NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
81 reportsClear category filter16,179 miles · Aug 30, 2005
Power TrainService Brakes, HydraulicCrash
WHEN COMING UP TO AN INTERSECTION, THE TRUCK FAILED TO COME TO A COMPLETE STOP, IN DRY CONDITIONS, WITH AMPLE STOPPING DISTANCE. THE TRUCK WAS REVVING AT A HIGH RPM, AND CONTINUED TO PUSH FORWARD WITH THE BRAKE PEDAL PUSHED AS HARD AS POSSIBLE. THIS RESULTED IN A ROLLING COLLISION. VEHICLE FINALLY STOPPED WHEN SHIFTED INTO P…
Read full complaint
WHEN COMING UP TO AN INTERSECTION, THE TRUCK FAILED TO COME TO A COMPLETE STOP, IN DRY CONDITIONS, WITH AMPLE STOPPING DISTANCE. THE TRUCK WAS REVVING AT A HIGH RPM, AND CONTINUED TO PUSH FORWARD WITH THE BRAKE PEDAL PUSHED AS HARD AS POSSIBLE. THIS RESULTED IN A ROLLING COLLISION. VEHICLE FINALLY STOPPED WHEN SHIFTED INTO PARK. IMMEDIATELY CALLED DEALERSHIP, AND GM. AFTER 2 DAYS IN THE DEALERSHIP THEY STATED NOTHING IS WRONG, AND WILL NOT INVESTIGATE ANY FURTHER. I WILL NOT DRIVE THE VEHICLE ANY LONGER AFTER THIS SCARY INCIDENT.*JB
NHTSA ODI #10134784
Mileage unknown · Aug 15, 2005
Power TrainCrash
THE TRUCK WAS PARKED AND THE KEY WAS IN THE ACCESSORY (ACC) POSITION, AND MY TWO YEAR OLD GRANDDAUGHTER HIT THE SHIFT LEVER OUT OF PARK, AND THE TRUCK ROLLED DOWN THE STREET AND HIT A U-HAUL TRUCK, SHE WAS NOT INJURED, HER MOTHER WAS IN THE TRUCK WITH HER BUT COULD NOT SHIFT IT BACK INTO PARK, OR HIT THE BRAKE. *JB
NHTSA ODI #10132886
16,000 miles · Jul 26, 2005
Electrical SystemPower TrainFire
GENERAL MOTORS HAVE A FAULTY NEUTRAL SAFETY SHIFT SWITCH ON THEIR SILVERADO 1500 1/2 TON PICKUPS THAT MAY LEAD TO FAILURE AND CAUSE THE TRUCK TO BURN. I HAVE BROUGHT THIS TO THE ATTENTION OF GENERAL MOTORS BUT THEY IGNORED ME. MY TRUCK BURNED AND WE PUT IT OUT. I SEE OTHERS THAT HAVE BURNED AND I BET THE NEUTRAL SAFETY SWITCH…
Read full complaint
GENERAL MOTORS HAVE A FAULTY NEUTRAL SAFETY SHIFT SWITCH ON THEIR SILVERADO 1500 1/2 TON PICKUPS THAT MAY LEAD TO FAILURE AND CAUSE THE TRUCK TO BURN. I HAVE BROUGHT THIS TO THE ATTENTION OF GENERAL MOTORS BUT THEY IGNORED ME. MY TRUCK BURNED AND WE PUT IT OUT. I SEE OTHERS THAT HAVE BURNED AND I BET THE NEUTRAL SAFETY SWITCH IS WHAT STARTED IT. IF YOU WERE TO INVESTIGATE HOW MANY 03 (MAYBE NEWER MAYBE OLDER) HAVE BURNED YOU WILL FIND THE CAUSE IN THIS SWITCH.
NHTSA ODI #10130023
10,461 miles · Jul 17, 2005
Power Train
I OWN A 2003 CHEVROLET SILVERADO EXTENDED CAB SHORT BOX Z71 4X4 PICK UP TRUCK. IT HAS THE 4 SPEED AUTOMATIC WITH OVERDRIVE TRANSMISSION. I HAVE A CONSISTANT SHIFTING DRIVELINE CLUNK THAT ONLY OCCURS WHEN THE TRANSMISSION UPSHIFTS FROM 2ND TO 3RD GEAR AND THEN DOWNSHIFTS FROM 3RD TO 2ND GEAR. I HAVE HAD THIS VEHICLE BACK TO THE C…
Read full complaint
I OWN A 2003 CHEVROLET SILVERADO EXTENDED CAB SHORT BOX Z71 4X4 PICK UP TRUCK. IT HAS THE 4 SPEED AUTOMATIC WITH OVERDRIVE TRANSMISSION. I HAVE A CONSISTANT SHIFTING DRIVELINE CLUNK THAT ONLY OCCURS WHEN THE TRANSMISSION UPSHIFTS FROM 2ND TO 3RD GEAR AND THEN DOWNSHIFTS FROM 3RD TO 2ND GEAR. I HAVE HAD THIS VEHICLE BACK TO THE CHEVROLET DEALER THREE TIMES SO FAR CONCERNING THIS ISSUE. ALL I GET IS THE USUAL GM RUNAROUND THAT THIS PROBLEM IS A NORMAL CONDITION AND NO REPAIRS SHOULD BE ATTEMPTED ACCORDING TO THE TSB RELATED TO THIS CONDITION. I HAVE OWNED OTHER GM VEHICLES IN THE PAST, AND I HAVE NEVER HAD OF ANY OF THEM BANG OR CLUNK FROM THE TRANSMISSION WHEN SHIFTING GEARS AUTOMATICALLY. THEY CLAIM THAT IT IS SOME TYPE OF A MOMENTARY TORQUE REVERSAL PROBLEM WHEN THAT PARTICULAR SHIFT OCCURS THAT CAUSES THE CLUNKING AND OR BANGING CONDITION IN THEIR TRANSMISSION. A MOMENTARY TORQUE REVERSAL IN THEIR DRIVETRAIN WHILE THE VEHICLE IS MOVING IN FORWARD GEARS IS A NORMAL CONDITION? NOT TO ME. THEY ABSOLUTELY WILL NOT FIX THIS PROBLEM UNDER WARRANTY STATING THAT IT IS A NORMAL CONDITION. ON THE OTHER HAND, IF THIS CAUSES THE TRANSMISSION TO SUDDENLY LOCK UP...AND SOMEONE GETS HURT IN THE PROCESS....THEN I'M SURE THAT IT WILL BE FIXED PROPERLY. WHY IS IT THAT THE AUTOMOTIVE MANUFACTURERS TODAY WILL NOT REPAIR THEIR ENGINEERED SCREWUPS AT THEIR EXPENSE, LIKE THEY SHOULD BE RESPONSIBLE TO DO? WHY IS IT THAT THEY WILL NOT FIX THEIR PROBLEMS UNLESS THAT COMPONET IN QUESTION FAILS COMPLETELY?
NHTSA ODI #10129025
68,000 miles · Jul 10, 2005
Power TrainCrash
UPON PARKING, HAD SLIGHT DIFFICULTY PLACING VEHICLE INTO PARK GEAR POSITION ON VERY SLIGHT INCLINE IN DRIVEWAY OF HOME. STEPPED OUT OF VEHICLE, RETURNED A FEW MINUTES LATER TO FIND VEHICLE HAD ROLLED INTO POLE. ATTEMPTED TO START VEHICLE, BUT WOULD NOT START, TRIED TO PUT VEHICLE IN NEUTRAL, AND COLUMN SHIFT WAS VERY LOOSE…
Read full complaint
UPON PARKING, HAD SLIGHT DIFFICULTY PLACING VEHICLE INTO PARK GEAR POSITION ON VERY SLIGHT INCLINE IN DRIVEWAY OF HOME. STEPPED OUT OF VEHICLE, RETURNED A FEW MINUTES LATER TO FIND VEHICLE HAD ROLLED INTO POLE. ATTEMPTED TO START VEHICLE, BUT WOULD NOT START, TRIED TO PUT VEHICLE IN NEUTRAL, AND COLUMN SHIFT WAS VERY LOOSE. APPLIED PARKING BRAKE AND CONTACTED DEALER FOR TOW NEXT MORNING. DEALERSHIP DETERMINED THE SHIFT CABLE HAD BROKEN, REPLACED WITH NEW SHIFT CABLE. ONLY EXPLANATION OFFERED WAS PLASTIC SHEATH HAD CRACKED ALLOWING CABLE TO KINK, THEY STATED INITIALLY IT SOMETIMES HAPPENS, BUT THEY DID NOT EXPLAIN WHY. I AM VERY CONCERNED THAT IF VEHICLE WERE PARKED ON STREET ON A SLIGHT GRADE IT WOULD HAVE ROLLED DOWNHILL POSSIBLE CAUSING DAMAGE OR INJURING SOMEONE.
NHTSA ODI #10128227
8,000 miles · Jul 5, 2005
Power Train
2003 AND UP CHEVROLET SILVERADO 1500 4.8L AUTOMATIC I FOUND I AM ABLE TO SHIFT THE TRANSMISSION OUT OF PARK WITHOUT THE ENGINE RUNNING AND WITH THE KEY IN THE ACCESSORY POSITION. THIS IS FROM NO KEY INSERTED TO INSERTING KEY AND ROTATING TO THE ACCESSORY WITHOUT GOING TO THE RUN OR START POSITIONS. THIS CAN BE DONE WITHOUT DEPR…
Read full complaint
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
NHTSA ODI #10127418
15,000 miles · Jun 23, 2005
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
4X4 NOT WORKING, CHARCOAL CANISTER, CD-PLAYER 3 TIMES, COMPLETE NEW BRAKE SYSTEM FROM ROTORS,SEALS,CALIPERES ETC. THAT I PAID FOR $1,000., WINDOW REGULATOR, DOOR LATCHES, NOISE COMING FROM THE STEERING AREA, DASH PEELING APART, CHAPMAN CHEVY REPLACED ALL FOUR TIRES TWICE WITHIN 50,000 MILES-I FINALLY WENT AND SPENT $1,200 ON NE…
Read full complaint
4X4 NOT WORKING, CHARCOAL CANISTER, CD-PLAYER 3 TIMES, COMPLETE NEW BRAKE SYSTEM FROM ROTORS,SEALS,CALIPERES ETC. THAT I PAID FOR $1,000., WINDOW REGULATOR, DOOR LATCHES, NOISE COMING FROM THE STEERING AREA, DASH PEELING APART, CHAPMAN CHEVY REPLACED ALL FOUR TIRES TWICE WITHIN 50,000 MILES-I FINALLY WENT AND SPENT $1,200 ON NEW TIRES TO MAKE SURE MY FAMILY AND I OUR SAFE
NHTSA ODI #10126360
41,000 miles · Mar 30, 2005
Power TrainVehicle Speed Control
WE HAVE HAD SEVERAL THING GO WRONG WITH OUR TRUCK. WE HAVE HAD THE EXPANDABLE MIRRORS REPLACED ONCE AND FIXED SEVERAL TIMES, THE TRANSMISSION WAS REBUILT, THE SPEEDOMETER QUIT WORKING AND THE MEMORY DOES NOT RECALL THE DRIVER OR SEAT POSITION. *AK
NHTSA ODI #10116067
32,000 miles · Mar 30, 2005
Electrical SystemEngine And Engine CoolingEquipment
WHEN BRAKING AT ANY SPEED BRAKE PEDAL WOULD GO TO THE FLOOR, AND THERE WOULD BE EXTENDED STOPPING DISTANCE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK ABS DISPLAYED BRAKE SYSTEM FAILURE. THE CONSUMER STATED THAT THE BRAKES FAILED ON INCLINES. THE CONSUMER STATED THAT THERE WAS AN ELECTRICAL SHORT. THE …
Read full complaint
WHEN BRAKING AT ANY SPEED BRAKE PEDAL WOULD GO TO THE FLOOR, AND THERE WOULD BE EXTENDED STOPPING DISTANCE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK ABS DISPLAYED BRAKE SYSTEM FAILURE. THE CONSUMER STATED THAT THE BRAKES FAILED ON INCLINES. THE CONSUMER STATED THAT THERE WAS AN ELECTRICAL SHORT. THE ODOMETER FAILED AND ADDED EXTRA MILEAGE. THE TIRES STARTED SEPARATING AFTER 300 MILES. THE RADIO BECAME HOT AND SHORTED OUT. THE AIR CONDITIONER SHORTED OUT. THE CONSUMER STATED THAT THE NEW VEHICLE CHECKLIST WAS NOT FILLED OUT NOR REVIEWED WITH HIM. THE CONSUMER STATED THAT THE ENGINE KNOCKS. THE CONSUMERS FINGERS WERE BURNED BY THE RADIO AFTER IT GOT HOT. THE CONSUMER STATED THAT HE HEARD A GROWLING NOISE IN THE POWER STEERING. THE CONSUMER HEARD A BUZZING NOISE IN THE TRANSMISSION. THE CONSUMER HAD TO USE THE EMERGENCY BRAKE TO STOP THE VEHICLE COMING DOWN A HILL. THE RIGHT HEADLIGHT WENT OUT AND TURNED BLACK. THE HEADLIGHT WAS REPLACED WITH THE WRONG HIGH BEAM LIGHT. THE CD PLAYER WILL NOT TAKE THE CD. THE SPEEDOMETER WILL ONLY GO TO 20 MPH AT TIMES. *TC
NHTSA ODI #10107108
18,486 miles · Mar 22, 2005
Power Train
WHEN SHIFTING FROM THE SECOND TO THIRD GEAR A LOUD BANGING NOISE WAS PRODUCED. DEALER HAS REBUILT THE TRANSMISSION. C URRENTLY, WHEN SHIFTING FIRST GEAR TO SECOND GEAR A LOUD NOISE IS PRODUCED. CONSUMER IS CONCERNED THAT THE TRANSMISSION WILL FAIL WHILE DRIVING. *AK
NHTSA ODI #10115551
Official recalls
6Apr 22, 2005
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence & remedy
Consequence: IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Apr 22, 2005
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
May 11, 2004
CERTAIN EXTENDED AND REGULAR CAB PICKUP TRUCKS AND CARGO VANS CONVERTED TO COMPRESSED NATURAL GAS (CNG) FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THESE VEHICLES HAVE ONE SEATING POSITION, THE CENTER REAR SEAT, EQUIPPED WITH CHILD RESTRAINT LOWER ANCHORAGES.
Consequence & remedy
Consequence: THE STANDARD REQUIRES CHILD SEAT LOWER ANCHORAGES IN TWO SEATING POSITIONS FOR VEHICLES WITH THREE REAR SEATING POSITIONS. THE STANDARD CAB AND CARGO VAN VEHICLES, WHICH ONLY HAVE FRONT SEATING POSITIONS, HAVE AN AIR BAG OFF SWITCH TO DISABLE THE FRONT PASSENGER AIR BAG AND DO NOT HAVE CHILD RESTRAINT LOWER ANCHORAGES IN THE PASSENGER SEAT. THE STANDARD REQUIRES PASSENGER SEAT CHILD SEAT LOWER ANCHORAGES IN VEHICLES WITH AN AIR BAG OFF SWITCH. HOWEVER, THE STANDARD DOES NOT REQUIRE VEHICLES WITH ONLY FRONT SEATING POSITIONS TO HAVE LOWER ANCHORAGE PROVISIONS IF THE VEHICLE IS NOT EQUIPPED WITH AN AIR BAG OFF SWITCH.
Remedy: TO BRING THE STANDARD CAB AND CARGO VAN VEHICLES INTO COMPLIANCE, DEALERS WILL INJECT EPOXY INTO THE AIR BAG OFF SWITCH TO PREVENT AIR BAG ACTIVATION, RELOCATE THE SWITCH BEHIND THE INSTRUMENT PANEL AND THEN INSTALL A COVER OVER THE RESULTING OPENING. THE SUN VISOR LABEL AND OWNER'S MANUAL WILL ALSO BE CHANGED. THE CORRECTION FOR THE EXTENDED CAB VEHICLE WILL CONSIST OF CHANGING THE FRONT PASSENGER SEAT TO A SEAT THAT HAS CHILD RESTRAINT LOWER ANCHORAGES. THE RECALL BEGAN ON SEPTEMBER 9, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Mar 17, 2004
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.
Consequence & remedy
Consequence: ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.
Remedy: DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence & remedy
Consequence: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Remedy: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Jan 23, 2003
CERTAIN PICKUP TRUCKS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING." SOME OF THESE VEHICLES LACK A CONTINUOUS URETHANE BONDING BEAD BETWEEN THE BODY SURFACE AND THE WINDSHIELD.
Consequence & remedy
Consequence: IN VEHICLES WITH THIS CONDITION, THE WINDSHIELD MAY NOT BE RETAINED IN ACCORDANCE WITH THE SAFETY STANDARD DURING A VEHICLE CRASH.
Remedy: DEALERS WILL REMOVE, RESEAL, AND REINSTALL THE WINDSHIELD. OWNER NOTIFICATION BEGAN ON JANUARY 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8EA11001 · Brake Line Corrosion Failure
Opened Jan 5, 2011 · Closed Apr 8, 2015
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
Service Brakes, Hydraulic
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
PE10010 · Brake Line Corrosion Failure
Opened Mar 30, 2010 · Closed Jan 5, 2011
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
Additional source detail variants (2)
Service Brakes, Hydraulic
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was granted and on March 30, 2010, Preliminary Evaluation PE10-010 was opened on more than six million model year 1999 through 2003 light trucks and sport utility vehicles manufactured and sold by General Motors Corporation (GM).On July 2, 2010, ODI received GM's response to an information request, which included GM's assessment of the frequency and safety consequences of the alleged defect. GM stated that:(1) the brake system of the subject vehicles is split front/rear and should a brake pipe suddenly fail for any reason, the affected vehicle would be capable of stopping with the pressure supplied by the remaining circuit; (2) the subject vehicles were designed to meet the hydraulic circuit partial failure requirements of Federal Motor Vehicle Safety Standards 105 and 135, Light Vehicle Brake Systems; and (3) should a brake fluid leak occur for any reason, the brake system malfunction indicator lamp (MIL) would illuminate and warn the driver before the brake fluid level was low enough to cause a loss of line pressure.ODI's and GM's analysis indicates that 85 percent of the complaints occurred on vehicles used primarily in States that use salt on the roads during Winter months (Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin).Overall the complaint rates per 100,000 vehicles for Salt Belt States is 43.0 and Non-Salt Belt is 3.0.In approximately 25 percent of the complaints the brake pipe failure occurred suddenly, with no warning (i.e., no MIL, Brake Fluid Loss Warning), and resulted in extended stopping distances.In 30 of these the increase in stopping distance that resulted was a factor in the crash and in 10 others the vehicle was intentionally steered off the road or into another lane of travel in order to avoid a crash.This investigation has been upgraded to an Engineering Analysis (EA11-001) for subject vehicles sold or currently registered in Salt Belt States to further assess the scope, frequency and safety risks associated with sudden failures of corroded brake pipes that can result in decreased brake effectiveness. ODI will continue to gather information on subject vehicles outside the Salt Belt as well.
DP05009 · Parking Brake Failure
Opened Dec 20, 2005 · Closed May 31, 2006
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Additional source detail variants (3)
Parking Brake:conventional
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
EA04012 · Hydraulic Pump Failres
Opened Apr 30, 2004 · Closed Feb 28, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
EA04011 · Parking Brake Failure
Opened Apr 9, 2004 · Closed May 10, 2005
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical; Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (4)
Parking Brake:conventional
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA04005 · Tailgate Cable Breakage
Opened Feb 19, 2004 · Closed Sep 28, 2004
Status: closed (inferred from source dates) · Latches/locks/linkages:tailgate:latch; Structure:body:tailgate ; Structure:body:tailgate:hinge And Attachments
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
Additional source detail variants (6)
Latches/locks/linkages:tailgate:latch
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
Latches/locks/linkages:tailgate:latch
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
Structure:body:tailgate
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
Structure:body:tailgate
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
Structure:body:tailgate:hinge And Attachments
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
Structure:body:tailgate:hinge And Attachments
GENERAL MOTORS FILED A DEFECT NOTICE 04V-129 ON MARCH 17, 2004, WHICH OUTLINES A PROGRAM TO REPLACE THE TAILGATE CABLES INSTALLED IN AFFECTED MODEL YEAR 2000-2004 VEHICLES.REFER TO ODI'S CLOSING REPORT FOR EA04-005 FOR ADDITIONAL INFORMATION.ODI IS AWARE OF REPORTS OF TAILGATE CABLE BREAKAGE OCCURRING IN MODEL YEAR 1999 AND EARLIER VEHICLES.THESE VEHICLES WERE EQUIPPED WITH SIMILAR TAILGATE CABLES AS ADDRESSED BY 04V-129, BUT ARE NOT BEING ADDRESSED BY CAMPAIGN O4V-129.ODI IS INITIATING A SEPARATE INVESTIGATION TO ADDRESS THESE VEHICLES.THE COMPLAINT-INJURY-FATALITY STATISTICS SUMMARIZED ABOVE PERTAIN TO MODEL YEAR 2000-2004 VEHICLES. THE COMPLAINT-INJURY STATISTICS FOR MODEL YEAR 1999 AND EARLIER VEHICLES ARE SUMMARIZED ON THE OPENING RESUME FOR THAT INVESTIGATION.
PE03057 · Parking Brake Failure
Opened Dec 8, 2003 · Closed Apr 9, 2004
Status: closed (inferred from source dates) · Parking Brake
ODI OPENED PE03-057 TO ASSESS PARKING BRAKE INEFFECTIVENESS IN THE SUBJECT VEHICLES.THESE VEHICLES ARE EQUIPPED WITH FOUR WHEEL DISC BRAKES THAT INCORPORATE A SINGLE-SHOE DRUM-IN-HAT PARKING BRAKE INDEPENDENT OF THE SERVICE BRAKES.COMPLAINT AND WARRANTY DATA INDICATE THAT THE PARKING BRAKE LININGS TEND TO WEAR OUT EARLY IN THE LIFE OF THE VEHICLE (AT AN AVERAGE OF 24 MONTHS IN SERVICE), REDUCING THE PARKING BRAKE SYSTEM'S TORQUE BELOW THAT NEEDED TO IMMOBILIZE THE VEHICLE.GM HAS ATTRIBUTED THIS ACCELERATED WEAR TO FOREIGN MATERIAL INTRUSION AND A FAILURE OF THE BRAKE SHOE TO PROPERLY SELF-CENTER WITHIN ITS BRAKE DRUM.EFFECTIVE WITH THE START OF MY 2003 PRODUCTION, A NEWER REDUCED FORCE HOLD-DOWN CLIP WAS INTRODUCED TO FACILITATE BRAKE SHOE DISENGAGEMENT FROM THE DRUM SURFACE.THIS PART IS ALSO AVAILABLE AT THE SERVICE LEVEL FOR THE MY 1999-2002 VEHICLES.GM HAS INDICATED THAT THE PAKING BRAKE IS INTENDED TO OPERATE IN CONJUNCTION WITH THE TRANSMISSION TO IMMOBILZE PARKED VEHICLES, AND THAT IN MANY CASES, ACCELERATED PARKING BRAKE LINING WEAR IS CAUSED BY ROUGH USE, VEHICLE MODIFICATIONS, AND DRIVING WITH THE PARKING ENGAGED. ODI HAS UPGRADED THE PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING PARKING BRAKE USAGE FACTORS AND THE CIRCUMSTANCES SURROUNDING THE SEVENTEEN REPORTED VEHICLE CRASHES.
PE03026 · Steel Wheel Rim Fracture
Opened Jun 12, 2003 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Wheels; Wheels:multi Piece; Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Wheels
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:multi Piece
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration