT PANEL WOULD NEED TO BE REPLACED. THE TAHOE HAD OVER 100,000 MILES ON IT SO IT WOULD NOT HAVE QUALIFIED FOR THE PROPOSED CLASS ACTION SETTLEMENT FILED BACK IN 2008. *TR
ON THIS DATE THE SPEEDOMETER AND BATTERY GAUGE BEGAN TO GO HAYWIRE, AT FIRST THEY BEGAN TO JUMP UP SO IT LOOKED LIKE I WAS DRIVING FASTER THEN I WAS DOWN THE INTERSTATE. THE NEXT DAY WHEN I DROVE MY TAHOE THE SPEEDOMETER KEPT GETTING HIGHER AND HAS MAXED OUT OVER 120 MPH, AND THE BATTERY METER WELL OVER 19 VOLTS AND THEY DO NOT…
Read full complaint
ON THIS DATE THE SPEEDOMETER AND BATTERY GAUGE BEGAN TO GO HAYWIRE, AT FIRST THEY BEGAN TO JUMP UP SO IT LOOKED LIKE I WAS DRIVING FASTER THEN I WAS DOWN THE INTERSTATE. THE NEXT DAY WHEN I DROVE MY TAHOE THE SPEEDOMETER KEPT GETTING HIGHER AND HAS MAXED OUT OVER 120 MPH, AND THE BATTERY METER WELL OVER 19 VOLTS AND THEY DO NOT MOVE ANYMORE. I NOW HAVE TO RELY ON A PORTABLE GPS IN MY CAR TO ESTIMATE HOW FAST I AM TRAVELING. I SEE THERE WAS A CLASS ACTION LAWSUIT ON THIS, BUT I AM 3,000 MILES OVER THE 80,000 REQUIRED TO GET A REPLACEMENT GAUGE CLUSTER. *TR
1. SPEEDOMETER STOPPED WORKING ON A 2004 TAHOE. 2. OCCURS - PERMANENTLY BROKEN. 3. ACTION TO CORRECT FAILURE IS NOTHING AT THIS POINT. SPEEDOMETER FAILURE OCCURRED AT APPROXIMATELY 42K MILES. *TR
2004 CHEVROLET TAHOE. SPEEDOMETER FAILURE AT AROUND 80,000 MILES. I'VE BEEN RUNNING ON THE SPEED INDICATOR OF MY GPS FOR THE LAST 20,000 MILES. SPEEDOMETER FAILURES, DUE TO FAULTY EQUIPMENT, SHOULD BE REPAIRED IN A RECALL BY THE MANUFACTURER. THE "SILENT" RECALL ISSUED IN 2007 NEVER MADE IT TO ME AND IT WAS ONLY FOR CARS UND…
Read full complaint
2004 CHEVROLET TAHOE. SPEEDOMETER FAILURE AT AROUND 80,000 MILES. I'VE BEEN RUNNING ON THE SPEED INDICATOR OF MY GPS FOR THE LAST 20,000 MILES. SPEEDOMETER FAILURES, DUE TO FAULTY EQUIPMENT, SHOULD BE REPAIRED IN A RECALL BY THE MANUFACTURER. THE "SILENT" RECALL ISSUED IN 2007 NEVER MADE IT TO ME AND IT WAS ONLY FOR CARS UNDER 70,000 MILES. SPEEDOMETERS ARE "SAFETY" EQUIPMENT. THEY SHOULDN'T FAIL AS OFTEN AS THE 2004 MODEL YEAR GENERAL MOTORS VEHICLES ARE FAILING. THERE ARE WAY TOO MANY PEOPLE HAVING TO SPEND FOUR-HUNDRED TO SIX-HUNDRED DOLLARS ON A REPAIR THAT SHOULD BE GENERAL MOTORS RESPONSIBILITY. *TR
2004 CHEVROLET TAHOE INSTRUMENT PANEL . OIL,TEMPERATURE,SPEED VOLTS GAUGES FAIL. *TR
2004 CHEVORLET TAHOE SPEEDOMETER BEGAN TO SHOW THAT THE SPEED WAS TO SLOW THAN I WAS GOING. NOW ITS SHOWING I AM GOING FASTER THAN I AM. TONIGHT MY SPEEDOMETER IS STUCK ON 0 MPH. *TR
2004 CHEVY TAHOE ELECTRICAL SYSTEM: INSTRUMENT PANEL. *TR
THE SPEEDOMETER ON MY 2004 TAHOE DOES NOT GIVE ACCURATE SPEED READINGS. IT SAID I WAS DOING 62 MILES AN HOUR ON THE HIGHWAY AND I STARTED PASSING EVERY CAR ON THE ROAD. I SLOWED DOWN AND THEN IT NEVER GOT ABOVE 15 MILES AN HOUR AND I WAS ON THE HIGHWAY. AFTER SHUTTING OFF THE TAHOE FOR A FEW MINUTES IT WORKED AGAIN. THIS HAP…
Read full complaint
THE SPEEDOMETER ON MY 2004 TAHOE DOES NOT GIVE ACCURATE SPEED READINGS. IT SAID I WAS DOING 62 MILES AN HOUR ON THE HIGHWAY AND I STARTED PASSING EVERY CAR ON THE ROAD. I SLOWED DOWN AND THEN IT NEVER GOT ABOVE 15 MILES AN HOUR AND I WAS ON THE HIGHWAY. AFTER SHUTTING OFF THE TAHOE FOR A FEW MINUTES IT WORKED AGAIN. THIS HAPPENS REGULARLY IF I DRIVE THE CAR FOR MORE THAN ABOUT 30 MINUTES AT A TIME. *TR
Official recalls
205V163000 · Seat Belts:rear/other
Apr 22, 2005
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
04V045000 · Service Brakes, Hydraulic
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence & remedy
Consequence: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Remedy: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.