WHILE DRIVING, APPROXIMATELY 70 MPH, THE TRUCK SHUTS DOWN COMPLETELY. NO POWER BRAKES NO POWER STEERING, NO POWER ANYTHING. AFTER 5 TO 10 SECONDS TRUCK STARTS BACK UP ON ITS OWN, SOMETIMES. VERY DANGEROUS WHEN HAULING A HEAVY LOAD. THIS HAPPENED MORE THAN ONCE, WAS INTERMITTENT AND VARIED IN FREQUENCY. I CHANGED CRANK SENSO…
Read full complaint
WHILE DRIVING, APPROXIMATELY 70 MPH, THE TRUCK SHUTS DOWN COMPLETELY. NO POWER BRAKES NO POWER STEERING, NO POWER ANYTHING. AFTER 5 TO 10 SECONDS TRUCK STARTS BACK UP ON ITS OWN, SOMETIMES. VERY DANGEROUS WHEN HAULING A HEAVY LOAD. THIS HAPPENED MORE THAN ONCE, WAS INTERMITTENT AND VARIED IN FREQUENCY. I CHANGED CRANK SENSOR AND PROBLEM HAS NOT OCCURRED. GM DEALERSHIPS WHERE NOT VERY HELPFUL. *JB
NHTSA ODI #10175888
19,707 miles · Jul 20, 2006
Engine And Engine Cooling
DT*: THE CONTACT STATED THE VEHICLE STALLED WHILE DRIVING AT 30MPH. THE VEHICLE WAS HARD TO RESTART. THE CHECK ENGINE LIGHT ILLUMINATED CONSTANTLY. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER WHO DETERMINED THAT THE CPS NEEDED REPLACING.
NHTSA ODI #10162960
Mileage unknown · Jun 2, 2004
Engine And Engine Cooling
2001 K3500 W/ 8100 V8. VEHICLE USES 3 TO 4 QUARTS OF OIL IN BETWEEN OIL CHANGES (EVERY 3,000 ML.). I'M NOT GETTING MUCH ACTION FROM THE DEALER & MY WARENTY IS ALMOST OUT!!*AK
NHTSA ODI #10074655
1 miles · Dec 10, 2003
Engine And Engine Cooling
I OWN A 2001 CHEVY SILVERADO K3500 WITH THE 6.0L ENGINE. MY VEHICLE HAS CONSUMED OIL FROM DAY ONE AND THIS PROBLEM IS GETTING WORSE. I TRAVELED TO OHIO LAST MONTH AND USED ONE QUART IN ABOUT 450 MILES. THIS IS OUTRAGEOUS. NOW I MUST GIVE YOU SOME BACKGROUND ON MYSELF. MY PREVIOUS VEHICLE WAS A 1995 GMC SIERRA K3500 WITH A 7.4L E…
Read full complaint
I OWN A 2001 CHEVY SILVERADO K3500 WITH THE 6.0L ENGINE. MY VEHICLE HAS CONSUMED OIL FROM DAY ONE AND THIS PROBLEM IS GETTING WORSE. I TRAVELED TO OHIO LAST MONTH AND USED ONE QUART IN ABOUT 450 MILES. THIS IS OUTRAGEOUS. NOW I MUST GIVE YOU SOME BACKGROUND ON MYSELF. MY PREVIOUS VEHICLE WAS A 1995 GMC SIERRA K3500 WITH A 7.4L ENGINE, BOTH THE 2001 AND THE 1995 I PURCHASED NEW. I FOLLOWED THE MANUFACTURER'S DIRECTIONS ON BREAKING IN THE VEHICLE IN BOTH CASES. THE 1995 VEHICLE NEVER CONSUMED OIL, EVEN AT 145,000 MILES. I CHECK MY OIL AT LEAST ONCE A WEEK, THAT IS A DISGRACE FOR A VEHICLE THAT IS ONLY THREE YEARS OLD. MY VEHICLE ALSO KNOCKS AND PINGS ALL THE TIME. I HAVE CALLED THE DEALERSHIP I PURCHASED THE VEHICLE FROM AT TWO DIFFERENT OCCASIONS AND HAVE RECEIVED TWO DIFFERENT STORIES. I AM TIRED OF THE "RUN AROUND" TREATMENT BY THE DEALER AND BY CHEVY WHEN I CALL THE "CHEVY HELP LINE", "WORK IT OUT WITH THE DEALER" IS ALL I'M TOLD. I AM AWARE OF A POSSIBLE CLASS ACTION LAWSUIT AGAINST CHEVROLET FOR THE ENGINE PROBLEMS. I WOULD APPRECIATE ANY INFORMATION OR ASSISTANCE YOU COULD OFFER IN THIS MATTER. *LA
NHTSA ODI #10049552
68,000 miles · Nov 28, 2003
Engine And Engine CoolingSuspensionCrash
CONSUMER COMPLAINED ABOUT AN ENGINE PROBLEM. IT DID NOT MAINTAIN THE THROTTLE. ENGINE WENT INTO NEUTRAL WITHOUT A CAUSE. ALSO, A SUSPENSION PROBLEM DUE TO BOLTS PLACE DIN UPSIDE DOWN POSITION WHICH MIGHT CAUSE VEHICLE TO FLIP. ALSO, WIRES AND PLASTIC BOLTS MELTED.*AK
NHTSA ODI #10048788
Mileage unknown · Nov 13, 2001
Engine And Engine CoolingSteering
SECURITY SYSTEM CUT POWER TO FUEL PUMP STOPPING ENGINE, A RESET TAKES 10 MINUTES. THE GM HELP LINE PROVIDED ME WITH THE METHOD OF RESETING THE SECURITY SYSTEM. GM'S HELP LINE ADMITS THIS IS A PROBLEM, BUT HAS NO CURRENT FACTORY UPGRADE OR REPAIR. THE ENGINE STALLS SHORTLY AFTER STARTING, ALLWOING THE VEHICLE TO BE MOVED A F…
Read full complaint
SECURITY SYSTEM CUT POWER TO FUEL PUMP STOPPING ENGINE, A RESET TAKES 10 MINUTES. THE GM HELP LINE PROVIDED ME WITH THE METHOD OF RESETING THE SECURITY SYSTEM. GM'S HELP LINE ADMITS THIS IS A PROBLEM, BUT HAS NO CURRENT FACTORY UPGRADE OR REPAIR. THE ENGINE STALLS SHORTLY AFTER STARTING, ALLWOING THE VEHICLE TO BE MOVED A FEW FEET (IN MY CASE OUT OF THE DRIVEWAY). *AK
NHTSA ODI #754499
Mileage unknown · May 8, 2001
Engine And Engine CoolingFireInjury
CONSUMER PULLED IN FIELD OF FARM AREA THOUGH GRASS. HE TURNED VEHICLE OFF, LEFT A FEW MINUTES, AND A YOUNG GENTLEMAN TOLD HIM THAT VEHICLE WAS ON FIRE. SMOKE WAS COMING FROM FRONT RIGHT TIRE . HE TRIED TO START VEHICLE, AND VEHICLE STOPPED. GRASS WAS ON FIRE, AND VEHICLE BURNED DOWN TO THE GROUND. FIRE DEPARTMENT WAS…
Read full complaint
CONSUMER PULLED IN FIELD OF FARM AREA THOUGH GRASS. HE TURNED VEHICLE OFF, LEFT A FEW MINUTES, AND A YOUNG GENTLEMAN TOLD HIM THAT VEHICLE WAS ON FIRE. SMOKE WAS COMING FROM FRONT RIGHT TIRE . HE TRIED TO START VEHICLE, AND VEHICLE STOPPED. GRASS WAS ON FIRE, AND VEHICLE BURNED DOWN TO THE GROUND. FIRE DEPARTMENT WAS CALLED OUT. HE WAS HURT A LITTLE BIT.*AK
VEHICLE DESCRIPTION: CERTAIN PICKUP TRUCKS EQUIPPED WITH 6.6L DIESEL ENGINES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THESE VEHICLES HAVE A BRAKE SYSTEM WARNING LIGHT IN THE INSTRUMENT CLUSTER THAT MAY NOT ILLUMINATE WHEN THE BRAKE FLUID IS LOW. IN ADDITION, WHEN THE BRAKE FLUID IS LOW, THE VEHICLE MAY NOT MEET THE PARTIAL SYSTEM REQUIREMENTS OF FMVSS NO. 105.
Consequence & remedy
Consequence: THESE CONDITIONS COULD RESULT IN REDUCED BRAKING CAPABILITY, WHICH COULD LEAD TO A CRASH.
Remedy: DEALERS WILL CHANGE THE LOCATION OF A WIRE CONNECTION IN THE UNDERHOOD BUSSED ELECTRICAL CENTER. OWNER NOTIFICATION BEGAN JULY 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA06016 · Crank Position Sensor Failure - Stall
Opened Sep 14, 2006 · Closed Nov 9, 2007
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine
IN A LETTER DATED NOVEMBER 7, 2007, GENERAL MOTORS (GM) REPORTED TO THE OFFICE OF DEFECTS INVESTIGATION (ODI) THAT IT WILL CONDUCT A SAFETY RECALL (07V-521) TO REPLACE THE CRANK POSITION SENSOR (CKP) IN APPROXIMATELY 12,000 MODEL YEAR (MY) 2001 CHEVROLET SILVERADO AND GMC SIERRA VEHICLES EQUIPPED WITH 8.1 LITER ENGINES MANUFACTURED ON OR BEFORE NOVEMBER 15, 2000.ACCORDING TO GM, THE CKP CAN FAIL INTERMITTENTLY OR PERMANENTLY.A PERMANENT CKP FAILURE WOULD RESULT IN AN ENGINE STALL WITHOUT RESTART.AN INTERMITTENT CKP FAILURE COULD CAUSE THE SERVICE ENGINE SOON LIGHT TO ILLUMINATE, THE VEHICLE TO RUN ROUGH OR THE ENGINE TO STALL BUT ALLOWS RESTART.AS A REMEDY, AN IMPROVED CKP WILL BE INSTALLED IN THE SUBJECT VEHICLES.THE RECALL CAMPAIGN WILL START IN DECEMBER 2007. DURING THE PRELIMINARY EVALUATION (PE06-016), AND THIS EA INVESTIGATION, GM AND ODI INDEPENDENTLY CONDUCTED DETAILED REVIEWS OF CERTAIN FIELD DATA TO UNDERSTAND THE NATURE AND RATE OF SUBJECT VEHICLE STALLING DUE TO CKP FAILURES.GM AND ODI REVIEWED GM'S WARRANTY CLAIMS FOR THE CKP WITH THE OBJECTIVE OF ASCERTAINING AN ESTIMATE OF THOSE CLAIMS REPRESENTING AN ENGINE STALL WHILE DRIVING.THE CKP WARRANTY CLAIMS WITHOUT VERBATIM TEXT WERE THE LARGEST SEGMENT OF WARRANTY CLAIMS.USING THOSE CLAIMS, GM SURVEYED VEHICLE OWNERS TO GATHER ADDITIONAL INFORMATION TO DETERMINE IF THE CLAIM WAS ASSOCIATED WITH A STALL WHILE DRIVING EVENT.BASED ON THE SURVEY, GM ESTIMATED THAT APPROXIMATELY 49% OF ALL WARRANTY REPAIRS FOR THE CKP INVOLVED A STALL WHILE DRIVING.ODI?S REVIEW OF GM'S SURVEY DATA PRODUCED A HIGHER ESTIMATE (71%) FOR STALL WHILE DRIVING.GM FURTHER ESTIMATED THE RATE OF STALL WHILE DRIVING FOR THE SUBJECT VEHICLES OVER TIME.IT ESTIMATED STALLING WHILE DRIVING RATES OF 1.6%, 4.6% AND 8.9% AT 1, 3 AND 6 YEARS IN SERVICE RESPECTIVELY.ODI'S REVIEW OF THE GM'S SURVEY DATA FINDS HIGHER ESTIMATED STALL WHILE DRIVING RATES OF 2.2%, 6.8% AND 13% AT 1, 3 AND 6 YEARS IN SERVICE RESPECTIVELY. ODI ALSO CONDUCTED A SURVEY OF VEHICLE OWNERS USING CONSUMER COMPLAINTS REPORTED TO BOTH ODI AND GM.THE OBJECTIVE WAS TO ASCERTAIN THE POTENTIAL SAFETY CONSEQUENCES OF AN ENGINE STALL DUE TO THE ALLEGED DEFECT.WITH RESPECT TO THE ABILITY TO RESTART THE VEHICLE AFTER A STALL, 11% REPORTED IMMEDIATE RESTART, 69% REPORTED DELAYED RESTART AND 20% REPORTED NO RESTART.OVER HALF NOTED AT LEAST ONE ENGINE STALL INCIDENT AT SPEEDS IN EXCESS OF 40MPH. ABOUT ONE-THIRD NOTED THE VEHICLE WAS STRANDED EITHER PARTIALLY OR FULLY IN A LANE OF TRAFFIC AFTER THE ENGINE STALL.ALL OF THE CONSUMERS SURVEYED NOTED MULTIPLE STALLING EVENTS PRIOR TO PROPER DIAGNOSIS AND REPLACEMENT OF THE CKP.BASED ON GM'S DECISION TO CONDUCT A SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Engine And Engine Cooling:engine
IN A LETTER DATED NOVEMBER 7, 2007, GENERAL MOTORS (GM) REPORTED TO THE OFFICE OF DEFECTS INVESTIGATION (ODI) THAT IT WILL CONDUCT A SAFETY RECALL (07V-521) TO REPLACE THE CRANK POSITION SENSOR (CKP) IN APPROXIMATELY 12,000 MODEL YEAR (MY) 2001 CHEVROLET SILVERADO AND GMC SIERRA VEHICLES EQUIPPED WITH 8.1 LITER ENGINES MANUFACTURED ON OR BEFORE NOVEMBER 15, 2000.ACCORDING TO GM, THE CKP CAN FAIL INTERMITTENTLY OR PERMANENTLY.A PERMANENT CKP FAILURE WOULD RESULT IN AN ENGINE STALL WITHOUT RESTART.AN INTERMITTENT CKP FAILURE COULD CAUSE THE SERVICE ENGINE SOON LIGHT TO ILLUMINATE, THE VEHICLE TO RUN ROUGH OR THE ENGINE TO STALL BUT ALLOWS RESTART.AS A REMEDY, AN IMPROVED CKP WILL BE INSTALLED IN THE SUBJECT VEHICLES.THE RECALL CAMPAIGN WILL START IN DECEMBER 2007. DURING THE PRELIMINARY EVALUATION (PE06-016), AND THIS EA INVESTIGATION, GM AND ODI INDEPENDENTLY CONDUCTED DETAILED REVIEWS OF CERTAIN FIELD DATA TO UNDERSTAND THE NATURE AND RATE OF SUBJECT VEHICLE STALLING DUE TO CKP FAILURES.GM AND ODI REVIEWED GM'S WARRANTY CLAIMS FOR THE CKP WITH THE OBJECTIVE OF ASCERTAINING AN ESTIMATE OF THOSE CLAIMS REPRESENTING AN ENGINE STALL WHILE DRIVING.THE CKP WARRANTY CLAIMS WITHOUT VERBATIM TEXT WERE THE LARGEST SEGMENT OF WARRANTY CLAIMS.USING THOSE CLAIMS, GM SURVEYED VEHICLE OWNERS TO GATHER ADDITIONAL INFORMATION TO DETERMINE IF THE CLAIM WAS ASSOCIATED WITH A STALL WHILE DRIVING EVENT.BASED ON THE SURVEY, GM ESTIMATED THAT APPROXIMATELY 49% OF ALL WARRANTY REPAIRS FOR THE CKP INVOLVED A STALL WHILE DRIVING.ODI?S REVIEW OF GM'S SURVEY DATA PRODUCED A HIGHER ESTIMATE (71%) FOR STALL WHILE DRIVING.GM FURTHER ESTIMATED THE RATE OF STALL WHILE DRIVING FOR THE SUBJECT VEHICLES OVER TIME.IT ESTIMATED STALLING WHILE DRIVING RATES OF 1.6%, 4.6% AND 8.9% AT 1, 3 AND 6 YEARS IN SERVICE RESPECTIVELY.ODI'S REVIEW OF THE GM'S SURVEY DATA FINDS HIGHER ESTIMATED STALL WHILE DRIVING RATES OF 2.2%, 6.8% AND 13% AT 1, 3 AND 6 YEARS IN SERVICE RESPECTIVELY. ODI ALSO CONDUCTED A SURVEY OF VEHICLE OWNERS USING CONSUMER COMPLAINTS REPORTED TO BOTH ODI AND GM.THE OBJECTIVE WAS TO ASCERTAIN THE POTENTIAL SAFETY CONSEQUENCES OF AN ENGINE STALL DUE TO THE ALLEGED DEFECT.WITH RESPECT TO THE ABILITY TO RESTART THE VEHICLE AFTER A STALL, 11% REPORTED IMMEDIATE RESTART, 69% REPORTED DELAYED RESTART AND 20% REPORTED NO RESTART.OVER HALF NOTED AT LEAST ONE ENGINE STALL INCIDENT AT SPEEDS IN EXCESS OF 40MPH. ABOUT ONE-THIRD NOTED THE VEHICLE WAS STRANDED EITHER PARTIALLY OR FULLY IN A LANE OF TRAFFIC AFTER THE ENGINE STALL.ALL OF THE CONSUMERS SURVEYED NOTED MULTIPLE STALLING EVENTS PRIOR TO PROPER DIAGNOSIS AND REPLACEMENT OF THE CKP.BASED ON GM'S DECISION TO CONDUCT A SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
IN A LETTER DATED NOVEMBER 7, 2007, GENERAL MOTORS (GM) REPORTED TO THE OFFICE OF DEFECTS INVESTIGATION (ODI) THAT IT WILL CONDUCT A SAFETY RECALL (07V-521) TO REPLACE THE CRANK POSITION SENSOR (CKP) IN APPROXIMATELY 12,000 MODEL YEAR (MY) 2001 CHEVROLET SILVERADO AND GMC SIERRA VEHICLES EQUIPPED WITH 8.1 LITER ENGINES MANUFACTURED ON OR BEFORE NOVEMBER 15, 2000.ACCORDING TO GM, THE CKP CAN FAIL INTERMITTENTLY OR PERMANENTLY.A PERMANENT CKP FAILURE WOULD RESULT IN AN ENGINE STALL WITHOUT RESTART.AN INTERMITTENT CKP FAILURE COULD CAUSE THE SERVICE ENGINE SOON LIGHT TO ILLUMINATE, THE VEHICLE TO RUN ROUGH OR THE ENGINE TO STALL BUT ALLOWS RESTART.AS A REMEDY, AN IMPROVED CKP WILL BE INSTALLED IN THE SUBJECT VEHICLES.THE RECALL CAMPAIGN WILL START IN DECEMBER 2007. DURING THE PRELIMINARY EVALUATION (PE06-016), AND THIS EA INVESTIGATION, GM AND ODI INDEPENDENTLY CONDUCTED DETAILED REVIEWS OF CERTAIN FIELD DATA TO UNDERSTAND THE NATURE AND RATE OF SUBJECT VEHICLE STALLING DUE TO CKP FAILURES.GM AND ODI REVIEWED GM'S WARRANTY CLAIMS FOR THE CKP WITH THE OBJECTIVE OF ASCERTAINING AN ESTIMATE OF THOSE CLAIMS REPRESENTING AN ENGINE STALL WHILE DRIVING.THE CKP WARRANTY CLAIMS WITHOUT VERBATIM TEXT WERE THE LARGEST SEGMENT OF WARRANTY CLAIMS.USING THOSE CLAIMS, GM SURVEYED VEHICLE OWNERS TO GATHER ADDITIONAL INFORMATION TO DETERMINE IF THE CLAIM WAS ASSOCIATED WITH A STALL WHILE DRIVING EVENT.BASED ON THE SURVEY, GM ESTIMATED THAT APPROXIMATELY 49% OF ALL WARRANTY REPAIRS FOR THE CKP INVOLVED A STALL WHILE DRIVING.ODI?S REVIEW OF GM'S SURVEY DATA PRODUCED A HIGHER ESTIMATE (71%) FOR STALL WHILE DRIVING.GM FURTHER ESTIMATED THE RATE OF STALL WHILE DRIVING FOR THE SUBJECT VEHICLES OVER TIME.IT ESTIMATED STALLING WHILE DRIVING RATES OF 1.6%, 4.6% AND 8.9% AT 1, 3 AND 6 YEARS IN SERVICE RESPECTIVELY.ODI'S REVIEW OF THE GM'S SURVEY DATA FINDS HIGHER ESTIMATED STALL WHILE DRIVING RATES OF 2.2%, 6.8% AND 13% AT 1, 3 AND 6 YEARS IN SERVICE RESPECTIVELY. ODI ALSO CONDUCTED A SURVEY OF VEHICLE OWNERS USING CONSUMER COMPLAINTS REPORTED TO BOTH ODI AND GM.THE OBJECTIVE WAS TO ASCERTAIN THE POTENTIAL SAFETY CONSEQUENCES OF AN ENGINE STALL DUE TO THE ALLEGED DEFECT.WITH RESPECT TO THE ABILITY TO RESTART THE VEHICLE AFTER A STALL, 11% REPORTED IMMEDIATE RESTART, 69% REPORTED DELAYED RESTART AND 20% REPORTED NO RESTART.OVER HALF NOTED AT LEAST ONE ENGINE STALL INCIDENT AT SPEEDS IN EXCESS OF 40MPH. ABOUT ONE-THIRD NOTED THE VEHICLE WAS STRANDED EITHER PARTIALLY OR FULLY IN A LANE OF TRAFFIC AFTER THE ENGINE STALL.ALL OF THE CONSUMERS SURVEYED NOTED MULTIPLE STALLING EVENTS PRIOR TO PROPER DIAGNOSIS AND REPLACEMENT OF THE CKP.BASED ON GM'S DECISION TO CONDUCT A SAFETY RECALL, THIS INVESTIGATION IS CLOSED.
EA04012 · Hydraulic Pump Failres
Opened Apr 30, 2004 · Closed Feb 28, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
PE04004 · Hydraulic Pump Shaft Failures
Opened Jan 8, 2004 · Closed Apr 30, 2004
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Additional source detail variants (5)
Service Brakes, Hydraulic
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Service Brakes, Hydraulic:power Assist
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Service Brakes, Hydraulic:power Assist:hydraulic
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Steering:hydraulic Power Assist:pump
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
Steering:hydraulic Power Assist System
THE PRELIMINARY EVAULATION IS BEING UPGRADED.DURING THE EA ODI WILL LIMITITS INVESTIGATION TO ONLY THOSE VEHICLES EQUIPPED WITH A HYDRO-BOOST SYSTEM, WHICH PROVIDES POWER ASSIST TO THE BRAKING AND STEERING SYTEMS.VACCUUM BRAKE BOOSTER VEHICLES ARE EXCLUDED.ODI HASEXPANDED THE SCOPE OF THE EA TO INCLUDE MODEL YEARS2003 AND 2004, ASDURING THE PE, ODI LEARNED THAT THE HYDROBOAST PUMPS WERE MODIFIED IN FEBRAURY 2004.THEREFORE,ODI HAS EXPANDED THE SCOPE TO INCLUDE THE ADDITIONAL MODEL YEARS.ODI'S IS CONCERNED BECAUSE THISISA SUDDEN FAILURE THAT AFFECTS TWO CRITICAL SYSTEMS OF THE VEHICLE, BRAKES AND STEERING, AT THE SAME TIME.THE ABILITY OF THE OPERATOR TO HANDLE THE DUAL FAILURES IS A CONCERN. FURTHER, THESE VEHICLES TEND TO BE WORK VEHICLES, WITH SOME OVER 10,000 POUNDS GVWR AND MANY EQUIPPED TO PULL LARGE TRAILERS.DUAL FAILURES OF HEAVILY LOADED VEHICLES AND VEHICLES PULLING TRAILERS FURTHER INCREASES THE SAFETY RISK.ODI PLANS TO CONDUCT TESTING TO QUANTIFY THE BRAKING AND STEERING PERFORMANCE DEGRADATION AND THE IMPACT ON SAFE VEHICLE CONTROL, WHEN A HYDROBOAST PUMP FAILS.
2001 Chevrolet Silverado 3500 Problems, Complaints & Recalls | Skip That Year
Illustration