NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
622 reports50,000 miles · Aug 13, 2008
Electrical System
TL*THE CONTACT OWNS A 2004 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE SPEEDOMETER ON THE INSTRUMENT CONTROL PANEL WAS INOPERATIVE. SHE WAS UNABLE TO DETERMINE WHAT SPEED SHE WAS TRAVELING. SHE TOOK THE VEHICLE TO THE DEALER, BUT THEY COULD NOT IDENTIFY WHAT COMPONENT NEEDED TO BE REPLACED. THE REPAIR WOULD COST $800. …
Read full complaint
TL*THE CONTACT OWNS A 2004 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE SPEEDOMETER ON THE INSTRUMENT CONTROL PANEL WAS INOPERATIVE. SHE WAS UNABLE TO DETERMINE WHAT SPEED SHE WAS TRAVELING. SHE TOOK THE VEHICLE TO THE DEALER, BUT THEY COULD NOT IDENTIFY WHAT COMPONENT NEEDED TO BE REPLACED. THE REPAIR WOULD COST $800. SHE CALLED THE MANUFACTURER IN REFERENCE TO A CLASS ACTION LAWSUIT AND WAS INFORMED THAT THEY WERE NOT RESPONSIBLE BECAUSE THE VEHICLE EXCEEDED 80,000 MILES. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 50,000. UPDATED 09/17/08. *LJ UPDATED 09/24/08. *JB
NHTSA ODI #10237972
30,000 miles · Aug 12, 2008
Tires
TL*THE CONTACT OWNS A 2004 CHEVROLET SILVERADO. THE CONSUMER NOTICED THAT THE SPARE TIRE WAS A DIFFERENT SIZE THAN THE ORIGINAL TIRE. THE CONTACT CALLED THE DEALER AND WAS INFORMED THAT HIS SPARE TIRE WAS THE CORRECT SPARE TIRE SIZE THAT COMES WITH HIS VEHICLE. THE FAILURE MILEAGE WAS 30,000.UPDATE 09/10/08 *CW UPADTED 09/15…
Read full complaint
TL*THE CONTACT OWNS A 2004 CHEVROLET SILVERADO. THE CONSUMER NOTICED THAT THE SPARE TIRE WAS A DIFFERENT SIZE THAN THE ORIGINAL TIRE. THE CONTACT CALLED THE DEALER AND WAS INFORMED THAT HIS SPARE TIRE WAS THE CORRECT SPARE TIRE SIZE THAT COMES WITH HIS VEHICLE. THE FAILURE MILEAGE WAS 30,000.UPDATE 09/10/08 *CW UPADTED 09/15/08. *JB
NHTSA ODI #10237859
50,000 miles · Jun 4, 2008
Suspension
I HAVE A2004 CHEVY 3500 SILVERADO, WITH 50,000 MILES ON, I NOTICED A CLICKING NOISE IN THE RIGHT FRONT. WITH FURTHER INVESTIGATION, I NOTICED THAT THE FRONT WHEEL WAS LOOSE ON THE TRUCK. THE WHEEL BEARING WAS LOOSE. I CALLED GENERAL MOTORS AND DISCUSSED THE BEARING FAILURE. I GOT THE NEW BEARING AND STARTED TO DO THE REPAIR. I …
Read full complaint
I HAVE A2004 CHEVY 3500 SILVERADO, WITH 50,000 MILES ON, I NOTICED A CLICKING NOISE IN THE RIGHT FRONT. WITH FURTHER INVESTIGATION, I NOTICED THAT THE FRONT WHEEL WAS LOOSE ON THE TRUCK. THE WHEEL BEARING WAS LOOSE. I CALLED GENERAL MOTORS AND DISCUSSED THE BEARING FAILURE. I GOT THE NEW BEARING AND STARTED TO DO THE REPAIR. I NOTICED THAT EVERYTHING LOOKED NEW YET, BUT THE BEARING WAS COMING APART. THE BEARING IS A SEALED UNIT-IT IS PRESSED TOGETHER. THE BEARING IS NOT MANUFACTURED PROPERLY- IT IS NOT PRESSED TOGETHER RIGHT SO THAT THE FRONT TIRE COULD FALL OFF AND CAUSE SERIOUS ACCIDENTS. I AM SURE THERE IS ALOT OF FAILURE ON THESE BEARINGS AND THIS SHOULD BE CHECKED OUT. WHEN THESE BEARINGS FAIL BECAUSE OF THE PRESSED FIT, THEY SELF DESTRUCT VIOLENTLY AND THERE IS NO WAY YOU CAN LOOK AT IT AFTER IT FAILS UNLESS YOU CATCH IT EARLY. I CAUGHT MINE EARLY AND IT CAN BE A DANGEROUS SITUATION TO THE PUBLIC. I MADE GENERAL MOTORS AWARE OF THE PROBLEM ON THEIR 800 NUMBER AND THEY REFUSED TO ADDRESS THE PROBLEM WITH ME. *TR
NHTSA ODI #10229958
32,700 miles · Jun 2, 2008
Electrical System
SPEEDOMETER/TACH DON'T WORK, FUEL GAUGE IS INCORRECT. THE VEHICLE IS AN 04 CHEVY SILVERADO 1500 2X4. PURCHASED NEW IN 04, WARRANTY HAS EXPIRED. *TR
NHTSA ODI #10229656
85,000 miles · May 29, 2008
Electrical SystemCrashInjury
INSTRUMENT CLUSTER PANEL GAUGES WORK SPORADIC, OR NOT AT ALL. SPEEDOMETER READS OVER 120 MPH ALL THE TIME, AND GAS GAUGE DOES NOT WORK AT ALL. I HAVE NOT REPAIRED THEM YET BECAUSE OF COST ($500+ LABOR AND PROGRAMMING FEES). *TR
NHTSA ODI #10229247
37,850 miles · Apr 14, 2008
Engine And Engine Cooling
ENGINE NOISE AT IDLE. TICKING WHICH SOUNDS LIKE LIFTERS OR INJECTORS HANGING UP. *TR
NHTSA ODI #10224411
50,000 miles · Apr 14, 2008
Engine And Engine Cooling
STARTING AT AROUND 50,000 MILES AND DURING ROUTINE DRIVING CONDITIONS I NOTICED A SCENT OF ANTI-FREEZE EMANATING FROM UNDER HOOD. AT FIRST UNABLE TO LOCATE LEAK AND CONTINUED TO DRIVE VEHICLE. AT AROUND 69,000 MILES LEAK BECAME APPARENT AND WAS LEAKING FROM THE WATER PUMP. DEALER ASSESSED THE PROBLEM AND PROCEEDED TO INFORM ME T…
Read full complaint
STARTING AT AROUND 50,000 MILES AND DURING ROUTINE DRIVING CONDITIONS I NOTICED A SCENT OF ANTI-FREEZE EMANATING FROM UNDER HOOD. AT FIRST UNABLE TO LOCATE LEAK AND CONTINUED TO DRIVE VEHICLE. AT AROUND 69,000 MILES LEAK BECAME APPARENT AND WAS LEAKING FROM THE WATER PUMP. DEALER ASSESSED THE PROBLEM AND PROCEEDED TO INFORM ME THE REPAIR WOULD BE $670. FORTUNATELY I HAD AN EXTENDED WARRANTY UP TO 75,000. VEHICLE NOW FIXED AND OPERATING PROPERLY. *TR
NHTSA ODI #10224409
49,000 miles · Mar 13, 2008
Electrical System
2004 CHEVY SILVERADO WITH THE SPEEDOMETER STICKING. CONSUMER STATES THAT THE SPEEDOMETER WILL STAY AT 50 MPH FOR A WHILE THEN DROP TO 0 MPH AFTER STOPPING A FEW TIMES AND MIGHT NOT MOVE FROM 0 UNLESS HE SHUTS THE VEHICLE OFF AND RESTART IT. *KB
NHTSA ODI #10221669
82,000 miles · Mar 12, 2008
Electrical System
SPEEDOMETER DOES NOT FUNCTION PROPERLY. IT WILL DISPLAY 70 MPH WHEN STANDING STILL. IT DOES NOT DISPLAY THE MPH CORRECTLY. THE NEEDLE WILL NOT RE-ZERO AFTER IGNITION IS TURNED OFF. *TR
NHTSA ODI #10220932
40,000 miles · Mar 6, 2008
Electrical SystemFire
THE CLUSTER PANEL GAUGES ARE ALL MALFUNCTIONING, SOME HAVE GONE COMPLETELY OUT I.E. SPEEDOMETER, OIL GAUGE, ALTERNATOR, ETC. FAN MOTOR AND ADAPTER WIRES CAUGHT FIRE, SHORTED OUT. *TR
NHTSA ODI #10220226
Official recalls
8Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Aug 3, 2006
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
Apr 22, 2005
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence & remedy
Consequence: IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Apr 22, 2005
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Feb 8, 2005
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
May 11, 2004
CERTAIN EXTENDED AND REGULAR CAB PICKUP TRUCKS AND CARGO VANS CONVERTED TO COMPRESSED NATURAL GAS (CNG) FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THESE VEHICLES HAVE ONE SEATING POSITION, THE CENTER REAR SEAT, EQUIPPED WITH CHILD RESTRAINT LOWER ANCHORAGES.
Consequence & remedy
Consequence: THE STANDARD REQUIRES CHILD SEAT LOWER ANCHORAGES IN TWO SEATING POSITIONS FOR VEHICLES WITH THREE REAR SEATING POSITIONS. THE STANDARD CAB AND CARGO VAN VEHICLES, WHICH ONLY HAVE FRONT SEATING POSITIONS, HAVE AN AIR BAG OFF SWITCH TO DISABLE THE FRONT PASSENGER AIR BAG AND DO NOT HAVE CHILD RESTRAINT LOWER ANCHORAGES IN THE PASSENGER SEAT. THE STANDARD REQUIRES PASSENGER SEAT CHILD SEAT LOWER ANCHORAGES IN VEHICLES WITH AN AIR BAG OFF SWITCH. HOWEVER, THE STANDARD DOES NOT REQUIRE VEHICLES WITH ONLY FRONT SEATING POSITIONS TO HAVE LOWER ANCHORAGE PROVISIONS IF THE VEHICLE IS NOT EQUIPPED WITH AN AIR BAG OFF SWITCH.
Remedy: TO BRING THE STANDARD CAB AND CARGO VAN VEHICLES INTO COMPLIANCE, DEALERS WILL INJECT EPOXY INTO THE AIR BAG OFF SWITCH TO PREVENT AIR BAG ACTIVATION, RELOCATE THE SWITCH BEHIND THE INSTRUMENT PANEL AND THEN INSTALL A COVER OVER THE RESULTING OPENING. THE SUN VISOR LABEL AND OWNER'S MANUAL WILL ALSO BE CHANGED. THE CORRECTION FOR THE EXTENDED CAB VEHICLE WILL CONSIST OF CHANGING THE FRONT PASSENGER SEAT TO A SEAT THAT HAS CHILD RESTRAINT LOWER ANCHORAGES. THE RECALL BEGAN ON SEPTEMBER 9, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Mar 17, 2004
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.
Consequence & remedy
Consequence: ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.
Remedy: DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence & remedy
Consequence: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Remedy: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration