NHTSA owner reports · September 18, 2026 snapshot.
Seats complaints
20 reportsClear category filterMileage unknown · Dec 18, 2002
Seats
I AM WRITING TO YOU AT THE REQUEST OF GENERAL MOTORS SERVICE ADVISOR. I HAVE A 2001 CHEVROLET TAHOE. AT 39,000 MILES ONE OF THE THIRD SEAT LATCHES IN THE BACK BROKE. THIS PREVENTED THE SEAT FROM LATCHING DOWN IN PLACE AND LET THE SEAT POP IN AND OUT OF THE FLOOR MOUNTED LOCKING BRACKETS. GENERAL MOTORS CUSTOMER SERVICE SENT …
Read full complaint
I AM WRITING TO YOU AT THE REQUEST OF GENERAL MOTORS SERVICE ADVISOR. I HAVE A 2001 CHEVROLET TAHOE. AT 39,000 MILES ONE OF THE THIRD SEAT LATCHES IN THE BACK BROKE. THIS PREVENTED THE SEAT FROM LATCHING DOWN IN PLACE AND LET THE SEAT POP IN AND OUT OF THE FLOOR MOUNTED LOCKING BRACKETS. GENERAL MOTORS CUSTOMER SERVICE SENT ME TO THE DEALERSHIP AND AGREED TO COVER THE ITEM AS A WARRANTY ISSUE AND THEN SUBSEQUENTLY ASKED ME TO FILE A COMPLAINT WITH NHTSA SO THAT THE ISSUE COULD BE LOOKED AT TO SEE IF THERE ARE ANY OTHER SIMILAR CIRCUMSTANCES IN WHICH THE SAFETY OF AN OCCUPANT RIDING IN THE SEAT COULD BE COMPROMISED. 2001 CHEVROLET TAHOE VIN 1GNEK13T51R101941 PART NUMBER 12478359
NHTSA ODI #10000211
Mileage unknown · Nov 18, 2002
Seats
DEALERSHIP WAS NOT NOTIFIED BY THE MANUFACTURER ON HOW TO FIX RECALL FOR THE VEHICLE HEAD REST RESTRAINT PER CONSUMER. TS
NHTSA ODI #8022884
Mileage unknown · Oct 29, 2002
Seats
WHILE DRIVING AN INK PEN DROPPED BETWEEN THE DRIVER'S SEAT AND CENTER CONSOLE. CONSUMER SUFFERED A SERIOUS CUT WHEN ATTEMPTING TO RETRIEVE PEN, DUE TO DESIGN OF SEAT TRACK. CUT REQUIRED 8 STITCHES. TS
NHTSA ODI #8021851
Mileage unknown · Oct 16, 2002
Seats
CONSUMER STATES THAT THE CLAMP ON THE THIRD ROLL OF SEATS THAT IS USED TO SECURE SEAT HAS SHEARED OFF. CONSUMER IS CONCERNED WITH CHILDREN THAT HAVE TO SIT THERE ARE NOT SECURE. PLEASE PROVIDE ANY FURTHER INFORMATION. MR
NHTSA ODI #8020957
Mileage unknown · Oct 8, 2002
Seats
CONSUMER STATES THAT THE CLAMP ON THE REMOVABLE THIRD ROLL SEAT HAS SHEARED OFF. CONSUMER STATES SEAT IS NOT SECURE. CONSUMER IS CONCERNED BECAUSE CHILDREN RIDE IN THAT SEAT. PLEASE PROVIDE ANY FURTHER INFORMATION. *MR
NHTSA ODI #8020430
Mileage unknown · Jul 24, 2002
SeatsInjury
IN THE PROCESS OF FOLDING DOWN THE UPRIGHT PORTION OF SEAT BACK HEAST REST FLIPPED BACK AGGRESSIVELY, ONE OF THE PASSENGERS HAD HAND ON/NEAR/OVER HEADREST SLOT; THUS WHILE PUSHING DOWN THE SEAT THE HEADREST UNEXPECTEDLY FLIPPED BACK, PINNING THE FINGER IN THE SLOT AND LACERATING IT FROM SIDE TO SIDE, THE SPRING LOADED HEADRE…
Read full complaint
IN THE PROCESS OF FOLDING DOWN THE UPRIGHT PORTION OF SEAT BACK HEAST REST FLIPPED BACK AGGRESSIVELY, ONE OF THE PASSENGERS HAD HAND ON/NEAR/OVER HEADREST SLOT; THUS WHILE PUSHING DOWN THE SEAT THE HEADREST UNEXPECTEDLY FLIPPED BACK, PINNING THE FINGER IN THE SLOT AND LACERATING IT FROM SIDE TO SIDE, THE SPRING LOADED HEADREST REMAINED TAUGHT UNTIL SEAT IS LIFTED BACK UP BEYOND THE LATCH RELEASE POINT AFTER WHICH THE HEADREST MUST BE FLIPPED FORWARD TO LATCH BACK INTO POSITION, THE PASSENGERS FINGER WAS FRACTURED, REQUIRED SEVEN STICHES. CURRENTLY, HAS TO GO TO A HAND SPECIALIST FOR NERVE DAMAGE. NLM. *AK
NHTSA ODI #566845
Mileage unknown · Apr 5, 2002
SeatsInjury
WHILE CLIMBING INTO THE THIRD ROW SEAT, MY NINE YEAR OLD SON RECEIVED A SEVERE CUT ON HIS RIGHT MIDDLE FINGER REQUIRING SEVEN STITCHES AND SEVERAL STERI STRIPS IN THE HOSPITAL EMERGENCY ROOM. AS HE WAS HE WAS LOWERING THE SECOND ROW SEAT, HE PUT HIS FINGER INTO TO THE HEADREST CLOSURE. AS THE HEADREST AUTOMATICALLY FOLDED REARWA…
Read full complaint
WHILE CLIMBING INTO THE THIRD ROW SEAT, MY NINE YEAR OLD SON RECEIVED A SEVERE CUT ON HIS RIGHT MIDDLE FINGER REQUIRING SEVEN STITCHES AND SEVERAL STERI STRIPS IN THE HOSPITAL EMERGENCY ROOM. AS HE WAS HE WAS LOWERING THE SECOND ROW SEAT, HE PUT HIS FINGER INTO TO THE HEADREST CLOSURE. AS THE HEADREST AUTOMATICALLY FOLDED REARWARD, HIS FINGER WAS SLICED OPEN.*AK
NHTSA ODI #760293
Mileage unknown · Nov 28, 2001
SeatsInjury
PUTTING DOWN THE SECOND ROW SEAT TO CLIMB INTO THE THIRD ROW SEAT THE HEADREST FOLDS DOWNS AUTOMATICLY. MY 10 1/2 YEAR OLD SON HAD HIS FINGER PRESSED DOWN INTO THE HEADREST CLOSURE AS HE WAS PUTTING DOWN THE SEAT. HE SEVERED THE NERVE AND TENDON IN THE UPPER HALF OF HIS MIDDLE FINGER THAT REQUIRED SURGERY AND 3 MONTHS RECOVERY…
Read full complaint
PUTTING DOWN THE SECOND ROW SEAT TO CLIMB INTO THE THIRD ROW SEAT THE HEADREST FOLDS DOWNS AUTOMATICLY. MY 10 1/2 YEAR OLD SON HAD HIS FINGER PRESSED DOWN INTO THE HEADREST CLOSURE AS HE WAS PUTTING DOWN THE SEAT. HE SEVERED THE NERVE AND TENDON IN THE UPPER HALF OF HIS MIDDLE FINGER THAT REQUIRED SURGERY AND 3 MONTHS RECOVERY, WITH THERAPY. I WAS WONDERING IF OTHER HEAD REST ACCIDENTS HAVE BEEN REPORTED. I HAVE A CLAIN ON FILE WITH GENERAL MOTORS ASKING THEM TO LOOK INTO OTHER REPORTS INVOLVING THE HEADREST.*AK
NHTSA ODI #755036
Mileage unknown · Aug 9, 2001
Seats
SEATS ARE DESIGNED TO ACCOMODATE A MALE NOT A FEMALE. SINCE FEMALES ARE MORE LIKELY NOWADAYS TO BUY THIS VEHICLE, COMFORT ISSUES ARE PROBLEM. A MAJOR DEAL IS THE WAY THE SEAT FOLDS YOU IN HALF OPPOSED TO RECLINING YOU. ALSO THE SEAT SUPPORT PRESSES AGAINST YOUR MIDDLE BACK CAUSING YOU TO HAVE TO PUSH YOUR TORSO OUTWARD WHILE YOU…
Read full complaint
SEATS ARE DESIGNED TO ACCOMODATE A MALE NOT A FEMALE. SINCE FEMALES ARE MORE LIKELY NOWADAYS TO BUY THIS VEHICLE, COMFORT ISSUES ARE PROBLEM. A MAJOR DEAL IS THE WAY THE SEAT FOLDS YOU IN HALF OPPOSED TO RECLINING YOU. ALSO THE SEAT SUPPORT PRESSES AGAINST YOUR MIDDLE BACK CAUSING YOU TO HAVE TO PUSH YOUR TORSO OUTWARD WHILE YOUR LEGS ARE DOWNWARD. YOU FEEL LIKE YOU ARE CONSTANTLY HAVING TO FLEX YOUR ABS AND IT IS JUST A MAJOR DISCOMFORT ESPECIALLY WITH YOUR BACK. PLEASE NOTE THAT ONLY 1MAN NOTICED THIS PROBLEM BUT EACH AND EVERY WOMEN NOTICED IT ALSO -IMMEDIATELY,RESULTING IN LOSS OF SALE TO OTHER MANUFACTURER'S VEHICLE. I HAVE NAMES AND COMPLAINTS EVEN FROM A FEMALE OWNER OF AN OLDER DENALI WITH COMFORT SEATS WHO DISLIKES THE NEW SEATS. ALSO THE SEAT-BELTS ARE EXTREMELY TIGHT. THE SEATS DONT GO BACK FAR ENOUGH AND THE REAR SEAT HAS NO LEG ROOM.MY COMPALINTS RESULTED IN DIFFERENT SOLUTIONS LIKE "WE CAN'T ALTER THE SEAT AT ALL OR IT'LL VOID THE WARRANTY" "YOU SHOULD HAVE NOTICED THAT BEFORE YOU DROVE IT OFF THE LOT, IT'S YOURS NOW" "YOU CAN TAKE IT TO AN UPHOLSTERY SHOP BUT YOU'LL HAVE TO PAY FOR IT" "THE LATEST, TAKE IT TO UPHOLSTERY SHOP AND SEE WHAT THEY CAN DO WHICH THE UPHOLSTERY SHOP SAID NOT MUCH SINCE GMC PUT THE AIRBAG IN THE SEAT" KNOWING ALL THIS, I SHOULD HAVE PURCHASED THE PLAIN TAHOO BECAUSE THE DISCOMFORT WAS NOT WORTH 13,000.00 DIFFERENCE!*AK
NHTSA ODI #750133
Mileage unknown · Jan 30, 2001
Seats
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #740153
Official recalls
5Aug 29, 2005
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA ONLY.
Consequence & remedy
Consequence: THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SIGNAL IS WITHIN SPECIFICATIONS. THE RECALL BEGAN SEPTEMBER 22, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Sep 17, 2002
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH REARWARD FOLDING HEAD RESTRAINTS ON THE SECOND ROW SEATS, TWO POTENTIAL PINCH POINTS EXIST ON EACH OF THE FOLDING HEAD RESTRAINTS WHEN THE RESTRAINTS ARE FOLDED REARWARD AS THE SEATBACK IS FOLDED DOWN.
Consequence & remedy
Consequence: IF A PERSON WERE TO INSERT THEIR FINGER(S) INTO THE PINCH POINT WHEN THE HEAD RESTRAINT FOLDS, IT COULD TRAP AND PINCH THE FINGER(S) CAUSING INJURY.
Remedy: DEALERS WILL INSTALL PROTECTIVE COVERS OVER THE PINCH POINTS. OWNER NOTIFICATION BEGAN NOVEMBER 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR CADILLAC AT 1-800-458-8006.
May 17, 2001
VEHICLE DESCRIPTION: PICKUP AND UTILITY TRUCKS. SOME OF THESE VEHICLES HAVE AN INTERNAL COMPONENT IN THE OUTBOARD SEAT BELT RETRACTORS FOR THE 2ND AND 3RD ROW OF SEATS THAT COULD BE CRACKED. WITH REPEATED ACTUATION OF THE LOCKING MECHANISM, THE CRACK COULD SPREAD TO THE POINT SUCH THAT THE SEAT BELT WOULD NO LONGER LOCK.
Consequence & remedy
Consequence: IN A CRASH, INCREASED OCCUPANT INJURY COULD RESULT FROM THE NO-LOCK CONDITION.
Remedy: DEALERS WILL INSPECT THE OUTBOARD SEAT BELTS FOR SPECIFIC LOT NUMBERS AND REPLACE THE BELTS IF NECESSARY. GM IS ENCLOSING AN INSPECTION PROCEDURE FOR THE OWNERS TO USE OR THEY CAN HAVE THEIR DEALERS DO THE INSPECTIONS. OWNER NOTIFICATION BEGAN JULY 2, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Oct 25, 2000
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES HAVE LOOSE OR MISSING REAR WHEELHOUSE PLUGS. UNDER CERTAIN VEHICLE OPERATING CONDITIONS, EXHAUST GASES CAN FLOW FORWARD AND ACCUMULATE IN THE REAR WHEELHOUSE.
Consequence & remedy
Consequence: THESE GASES COULD FLOW INTO THE PASSENGER COMPARTMENT IF THE PLUG IS MISSING OR LOOSE AND COULD CAUSE POSSIBLE ILLNESS, UNCONSCIOUSNESS, OR DEATH.
Remedy: DEALERS WILL INSPECT THE VEHICLE FOR LOOSE OR MISSING WHEELHOUSE PLUGS AND INSTALL NEW PLUGS IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA11001 · Brake Line Corrosion Failure
Opened Jan 5, 2011 · Closed Apr 8, 2015
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
Service Brakes, Hydraulic
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
DP05009 · Parking Brake Failure
Opened Dec 20, 2005 · Closed May 31, 2006
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Additional source detail variants (3)
Parking Brake:conventional
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
PE05020 · Unwanted LOW-SPEED Abs Activation
Opened Apr 28, 2005 · Closed Sep 13, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
Additional source detail variants (2)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
PE03026 · Steel Wheel Rim Fracture
Opened Jun 12, 2003 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Wheels; Wheels:multi Piece; Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Wheels
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:multi Piece
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE02067 · Alleged Failure Of 2ND Row Seatbelt Alr
Opened Sep 25, 2002 · Closed Feb 11, 2003
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:rear/other
THE AUTOMATIC LOCKING RETRACTOR (ALR) IS A FEATURE INCORPORATED IN THE SUBJECT VEHICLE FOR LOCKING THE WEBBING TO PROPERLY SECURE A CHILD SAFETY SEAT INTO A VEHICLE.THIS PE WAS OPENED BASED ON A GM TECHNICAL SERVICE BULLETIN STATING THAT WITH CERTAIN CHILD SAFETY SEATS THE WEBBING MAY NOT REMAIN LOCKED.THERE ARE NO COMPLAINTS IN THE ODI DATABASE AND ONLY TWO COMPLAINTS TO GM.GM'S INSTRUCTIONS STATE FOR THE FINAL STEP IN USING THE WEBBING LOCK FEATURE TO PUSH AND PULL THE CHILD RESTRAINT TO BE SURE IT IS SECURE. IF THE ALR IS NOT LOCKED, THE USER WOULD BE FULLY AWARE OF THIS CONDITION PRIOR TO COMPLETING PROPER INSTALLATION OF THE CHILD SAFETY SEAT IN THIS VEHICLE.THIS INVESTIGATION DID NOT UNCOVER ANY COMPLAINTS OF THE ALR INADVERTENTLY UNLOCKING WHILE THE VEHICLE IS IN MOTION.THE EMERGENCY LOCKING RETRACTOR (ELR) FEATURE REMAINS AVAILABLE TO LOCK THE RETRACTOR IN A CRASH.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY FOR ADDITIONAL INFORMATION.
Additional source detail variants (2)
Seat Belts
THE AUTOMATIC LOCKING RETRACTOR (ALR) IS A FEATURE INCORPORATED IN THE SUBJECT VEHICLE FOR LOCKING THE WEBBING TO PROPERLY SECURE A CHILD SAFETY SEAT INTO A VEHICLE.THIS PE WAS OPENED BASED ON A GM TECHNICAL SERVICE BULLETIN STATING THAT WITH CERTAIN CHILD SAFETY SEATS THE WEBBING MAY NOT REMAIN LOCKED.THERE ARE NO COMPLAINTS IN THE ODI DATABASE AND ONLY TWO COMPLAINTS TO GM.GM'S INSTRUCTIONS STATE FOR THE FINAL STEP IN USING THE WEBBING LOCK FEATURE TO PUSH AND PULL THE CHILD RESTRAINT TO BE SURE IT IS SECURE. IF THE ALR IS NOT LOCKED, THE USER WOULD BE FULLY AWARE OF THIS CONDITION PRIOR TO COMPLETING PROPER INSTALLATION OF THE CHILD SAFETY SEAT IN THIS VEHICLE.THIS INVESTIGATION DID NOT UNCOVER ANY COMPLAINTS OF THE ALR INADVERTENTLY UNLOCKING WHILE THE VEHICLE IS IN MOTION.THE EMERGENCY LOCKING RETRACTOR (ELR) FEATURE REMAINS AVAILABLE TO LOCK THE RETRACTOR IN A CRASH.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY FOR ADDITIONAL INFORMATION.
Seat Belts:rear/other
THE AUTOMATIC LOCKING RETRACTOR (ALR) IS A FEATURE INCORPORATED IN THE SUBJECT VEHICLE FOR LOCKING THE WEBBING TO PROPERLY SECURE A CHILD SAFETY SEAT INTO A VEHICLE.THIS PE WAS OPENED BASED ON A GM TECHNICAL SERVICE BULLETIN STATING THAT WITH CERTAIN CHILD SAFETY SEATS THE WEBBING MAY NOT REMAIN LOCKED.THERE ARE NO COMPLAINTS IN THE ODI DATABASE AND ONLY TWO COMPLAINTS TO GM.GM'S INSTRUCTIONS STATE FOR THE FINAL STEP IN USING THE WEBBING LOCK FEATURE TO PUSH AND PULL THE CHILD RESTRAINT TO BE SURE IT IS SECURE. IF THE ALR IS NOT LOCKED, THE USER WOULD BE FULLY AWARE OF THIS CONDITION PRIOR TO COMPLETING PROPER INSTALLATION OF THE CHILD SAFETY SEAT IN THIS VEHICLE.THIS INVESTIGATION DID NOT UNCOVER ANY COMPLAINTS OF THE ALR INADVERTENTLY UNLOCKING WHILE THE VEHICLE IS IN MOTION.THE EMERGENCY LOCKING RETRACTOR (ELR) FEATURE REMAINS AVAILABLE TO LOCK THE RETRACTOR IN A CRASH.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY FOR ADDITIONAL INFORMATION.
EA02015 · Throttle Sticking Closed
Opened Aug 1, 2002 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THIS INVESTIGATION INVOLVES THE GENERAL MOTORS CORPORATION (GM)THROTTLE BODY (TB) UTILIZED IN MODEL YEAR (MY) 1999-2002 SILVERADO, SIERRA, TAHOE, SUBURBAN, AVALANCHE AND YUKON (SUBJECT VEHICLE(S)) WITH 4.8L, 5.3L, AND 6.0L ENGINES. THE TB VALVE MAY INTERMITTENTLY STICK IN A CLOSED POSITION.IN SUCH A SITUATION, AN OPERATOR MAY APPLY ADDITIONAL ACCELERATOR PEDAL FORCE TO INCREASE ENGINE SPEED.THE APPLICATION OF ADDITIONAL ACCELERATOR PEDAL FORCE, TO OPEN A STUCK THROTTLE VALVE, MAY OPEN THE THROTTLE VALVE MORE THAN INTENDED AND, IN TURN, ACCELERATE THE ENGINE AND VEHICLE MORE THAN INTENDED AND REASONABLY EXPECTED BY THE DRIVER.ON AUGUST 1, 2002, THE OFFICE OF DEFECTS INVESTIGATION (ODI), OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA), OPENED THIS ENGINEERING ANALYSIS.THE INVESTIGATION REVEALED THAT TWO FACTORS MAY CAUSE THE DEFECT: 1) TB MANUFACTURING PROCESS PROBLEMS; AND 2) ACCUMULATION OF DEPOSITS (A PCV SYSTEM BY-PRODUCT) ON OR AROUND THE TB THROTTLE VALVE AND BORE.ODI CONCLUDES THAT THE TB PERFORMS IN A DEFECTIVE MANNER AFTER ANALYZING GM?S DATA SUBMISSIONS, AND TEST DATA COLLECTED BY THE VEHICLE RESEARCH AND TEST CENTER (VRTC).FIFTY-NINE CRASHES ARE ALLEGED TO HAVE OCCURRED AS A RESULT OF GM?S TB DEFECT.THE MAJORITY OF THE CRASHES INVOLVE A SINGLE VEHICLE, ENGAGING IN A CLOSE QUARTER VEHICLE MANEUVER (OR LOW SPEED), AND CAUSING ONLY MINOR PROPERTY DAMAGE.FOUR OUT OF THE FIFTY-NINE CRASHES INVOLVE INJURY, AND THOSE INJURIES WERE MINOR.ALTHOUGH GM?S TB IS DEFECTIVE, BASED ON THE EVIDENCE GATHERED, ODI HAS FOUND THAT THE ACCELERATOR PEDAL FORCE REQUIRED TO OPEN A STUCK THROTTLE VALVE IS NEGLIGIBLE, AND THE THROTTLE VALVE DOES NOT STICK IN THE OPEN POSITION.THEREFORE THIS ENGINEERING ANALYSIS (EA02-015) WILL BE CLOSED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.FOR A DETAILED DISCUSSION OF THE TB COMPONENT AND TESTING, PLEASE SEE THE ATTACHED REPORT.
Illustration