NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
9 reportsClear category filter50,000 miles · Aug 31, 2026
Engine And Engine CoolingPower Train
The contact owns a 2023 Chevrolet Suburban. The contact stated that while entering a parking lot at a low speed, the engine shut off without warning. The vehicle was towed to a dealer, where it was diagnosed with engine failure, which was associated with NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The vehicle r…
Read full complaint
The contact owns a 2023 Chevrolet Suburban. The contact stated that while entering a parking lot at a low speed, the engine shut off without warning. The vehicle was towed to a dealer, where it was diagnosed with engine failure, which was associated with NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The vehicle remained at the dealer for approximately three months before the engine was repaired. The contact stated that while driving recently, the vehicle hesitated upon depressing the accelerator pedal. No warning light illuminated. The dealer and the manufacturer were not notified of the recent failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 50,000.
NHTSA ODI #11760861
63,000 miles · Aug 21, 2026
Engine And Engine Cooling
The contact owns a 2023 Chevrolet Suburban. The contact stated that the vehicle had experienced excessive oil consumption. The contact stated that while driving at various speeds, the vehicle chugged, jerked, and lunged forward. The vehicle was taken to the dealer; however, the failure could not be duplicated. The contact stated…
Read full complaint
The contact owns a 2023 Chevrolet Suburban. The contact stated that the vehicle had experienced excessive oil consumption. The contact stated that while driving at various speeds, the vehicle chugged, jerked, and lunged forward. The vehicle was taken to the dealer; however, the failure could not be duplicated. The contact stated that the failure reoccurred. The vehicle was taken back to the dealer, where the spark plugs were replaced; however, the failure persisted. The dealer was notified of the failure and advised the contact that the spark plugs might need to be replaced. The contact stated that while driving and coming to a stop, the vehicle chugged, lunged forward, made an abnormal clicking sound, and almost struck another vehicle. The check engine warning light illuminated. The OnStar mobile APP displayed the messages "Engine and Transmission System - Please Schedule Service Now," "Transmission System Issue - Please Schedule Service Now," and "VVT Issue detected - Please Schedule Service Now". The contact was able to pull into a parking lot. The vehicle was taken to the dealer, where it was diagnosed with engine lifter failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 63,000.
NHTSA ODI #11758574
25,300 miles · Aug 3, 2026
Engine And Engine Cooling
The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving approximately 65 MPH, the transmission erroneously shifted to neutral(N), and the vehicle decelerated unexpectedly. The vehicle was pulled off the freeway and parked on the shoulder of the road, and the police were contacted and arrived at the scen…
Read full complaint
The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving approximately 65 MPH, the transmission erroneously shifted to neutral(N), and the vehicle decelerated unexpectedly. The vehicle was pulled off the freeway and parked on the shoulder of the road, and the police were contacted and arrived at the scene and assisted with removing the small children from the vehicle. The vehicle was later towed to a nearby towing lot. The contact later received messages on the App for transmission and engine failures. The cause of the failures was not yet determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The contact stated that the vehicle was previously serviced under the NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING); even though the vehicle had experienced the failure listed in the recall. The failure mileage was 25,300.
NHTSA ODI #11754537
104,849 miles · Apr 30, 2026
Engine And Engine Cooling
The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. Additionally, the messages “Coolant Control Valve” and “Acceleration Reduced – Stop Vehicle” were displayed. The vehicle was taken to the dealer, where it was diagnosed and deter…
Read full complaint
The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. Additionally, the messages “Coolant Control Valve” and “Acceleration Reduced – Stop Vehicle” were displayed. The vehicle was taken to the dealer, where it was diagnosed and determined that the coolant control valve had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 104,849.
NHTSA ODI #11734824
100,000 miles · Apr 7, 2026
Engine And Engine Cooling
The contact owns a 2023 Chevrolet Suburban. The contact stated that the engine and oil warning lights were displayed. The vehicle was taken to the local dealer, and the vehicle was diagnosed with engine failure. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failur…
Read full complaint
The contact owns a 2023 Chevrolet Suburban. The contact stated that the engine and oil warning lights were displayed. The vehicle was taken to the local dealer, and the vehicle was diagnosed with engine failure. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 100,000.
NHTSA ODI #11729595
134,943 miles · Jan 2, 2026
EngineEngine And Engine Cooling
The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed with a failed coolant control valve. The contact was informed that the coolant control valve needed to be replaced. The…
Read full complaint
The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed with a failed coolant control valve. The contact was informed that the coolant control valve needed to be replaced. The vehicle was not repaired. In addition, the contact referenced a Special Coverage Program: N252508341, however the VIN was not included. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. In addition, the contact was informed that the NHTSA could add the VIN to the special Coverage Program. The failure mileage was approximately 134,943.
NHTSA ODI #11708318
30,000 miles · Aug 5, 2025
Engine And Engine Cooling
The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the engine made an abnormal sound. No warning light was illuminated. The vehicle was taken to the dealer; however, the dealer was unable to duplicate the failure. The contact later received notification of NHTSA Campaign Nu…
Read full complaint
The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the engine made an abnormal sound. No warning light was illuminated. The vehicle was taken to the dealer; however, the dealer was unable to duplicate the failure. The contact later received notification of NHTSA Campaign Number: 25V274000(Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was taken back to the dealer, but the dealer declined to inspect the engine. The contact was informed that parts were not yet available. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000.
NHTSA ODI #11678460
Mileage unknown · Jun 23, 2025
Engine And Engine Cooling
The contact owns a 2023 Chevrolet Suburban. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was ma…
Read full complaint
The contact owns a 2023 Chevrolet Suburban. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact was dissatisfied with the manufacturer’s remedy for vehicles that pass the engine inspection. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA ODI #11668680
Mileage unknown · May 29, 2025
Engine And Engine Cooling
The contact owns a 2023 Chevrolet Suburban. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was ma…
Read full complaint
The contact owns a 2023 Chevrolet Suburban. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA ODI #11663629
Official recalls
3Apr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Sep 20, 2023
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
Consequence & remedy
Consequence: A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
Remedy: Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.
Dec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration