IllustrationSPEEDOMETER QUIT WORKING CORRECTLY IT DOES NOT GO BELOW 42 MPH AND SOMETIMES WILL NOT GO BELOW 90 MPH. *TR
2004 Chevrolet Suburban 2500
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Suburban 2500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
10–25K
225–50K
650–75K
675–100K
3100–150K
2150K+
20 reports with mileage · 0 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seats. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports1 fire reports0 injury reports
Electrical System complaints
7 reportsTL*THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN 2500. THE CONTACT STATED THAT THE CLUSTER IN THE VEHICLE WAS FAULTY AND THE INSTRUMENT PANEL FAILED. AS A RESULT, THE CONTACT DOES NOT KNOW HOW FAST SHE IS DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIR, WHICH WOULD COST BETWEEN $500-$600. THE MANUFACTURER STATED THAT TH…
Read full complaint
TL*THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN 2500. THE CONTACT STATED THAT THE CLUSTER IN THE VEHICLE WAS FAULTY AND THE INSTRUMENT PANEL FAILED. AS A RESULT, THE CONTACT DOES NOT KNOW HOW FAST SHE IS DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIR, WHICH WOULD COST BETWEEN $500-$600. THE MANUFACTURER STATED THAT THE WARRANTY WAS EXPIRED ON THE VEHICLE AND WOULD HAVE TO BE REPAIRED AT THE CONTACT'S EXPENSE. THERE WERE NO RECALLS FOR THE FAILURE. THE FAILURE MILEAGE WAS 87,000.
FIRST OCCURRENCE WAS IN 02/2008. POWER SEAT ADJUSTER AND SEAT HEATER QUIT WORKING. PROBLEM FOUND TO BE HIGH RESISTANCE IN THE ELECTRICAL CONNECTOR UNDER DRIVERS SEAT. SUBSTANTIAL BURNING AND MELTING OF THE CONNECTOR PRESENT. SECOND OCCURRENCE ON 2/13/09, FOUND SAME HIGH RESISTANCE PROBLEM AT THE CONNECTOR BETWEEN BODY AND RE…
Read full complaint
FIRST OCCURRENCE WAS IN 02/2008. POWER SEAT ADJUSTER AND SEAT HEATER QUIT WORKING. PROBLEM FOUND TO BE HIGH RESISTANCE IN THE ELECTRICAL CONNECTOR UNDER DRIVERS SEAT. SUBSTANTIAL BURNING AND MELTING OF THE CONNECTOR PRESENT. SECOND OCCURRENCE ON 2/13/09, FOUND SAME HIGH RESISTANCE PROBLEM AT THE CONNECTOR BETWEEN BODY AND REAR HATCH. CAUSED REAR WIPER AND DEFROSTER TO BECOME INOPERATIVE. BOTH INCIDENTS RAISE CONCERNS ABOUT A VEHICLE FIRE DUE TO THE EXTREME HEAT THAT IS PRODUCED BY CURRENT FLOWING THROUGH A HIGH RESISTANCE CONNECTION. BOTH CONNECTORS HAVE EVIDENCE OF EXTREME HEAT AND LEAD ME TO BE LESS THAN CONFIDENT THAT THESE TWO CONNECTORS ARE THE ONLY ONES ON THIS VEHICLE THAT ARE FAULTY. I SUBMITTED A COMPLAINT ABOUT THE SEAT CONNECTOR IN FEBRUARY OF 2008, BUT FIND NO RECORD OF IT AT SAFECAR.GOV AND HAVE NEVER BEEN CONTACTED ABOUT THE COMPLAINT. *TR
SPEEDOMETER JUMPED FROM APPROX.69 TO 110 AND CONTINUED TO STAY HAYWIRE AND IS NOT READING ACCURATELY. APPARENTLY A KNOWN PROBLEM BY CHEVY BUT THEY ARE ONLY REPAIRING IN 7 YEARS 70,000 MILES. OF COURSE I AM AT 4 YEARS AND AT 77,000. I WAS OVER 74K MILES WHEN NOTICE CAME OUT SO EVEN THEN WOULD NOT HAVE BEEN ABLE TO GET KNOWN DEFEC…
Read full complaint
SPEEDOMETER JUMPED FROM APPROX.69 TO 110 AND CONTINUED TO STAY HAYWIRE AND IS NOT READING ACCURATELY. APPARENTLY A KNOWN PROBLEM BY CHEVY BUT THEY ARE ONLY REPAIRING IN 7 YEARS 70,000 MILES. OF COURSE I AM AT 4 YEARS AND AT 77,000. I WAS OVER 74K MILES WHEN NOTICE CAME OUT SO EVEN THEN WOULD NOT HAVE BEEN ABLE TO GET KNOWN DEFECT FIXED. *TR
A SHORT IN THE WIRING THAT POWERS THE HEATED SEATS AND POWER DRIVERS SEAT. CONNECTOR IS BURNED AND MELTED. AS A RESULT OF THE SHORT, MY BATTERY HAS BEEN DRAINED TWICE. LUCKILY THIS WAS FOUND BEFORE A FIRE OR SERIOUS INJURY. *TR
1. DRIVING AT HIGHWAY SPEEDS WHEN SPEEDOMETER STARTS SLOWLY REGISTERING DOWN TO ZERO 2. COULD NOT TELL HOW FAST I WAS GOING 3. DEALERSHIP AGREED TO REPLACE THE INSTRUMENT CLUSTER. *JB
THE SPEEDOMETER ON MY 2004 CHEVROLET SUBURBAN DOES NOT READ THE CORRECT SPEED. I AM CONCERNED THAT MY 16 YEAR OLD DAUGHTER IS NOT EXPERIENCED ENOUGH TO REALIZE THAT THE SPEEDOMETER IS WRONG, CAUSING HER TO DRIVE AT AN UNSAFE SPEED, INCREASING THE RISK OF AN EXCESSIVE SPEED ACCIDENT. CONVERSELY, AS THE SPEEDOMETER TYPICALLY REA…
Read full complaint
THE SPEEDOMETER ON MY 2004 CHEVROLET SUBURBAN DOES NOT READ THE CORRECT SPEED. I AM CONCERNED THAT MY 16 YEAR OLD DAUGHTER IS NOT EXPERIENCED ENOUGH TO REALIZE THAT THE SPEEDOMETER IS WRONG, CAUSING HER TO DRIVE AT AN UNSAFE SPEED, INCREASING THE RISK OF AN EXCESSIVE SPEED ACCIDENT. CONVERSELY, AS THE SPEEDOMETER TYPICALLY READS A SPEED HIGHER THAN ACTUAL SPEED, I AM CONCERNED ABOUT CREATING A TRAFFIC HAZARD BY IMPEDING THE FLOW OF TRAFFIC AND POSSIBLY BEING REAR ENDED BY A FASTER VEHICLE. I BELIEVE THAT THESE CONCERNS ARE A SAFETY RISK WITH THIS VEHICLE THAT SHOULD BE SUBJECT TO A RECALL CAMPAIGN. *JB
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.