IllustrationAir bag sensors went out making air bag inoperable.
2005 Chevrolet Suburban
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Chevrolet Suburban do not stand out strongly from the model-year median of 118.
About this comparison →How this year compares
Owner complaints by model year
Compare all Suburban years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
110–25K
725–50K
2250–75K
2275–100K
22100–150K
11150K+
95 reports with mileage · 34 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports1 fire reports3 injury reports
Air Bags complaints
10 reportsTHE WIRING FOR THE LIGHTERS, POWER PORTS AND COMPUTER LINK MELTED. IT'S ALL PART OF THE UNDER-DASH WIRING HARNESS.
TRUCK DOOR IS NOT OPENING, FUEL GAS DEFECTIVE, REAR LIGHT SYSTEM HAS ELECTRICAL PROBLEM ALL THE TIMES, A/C SYSTEM ELECTRICAL PROBLEM.
ONE MORNING CAME OUT TO START MY 2005 SUBURBAN AND THE SERVICE AIRBAG MESSAGE POPPED ON ALONG WITH THE AIRBAG LIGHT. TOOK IT TO MY SERVICE CENTER AND WAS TOLD IT WAS A FRONT IMPACT SENSOR. WAS ALSO TOLD THIS IS A COMMON PROBLEM ON THESE VEHICLES. AFTER DOING SOME RESEARCH ONLINE I HAVE FOUND THIS TO BE A VERY COMMON PROBLEM REND…
Read full complaint
ONE MORNING CAME OUT TO START MY 2005 SUBURBAN AND THE SERVICE AIRBAG MESSAGE POPPED ON ALONG WITH THE AIRBAG LIGHT. TOOK IT TO MY SERVICE CENTER AND WAS TOLD IT WAS A FRONT IMPACT SENSOR. WAS ALSO TOLD THIS IS A COMMON PROBLEM ON THESE VEHICLES. AFTER DOING SOME RESEARCH ONLINE I HAVE FOUND THIS TO BE A VERY COMMON PROBLEM RENDERING THE AIRBAG SYSTEM INOP. I BELIEVE GM NEEDS TO STEP UP AND FIX THE ISSUE WITH THE SENSORS AS NOT EVERYONE HAS $400 TO FIX A FAULTY SENSOR. THE ODOMETER ON MY SUBURBAN IS 127,000 MILES, SO BY NO MEANS DRIVEN HARD.
AIR BAG SENSOR FAILURE RENDERING THE AIRBAGS INOPERABLE.
HAD TO REPLACE SECOND FAULTY IMPACT SENSOR FOR AIR BAG ON MY VEHICLE. THIS IS LOCATED IN FRONT OF VEHICLE. THE FIRST REPLACEMENT OF THE OTHER SENSOR WAS JULY 26, 2013. THIS VEHICLE WAS NEVER IN A CRASH AND HAD NOT DAMAGE TO THE FRONT OF THE VEHICLE. WHEN THE AIR BAG COMES ON THEY TELL ME MY AIR BAGS NO LONGER WORK. MY FAMI…
Read full complaint
HAD TO REPLACE SECOND FAULTY IMPACT SENSOR FOR AIR BAG ON MY VEHICLE. THIS IS LOCATED IN FRONT OF VEHICLE. THE FIRST REPLACEMENT OF THE OTHER SENSOR WAS JULY 26, 2013. THIS VEHICLE WAS NEVER IN A CRASH AND HAD NOT DAMAGE TO THE FRONT OF THE VEHICLE. WHEN THE AIR BAG COMES ON THEY TELL ME MY AIR BAGS NO LONGER WORK. MY FAMILY HAS A 2000 CHEVROLET TAHOE THAT HAS NEVER HAD THIS PROBLEM. I AM SURE THERE IS A LOT OF PEOPLE WHO WOULD NOT HAVE THIS ITEM FIXED. *TR
TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE AIR BAG WARNING LAMP ILLUMINATED. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC AND THE AIR BAG SENSOR WAS REPLACED HOWEVER, THE FAILURE LATER RECURRED. THE VEHICLE WAS NOT FURTHER REPAIRED AND MANUFACTURER WAS NOT MADE AWARD OF THE ISSUE. THE APP…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE AIR BAG WARNING LAMP ILLUMINATED. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC AND THE AIR BAG SENSOR WAS REPLACED HOWEVER, THE FAILURE LATER RECURRED. THE VEHICLE WAS NOT FURTHER REPAIRED AND MANUFACTURER WAS NOT MADE AWARD OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 75000.
TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, SHE CRASHED INTO THE REAR OF A TRASH TRUCK. UPON IMPACT, THE AIR BAGS DID NOT DEPLOY. THE DRIVER SUSTAINED INJURIES TO THE LEFT ARM AND LEFT LEG. THE POLICE WERE CONTACTED AND A REPORT WAS FILED. THE VEHICLE WAS TOWED TO A…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, SHE CRASHED INTO THE REAR OF A TRASH TRUCK. UPON IMPACT, THE AIR BAGS DID NOT DEPLOY. THE DRIVER SUSTAINED INJURIES TO THE LEFT ARM AND LEFT LEG. THE POLICE WERE CONTACTED AND A REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THEY DEEMED THE VEHICLE AS BEING DESTROYED. THE MANUFACTURER WAS CONTACTED AND AFTER DIAGNOSING THE VEHICLE, THEY ADVISED HER THAT THE VEHICLE WAS NOT TRAVELING FAST ENOUGH AT THE TIME OF IMPACT FOR THE AIRBAGS TO DEPLOY. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.
CHECK AIR BAG LIGHT IS ON. THIS HAS HAPPENED BEFORE AND AFTER A FEW WEEKS THE LIGHT MAY GO OFF. DEALER COULD NOT FIND A PROBLEM. THERE NEEDS TO BE A RECALL ON THIS. THOUSANDS OF PEOPLE HAVING THE SAME PROBLEM. *TR
THE AIRBAG SYSTEM HAS STOPPED WORKING 6 TIMES SINCE I BOUGHT MY BRAND NEW SUBURBAN. THE SERVICE AIR BAG LIGHT COMES ON WHICH MEANS THE SYSTEM WILL NOT WORK IF IN AN ACCIDENT. THE HAVE ATTEMPTED TO FIX IT SIX TIMES. NOW GM STATED THAT THEY WILL NOT DO ANYTHING FURTHER AND THEIR SOLUTION IS FOR ME TO BUY A NEW CAR WHEN MY CAR IS…
Read full complaint
THE AIRBAG SYSTEM HAS STOPPED WORKING 6 TIMES SINCE I BOUGHT MY BRAND NEW SUBURBAN. THE SERVICE AIR BAG LIGHT COMES ON WHICH MEANS THE SYSTEM WILL NOT WORK IF IN AN ACCIDENT. THE HAVE ATTEMPTED TO FIX IT SIX TIMES. NOW GM STATED THAT THEY WILL NOT DO ANYTHING FURTHER AND THEIR SOLUTION IS FOR ME TO BUY A NEW CAR WHEN MY CAR IS ONLY 2.5 YEARS OLD AND ONLY HAS 36,000 MILES ON IT.
Official recalls
606V289000 · Engine And Engine Cooling
Aug 3, 2006
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
05V163000 · Seat Belts:rear/other
Apr 22, 2005
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
05V103000 · Service Brakes, Hydraulic:pedals And Linkages
Mar 18, 2005
ON CERTAIN SPORT UTILITY VEHICLES, THE BRAKE PEDAL PUSHROD RETAINER MAY BE MISSING. IF THE RETAINER IS MISSING, THE BRAKE BOOSTER PUSHROD COULD DISENGAGE FROM THE BRAKE PEDAL.
Consequence & remedy
Consequence: THIS COULD RESULT IN A LOSS OF BRAKES WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE VEHICLES FOR THE BRAKE PEDAL PUSHROD RETAINER AND INSTALL ONE IF IT IS MISSING FREE OF CHARGE. THE MANUFACTURER BEGAN CONTACTING OWNERS BY TELEPHONE ON MARCH 10, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
05V055000 · Power Train:manual Transmission:shift Pattern Indicator
Feb 14, 2005
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
05V043000 · Service Brakes, Hydraulic
Feb 8, 2005
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
04V376000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Aug 2, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.
Consequence & remedy
Consequence: IF THE TUBE RETAINER SCREW BREAKS, FUEL COULD LEAK FROM THE FUEL RAIL CROSSOVER JOINT, THE ENGINE MAY STALL AND, IF AN IGNITION SOURCE WERE PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL RAIL CROSSOVER TUBE AND, IF NECESSARY, REPLACE THE RETAINER SCREWS. OWNERS WERE NOTIFIED BY TELEPHONE ON JULY 30, 2004, WITH A FOLLOWUP OWNER LETTER BEGAN AUGUST 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. NOTE: THE GM BULLETIN LISTS THE TAHOE AND YUKON MODELS BECAUSE CANADIAN VEHICLES ARE INCLUDED IN THE BULLETIN. NO U.S. TAHOE OR YUKON VEHICLES ARE INCLUDED IN THE U.S. CAMPAIGN.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.