NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
11 reportsClear category filterMileage unknown · Jan 7, 2025
Fuel/propulsion System
On [XXX] while traveling down [XXX] in VA I experienced a catastrophic Bosch CP4 Fuel Pump Failure. Vehicle was towed to Marion Auto Group in Marion, VA and kept for 5 weeks to repair fuel system. We paid $6,500 once we were told the repairs were complete and picked the vehicle up. Within 50 miles of driving, the fuel system e…
Read full complaint
On [XXX] while traveling down [XXX] in VA I experienced a catastrophic Bosch CP4 Fuel Pump Failure. Vehicle was towed to Marion Auto Group in Marion, VA and kept for 5 weeks to repair fuel system. We paid $6,500 once we were told the repairs were complete and picked the vehicle up. Within 50 miles of driving, the fuel system error lights/codes began again and the service engine light came on. We called Marion Auto Group, they told us it was warranted for 24 months for parts and labor. We could take it to any Chevy dealer and have it looked at. We made an appt with our local Chevy dealer, Joe Bowman Chevrolet in Harrisonburg, VA. They kept the vehicle for approximately 5-6 weeks. Told us daily about the faulty repairs that Marion Auto Group had made, corrected the faulty repairs, with pictures, videos and even a coffee cup full of bad bolts and weld pieces that they replaced. Marion Auto Group agreed to pay Joe Bowman Chevrolet $5,500 in reimbursement for the work they performed to correct Marion Auto Groups work. When I got in the truck to bring it home and started it, the service engine light came on. They pulled it back in the shop, ran a diagnostic and said we needed some type of sensor ($900) so we scheduled an appt to have that done. Then we took the truck to Tennessee, fuel system failure lights and codes immediately came on. When I stopped to eat, it wouldn't start back. Took the truck to Tarr Chevrolet in Jefferson City TN, they diagnosed it as needing a new fuel line (from prev faulty fuel system) changed it ($1,700) and we headed back home with all the fuel system warning lights flashing again. Took it back to Joe Bowman Chevrolet in Harrisonburg where it's been sitting for over 7 weeks while GM decides if they should cover the entire new fuel system that it needs again ($19,000) because it's never been properly repaired since the initial catastrophic failure. Almost 7 months and $14,,600 in previous repairs.......Please HELP US! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT
NHTSA ODI #11634518
Mileage unknown · Nov 7, 2024
Fuel/propulsion SystemVehicle Speed Control
I was driving the truck and the dashboard said fuel filter at 0 % entering low power mode. The truck did not accelerate at all and stopped running within 5 minutes . The repair cost almost 9000.00 for a 100.00 fuel filter.
NHTSA ODI #11624063
Mileage unknown · Oct 11, 2023
EngineFuel/propulsion System
Probable High Pressure Fuel Pump (CP4) failure resulting in the vehicle stalling without warning. This event has not yet occurred, however due to the high number of vehicles involved in the Stellantis recall which are using the same CP4 pumps which are known to fail, I am scared to drive my truck as the CP4 pump may fail at any…
Read full complaint
Probable High Pressure Fuel Pump (CP4) failure resulting in the vehicle stalling without warning. This event has not yet occurred, however due to the high number of vehicles involved in the Stellantis recall which are using the same CP4 pumps which are known to fail, I am scared to drive my truck as the CP4 pump may fail at any time. I have spoken to MANY other GM truck owners who have experienced this failure and it has cost them tens of thousands of dollars. Please open a recall for the CP4 High Pressure Fuel Pump for 2011-2016 GM trucks using this HPFP. Thank you,
NHTSA ODI #11549346
Mileage unknown · Jan 31, 2022
Fuel/propulsion System
Friday October 8th 2021, my truck shut off in the middle of Chesnee SC within 1/4 mile after filling up with diesel fuel at the Hot Spot in Chesnee. I had it towed to Burns Chevrolet in Gaffney SC for analysis. They determine it was the result of contamination in the fuel and that is not a warranty issue. I would agree that is n…
Read full complaint
Friday October 8th 2021, my truck shut off in the middle of Chesnee SC within 1/4 mile after filling up with diesel fuel at the Hot Spot in Chesnee. I had it towed to Burns Chevrolet in Gaffney SC for analysis. They determine it was the result of contamination in the fuel and that is not a warranty issue. I would agree that is not the responsibility of Chevrolet and I authorized them to make the repairs. They did what you would normally expect with the exception of one thing. They came back and said they had to replace the fuel transfer line between the fuel tanks. Said it was kinked. I questioned how water in the fuel could cause that to happen but they said the contamination was the root cause and I had to pay to fix that as well. I requested a sample of the contamination and all parts replaced. That charge was included on the invoice and I paid it. There are other issues with the quality of the service which included returning the next day because the water contamination light came on again. They had to bleed the newly installed fuel filter there in the parking lot and the light went off. When I got home and inspected the replaced parts, I found that the fuel transfer line not only was kinked, but also ruptured. I just retired from an OEM as a quality specialist, and many of my parts were safety critical. I would be willing to bet that the Tier 1 supplier does not have a ruptured fuel line ranked very high on their FEMA plan due to the probability of water causing a kink little on a rupture, but according to the Chevrolet technician that was the root cause, so they own it. I called Chevrolet corporate and informed them of my plan to report this incident. They opened an incident report, but failed to take any action to address my concerns. You will find when you check the dealers repairs to this vehicle, it has had several issues related to fuel problems. Due to space limitations on this page, I cannot tell you the whole story. Contact me and I can explain furthe
NHTSA ODI #11449552
Mileage unknown · Jul 11, 2019
Fuel/propulsion System
TL* THE CONTACT OWNS A 2016 CHEVROLET SILVERADO 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V088000 (FUEL SYSTEM, GASOLINE). THE CONTACT CALLED CARL BLACK CHEVROLET BUICK GMC AT (888) 457-2417 (LOCATED AT 1110 ROBERTS BLVD NW, KENNESAW, GA 30144) AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE MA…
Read full complaint
TL* THE CONTACT OWNS A 2016 CHEVROLET SILVERADO 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V088000 (FUEL SYSTEM, GASOLINE). THE CONTACT CALLED CARL BLACK CHEVROLET BUICK GMC AT (888) 457-2417 (LOCATED AT 1110 ROBERTS BLVD NW, KENNESAW, GA 30144) AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #11230952
38,000 miles · Apr 10, 2018
EngineFuel/propulsion SystemSteering
TL* THE CONTACT OWNS A 2016 CHEVROLET SILVERADO 3500. WHILE DRIVING 40-45 MPH, THE REDUCED ENGINE SPEED WARNING INDICATOR ILLUMINATED AND THE VEHICLE STALLED. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO HERB EASLEY MOTORS (1125 CENTRAL E FWY, WICHITA FALLS, TX 76306, (940) 723-6631) WHERE IT WAS DIAGN…
Read full complaint
TL* THE CONTACT OWNS A 2016 CHEVROLET SILVERADO 3500. WHILE DRIVING 40-45 MPH, THE REDUCED ENGINE SPEED WARNING INDICATOR ILLUMINATED AND THE VEHICLE STALLED. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO HERB EASLEY MOTORS (1125 CENTRAL E FWY, WICHITA FALLS, TX 76306, (940) 723-6631) WHERE IT WAS DIAGNOSED THAT THE FAILURE WAS DUE TO CONTAMINATION OF METAL SHAVINGS IN THE FUEL PUMP AND FUEL RAILS. IN ADDITION, THE FAN CLUTCH FAILED AND NEEDED TO BE REPLACED, INCLUDING THE ENTIRE FUEL SYSTEM. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED SEVERAL MONTHS LATER. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL SYSTEM NEEDED TO BE REPLACED AGAIN. THE VEHICLE WAS NOT REPAIRED DUE TO COST. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND CASE NUMBER: 8-4064184145 WAS OPENED. THE APPROXIMATE FAILURE MILEAGE WAS 38,000.
NHTSA ODI #11084287
43,000 miles · May 19, 2017
Fuel/propulsion System
TRUCK WOULD NOT START. SECOND TIME THIS HAS OCCURRED. FIRST TIME TRANSFER PUMP WAS EXCHANGED. NOW BEING TOLD IT IS REQUIRING FRONT AND REAR TANK LEVEL SENSORS. TWICE HAVE BEEN STRANDED IN THIS VEHICLE FOR FUEL ISSUES. PRIOR ISSUE OCCURRED WHILE TRUCK WAS DRIVING ON A STREET. THIS TIME, WHEN TRYING TO RESTART AFTER COMPLETING…
Read full complaint
TRUCK WOULD NOT START. SECOND TIME THIS HAS OCCURRED. FIRST TIME TRANSFER PUMP WAS EXCHANGED. NOW BEING TOLD IT IS REQUIRING FRONT AND REAR TANK LEVEL SENSORS. TWICE HAVE BEEN STRANDED IN THIS VEHICLE FOR FUEL ISSUES. PRIOR ISSUE OCCURRED WHILE TRUCK WAS DRIVING ON A STREET. THIS TIME, WHEN TRYING TO RESTART AFTER COMPLETING A DELIVERY.
NHTSA ODI #10990638
21,971 miles · Apr 21, 2017
Fuel/propulsion System
GAS EXPLODED OUT THE TOP OF THE TANK - CAUSING GAS TO FLOW OUT OF THE TOP. NO FIRE STARTED SINCE IT HAPPENED RIGHT AS THE FIRETRUCK WAS PASSING THE AREA. THEY HEARD THE NOISE AND SMELLED THE GAS. THEY DISCONNECTED THE BATTERY AND MARKED OFF THE AREA. THEY ALSO ASSISTED IN CLEANING UP THE SPILL. VEHICLE WAS IN MOTION WHEN THE EXP…
Read full complaint
GAS EXPLODED OUT THE TOP OF THE TANK - CAUSING GAS TO FLOW OUT OF THE TOP. NO FIRE STARTED SINCE IT HAPPENED RIGHT AS THE FIRETRUCK WAS PASSING THE AREA. THEY HEARD THE NOISE AND SMELLED THE GAS. THEY DISCONNECTED THE BATTERY AND MARKED OFF THE AREA. THEY ALSO ASSISTED IN CLEANING UP THE SPILL. VEHICLE WAS IN MOTION WHEN THE EXPLOSION TOOK PLACE AND THEY CONTINUED TO COAST TO A SAFE SPOT SINCE THE TRUCK NO LONGER WAS GETTING FUEL.
NHTSA ODI #10979746
40,396 miles · Mar 17, 2017
Fuel/propulsion System
P2636 TRANSFER PUMP - DRIVER INDICATED FUEL GAUGE WAS FLUCTUATING FROM FULL TO EMPTY. CHECK ENGINE LIGHT CAME ON AND GAUGE DROPPED TO EMPTY. DRIVER SAW SMOKE COMING FROM LEFT SIDE OF ENGINE. UPON INSPECTION STRONG FUEL ODOR. DEALERSHIP FOUND CLEARED CODE AND FOUND GAUGES READING NORMAL, THEN PUMP "GOT LOUD AND HOT AND QUIT OPER…
Read full complaint
P2636 TRANSFER PUMP - DRIVER INDICATED FUEL GAUGE WAS FLUCTUATING FROM FULL TO EMPTY. CHECK ENGINE LIGHT CAME ON AND GAUGE DROPPED TO EMPTY. DRIVER SAW SMOKE COMING FROM LEFT SIDE OF ENGINE. UPON INSPECTION STRONG FUEL ODOR. DEALERSHIP FOUND CLEARED CODE AND FOUND GAUGES READING NORMAL, THEN PUMP "GOT LOUD AND HOT AND QUIT OPERATING". REPLACED FUEL TRANSFER PUMP. VEHICLE HAD 40,396 MILES. BELIEVE THIS TO BE A HAZARD TO OUR DRIVERS, WITH FUEL LEAK/FIRE AND STALLING POTENTIAL OUTCOMES.
NHTSA ODI #10966553
20,000 miles · Jan 3, 2017
Fuel/propulsion System
TL* THE CONTACT OWNS A 2016 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT FUEL MONITORING SYSTEM MALFUNCTIONED DUE TO TRANSFER FUEL PUMPS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL SYSTEM SOFTWARE NEEDED TO BE UPDATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 20,0…
Read full complaint
TL* THE CONTACT OWNS A 2016 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT FUEL MONITORING SYSTEM MALFUNCTIONED DUE TO TRANSFER FUEL PUMPS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL SYSTEM SOFTWARE NEEDED TO BE UPDATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 20,000.
NHTSA ODI #10939189
Official recalls
6Jul 1, 2021
General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500, 2500, 3500, and Chevrolet Silverado 1500, 2500, and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Consequence & remedy
Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will replace the left and right side RRAB modules, free of charge. Interim owner notification letters informing owners of the safety risk were mailed on August 18, 2021. Owners will receive a second notice when the remedy is available. Phase I owner notification letters were mailed on May 5, 2022. Phase II owner notification letters are expected to be mailed on May 31, 2022. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. This recall supersedes NHTSA recall number 20V-736. GM's number for this recall is N202324251.
Feb 7, 2019
General Motors, LLC (GM) is recalling certain 2016-2018 GMC Sierra 3500 and Chevrolet Silverado 3500 trucks equipped with gasoline engines and dual fuel tanks. The fuel-level sensor in the front tank may stick in a low-level position, allowing the rear tank to overfill the front tank.
Consequence & remedy
Consequence: If the front tank overfills, the excess pressure may cause the front tank to expand and contact the driveshaft, possibly resulting in a hole in the tank. The hole will leak fuel, which in the presence of an ignition source, can increase the risk of a fire.
Remedy: GM has notified owners, and dealers will replace the rear-tank fuel-pump module, inspect the front tank and, if necessary, replace the front tank, free of charge. The recall began July 30, 2019. GM's number for this recall is N182204190.
Aug 30, 2018
General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 2500, 3500, 1500 Crew Cab Special Service, Tahoe Police Pursuit/Special Service, GMC Sierra 2500, and 3500 vehicles. The brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.
Consequence & remedy
Consequence: If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.
Remedy: GM will notify owners, and dealers will add adhesive to the nut and reinstall the nut with increased tightness, free of charge. The recall began October 3, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18278. Note: The vehicles in this recall need this additional remedy despite being covered by recall 16V069 for brake pedal loosening.
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Feb 5, 2016
General Motors LLC (GM) is recalling certain model year 2015-2016 Chevrolet Silverado 1500, 2500, and 3500 heavy duty trucks manufactured October 1, 2013, to February 1, 2016, 2015-2016 Chevrolet Tahoe Police Pursuit Vehicles (PPV) manufactured March 1, 2014, to February 1, 2016, and 2015-2016 GMC Sierra 2500 and 3500 heavy duty trucks manufactured October 29, 2013, to February 1, 2016. On the affected vehicles, the brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.
Consequence & remedy
Consequence: If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.
Remedy: GM will notify owners, and dealers will add adhesive to the brake pedal pivot nut and reinstall with an increased torque, free of charge. The recall began on March 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 20760.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration