TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 15 MPH, THE BRAKE PEDAL EXTENDED TO THE FLOOR WITHOUT WARNING AND IT BECAME DIFFICULT TO STOP THE VEHICLE. THE DEALER STATED THAT THE BRAKE LINES WERE RUSTED AND LEAKING. THE FUEL LINES WERE ALSO RUSTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. T…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 15 MPH, THE BRAKE PEDAL EXTENDED TO THE FLOOR WITHOUT WARNING AND IT BECAME DIFFICULT TO STOP THE VEHICLE. THE DEALER STATED THAT THE BRAKE LINES WERE RUSTED AND LEAKING. THE FUEL LINES WERE ALSO RUSTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 36,900.
NHTSA ODI #10661539
36,900 miles · Dec 1, 2014
Fuel/propulsion SystemService Brakes
TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 15 MPH, THE BRAKE PEDAL SANK TO THE FLOORBOARD WITHOUT WARNING AND THE VEHICLE FAILED TO STOP. THE DEALER STATED THAT THE BRAKE LINES WERE RUSTED AND CONTAINED LEAKS. ALSO, THE TECHNICIAN DIAGNOSED THAT THE FUEL LINES WERE RUSTED. THE MANUFACTURER WAS M…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 15 MPH, THE BRAKE PEDAL SANK TO THE FLOORBOARD WITHOUT WARNING AND THE VEHICLE FAILED TO STOP. THE DEALER STATED THAT THE BRAKE LINES WERE RUSTED AND CONTAINED LEAKS. ALSO, THE TECHNICIAN DIAGNOSED THAT THE FUEL LINES WERE RUSTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 36,900. UPDATED 3/31/15*CN UPDATED 9/7/2017*CN
NHTSA ODI #10661387
107,000 miles · Dec 13, 2013
Fuel/propulsion SystemService Brakes, Hydraulic
BRAKE LINES RUSTED COMPLETELY THROUGH AND BLEW OUT WHILE BRAKING AND LOST ALL PRESSURE. FUEL LINES ARE SEVERELY RUSTED. *TR
NHTSA ODI #10555919
9,028 miles · Nov 13, 2013
Fuel/propulsion SystemService Brakes
CHEVROLET SILVERADO 2500 HD (2006) WAS PURCHASED NEW, FROM GENGRAS CHEVROLET-585 CONNECTICUT BLVD.- EAST HARTFORD, CT. 06108- TELEPHONE # 860-528-2575. BRAKE LINE RUPTURED DUE TO CORROSION, FORTUNATELY, VEHICLE WAS BEING OPERATED AT A SLOW SPEED (25) MPH. UPON INSPECTION OF UNDER THE VEHICLE, I WAS APPALLED AT THE CONDITIO…
Read full complaint
CHEVROLET SILVERADO 2500 HD (2006) WAS PURCHASED NEW, FROM GENGRAS CHEVROLET-585 CONNECTICUT BLVD.- EAST HARTFORD, CT. 06108- TELEPHONE # 860-528-2575. BRAKE LINE RUPTURED DUE TO CORROSION, FORTUNATELY, VEHICLE WAS BEING OPERATED AT A SLOW SPEED (25) MPH. UPON INSPECTION OF UNDER THE VEHICLE, I WAS APPALLED AT THE CONDITION OF BRAKE LINES,FITTINGS,BRACKETS AND RELATED COMPONENTS. THE RUST ON THE UNDERSIDE INCLUDING THE FRAME WAS SUCH THAT IT COULD BE FLAKED OFF IN 1/16" THICK CHUNKS. THIS TRUCK HAS ONLY 9028 MILES, WHAT KIND OF AUTO INDUSTRY DO WE HAVE !!!!! ? I WAS MADE AWARE OF THIS CORROSION PROBLEM (THAT CHEVROLET IS AWARE OF) BY A LOCAL AUTO MECHANIC THAT THIS CORROSION PROBLEM WAS IN PRIMARILY (2004-2005-2006) SILVERADOS. THE MATERIALS GM IS USING TO CAUSE THESE PROBLEMS IS A DISGUSTING SAMPLE OF OUR MANUFACTURING SYSTEM. THIS VEHICLE WAS PARKED OUTDOORS (ON A ASPHALT DRIVEWAY). THE REPAIRS FOR THIS SITUATION ARE IN LINE WITH THE POOR QUALITY MATERIALS THAT WERE USED, I WAS INFORMED THAT THE BODY OF THE TRUCK BED HAD TO BE REMOVED (LIFTED-OFF) TO ACCESS BRAKE LINES AND GET THIS, THE FUEL LINE IS ALSO IN THE SAME LOCATION, MIGHT BE SUSPECT TO CORROSION. THE COST OF THESE REPAIRS IS OFF THE CHARTS. (WHO IS RESPONSIBLE FOR THESE DESIGN FLAWS). AS AN AMERICAN, WHO ADVOCATES BUYING DOMESTIC VEHICLES, I WONDER WHO IS WATCHING WHAT IS GOING ON. I HOPE SOMEONE OF AUTHORITY READS THIS AND ACTS ON IT, BEFORE IT IS TO LATE FOR ALL OF US. REMEMBER, THIS VEHICLE HAS (9028) MILES ON IT, AND EXPERIENCING THESE PROBLEMS. YES, THAT IS CORRECT (9028) MILES !!!!!!!!!! *TR
NHTSA ODI #10552062
80,466 miles · Sep 27, 2013
Fuel/propulsion SystemService BrakesSuspension
EVERY BRAKE GAS AND COOLING LINE RUSTED. I HAVE LOOKED AT OTHER VEHICLES OF SAME YEAR AND MILES DIFFERENT MAKES. NO WHERE AS RUSTED AS MY 06 SILVERADO. *TR
CERTAIN SPORT UTILITY VEHICLES AND TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES HAVE AN INCOMPLETE TIRE RIM DESIGNATION ON THE CERTIFICATION/TIRE LABEL LOCATED ON THE DRIVER'S DOOR EDGE. IN ADDITION, THE LABEL MAY ALSO BE MISSING THE TIRE LOAD RATING ON THE LABEL. ALTHOUGH THIS INFORMATION IS NOT REQUIRED BY THE STANDARD, IF A TIRE OF A LESSER LOAD RATING IS INSTALLED, THE TIRE MAY NOT BE ABLE TO SUSTAIN THE LOADS ENCOUNTERED DURING USE.
Consequence & remedy
Consequence: IF A CUSTOMER REPLACES A WHEEL AND ONLY RELIES ON THE RIM SIZE DESIGNATION THAT IS INDICATED ON THE LABEL, A WHEEL THAT IS OF A DIFFERENT RIM CONTOUR DESIGNATION MAY BE INSTALLED. IT MAY BE DIFFICULT OR IMPOSSIBLE TO MOUNT THE TIRE ON A WHEEL WITH THE WRONG CONTOUR. IF THE TIRE IS MOUNTED ON THE WHEEL WITH THE WRONG CONTOUR, THE WHEEL AND TIRE MAY NOT PERFORM AS INTENDED, WHICH COULD INCREASE THE RISK OF A CRASH.
Remedy: A LABEL THAT WILL CORRECT THE LABEL ORIGINALLY INSTALLED WILL BE MAILED TO CONSUMERS ALONG WITH INSTALLATION INSTRUCTIONS. THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL. THE RECALL BEGAON ON NOVEMBER 7, 2006. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2239, CHEVROLET AT 1-800-630-2438, AND GMC TRUCKS AT 1-866-996-9463.
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
Consequence & remedy
Consequence: A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration