IllustrationTHE PIECE BROKE OFF THE BOTTEM LATCH TO THE FRAME ON THE SEAT FOR THE 3RD ROW SEATING AND SOMETIMES THE SEATBELT WANT LATCH IN BACK SEAT. DASHBOARD GAUGE LIGHTS BLOWN ALOT OF INSIDE GAGE LIGHTS ARE NOT WORKING AND HEATER/AIR STOPPED WORKING ON NUMBER 5 FAN.
2003 Chevrolet Tahoe
Owner reports · Recalls · Investigations
More warning signs than most Tahoe years
Owner complaints for the 2003 Chevrolet Tahoe are substantially higher than the model-year median of 246.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tahoe years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
590–25K
5825–50K
8850–75K
7375–100K
89100–150K
41150K+
408 reports with mileage · 99 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 193 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports9 fire reports13 injury reports
What owners actually said
507 reportsEXITING FROM THE EXPRESSWAY WITH TRAFFIC LIGHT ABOUT 20 YARDS AWAY, CARS WERE STOPED DUE TO RED LIGHT AND I AM COMING DOWN HILL EXITING. APPLYING THE BREAKS AND THE PADDLE GOES TO THE FLOOR, I REAR ENDED THE VEHICLE ON THE FAR RIGHT .
MY AIR BAG LIGHTS ARE ALWAYS AND 4WD LIGHTS ARE I TOOK MY TRUCK TO A TRANSMISSION SPECIALIST THEY REPLACE THE TRANSFER CASE FOR THE 4WD BUT LIGHT REMAIN ON AND I STIIL FEEL THE SHIFT FROM 2-4 I TOOK IT BACK TO THE SPECIALIST AGAIN AND AGAIN STILL THE SAME PROBLEM
TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. THE CONTACT STATED AFTER THE TIRE BLEW THEY MOVED THE VEHICLE TO THE SIDE OF THE ROAD AND ATTEMPTED TO DETACHED THE SPARE TIRE, HOWEVER IT DID NOT DETACH. THE CONTACT STATED THAT THE INSTRUCTIONS STATED THAT IF THE SPARE TIRE DID NOT DETACH THE LATCH MECHANISM WAS IN SAFETY MODE. THE …
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. THE CONTACT STATED AFTER THE TIRE BLEW THEY MOVED THE VEHICLE TO THE SIDE OF THE ROAD AND ATTEMPTED TO DETACHED THE SPARE TIRE, HOWEVER IT DID NOT DETACH. THE CONTACT STATED THAT THE INSTRUCTIONS STATED THAT IF THE SPARE TIRE DID NOT DETACH THE LATCH MECHANISM WAS IN SAFETY MODE. THE CONTACT CALLED A TOW DRIVER AND THEY ATTEMPTED TO REMOVE THE SPARE PER GMC OWNERS MANUAL INSTRUCTIONS HOWEVER, THEY COULD NOT REMOVE THE TIRE. THE TOW DRIVER CALLED ANOTHER TOW TRUCK DRIVER, THEY CUT THE LATCH MECHANISM OFF THE VEHICLE, AND THE TIRE WAS LOWERED. THE CONTACT STATED THAT THEY WERE ON THE SIDE OF THE ROAD APPROXIMATELY THREE HOURS ATTEMPTING TO CHANGE THE SPARE TIRE. THE VEHICLE WAS TAKEN TO TIRE SHOP WHERE IT WAS DIAGNOSED THAT DUE TO THE SALT ON THE ROAD THE LATCH CORRODED. RYAN CHEVROLET LOCATED 911 HWY 55 BUFFALO, MN WAS CONTACTED AND THE TECHNICIAN ALSO INFORMED THE CONTACT DUE TO THE STATE THEY WERE LOCATED IN IT WAS AN INHERENT FAILURE WITH THE VEHICLE. THE MANUFACTURER WAS NOTIFIED HOWEVER NO FURTHER ASSISTANCE WAS OFFERED. THE CONTACT STATED IT WAS NOT STATED IN THE OWNERS MANUAL THAT THE LATCH NEEDED TO BE CUT AND THE SITUATIONAL FAILURE SHOULD BE REFLECTED IN THE MANUAL. THE FAILURE MILEAGE WAS APPROXIMATELY 285,000. *TT CONSUMER STATED WHEEL BLOCKS, ONLY MADE THE VEHICLE LESS STABLE AFTER IT WAS LIFTED UP BY THE SPARE TIRE, BALANCING ACT. DESIGN PROBLEM UPDATED 10/1/18*JB
TAMARA RECALLS
I BROUGHT IN MY 2003 CHEVROLET TAHOE TO CUTTER CHEVROLET IN HONOLULU, HAWAII TO REPORT AN "ENGINE LIGHT ON" CONCERN. SERVICE ADVISOR JULIANNA PARKS REPORTED THAT THE ISSUE MAY BE ATTRIBUTE TO (2) BROKEN EXHAUST BOLTS ON MY VEHICLE'S 5.3 LITER MFI IRON V8 ENGINE. CUTTER CHEVROLET IS AT 711 ALA MOANA BOULEVARD, HONOLULU, HI 96…
Read full complaint
I BROUGHT IN MY 2003 CHEVROLET TAHOE TO CUTTER CHEVROLET IN HONOLULU, HAWAII TO REPORT AN "ENGINE LIGHT ON" CONCERN. SERVICE ADVISOR JULIANNA PARKS REPORTED THAT THE ISSUE MAY BE ATTRIBUTE TO (2) BROKEN EXHAUST BOLTS ON MY VEHICLE'S 5.3 LITER MFI IRON V8 ENGINE. CUTTER CHEVROLET IS AT 711 ALA MOANA BOULEVARD, HONOLULU, HI 96813. IN FOLLOWING UP TODAY OCTOBER 18, 2017, SHOP MANAGER BRAD EISEN REPORTED THAT THESE BOLTS BREAKING IS NOT A COMMON PROBLEM, AND THAT THERE IS NO RECALL FOR SUCH ISSUES. CUTTER CHEVROLET HAS HAD MY VEHICLE SINCE OCTOBER 01, 2017 AND REPORTED THAT IN ADDITION TO MY $500+ INSPECTION COSTS, THAT MY COSTS FOR REPAIR THUS FAR HAS EXCEEDED $1,400.00 IN THEIR ATTEMPTS TO REPAIR THESE BROKEN BOLTS, AND THAT THEY EXPECT THE FINAL COST TO BE MUCH HIGHER BY THE TIME THEY ARE DONE AS THEY HAVE TO CONTRACT A SPECIALIST MECHANIC FROM ANOTHER TOWN TO COME INTO THE CUTTER CHEVROLET REPAIR SHOP THIS COMING SATURDAY OCTOBER 21, 2017 TO MEET WITH MANAGER MS. TINA TO DO SPECIAL WORK TO REMOVE THESE BROKEN BOLTS. THIS IS RIPOFF BY GM TO HAVE SUCH SUB-QUALITY EXHAUST MANIFOLD BOLTS BREAKING OFF. HELP!!!! GM NEEDS TO DO A RECALL ON THIS!
TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. WHILE DRIVING DOWN AN INCLINE AT APPROXIMATELY 10 MPH, THE BRAKES FAILED AND THE VEHICLE ACCELERATED TO APPROXIMATELY 30 MPH. THE VEHICLE STOPPED AT THE END OF THE ROAD ON A FLAT AREA ON ITS OWN. THE CONTACT ALSO STATED THAT THE BRAKE PADS, ROTORS, AND MASTER CYLINDER WERE REPLACED …
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. WHILE DRIVING DOWN AN INCLINE AT APPROXIMATELY 10 MPH, THE BRAKES FAILED AND THE VEHICLE ACCELERATED TO APPROXIMATELY 30 MPH. THE VEHICLE STOPPED AT THE END OF THE ROAD ON A FLAT AREA ON ITS OWN. THE CONTACT ALSO STATED THAT THE BRAKE PADS, ROTORS, AND MASTER CYLINDER WERE REPLACED APPROXIMATELY ONE YEAR AGO IN AUGUST OF 2016 BY AN INDEPENDENT MECHANIC. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED AGAIN. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.
TAKATA RECALL IS NECESSARY MY AIRBAG LIGHT IS ON UPON STARTING VEHICLE ALONG WITH SERVICE AIRBAG WARNING. I AM AFRAID THAT THIS IS AN UNSAFE CONDITION THAT SHOULD BE REPAIRED AT NO COST TO ME AS THERE SEEMS TO BE MANY OTHER COMPLAINTS ON THIS SAME ISSUE.
WHEN MAKING A RIGHT TURN VEHICLE LOSES POWER STEERING. DOESN'T HAPPEN ALL THE TIME COMES AND GOES. IF YOU GIVE VEHICLE A LITTLE GAS IT WILL START WORKING AGAIN BUT THAT'S NOT ALWAYS AN OPTION. I NOTICE IT MOST IF MY VEHICLE IS MOVING AT A SLOW RATE OF SPEED OR STOPPED. THIS IS A VERY DANGEROUS ISSUE AND NO ONE CAN SEEM TO OFFER …
Read full complaint
WHEN MAKING A RIGHT TURN VEHICLE LOSES POWER STEERING. DOESN'T HAPPEN ALL THE TIME COMES AND GOES. IF YOU GIVE VEHICLE A LITTLE GAS IT WILL START WORKING AGAIN BUT THAT'S NOT ALWAYS AN OPTION. I NOTICE IT MOST IF MY VEHICLE IS MOVING AT A SLOW RATE OF SPEED OR STOPPED. THIS IS A VERY DANGEROUS ISSUE AND NO ONE CAN SEEM TO OFFER ANY IDEAS ON FIXING IT.
MY TAHOE CAUGHT FIRE INSIDE THE DRIVER SIDE DASH. IT WAS PARKED, NO ONE HAD DRIVEN IT THAT DAY. I PUT IN A CLAIM WITH GM (CLAIM #SR 8-2955875514) AND IT WAS DENIED AS THEY SAID THERE ARE NO RECALLS FOR MY TAHOE. THIS FIRE STARTED OUT OF NO WHERE. THANK GOODNESS OUR NEIGHBOR CAME BANGING AT THE DOOR TO LET US KNOW THAT OUR TAHOE …
Read full complaint
MY TAHOE CAUGHT FIRE INSIDE THE DRIVER SIDE DASH. IT WAS PARKED, NO ONE HAD DRIVEN IT THAT DAY. I PUT IN A CLAIM WITH GM (CLAIM #SR 8-2955875514) AND IT WAS DENIED AS THEY SAID THERE ARE NO RECALLS FOR MY TAHOE. THIS FIRE STARTED OUT OF NO WHERE. THANK GOODNESS OUR NEIGHBOR CAME BANGING AT THE DOOR TO LET US KNOW THAT OUR TAHOE WAS ON FIRE. WE WEREN'T HOME AT THE TIME BUT MY SON WAS, WE ARRIVED TO FIND HIM WITH THE WATER HOSE EXTINGUISHING THE FLAMES THAT WERE COMING FROM INSIDE THE VEHICLE. I SENT THE PICS TO GM AND THEY JUST DENIED IT WITH NO OTHER EXPLANATION OTHER THAN THERE WAS NO CURRENT RECALL. THEY DIDN'T EVEN TELL ME WHY THE FIRE STARTED NO ONE CAME OUT TO SEE THE VEHICLE.
Official recalls
405V163000 · Seat Belts:rear/other
Apr 22, 2005
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
04V045000 · Service Brakes, Hydraulic
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence & remedy
Consequence: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Remedy: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
03V094000 · Structure
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
03V037000 · Structure:body:door:hinge And Attachments
Feb 6, 2003
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 214, "SIDE IMPACT PROTECTION." THESE VEHICLES ARE BUILT WITH FOUR WELDS ON THE REAR DOOR UPPER HINGE. ON SOME OF THESE VEHICLES, ONE OR TWO OF THE WELDS MAY NOT BE TO SPECIFICATION.
Consequence & remedy
Consequence: AS A RESULT, THE DOOR STRENGTH MAY BE DEGRADED DURING A SIDE IMPACT VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE WELDS ON THE LEFT REAR DOOR UPPER HINGE. IF A WELD IS FOUND OUT-OF-SPECIFICATION, A BOLT WILL BE INSTALLED TO SECURE THE HINGE. OWNER NOTIFICATION BEGAN FEBRUARY 17, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, OR GMC AT 1-800-462-8782.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA11001 · Brake Line Corrosion Failure
Opened Jan 5, 2011 · Closed Apr 8, 2015
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
Service Brakes, Hydraulic
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
DP05009 · Parking Brake Failure
Opened Dec 20, 2005 · Closed May 31, 2006
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Additional source detail variants (3)
Parking Brake:conventional
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
PE03026 · Steel Wheel Rim Fracture
Opened Jun 12, 2003 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Wheels; Wheels:multi Piece; Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Wheels
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:multi Piece
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.