IllustrationTHERE IS A WEAK FEELING AND A KNOCKING IN THE STEERING BOX OR STEERING COLUMN IN THE VEHICLE. IT FEELS UNSTABLE LIKE THE CAR'S FRONT END COULD FALL APART AT ANY MINUTE. *TR
2003 Chevrolet Tahoe
Owner reports · Recalls · Investigations
More warning signs than most Tahoe years
Owner complaints for the 2003 Chevrolet Tahoe are substantially higher than the model-year median of 246.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tahoe years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
590–25K
5825–50K
8850–75K
7375–100K
89100–150K
41150K+
408 reports with mileage · 99 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 193 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports9 fire reports13 injury reports
Steering complaints
52 reportsI BOUGHT MY 2003 CHEVY TAHOE IN OCTOBER 2006, AND WITHIN 3 MONTHS AFTER I HAD IT THE STEERING SHAFT WAS VIBRATING TERRIBLY, MADE ME VERY NERVOUS AS IT FELT LOOSE. I TOOK IT TO OUR LOCAL MECHANIC WHO CHECKED IT OUT AND ASSUMED THERE MAY BE A RECALL BUT THERE WAS NOT SO HE STUCK A BUNCH OF GREASE IN IT AND IT WAS GOOD. THAT LASTED…
Read full complaint
I BOUGHT MY 2003 CHEVY TAHOE IN OCTOBER 2006, AND WITHIN 3 MONTHS AFTER I HAD IT THE STEERING SHAFT WAS VIBRATING TERRIBLY, MADE ME VERY NERVOUS AS IT FELT LOOSE. I TOOK IT TO OUR LOCAL MECHANIC WHO CHECKED IT OUT AND ASSUMED THERE MAY BE A RECALL BUT THERE WAS NOT SO HE STUCK A BUNCH OF GREASE IN IT AND IT WAS GOOD. THAT LASTED ABOUT 6 MONTHS AND AGAIN IN ANOTHER 6 MONTHS OR SO. I HAVE HAD IT IN 3 TIMES FOR THIS ISSUE AND HAVE TO PAY EACH TIME TO GET THE STEERING SHAFT GREASED AND I THINK THAT IS RIDICULOUS. THIS IS A TOP DOLLAR AUTOMOBILE SO ONE WOULD THINK THESE PROBLEMS WOULD NOT BE AN ISSUE. VERY DISAPPOINTED. *TR
THE STEERING HAS POPPING AND PINING WHEN TURNING LEFT OR RIGHT ALMOST SOUNDING AS IF THE WHEELS ARE GOING TO COME OFF OF THE TIE RODS, SUSPENSION. YOU CAN FEEL IT IN THE STEERING COLUMN. HARD STEERING. *TR
TL*THE CONTACT OWNS A 2003 CHEVROLET TAHOE. WHEN DRIVING AT ANY SPEED OR ON ANY ROAD CONDITION THE STEERING WHEEL VIBRATED. THE DEALER ACKNOWLEDGED THE FAILURE, BUT ONLY PERFORMED A TEMPORARY REPAIR BY APPLYING GREASE TO THE INTERMEDIATE STEERING SHAFT. THE DEALER STATED THAT THERE WASNO REMEDY TO PERMANENTLY SOLVING THE FAI…
Read full complaint
TL*THE CONTACT OWNS A 2003 CHEVROLET TAHOE. WHEN DRIVING AT ANY SPEED OR ON ANY ROAD CONDITION THE STEERING WHEEL VIBRATED. THE DEALER ACKNOWLEDGED THE FAILURE, BUT ONLY PERFORMED A TEMPORARY REPAIR BY APPLYING GREASE TO THE INTERMEDIATE STEERING SHAFT. THE DEALER STATED THAT THERE WASNO REMEDY TO PERMANENTLY SOLVING THE FAILURE. THE CURRENT MILEAGE IS 51,000 , AND THE FAILURE MILEAGE WAS UNKNOWN. *AK
TL* - THE CONTACT OWNS A 2003 TAHOE THAT THE PASSENGER 'S SIDE AIRBAG DEPLOYED UNEXPECTEDLY ON 1/27/07, A WARNING LIGHT TURNED ON AT THAT TIME. THE CONTACT HAS NOT TAKEN THE VEHICLE TO THE DEALER BECAUSE OF A WARRANTY ISSUE. THE CONTACT COMPLAINED SINCE THIS WAS A 3 YEAR OLD VEHICLE AND HAS BEEN IN NO ACCIDENTS. THE CONTA…
Read full complaint
TL* - THE CONTACT OWNS A 2003 TAHOE THAT THE PASSENGER 'S SIDE AIRBAG DEPLOYED UNEXPECTEDLY ON 1/27/07, A WARNING LIGHT TURNED ON AT THAT TIME. THE CONTACT HAS NOT TAKEN THE VEHICLE TO THE DEALER BECAUSE OF A WARRANTY ISSUE. THE CONTACT COMPLAINED SINCE THIS WAS A 3 YEAR OLD VEHICLE AND HAS BEEN IN NO ACCIDENTS. THE CONTACT STATED THAT SIX MONTHS AFTER PURCHASING THE VEHICLE THE STEERING SHAFT VIBRATED WHEN MAKING A LEFT OR A RIGHT TURN, THE DEALER REPLACED IT AT NO CHARGE. THIS RESOLVED THE ISSUE. HOWEVER, 7 MONTHS LATER THE VIBRATION RESTARTED. THE DEALER LUBRICATED THE PARTS AND IT WORKED AGAIN. THE CONTACT WANTED TO FILE A COMPLAINT SINCE THIS PROBLEM WAS STILL UNRESOLVED. HOWEVER, THE VEHICLEWAS NOW OUT OF WARRANTY. THE CURRENT MILEAGE WAS 44,796 AND THE FAILURE MILEAGE WAS 10,000.*AK
SHORTLY AFTER MY YEAR WARRANTY ON MY 2003 CHEVY TAHOE I HAD A KNOCKING NOISE IN THE STEERING COLUMN. CHEVY PUT HEAVIER GREASE IN IT. THE NOISE HAS RETURNED SHORTLY AFTER AND HAS CONTINUED TO THIS DATE YET IN 2007. IF YOU GOOGLE SEARCH THIS PROBLEM YOU WILL SEE MANY PEOPLE HAVE THE SAME PROBLEM EVEN AFTER STEERING COLUMNS HAVE BE…
Read full complaint
SHORTLY AFTER MY YEAR WARRANTY ON MY 2003 CHEVY TAHOE I HAD A KNOCKING NOISE IN THE STEERING COLUMN. CHEVY PUT HEAVIER GREASE IN IT. THE NOISE HAS RETURNED SHORTLY AFTER AND HAS CONTINUED TO THIS DATE YET IN 2007. IF YOU GOOGLE SEARCH THIS PROBLEM YOU WILL SEE MANY PEOPLE HAVE THE SAME PROBLEM EVEN AFTER STEERING COLUMNS HAVE BEEN REPLACED. WHEN WILL CHEVY FIX THIS PROBLEM FOR CONSUMERS. *JB
CONTINUING PROBLEM WITH THE STEERING SHAFT OF MY 2003 CHEVROLET TAHOE. STEERING SHAFT AND FRONT END "POPPING" AND LOOSENESS CONTINUE EVEN AFTER REPLACEMENT. DEALERSHIPS KNOW ABOUT THIS PROBLEM AND HAVE BEEN INSTRUCTED BY GM SERVICE TO NO LONGER REPLACE THE STEERING SHAFT AS THIS "FIX" IS NOT WORKING. THEY ARE CURRENTLY UNSURE…
Read full complaint
CONTINUING PROBLEM WITH THE STEERING SHAFT OF MY 2003 CHEVROLET TAHOE. STEERING SHAFT AND FRONT END "POPPING" AND LOOSENESS CONTINUE EVEN AFTER REPLACEMENT. DEALERSHIPS KNOW ABOUT THIS PROBLEM AND HAVE BEEN INSTRUCTED BY GM SERVICE TO NO LONGER REPLACE THE STEERING SHAFT AS THIS "FIX" IS NOT WORKING. THEY ARE CURRENTLY UNSURE HOW TO FIX THE PROBLEM. IN THE MEAN TIME OWNERS HAVE A VEHICLE THAT DRIVES AS IF IT IS GOING TO FALL APART IN THE FRONT END. THE TAHOE HANDLES BADLY OVER ROUGH ROAD AND CORNERING MAKING IT DIFFICULT TO STEER AT TIMES ESPECIALLY AT HI-WAY SPEED. *JB
THE STEERING LOCKS UP WHEN I TURN LEFT IN MY 2003 CHEVROLET TAHOE. IF THIS HAD HAPPENED DURING AN EVASIVE MANEUVER THE RESULTS COULD HAVE BEEN CATASTROPHIC. I HAVEN'T HAD IT FIXED YET, BUT I DON'T BELIEVE IT WAS THE RESULT OF DAMAGE DONE BY ME. *JB
STEERING COLUMN MAKES LOUD GRINDING NOISES AND VIBRATES WHILE TURNING WHEEL. I HAVE TAKEN IT TO BE REPAIRED/REPLACED 4 TIMES IN 3 YEARS AND CHEVROLET DOESN'T THINK THIS IS A PROBLEM. AS SOMEONE ELSE STATED, ONCE YOUR WARRANTY IS OVER YOU WILL GET NO HELP FROM CHEVY. ONE TIME THEY REPLACED MY DRIVE SHAFT, BUT THE PROBLEM STILL…
Read full complaint
STEERING COLUMN MAKES LOUD GRINDING NOISES AND VIBRATES WHILE TURNING WHEEL. I HAVE TAKEN IT TO BE REPAIRED/REPLACED 4 TIMES IN 3 YEARS AND CHEVROLET DOESN'T THINK THIS IS A PROBLEM. AS SOMEONE ELSE STATED, ONCE YOUR WARRANTY IS OVER YOU WILL GET NO HELP FROM CHEVY. ONE TIME THEY REPLACED MY DRIVE SHAFT, BUT THE PROBLEM STILL EXISTS. I'D LOVE TO SEE A RECALL AS THAT'S THE ONLY WAY I'LL EVER GET THE THING RECTIFIED. *JB
2003 TAHOE, SPEEDOMETER FAULTY, SOMETIMES DOESN'T REGISTER AT ALL SOMETIMES TOO LOW, AND SOMETIMES TO HIGH. STEERING BOX GOING BAD NOTHING GM WILL DO. *NM
Official recalls
405V163000 · Seat Belts:rear/other
Apr 22, 2005
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
04V045000 · Service Brakes, Hydraulic
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence & remedy
Consequence: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Remedy: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
03V094000 · Structure
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
03V037000 · Structure:body:door:hinge And Attachments
Feb 6, 2003
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 214, "SIDE IMPACT PROTECTION." THESE VEHICLES ARE BUILT WITH FOUR WELDS ON THE REAR DOOR UPPER HINGE. ON SOME OF THESE VEHICLES, ONE OR TWO OF THE WELDS MAY NOT BE TO SPECIFICATION.
Consequence & remedy
Consequence: AS A RESULT, THE DOOR STRENGTH MAY BE DEGRADED DURING A SIDE IMPACT VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE WELDS ON THE LEFT REAR DOOR UPPER HINGE. IF A WELD IS FOUND OUT-OF-SPECIFICATION, A BOLT WILL BE INSTALLED TO SECURE THE HINGE. OWNER NOTIFICATION BEGAN FEBRUARY 17, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, OR GMC AT 1-800-462-8782.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA11001 · Brake Line Corrosion Failure
Opened Jan 5, 2011 · Closed Apr 8, 2015
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
Service Brakes, Hydraulic
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
DP05009 · Parking Brake Failure
Opened Dec 20, 2005 · Closed May 31, 2006
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Additional source detail variants (3)
Parking Brake:conventional
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
PE03026 · Steel Wheel Rim Fracture
Opened Jun 12, 2003 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Wheels; Wheels:multi Piece; Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Wheels
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:multi Piece
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.