2004 Chevrolet Suburban

I LIVE NEAR FREDERICK, MARYLAND AND TODAY I DROVE MY 2004 SUBURBAN DOWN TO THE CUL DE SAC AT THE END OF OUR STREET GOING AROUND 20MPH, BUT WHEN I PRESSED THE BRAKES, I FELT THEM GO ALMOST TO THE FLOOR, SO I PUMPED/PRESSED THEM AGAIN TWICE AND EACH TIME THEY THEN WENT FULLY TO THE FLOOR BUT THE TRUCK WAS NOT STOPPING. I MANAGED TO PUT THE VEHICLE IN NEUTRAL AND PRESS THE EMERGENCY BRAKE TO GET THE VEHICLE STOPPED WITH THE FRONT TIRES JUST 3 FEET FROM MY NEIGHBORS LAWN. I THEN GOT OUT AND LOOKED UNDER THE VEHICLE AND THERE WAS BRAKE FLUID EVERYWHERE ALONG WITH A TRAIL OF IT ABOUT 30-40 FEET UP THE STREET FROM WHERE I FIRST PRESSED THE BRAKES. I TOWED THE TRUCK BACK TO MY DRIVEWAY AND LOOKED UNDERNEATH AND CAN SEE THAT ALL OF THE STEEL BRAKE LINES ARE HEAVILY RUSTED ALONG THE FRAME BELOW THE DRIVERS DOOR AREA. I COULD SEE THAT ONE OF THE LINES CLEARLY RUPTURED AND SPRAYED BRAKE FLUID EVERYWHERE. I STARTED LOOKING ON THE INTERNET AND SEE THE SAME SYMPTOM/PROBLEMS ARE ALREADY LISTED AS UNDER INVESTIGATION FOR 1999-2003 CHEVY TRUCKS UNDER NHTSA ACTION NUMBER : PE10010. MINE IS A 2004 MODEL YEAR BUT IT MAY HAVE BEEN BUILT IN LATE 2003. IN ANY CASE, I WAS EXTREMELY LUCKY THAT IT HAPPENED IN MY NEIGHBORHOOD AT 20MPH AND NOT ON THE HIGHWAY OR WHILE TOWING. CLEARLY GM HAS A PROBLEM AND THESE TRUCKS THAT NEEDS TO BE RECALLED AS THIS PROBLEM COULD KILL PEOPLE VERY EASILY! *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. WHILE PARKED, THE DRIVER DEPRESSED THE BRAKE PEDAL BUT THE BRAKES WOULD NOT RESPOND. THE PARKING BRAKE WAS APPLIED IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE BRAKE LINES HAD CORRODED FROM THE INSIDE AND WOULD HAVE TO BE REPLACED ALONG WITH THE BRAKE PADS AND ROTORS. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 39,000. ...UPDATED 10/17/12 *BF THE CONSUMER STATED THE VEHICLE DID NOT SHOW ANY WARNING LIGHTS. GM OFFERED A CREDIT TOWARDS PURCHASING A NEW CHEVROLET VEHICLE. THE CONSUMER DECLINED. UPDATED 10/17/2012 *JS THE CONSUMER ALSO STATED THE CALIPERS WERE SEVERELY RUSTED, ALONG WITH THE FRONT CALIPER HOSES AND FRONT ROTORS, WHICH CAUSED THE BRAKE PADS TO CRACK AND WEAR UNEVENLY. UPDATED EVOQ 10/24/12 UPDATED EVOQ 11/21/12

WAS DRIVING AT A VERY LOW RATE OF SPEED; TRYING TO STOP WHEN WHAT FELT LIKE THE ANTILOCK BRAKES KICKED ON AND THE MESSAGE "TRACTION ACTIVE" APPEARED ON MY CONSOLE. THIS MADE IT VERY DIFFICULT TO CONTROL AND STOP THE VEHICLE. THEN WHEN TRYING TO ACCELERATE, VEHICLE WOULD LUG DOWN AND NOT WANT TO GO. THERE WAS ALSO A NOISE, LIKE A PUMP OR SOMETHING WHEN TRYING TO BRAKE OR ACCELERATE. TURNING OFF THE STABILITRACK SEEMS TO STOP THIS FROM HAPPENING, WHICH IN TURN MEANS I DO NOT HAVE ANTILOCK BRAKES. THIS IS A HUGE SAFETY ISSUE, ESPECIALLY IF TRYING TO MERGE, PASS THROUGH AN INTERSECTION OR WHILE DRIVING AT A HIGH RATE OF SPEED. *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE BRAKES WERE SPONGY AND CONTINUED TO FEEL WEAKENED. THE DEALER REPLACED THE SENSOR FOR THE FRONT ANTI-LOCK BRAKING SYSTEM FIVE TIMES TO NO AVAIL. THE CONTACT STATED THAT THE ANTI-LOCK BRAKING SYSTEMS WOULD INDEPENDENTLY ENGAGE AT LOW SPEED AND THE BRAKES WOULD FEEL SHAKY. THE DEALER WAS UNABLE TO PROVIDE A CAUSE FOR THE FAILURE. THE FAILURE MILEAGE WAS 37,520 AND THE CURRENT MILEAGE WAS 80,000.

TL*THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. WHILE DRIVING APPROXIMATELY 35 MPH, THE STEERING WHEEL REQUIRED GREATER EFFORT TO TURN. THERE WAS A LOW POWER RESPONSE WHEN THE BRAKE PEDAL WAS DEPRESSED. IN ADDITION, THE SERVICE BRAKE BOOSTER WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 05V043000 (SERVICE BRAKES, HYDRAULIC), ALTHOUGH THE FAILURES WERE IDENTICAL. THE FAILURE AND CURRENT MILEAGES WERE 23,400. UPDATED 08/28/09. *LJ UPDATED 08/31/09.*JB

THE VEHICLE LOST IT'S SERVICE STABILITY CONTROL AT 40 MILES PER HOUR MAKING IT DIFFICULT FOR THE DRIVER TO MAINTAIN CONTROL OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIR FOR THE FOURTH TIME, BUT THERE STILL CONTINUES TO BE A STEERING PROBLEM. *NM THERE WERE FIVE REPAIR ATTEMPTS TO REPAIR THE SYSTEM. THE BRAKES WOULD PULSE AND COME ON WHILE THE VEHICLE WAS IN MOTION FOLLOWED BY THE SERVICE STABILITY LIGHT. THE VEHICLE WOULD SHAKE VIOLENTLY AS IF IT WERE OUT OF CONTROL. THE TRANSMISSION WOULD SLIP AT TIMES. A SERVICE BULLETIN WAS FOUND IN RE TO THE CLUTCH. THE FORWARD CLUTCH SEAL/PISTON DISS PUMP AS WELL AS THE SHIFT CABLE. THE YAW RATE SENSOR TABLE WAS REPLACED AND THE ABS MODULE WAS REPROGRAMMED. THERE WAS POPPING COMING FROM THE LEFT WHEN TURNING DUE TO THE CROSSMEMBER. STATIC NOISE WAS HEARD UNDER THE DASH AT TIMES WHEN THE HEADLIGHTS FLICKERED. BOTH UPPER SHOCK INSULATORS WERE SQUEAKING. BOTH SHOCK INSULATORS WERE REMOVED AND REPLACED BY NEW STYLE INSULATORS. THE YAW RATE SENSOR WAS REPLACED AGAIN WITH ONE FORM A NEW UNIT, THE STEERING ROTATION SENSOR WAS REPLACED AND THE STABILITY MODULE WAS REPROGRAMMED. *SC *JB