NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
42 reportsMileage unknown · Jun 11, 2025
Air BagsEngineStructure
Since purchasing the vehicle on September 27, 2024, I have experienced a series of troubling issues that raise serious concerns about its design, manufacturing, and overall safety, including: Airbag system malfunction: My airbags were nonfunctional for over a month. Tire-related issues: Required full replacement of the initi…
Read full complaint
Since purchasing the vehicle on September 27, 2024, I have experienced a series of troubling issues that raise serious concerns about its design, manufacturing, and overall safety, including: Airbag system malfunction: My airbags were nonfunctional for over a month. Tire-related issues: Required full replacement of the initial set of tires. Persistent alignment problems Bluetooth audio problems: Poor quality and connectivity with multiple phones, resolved only after a service visit in May 2025. Defective seat frame: Rear passenger-side bucket seat required full replacement. Defective paint: Blisters and bubbles in the rear quarter panel paint. Fuel module failure: Most concerning, the vehicle abruptly stopped on the road last week and required towing. I was later told the cause was a fuel module failure. Each of these issues is concerning on its own. Taken together, they represent a troubling pattern of unreliability and potential risk to my safety and that of others on the road. They’ve also resulted in a significant loss of my time. This vehicle has spent over a month at the dealership for service—astounding for a truck that’s only eight months old. These are the kinds of delays and disruptions I specifically try to avoid by purchasing and maintaining new Chevrolet vehicles.
NHTSA ODI #11666254
Mileage unknown · Jun 9, 2025
Electrical SystemForward Collision AvoidanceService Brakes
I have had my cruise control set and my car will slam on the brakes with no vehicles in front of my car or on each side. This has happened multiple times, it doesn’t matter if I am going 40MPH or 60+MPH. I have taken it in and they say there is nothing they can do for the issue. I’m worried for the safety of myself, my family, a…
Read full complaint
I have had my cruise control set and my car will slam on the brakes with no vehicles in front of my car or on each side. This has happened multiple times, it doesn’t matter if I am going 40MPH or 60+MPH. I have taken it in and they say there is nothing they can do for the issue. I’m worried for the safety of myself, my family, and my unborn child. As well as any cars around (behind me potentially) when this happens. I do not want to unintentionally cause an accident.
NHTSA ODI #11665912
Mileage unknown · Apr 18, 2025
EngineFire
I parked at my home, approximately 5 minutes after arriving home my grandson ran in yelling papa your car is on fire. The engine was on fire, shooting flames onto the windsheild. The cause of fire is unknown at this time.
NHTSA ODI #11655369
Mileage unknown · Mar 29, 2025
Engine
I was entering the interstate, at 65 miles per hour, and went to set the cruise once I reached 70mph, and noticed that I was losing power, the engine had stopped and we dangerously lost speed on a interstate where folks were traveling north of 75-80 mph. I costed to the shoulder and tried to reset with no luck. We called Onstar …
Read full complaint
I was entering the interstate, at 65 miles per hour, and went to set the cruise once I reached 70mph, and noticed that I was losing power, the engine had stopped and we dangerously lost speed on a interstate where folks were traveling north of 75-80 mph. I costed to the shoulder and tried to reset with no luck. We called Onstar and had it towed to Hendrick or Monroe NC. We found out that this was an engine failure and the long block had to be replaced. This left us stranded without a car to drive to our cruise —GM told me I could buy plane tickets and they’ve never denied reimbursement. Unfortunately they denied it once I submitted all the receipts. It been a horrible experience with no help from GM.
NHTSA ODI #11651442
Mileage unknown · Mar 23, 2025
Engine
We were driving down the [XXX] in Wichita KS when our 2024 Suburbans engine shut off and the car went into neutral. The display said “ "conditions not correct for shift". We were able to safely coast to the nearest exit [XXX] and we completely stopped at the bottom of the exit ramp. We contacted onstar who dispatched Kansas High…
Read full complaint
We were driving down the [XXX] in Wichita KS when our 2024 Suburbans engine shut off and the car went into neutral. The display said “ "conditions not correct for shift". We were able to safely coast to the nearest exit [XXX] and we completely stopped at the bottom of the exit ramp. We contacted onstar who dispatched Kansas Highway Patrol who blocked off the exit until we could get the vehicle towed. The car is currently at the dealership, being that it is Sunday they are closed so more information tomorrow on the issue. The photos are of the car being towed from The incident location and dropped off at the dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11650033
360 miles · Mar 18, 2025
Exterior Lighting
The contact owns a 2024 Chevrolet Suburban. The contact stated that upon brushing snow off the vehicle, the contact noticed that there was snow inside the headlights, which later turned into ice and dimmed the headlights. The contact stated that while driving at an undisclosed speed, the failure recurred, causing the contact to …
Read full complaint
The contact owns a 2024 Chevrolet Suburban. The contact stated that upon brushing snow off the vehicle, the contact noticed that there was snow inside the headlights, which later turned into ice and dimmed the headlights. The contact stated that while driving at an undisclosed speed, the failure recurred, causing the contact to pull over to the side of the road to clean the headlights. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 360.
NHTSA ODI #11648988
Mileage unknown · Feb 28, 2025
Back Over PreventionElectrical SystemService Brakes
The check engine light came on at 14k miles indicating there was an emissions error. The brakes squeal and have had to be replaced 3 times since the original purchase in March of 2024. After the third replacement of brakes they still squeal. Even if the car is not braking it makes the noise. The radio shuts on and off constantl…
Read full complaint
The check engine light came on at 14k miles indicating there was an emissions error. The brakes squeal and have had to be replaced 3 times since the original purchase in March of 2024. After the third replacement of brakes they still squeal. Even if the car is not braking it makes the noise. The radio shuts on and off constantly. Chevy reported they are aware of the issue but there is no fix at this time. The dealerships reset the radio but the issue persists. I’ve had to park the car because I’m afraid the brake issue is much more than they’re willing to admit.
NHTSA ODI #11645479
Mileage unknown · Jan 31, 2025
Child Seat
The contact owns a Nuna Rava Car Seat, Model Type: Convertible, Model Number: CS05013-GRN, Manufactured Date: July 16, 2016. The contact stated that the harness buckle became difficult to adjust while attempting to secure the child in the car seat. The contact received notifications of NHTSA Campaign Numbers: 24C002000 (Child Se…
Read full complaint
The contact owns a Nuna Rava Car Seat, Model Type: Convertible, Model Number: CS05013-GRN, Manufactured Date: July 16, 2016. The contact stated that the harness buckle became difficult to adjust while attempting to secure the child in the car seat. The contact received notifications of NHTSA Campaign Numbers: 24C002000 (Child Seat); however, the parts to do the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue.
NHTSA ODI #11639840
Mileage unknown · Jan 24, 2025
EnginePower Train
On[XXX], at approximately [XXX], while driving on [XXX] at a speed of 80 mph, my vehicle suddenly lost all power and shut down without warning. I had no choice but to steer to the shoulder lane amidst high-speed traffic on the busy interstate. After coming to a stop, the car would not restart, leaving me stranded in a highly pre…
Read full complaint
On[XXX], at approximately [XXX], while driving on [XXX] at a speed of 80 mph, my vehicle suddenly lost all power and shut down without warning. I had no choice but to steer to the shoulder lane amidst high-speed traffic on the busy interstate. After coming to a stop, the car would not restart, leaving me stranded in a highly precarious situation. As the weather conditions worsened, turning into a blizzard, and darkness set in, I contacted GM Roadside Assistance for help. I was informed that assistance would take at least an hour to arrive. Feeling unsafe, I called local law enforcement. The officers arrived and parked behind my vehicle with their flashers on to ensure approaching drivers would slow down and avoid an accident. This was an extremely distressing and frightening experience. After an hour, GM Roadside Assistance called back and informed me they were unable to find an operator to tow the vehicle. By this time, the officers on-site had contacted a local tow company for my safety. The tow company advised me that I would need to pay in cash for their services, which I accepted due to the urgency of the situation. They towed the vehicle from [XXX] to their yard in Douglas, Wyoming. I then arranged for a ride to Cheyenne, Wyoming, where I had to report to work that night. This incident not only jeopardized my safety but also left me with significant unexpected expenses and inconvenience, all due to what I believe is a manufacturing defect in the vehicle. A new vehicle should not experience such catastrophic failure, and the delayed response from GM Roadside Assistance compounded the problem. I respectfully request the following actions 1. A thorough investigation into the root cause of the sudden failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11638176
Mileage unknown · Jan 22, 2025
Engine
6.2L engine failure at 9600 miles
NHTSA ODI #11637841
NHTSA investigations
4EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration