Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 20 of 119 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports1 fire reports2 injury reports
What owners actually said
119 reports
Mileage unknown · Jun 1, 2023
Steering
the steering wheel heater turned on unexpectedly (it was 70 degrees outside) when I started the car this morning. The wheel was hot to the touch. To turn it off I had to turn it on and then off again. I am worried it may have a short or be a fire hazard if it is on all the time or without being turned on by a sensor or the dri…
Read full complaint
the steering wheel heater turned on unexpectedly (it was 70 degrees outside) when I started the car this morning. The wheel was hot to the touch. To turn it off I had to turn it on and then off again. I am worried it may have a short or be a fire hazard if it is on all the time or without being turned on by a sensor or the driver.
NHTSA ODI #11524772
Mileage unknown · May 5, 2023
SeatsCrash
This is the second Chevrolet Suburban we have owned. In both cars, the middle seat of the 2nd and 3rd row bench seats are missing a head rest. This could result in a severe neck injury to the passenger in a car accident. How is Chevrolet allowed to roll out these cars from the factory with this obvious safety defect?
NHTSA ODI #11520667
Mileage unknown · Apr 15, 2023
Back Over Prevention
When the vehicle was ordered I paid an extra amount for "driver safety alert package" to include rear and front parking sensors. It's a big car and these are quite important for safe operations. Upon car delivery in 3/2022, I got a note saying the chip operating the driver assist is missing and will be provided later. The deale…
Read full complaint
When the vehicle was ordered I paid an extra amount for "driver safety alert package" to include rear and front parking sensors. It's a big car and these are quite important for safe operations. Upon car delivery in 3/2022, I got a note saying the chip operating the driver assist is missing and will be provided later. The dealer promised to install it within a quarter. More than a year went buy, and the service department recently told me that GM would not make the chip available, even tough new cars are now being delivered with the same chip. As GM or the dealer would not respond to my request, I'm filing this complaint, hoping you can get them to finally provide the missing chip and to allow safe operation of the vehicle as ordered.
NHTSA ODI #11517247
Mileage unknown · Mar 14, 2023
Air BagsEngine
2022 CHEVROLET SUBURBAN. CONSUMER WRITES IN REGARD TO ENGINE STALLING, ILLUMINATED AIR BAG LIGHT AND LOUD RATTLING SOUND COMING FROM THE ENGINE.
NHTSA ODI #11511738
Mileage unknown · Mar 3, 2023
Air BagsSeat BeltsCrashFire
The contact owned a 2022 Chevrolet Suburban. The contact stated while his wife was driving at approximately 30 MPH she crashed into another vehicle striking the driver's side door of the other vehicle, which then crashed into another vehicle in the rear having been redirected from the force of the impact. The vehicle had been mo…
Read full complaint
The contact owned a 2022 Chevrolet Suburban. The contact stated while his wife was driving at approximately 30 MPH she crashed into another vehicle striking the driver's side door of the other vehicle, which then crashed into another vehicle in the rear having been redirected from the force of the impact. The vehicle had been moved in the same direction that the wife's vehicle was traveling. The vehicle that the wife had crashed into had run a stop sign. The contact stated that all the front air bags deployed, however, the wife told him that the passenger side air bag had begun to emit smoke after deploying and then a fire started. The contact stated that the vehicle had stopped after the impact and that his wife was having difficulty unbuckling her seat belt. The wife had stated that OnStar had contacted her the moment following the crash, she told OnStar that she was having trouble unbuckling and that the vehicle was on fire. OnStar released her seat belt. The police, ambulance, and fire department were on the scene. There were no injuries, however, the contact's vehicle was fully engulfed in flames and exploded. The contact stated that the fire department extinguished the fire with water. The police wrote a report. The other two vehicles drove away from the scene, and the contact's vehicle was towed to a police impound lot. The manufacturer had not been informed of the failure. The failure mileage was unknown.
NHTSA ODI #11510032
1,000 miles · Feb 3, 2023
Forward Collision Avoidance
The contact owns a 2022 Chevrolet Suburban. The contact stated that after an unknown over-the-air (OTA) software update was performed, the Forward Collision alert system failed to operate. The contact was made aware of the failure while reversing the vehicle. The contact stated that the alert failed to alert her of a nearby vehi…
Read full complaint
The contact owns a 2022 Chevrolet Suburban. The contact stated that after an unknown over-the-air (OTA) software update was performed, the Forward Collision alert system failed to operate. The contact was made aware of the failure while reversing the vehicle. The contact stated that the alert failed to alert her of a nearby vehicle. The vehicle was taken to the dealer, and the dealer confirmed that the Forward Collision alert system chip needed to be installed; however, the chip was on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that there was a chip shortage. The failure mileage was approximately 1,000.
When I started up the vehicle with the key fab button I noticed the cabin air blower came on as normal however when we went to the cockpit we noticed the engine was not running. When we went to start the vehicle (holding break and pressing start button) the dashboard started the Z71 launch sequence and then went to a dashboard …
Read full complaint
When I started up the vehicle with the key fab button I noticed the cabin air blower came on as normal however when we went to the cockpit we noticed the engine was not running. When we went to start the vehicle (holding break and pressing start button) the dashboard started the Z71 launch sequence and then went to a dashboard as if I was in the normal drive mode however the dashboard was extremely dimly lit as if the backlight was not on and the engine still was not running. After several attempts to start using the brake+start button method we noticed a clicking sound that seemed to be coming from the engine cabin just in front of the passenger cabin however it would never ignite/start the engine. After several attempts to start the engine through the brake+button, we tried to just press the start button, which would sometimes be prompted on the dashboard, and get some feedback from the dashboard through better backlighting and messages I now cannot recall but never ignited the engine. When we tried again with the key fab x2 button (hoping it would either start or "cancel" the current vehicle state), we received no response from the vehicle. When we attempted to shift, it stated the "conditions were not met", which I perceived as the correct response. The vehicle was stuck in this "mode" with the air blower still running and exterior lights still on and it was only a matter of time until the battery ran out. When it ran out later that day (though not completely ded) in rebooted in the same tweener mode. However, when we came the next day with a tow truck and a fully dead battery in the Suburban, the vehicle booted right up as normal. The tow truck driver indicated several new Tahoe drivers experiencing the same issue. To me, this is a software launch issue. While the vehicle was not perceived to be in danger, it left us stranded in what could be a dangerous location. Several episodes as reported by tow truck. Unsure if inspected. No symptoms before problem.
NHTSA ODI #11486651
Mileage unknown · Feb 14, 2022
Tires
I purchased a 2022 Chevrolet Suburban on December 6, 2022 equipped with4 Bridgestone Alenza A/S 02 tires sized 275 50R22. On December 21, on my way home I hit a bump. When I got home I could audibly hear air leaking out of the passenger rear tire. I called OnStar who sent a tow truck driver out to put the spare on. We could n…
Read full complaint
I purchased a 2022 Chevrolet Suburban on December 6, 2022 equipped with4 Bridgestone Alenza A/S 02 tires sized 275 50R22. On December 21, on my way home I hit a bump. When I got home I could audibly hear air leaking out of the passenger rear tire. I called OnStar who sent a tow truck driver out to put the spare on. We could not find a nail or anything in the tire but there was about a 1.5 inch crack in the sidewall about 1 inch away from the rim with nothing sticking in it. I took it to the dealership where I purchased the tire and they ordered a replacement tire. They said that I could file a complaint with the State Department of Transportation if I wanted. It cost me about $328 to repair. On February 12, around 9:00 pm, I was about an hour and a half away from home about to drive back when the tire sensor light came on saying the passenger rear tire had low air pressure. I pulled into a park and went to look and I again could audibly hear air leaking from the tire. I had not hit any bumps this time, but the tire was completely flat within 20 minutes. When the tow truck driver came to put the spare on, I explained to him what happened previously and that was the second time this had happened within 2 months of purchasing the vehicle. He looked at the tire with me and it had the same tear in the sidewall in the same location as the previous tire. There was no nail or object in the tire, just a 1.5 inch long rigid crack. I noticed that there had been a Bridgestone recall for this type of tire for size 275 55R20 in 2021 because of a pin hole in the sidewall. I believe that my tires are defective.
NHTSA ODI #11451802
Mileage unknown · Jan 18, 2022
Unknown Or Other
I was driving on the interstate and my sunroof exploded. There were few cars around me and I was not under a bridge. I did not see anything coming at the car or see anything drop or fall behind us. Just heard a lot exploding noise.
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence & remedy
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module:software
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Power Train:automatic Transmission:fluid/lubricant:valves/valve Body
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
General Motors, LLC (M) is recalling certain 2021-2022 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL vehicles equipped with third-row seats. The rivet that retains the buckle to the mounting bracket in the left or right side third-row seat belt buckle assembly may have been improperly formed.
Consequence & remedy
Consequence: A seat belt with a deformed rivet may not properly restrain an occupant, increasing the risk of injury during a crash.
Remedy: Dealers will inspect the rivet head formation on both the left and right side third-row seat belt buckle assemblies and replace seat belt buckle assemblies, as necessary, free of charge. Interim owner notification letters informing owners of the safety risk were mailed September 28, 2022. Owner notification letters were mailed on November 1, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N222372380.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2022 Chevrolet Suburban Problems, Complaints & Recalls | Skip That Year
Illustration