IllustrationWHILE DRIVING THERE WAS VIBRATION IN THE STEERING WHEEL. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
1997 Chevrolet Suburban
Owner reports · Recalls · Investigations
More warning signs than most Suburban years
Owner complaints for the 1997 Chevrolet Suburban are substantially higher than the model-year median of 118.
About this comparison →How this year compares
Owner complaints by model year
Compare all Suburban years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 76 of 414 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 105 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
22 crash reports13 fire reports13 injury reports
What owners actually said
414 reportsMY VEHICLE WAS FITTED WITH THE FIX FOR INTERMITTENT WINDSHIELD WIPERS. THE FIX WAS WARRANTED FOR TWELVE MONTHS OR 12KMILES. NINE MONTHS LATER, ON TOP OF A MOUNTAIN IN COLORADO, WITH A BLIZZARD BLOWING, THE W/W DECIDED TO STOP WORKING, I STOPPED THE VEHICLE AND BEAT ON THE W/W WITH A WATER BOTTLE AND THEY STARTED WORKING AGAIN. N…
Read full complaint
MY VEHICLE WAS FITTED WITH THE FIX FOR INTERMITTENT WINDSHIELD WIPERS. THE FIX WAS WARRANTED FOR TWELVE MONTHS OR 12KMILES. NINE MONTHS LATER, ON TOP OF A MOUNTAIN IN COLORADO, WITH A BLIZZARD BLOWING, THE W/W DECIDED TO STOP WORKING, I STOPPED THE VEHICLE AND BEAT ON THE W/W WITH A WATER BOTTLE AND THEY STARTED WORKING AGAIN. NEITHER CHEVROLET OR MY CHEV. DEALER WILL REPLACE THE DEFECTIVE MODULE BECAUSE THE FAULT OCCURRED AT 12K MILES. *JB
I OWN A1997 CHEVY SUBURBAN LT. WE ASKED A LOCAL CHEVY DEALER TO FIX THE DOORS TO CLOSE PROPERLY, WHICH THEY CLAIMED TO DO. I NOTICED THAT THE DOOR DID NOT LINE UP AND THEY SAID THEY ADJUSTED THE STRIKE PLATE. EVIDENTLY THAT MEANS THEY USED A SLEDGE HAMMER. MY WIFE WAS DRIVING DOWN THE ROAD AND ONE OF THE LOCKED DOORS OPENED…
Read full complaint
I OWN A1997 CHEVY SUBURBAN LT. WE ASKED A LOCAL CHEVY DEALER TO FIX THE DOORS TO CLOSE PROPERLY, WHICH THEY CLAIMED TO DO. I NOTICED THAT THE DOOR DID NOT LINE UP AND THEY SAID THEY ADJUSTED THE STRIKE PLATE. EVIDENTLY THAT MEANS THEY USED A SLEDGE HAMMER. MY WIFE WAS DRIVING DOWN THE ROAD AND ONE OF THE LOCKED DOORS OPENED UP AS SHE WAS DRIVING DOWN THE ROAD. LUCKILY MY 4 YEAR OLD SON WAS IN HIS CARSEAT. IT HAS HAPPENED TWICE. SHE COULD NOT RECLOSE THE DOOR AND SO SHE TIED IT SHUT. I FOUND THAT THE DOOR LATCH WAS STILL SHUT. I HELD THE HANDLE UP AND MANUALLY LIFTED THE LATCH AFTER WHICH THE DOOR WOULD CLOSE. ANOTHER SAFTEY ISSUE; WHILE DRIVING DOWN THE ROAD THE STEERING WHEEL JERKS SUDDENLY TO THE RIGHT. I LIVE IN A MOUNTAINOUS AND OCCASIONAL SNOW AREA. I WORRY THAT WITH THE STEERING WHEEL JERKING, AND SOMETIMES IT HAS SENT ME TOWARDS THE LANE NEXT TO ME, THIS COULD BE A SERIOUS PROBLEM. I HAVE ALSO HAD THE POWER STEERING PUMP REPLACED ONCE AFTER THE SHAFT COMPLETLY SEPERATED FROM THE PUMP WHILE I WAS DRIVING DOWN A STEEP MOUNTAIN WITH 7 BOYSCOUTS FROM A CAMPING TRIP IN THE SNOW. LET ME TELL YOU IF THAT HAD BEEN MY WIFE IN THE CAR SHE PROBABLY WOULD HAVE BEEN DOWN THE SIDE OF THE CLIFF. IN 2 1/2 YRS. I HAVE REPLACED THE FOUR WHEEL DRIVE ACTUATOR, DOOR HANDLES, TRANSMISSION, REAR END SEALS AND AXLE, FRONT END, A/C EVERYTHING,WINDSHIELD WIPER SWITCH OF SOME SORT,BRAKES EVERY 20,000 OR SO, THEY TELL ME THE HEAD GASKET IS BAD,THERE IS A WHINING SOUND I THINK IS THE FAN CLUTCH,AND NOW IT LOOKS LIKE ITS EITHER THE U JOINTS OR THE LIMITED SLIP CLUTCHES, HUB OR BOTH. I DO NOT FEEL THAT MY WIFE AND CHILDREN ARE SAFE IN THIS CAR. ALL LAMB CHEVROLET OF PRESCOTT VALLEY AZ HAS SAID IS THEY WARRANTY THEIR VEHICLES TO 36,000 MILES. THEY OFFERED TO SELL ME ONE OF THEIR NICE NEW TAHOES. WHICH HE CLAIMS THEY HAVE IMPROVED. OH YEA THE SALES PRICE IS 42,000. ON A 36,000 VEHICLE BECAUSE I AM UPSIDE DOWN ON THE CAR THEY SOLD ME 2 YEARS AGO.*AK
FUEL INJECTION SYSTEM INJECTORS FAILED TWICE. AS A RESULT, VEHICLE STALLED. THE PART WAS REPLACED FOUR TIMES,HOWEVER PROBLEM STILL EXISTS. *AK
WHEN MAKING A RIGHT OR LEFT TURN, THE STEERING FAILED. *AK *JB
FRONT BRAKES WORE OUT PREMATURELY AT 12,000 MILES. SINCE 1997 HAD BEEN REPLACED SEVEN TIMES. DEALER AND MANUFACTURER WERE CONTACTED, BUT PROBLEM HAD NOT BEEN RESOLVED. ALSO, AUTOMATIC TRANSMISSION FAILURE. *AK
WHILE MAKING A LEFT TURN VEHICLE LOST POWER STEERING. THE VEHICLE BEGAN TO WANDER AND JERKED TO THE LEFT. THERE WAS RECALL 03V527000 FOR THE STEERING GEAR BEARING, BUT THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. *AK THIS OCCURRED DUE TO THE SENSOR CONTROLLING POWER ASSIST (EVO SENSOR/EXHAUST VALVE OPENING). *SC
WINDSHIELD WIPERS COME ON AND OFF BY THEMSELVES WHILE DRIVING IN INCLEMENT WEATHER. THIS PROBLEM IS INTERMITTENT, AND THE DEALER IS AWARE OF THE PROBLEM.*AK *MR
WHEN TURNING RIGHT, STEERING SEEMS TO ASSIST MORE, CAUSING ABRUPT OVERSTEER. HAPPENS INTERMITANTLY.*AK
1997 CHEVROLET SUBURBAN FUEL TANK SAFETY CONCERNS ELECTRIC FUEL PUMP FAILURE, WIRING HARNESS INSIDE TANK MELTED PER CERTIFIED MECHANICS AT MOTOR CAR MALL, PERALTA, NM IS THERE NO CIRCUIT PROTECTION? *AK
Official recalls
203V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
03V093000 · Visibility:rearview Mirrors/devices:exterior
Mar 7, 2003
CERTAIN SPORT UTILITY VEHICLES, MINI VANS, AND PICKUP TRUCKS MAY DEVELOP A SHORT CIRCUIT IN THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH.
Consequence & remedy
Consequence: IF THIS WERE TO HAPPEN, IT COULD RESULT IN AN INOPERATIVE SWITCH, HEAT DAMAGE TO THE DRIVER'S DOOR, AND/OR IGNITION OF COMPONENTS IN THE DRIVER'S DOOR AND A SUBSEQUENT VEHICLE FIRE WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSTALL A FUSED JUMPER HARNESS TO THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH. OWNER NOTIFICATION BEGAN ON APRIL 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA00013 · Battery Leaks Acid
Opened May 2, 2000 · Closed Jun 28, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
DP00001 · Oem Hitch Receiver Platform Cracking
Opened Jan 31, 2000 · No close date supplied
Status: open (inferred from source dates) · Equipment
THE PETITION ALLEGES THAT CRACKS IN THE HITCH RECEIVER PLATFORM MAY LEAD TO SEPARATION OF THE TRAILER AND LOSS OF STEERING CONTROL
EA99011 · Erratic Power Steering Assist While Driv
Opened May 12, 1999 · Closed Feb 27, 2001
Status: closed (inferred from source dates) · Steering
THE OFFICE OF DEFECT INVESTIGATION (ODI) HAS INVESTIGATED ALLEGATIONS OF POWER STEERING ASSIST FLUCTUATIONS IN THE SUBJECT VEHICLES.FOR DETAILS AND A BASIS FOR THE INVESTIGATION CONCLUSIONS, PLEASE SEE THE CLOSING REPORT IN THE EA99-011 PUBLIC FILE.ODI HAS NOT IDENTIFIED A SAFETY-RELATED DEFECT TREND IN THE SUBJECT VEHICLE POPULATION.FUTHER EXPENDITURE OF AGENCY RESOURCES ON THIS SUBJECT DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ENGINEERING IS CLOSED.
EA95026 · Poor Brake Performance
Opened Sep 20, 1995 · Closed Sep 20, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
POOR PERFORMANCE OF ABS BRAKES