Hi My 2013 Chevy Suburban's Dash has a crack near the air bag.
2013 Chevrolet Suburban
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2013 Chevrolet Suburban do not stand out strongly from the model-year median of 118.
About this comparison →How this year compares
Owner complaints by model year
Compare all Suburban years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
80 reports with mileage · 38 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
118 reportsRecall no remedy available extended time frame.
Takata Recall. The contact owns a 2013 Chevrolet Suburban. The contact received notification of NHTSA Campaign Number: 21V053000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not …
Read full complaint
Takata Recall. The contact owns a 2013 Chevrolet Suburban. The contact received notification of NHTSA Campaign Number: 21V053000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. The dealer and manufacturer were not made aware of the issue. Vin tool confirms parts not available.
MY 2013 CHEVROLET SUBURBAN HAS CRACKS IN THE DASHBOARD IN THE SAME SPOTS AS MANY OTHER PEOPLE I HAVE TALKED TO, NOT ONLY DOES THIS DIMINISH THE VALUE OF OUR VEHICLES THE CRACKS AROUND THE PASSENGER SIDE AIR BAG SEEM LIKE IT COULD BE A DANGER IF THE AIR BAG WERE TO DEPLOY POSSIBLY CAUSING PLASTIC SHRAPNEL TO BE EJECTED WITH EXT…
Read full complaint
MY 2013 CHEVROLET SUBURBAN HAS CRACKS IN THE DASHBOARD IN THE SAME SPOTS AS MANY OTHER PEOPLE I HAVE TALKED TO, NOT ONLY DOES THIS DIMINISH THE VALUE OF OUR VEHICLES THE CRACKS AROUND THE PASSENGER SIDE AIR BAG SEEM LIKE IT COULD BE A DANGER IF THE AIR BAG WERE TO DEPLOY POSSIBLY CAUSING PLASTIC SHRAPNEL TO BE EJECTED WITH EXTREME FORCE INJURING OR POSSIBLY KILLING SOMEONE ESPECIALLY CONSIDERING THE AIRBAGS ARE ALREADY UNDER A RECALL FOR THEIR ISSUES THEY (THE DASH ) SHOULD BE RECALLED
I HAVE BEEN NOTIFIED OF A DANGEROUS AIRBAG RECALL ON MY 2013 SUBURBAN. THE PARTS ARE NOT AVAILABLE TO FIX THE ISSUE AT THIS TIME. THIS IS UNACCEPTABLE. MY VEHICLE IS NOT SAFE TO DRIVE. CHEVY IS NOT RETURNING OUR PHONE CALLS. APPARENTLY IT IS OK WITH THEM FOR ME TO DRIVE MY FAMILY AROUND WITH WHAT IS EQUIVALENT TO A HAND GRENADE …
Read full complaint
I HAVE BEEN NOTIFIED OF A DANGEROUS AIRBAG RECALL ON MY 2013 SUBURBAN. THE PARTS ARE NOT AVAILABLE TO FIX THE ISSUE AT THIS TIME. THIS IS UNACCEPTABLE. MY VEHICLE IS NOT SAFE TO DRIVE. CHEVY IS NOT RETURNING OUR PHONE CALLS. APPARENTLY IT IS OK WITH THEM FOR ME TO DRIVE MY FAMILY AROUND WITH WHAT IS EQUIVALENT TO A HAND GRENADE IN MY GLOVE BOX.
I WANT MY AIRBAG RECALL REPLACED BUT THERE IS STILL NO TIME FRAME AS TO WHEN I CAN GO TAKE IT AND GET IT FIXED BY THE MANUFACTURER... THIS IS DANGEROUS.
FEB. 15 , 2019 TRANSMISSION WENT OUT IN CAR. BROUGHT CAR EARLIER IN THE YEAR BECAUSE IT WAS JERKING BUT THEY SAID IT WAS NORMAL. WENT OUT OF TOWN AND TRANSMISSION WENT OUT AT 93,721 MILES. EXTENDED WARRANTY WENT OUT ON FEB. 14, 2019. ONLY HOURS BEFORE AND NO COMPANY WOULD HELP! WE PAID 5,000 FOR A REPLACEMENT AND NOTICED THAT MY…
Read full complaint
FEB. 15 , 2019 TRANSMISSION WENT OUT IN CAR. BROUGHT CAR EARLIER IN THE YEAR BECAUSE IT WAS JERKING BUT THEY SAID IT WAS NORMAL. WENT OUT OF TOWN AND TRANSMISSION WENT OUT AT 93,721 MILES. EXTENDED WARRANTY WENT OUT ON FEB. 14, 2019. ONLY HOURS BEFORE AND NO COMPANY WOULD HELP! WE PAID 5,000 FOR A REPLACEMENT AND NOTICED THAT MY DASH HAD A CRACK IN IT AFTER BEING REPAIRED. CHEVROLET COMPANY SAID THEY DIDN'T DO IT. NOW THE DASH IS ALMOST CRACKED ALL THE WAY TO MY STEERING WHEEL. I UNDERSTAND THE WEAR AND TEAR OF ANY VEHICLE, BUT FOR THE WARRANTY TO GO OUT HOURS BEFORE HAND WAS UNBELIEVABLE. PLUS, THE REPAIR MAN THAT INSTALLED MY TRANSMISSION SAID MY MOTOR DRINKS OIL. YES, WE KNOW THAT. HE EXPLAINED TO US WHY AND SAID THAT CHEVY SHOULD HAVE REPLACED MY MOTOR WHEN WE BROUGHT IT IN DURING OUR BUMPER TO BUMPER WARRANTY. WE NO LONGER USE CHEVYLAND BECAUSE OF THEIR LACK OF SERVICE DEPARTMENT. I WILL SAY THAT CHEVY NEEDS TO BUILD BETTER DOOR RESTS. EVERY TIME I PUSH OPEN MY DOOR OR CLOSE IT, THE HANDLE AREA IS BROKE IN HALF. ITS A THIN PIECE OF PLASTIC AND ITS NOT WORTH PAYING AN ARM AND LEG TO FIX IT. NEEDS TO BE A PIECE OF METAL.
REPLACEMENT OF RACK AND PINION
TL* THE CONTACT OWNS A 2013 CHEVROLET SUBURBAN. THE CONTACT STATED THAT VARIOUS ELECTRICAL FAILURES WOULD INTERMITTENTLY OCCUR WHILE DRIVING AT VARIOUS SPEEDS. THE CONTACT STATED THAT THE AUTOMATIC DOORS WOULD INDEPENDENTLY LOCK AND UNLOCK, SEVERAL WARNING LIGHTS WOULD FLASH ON THE INSTRUMENT PANEL, AND THAT THE HOME SCREEN WOUL…
Read full complaint
TL* THE CONTACT OWNS A 2013 CHEVROLET SUBURBAN. THE CONTACT STATED THAT VARIOUS ELECTRICAL FAILURES WOULD INTERMITTENTLY OCCUR WHILE DRIVING AT VARIOUS SPEEDS. THE CONTACT STATED THAT THE AUTOMATIC DOORS WOULD INDEPENDENTLY LOCK AND UNLOCK, SEVERAL WARNING LIGHTS WOULD FLASH ON THE INSTRUMENT PANEL, AND THAT THE HOME SCREEN WOULD FLICKER ON AND OFF. ONCE THE FAILURE OCCURRED, THE VEHICLE WOULD STALL WITHOUT WARNING. EACH TIME THE FAILURE OCCURRED, THE CONTACT PULLED OFF TO THE SIDE OF THE ROAD, MANUALLY SHIFT THE BATTERY CABLES UNDERNEATH THE HOOD AND RESTART THE VEHICLE. THE CONTACT HAD TAKEN THE VEHICLE TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT ALSO CONTACTED THREE DIFFERENT DEALERS, GOLD RUSH CHEVROLET (570 GRASS VALLEY HWY, AUBURN, CA 95603), JOHN L SULLIVAN CHEVROLET (350 AUTOMALL DR, ROSEVILLE, CA 95661) AND WINNER CHEVROLET (1624 S CANYON WAY, COLFAX, CA 95713), ALL OF WHOM STATED THAT THEY HAD NEVER HEARD OF SUCH A FAILURE. UPON INVESTIGATION, THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 14V614000 (ELECTRICAL SYSTEM) WHICH HE LINKED TO THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.
I PREVIOUSLY FILED A REPORT CONCERNING THE DASHBOARD CRACKING IN 2 SPOTS. ON THE PASSENGER SIDE THE CRACK IS AT THE TOP LEFT CORNER OF WHERE THE AIRBAG SITS. THIS HAS BEEN BROUGHT TO GM'S ATTENTION THEY'VE FOUGHT REPLACING THESE DASHBOARDS. NOW YOU HAVE ISSUED A RECALL ON THE AIRBAGS. HOW ARE THEY TO BE REPAIRED CORRECTLY AND M…
Read full complaint
I PREVIOUSLY FILED A REPORT CONCERNING THE DASHBOARD CRACKING IN 2 SPOTS. ON THE PASSENGER SIDE THE CRACK IS AT THE TOP LEFT CORNER OF WHERE THE AIRBAG SITS. THIS HAS BEEN BROUGHT TO GM'S ATTENTION THEY'VE FOUGHT REPLACING THESE DASHBOARDS. NOW YOU HAVE ISSUED A RECALL ON THE AIRBAGS. HOW ARE THEY TO BE REPAIRED CORRECTLY AND MADE SAFE WHEN THE PLASTIC SEATED AROUND THEM IS CRACKED AND DEFECTIVE THUS LEAVING US STILL EXPOSED TO SHATTERED PLASTIC FROM A DEFECTIVE DASHBOARD. THE DASHBOARD REPLACEMENT SHOULD ALSO BE PART OF THE RECALL!
Official recalls
421V053000 · Air Bags:frontal:passenger Side:inflator Module
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2010 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2009 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 24, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328790.
21V054000 · Air Bags:frontal:passenger Side:inflator Module
Feb 5, 2021
General Motors, LLC (GM) is recalling certain 2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally GM is recalling certain 2011-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, Yukon XL and 2011-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Additionally, GM is recalling certain 2010-2014 Cadillac Escalade, Escalade ESV, Chevrolet Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 2500, Sierra 3500, Yukon, and Yukon XL and 2010-2013 Cadillac Escalade EXT, Chevrolet Avalanche, Silverado 1500, and GMC Sierra 1500 vehicles originally sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 25, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed to 40 VIN owners on May 11, 2021. A second owner notification letter was mailed to all other owners on January 24, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328800.
14V614000 · Electrical System
Oct 1, 2014
General Motors LLC (GM) is recalling certain model year 2013-2014 Cadillac CTS, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL, and 2014 Buick Enclave, Chevrolet Express, Impala, Silverado HD, Traverse, GMC Acadia, Savana, and Sierra HD vehicles. In the affected vehicles, the chassis electronic module may be internally contaminated, resulting in an electrical short.
Consequence & remedy
Consequence: If the module experiences an electrical short, the vehicle could stall, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the chassis electronic module, free of charge. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-006 (Cadillac), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GMs number for this recall is 14515.
13V001000 · Power Train:automatic Transmission; Steering:column LOCKING:ANTI-THEFT Device
Jan 2, 2013
General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.
Consequence & remedy
Consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.
Remedy: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.
Additional source detail variants (2)
Power Train:automatic Transmission
General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.
Consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.
Remedy: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.
Steering:column LOCKING:ANTI-THEFT Device
General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.
Consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.
Remedy: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Illustration