TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH WHEN THE BRAKES LOCKED AND THE VEHICLE WOULD ONLY ACCELERATE AT A VERY LOW SPEED. THE CONTACT CONTINUED TO DRIVE AT A LOW SPEED UNTIL SHE HEARD A LOUD BANG AND THE VEHICLE SUDDENLY BEGAN TO PICK UP SPEED. THE FAILURE RECURRED INTERMITT…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH WHEN THE BRAKES LOCKED AND THE VEHICLE WOULD ONLY ACCELERATE AT A VERY LOW SPEED. THE CONTACT CONTINUED TO DRIVE AT A LOW SPEED UNTIL SHE HEARD A LOUD BANG AND THE VEHICLE SUDDENLY BEGAN TO PICK UP SPEED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT REPAIRED NOR WAS THE VEHICLE INSPECTED FOR THE FAILURE. ON A LATER DATE WHILE DRIVING 45 MPH, SHE APPLIED PRESSURE TO THE BRAKE PEDAL AND THE PEDAL ABNORMALLY DEPRESSED INTO THE FLOORBOARD. THE BRAKES DID NOT RESPOND AND THE CONTACT SHIFTED THE VEHICLE INTO NEUTRAL AND COASTED TO A STOP. THE VEHICLE WAS EXAMINED BY AN INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE BRAKE DISCS HAD FAILED. THE VEHICLE WAS REPAIRED. SHE ALSO STATED THAT THE SPEEDOMETER WAS INOPERABLE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS UNKNOWN.
NHTSA ODI #10365013
88,000 miles · Feb 12, 2010
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE ABS BRAKES AND THE STABILITRAK WERE OUT OF ORDER UNTIL THE ABS CONTROL MODULE PART BECOMES AVAILABLE. PART#15234605 HAS BEEN ON BACK ORDER FOR OVER THREE WEEKS AND EACH WEEK THE DEALER ADDED TWO ADDITIONAL WEEKS AS THE AVAILABILITY DATE. THE GM MANUFACTUR…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE ABS BRAKES AND THE STABILITRAK WERE OUT OF ORDER UNTIL THE ABS CONTROL MODULE PART BECOMES AVAILABLE. PART#15234605 HAS BEEN ON BACK ORDER FOR OVER THREE WEEKS AND EACH WEEK THE DEALER ADDED TWO ADDITIONAL WEEKS AS THE AVAILABILITY DATE. THE GM MANUFACTURER WAS CONTACTED AND STATED THAT THERE WAS NOTHING THEY COULD DO. THE CONTACT FILED A CLAIM WITH THE MANUFACTURER. THE FAILURE MILEAGE WAS 88,000.
NHTSA ODI #10308902
Mileage unknown · Jan 12, 2006
Power TrainService Brakes, HydraulicStructure
DT*: THE CONTACT STATED THAT THE 2005 CHEVROLET SUBURBAN HAS NO QUICK EXIT FROM THE THIRD SEAT AND THE TAILGATE. IT TAKES TOO MUCH FORCE TO OPEN FROM THE INSIDE. THE VEHICLE IS SO LONG THE SIDE VIEW MIRRORS DO NOT SHOW THE ROAD VERY WELL EVEN AFTER ADJUSTMENTS ARE MADE. THE BRAKES ON THE VEHICLE TAKE TOO MUCH FORCE TO STOP TH…
Read full complaint
DT*: THE CONTACT STATED THAT THE 2005 CHEVROLET SUBURBAN HAS NO QUICK EXIT FROM THE THIRD SEAT AND THE TAILGATE. IT TAKES TOO MUCH FORCE TO OPEN FROM THE INSIDE. THE VEHICLE IS SO LONG THE SIDE VIEW MIRRORS DO NOT SHOW THE ROAD VERY WELL EVEN AFTER ADJUSTMENTS ARE MADE. THE BRAKES ON THE VEHICLE TAKE TOO MUCH FORCE TO STOP THE VEHICLE IN AN EMERGENCY. LASTLY, THE PICKUP ON THE TRANSMISSION IS SLUGGISH WHICH IS A CONCERN IN EMERGENCY CONDITIONS WHEN ACCELERATING FROM A STOPPED POSITION. THE CONTACT SPOKE WITH THE DEALER, AND WAS REFERRED TO THE MANUFACTURER BECAUSE ALL ISSUES ARE WITH THE DESIGN OF THE VEHICLE.*AK
NHTSA ODI #10147622
Mileage unknown · Oct 25, 2005
Service Brakes, Hydraulic
GENERAL MOTORS RECENTLY ANNOUNCED AN SUV/TRUCK RECALL FOR DEFECTIVE AND UNSAFE ANTI-LOCK BRAKE SYSTEMS. THE RECALL WENT INTO EFFECT IN 14 COLD-WEATHER STATES AND CANADA...BUT IT EXCLUDED WISCONSIN!!!! IT DID SO BECAUSE GM SAID IT DIDN'T HAVE ENOUGH COMPLAINTS FROM WISCONSIN. THAT'S LUDICROUS! MANY HERE HAD THE SAME PROBLEMS A…
Read full complaint
GENERAL MOTORS RECENTLY ANNOUNCED AN SUV/TRUCK RECALL FOR DEFECTIVE AND UNSAFE ANTI-LOCK BRAKE SYSTEMS. THE RECALL WENT INTO EFFECT IN 14 COLD-WEATHER STATES AND CANADA...BUT IT EXCLUDED WISCONSIN!!!! IT DID SO BECAUSE GM SAID IT DIDN'T HAVE ENOUGH COMPLAINTS FROM WISCONSIN. THAT'S LUDICROUS! MANY HERE HAD THE SAME PROBLEMS AS IN IOWA, MICHIGAN, AND ALL THE REST. I EXPERIENCED THE PROBLEM, TOOK MY 2001 SUBURBAN TO MY GM DEALER FOR REPAIRS, AND WAS TOLD I'D BE REIMBURSED SUBJECT TO THE RECALL. THEN THE WISCONSIN EXCLUSION WAS ANNOUNCED. MANY PEOPLE HERE WILL BE OPERATING UNSAFE VEHICLES...AND THAT'S NOT RIGHT! PLEASE HELP. MARK & SHARON LEIDER. *NM
NHTSA ODI #10140712
58,000 miles · Jul 22, 2005
Service Brakes, Hydraulic
THE ANTILOCK BRAKES COME ON AT LOW SPEED, WHICH IS STARTLING AND INCREASES STOPPING DISTANCE. THIS DEFECT IS ACKNOWLEGED BY GENERAL MOTORS, THOUGH THEY REFUSE TO ISSUE A RECALL. THEY TELL ME TO PAY FOR IT MYSELF. I AM AFRAID THAT THIS DEFECT WILL CAUSE AN ACCIDENT.
NHTSA ODI #10129728
101,000 miles · May 5, 2005
Service Brakes, HydraulicCrash
2001 CHEVROLET SUBURBAN K-1500 4WD; WAS DRIVING AT LOW SPEED ~10-15 MPH AND APPLIED BRAKES HARD WITH SUDDEN AND UNEXPECTE LOSS OF BRAKES RESULTING IN MVA AND DAMAGE TO THREE VEHICLES, INCLUDING MY OWN
NHTSA ODI #10120032
Mileage unknown · Apr 19, 2005
Service Brakes, Hydraulic
MANUFACTURER PROMISED TO PURCHASE CONSUMER'S VEHICLE DUE TO THE HYDROBOOST BRAKE RECALL. THEY PROMISED TO MAKE THE FIRST PAYMENT UPON RECEIPT OF THE NEW VEHICLE. OWNER HAD IN HER POSSESSION AN ALERT BULLETIN ABOUT THE HYDROBOOST. NEITHER MANUFACTURER NOR DEALERSHIP CLAIMED RESPONSIBILITY. NOTICE STATED, EFFECTIVE IMMEDIATE…
Read full complaint
MANUFACTURER PROMISED TO PURCHASE CONSUMER'S VEHICLE DUE TO THE HYDROBOOST BRAKE RECALL. THEY PROMISED TO MAKE THE FIRST PAYMENT UPON RECEIPT OF THE NEW VEHICLE. OWNER HAD IN HER POSSESSION AN ALERT BULLETIN ABOUT THE HYDROBOOST. NEITHER MANUFACTURER NOR DEALERSHIP CLAIMED RESPONSIBILITY. NOTICE STATED, EFFECTIVE IMMEDIATELY TO STOP DELIVERY AND ANY PURCHASES FOR THE SUBURBANS AND OTHER GM TRUCKS DATED FEBRUARY 4, 2005. HIGHLIGHTED SENTENCE STATED NOT TO ALLOW CONSUMERS TO PURCHASE. *AK
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
ON CERTAIN SPORT UTILITY VEHICLES, THE BRAKE PEDAL PUSHROD RETAINER MAY BE MISSING. IF THE RETAINER IS MISSING, THE BRAKE BOOSTER PUSHROD COULD DISENGAGE FROM THE BRAKE PEDAL.
Consequence & remedy
Consequence: THIS COULD RESULT IN A LOSS OF BRAKES WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE VEHICLES FOR THE BRAKE PEDAL PUSHROD RETAINER AND INSTALL ONE IF IT IS MISSING FREE OF CHARGE. THE MANUFACTURER BEGAN CONTACTING OWNERS BY TELEPHONE ON MARCH 10, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.
Consequence & remedy
Consequence: IF THE TUBE RETAINER SCREW BREAKS, FUEL COULD LEAK FROM THE FUEL RAIL CROSSOVER JOINT, THE ENGINE MAY STALL AND, IF AN IGNITION SOURCE WERE PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL RAIL CROSSOVER TUBE AND, IF NECESSARY, REPLACE THE RETAINER SCREWS. OWNERS WERE NOTIFIED BY TELEPHONE ON JULY 30, 2004, WITH A FOLLOWUP OWNER LETTER BEGAN AUGUST 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. NOTE: THE GM BULLETIN LISTS THE TAHOE AND YUKON MODELS BECAUSE CANADIAN VEHICLES ARE INCLUDED IN THE BULLETIN. NO U.S. TAHOE OR YUKON VEHICLES ARE INCLUDED IN THE U.S. CAMPAIGN.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Chevrolet Suburban Problems, Complaints & Recalls | Skip That Year
Illustration